[Pilot-scale cultivation of Spirulina plantensis with digested piggery wastewater ].

The swine waste pretreated with coagulation sedimentation was used for the outdoor pilot-scale cultivation of Spirulina platensis isolated from digested piggery wastewater (DPW) in a raceway pond. The growth of S. platensis and removal of nitrogen/ phosphorus were studied, moreover, the conversion efficiency of total nitrogen (TN) or total phosphorus (TP) from DPW to S. platensis was calculated. On this basis, the existing problems and countermeasures during outdoor pilot-scale culture were analyzed and summarized combined with the laboratory research. We conducted 6 batches culture experiments, only 3 of which could reach the S. platensis harvest requirements (D560 >0. 8). Meanwhile, the 3 successful batches achieved removal of COD, ammonia nitrogen, TN, TP with corresponding 28. 6% -48. 5% , 0.4% -48. 5% , 41. 8% -48. 6% , 14. 3% -94. 5% , and the conversion efficiency of TN or TP from DPW to S. platensis reached 12. 1% -98. 5% , 21.2% -83.7% , respectively. High concentration of ammonia nitrogen and insect attack of remaining egg hatching in the pretreated swine waste were the main factors to cause the slow-growing of the 3 batches of S. platensis. Therefore, it is highly necessary for the removal of ammonia nitrogen with biological treatment technology and insect eggs with membrane to achieve a stable high productivity.

[Study on the quality of digested piggery wastewater in large-scale farms in Jiaxing].

Pollution characteristics of digested piggery wastewater (DPW), including not only the chemical oxygen demand (COD), nitrogen and phosphorus but also the veterinary antibiotics and heavy metals, were investigated in ten large-scale pig farms in Jiaxing City. Results showed that the water quality of DPW greatly varied with farms and seasons. DPW in the spring group showed the highest pollutant concentration, with seven of the ten pig farms demonstrating COD of over 2 000 mg x L(-1), total nitrogen and ammonia nitrogen of over 1 000 mg x L(-1) and total phosphorus of over 60 mg x L(-1). Pollutant concentrations of DPW were lower in the autumn and winter groups, while the lowest was observed in the summer group. Unbalanced nutrient was observed in DPW, the carbon nitrogen ratio showed the lowest value of 0.8-4.3 in the autumn group. Four classes (tetracyclines, quinolones, macrolides and sulfonamides) of ten antibiotics and six heavy metals (Cu, Zn, Pb, Cd, Ni and Cr) were detectable in DPW from all the ten farms. Cu and Zn were the top two dominant heavy metals, with an average concentration of 1.88 mg x L(-1) and 7.63 mg L(-1), respectively. Tetracyclines (including Tetracycline, Oxytetracycline and Chlortetracycline) were always the dominant antibiotics. The total concentration of the ten antibiotics was in the range of 10.1 microg x L(-1) to 1090 microg x L(-1), far exceeding the antibiotics limit of 10 ng x L(-1) in the water environment specified by EU. Efficient but low cost treatment technologies are in urgent need in order to deal with the pollution by DPW, a wastewater that is not only difficult to remove nitrogen and phosphorus, but also seriously polluted by heavy metals and antibiotics.