The supplementation of low-P diets with microbial 6-phytase expressed in Aspergillus oryzae increases P and Ca digestibility in growing pigs.

A trial was conducted to evaluate the dose response of a novel microbial 6-phytase expressed in Aspergillus oryzae (Ronozyme HiPhos; DSM Nutritional Products, Basel, Switzerland) in pigs. Forty-eight individually housed pigs (Landrace × Pietrain; 52 kg BW; 24 males and 24 females) were distributed among 6 experimental treatments consisting of a low-P diet (3.5 g P/kg; 1.1 g digestible P/kg), which was supplemented with 500, 1000, 2000, or 4000 units of phytase activity/kg, and a standard-P diet (4.5 g P/kg; 1.8 g digestible P/kg) that was supplemented with CaHPO(4). After 17 d, fresh feces were sampled from all pigs and the apparent total tract digestibility of DM, OM, ash, P, and Ca was measured using TiO(2) as indigestible marker. Blood samples were also obtained from each pig and serum was analyzed for P and Ca concentrations. The nonsupplemented low-P diet increased Ca and reduced P blood serum concentrations (P < 0.05) relative to the standard-P diet (10.8 vs. 10.2 and 6.7 vs. 7.7 mg/dL, respectively). Phytase supplementation of the low-P diet reduced Ca (from 10.8 to 9.9 mg/dL; linear, P < 0.001) and increased P concentrations (from 6.7 to 8.0 mg/dL; linear and quadratic, P < 0.001) in serum and reduced P concentration in feces (from 13.7 to 7.6 g/kg DM; linear and quadratic, P < 0.001). Phytase improved the total tract digestibility of P (from 29.0 to 62.3%; linear and quadratic, P < 0.001 and P < 0.05), Ca (from 54.0 to 75.7%; quadratic, P < 0.01), and ash (from 46.2 to 57.7%; quadratic, P < 0.01). In conclusion, the microbial 6-phytase tested improves the apparent total tract digestibility of P in growing pigs and reduces P excretion in feces in a dose-dependent manner.

The supplementation of low-P diets with microbial 6-phytase expressed in Aspergillus oryzae improves P digestibility in sows.

Two trials were conducted to evaluate a novel microbial 6-phytase expressed in Aspergillus oryzae (Ronozyme HiPhos; DSM Nutritional Products, Basel, Switzerland) in gestating and lactating sows. In the first trial, 24 sows (Duroc × Landrace; 223 kg BW) were offered, at 16 d of gestation, a low-P control diet (formulated to provide 4.0 g total P/kg; 1.5 g digestible P/kg) supplemented with 0, 500, or 1000 phytase activity (FYT)/kg of phytase. Two weeks later, fresh feces were sampled from all sows and the apparent total tract digestibility of P was measured using TiO(2) as indigestible marker. Phytase supplementation did not (P > 0.10) affect the total tract digestibility of P but reduced (P < 0.05) P concentration in feces (from 14.5 to 12.0 and 12.0 g/kg DM). In the second trial, 32 lactating sows (Duroc × Landrace; 282 kg BW) were used. They were offered, at 7 d of lactation, a low-P control diet (formulated to provide 6.1 g total P/kg; 3 g digestible P/kg) or the same diet supplemented with 500 FYT/kg of phytase. After 2 wk, fresh feces were sampled from all sows and the apparent total tract digestibility of P was measured using TiO(2) as indigestible marker. Phytase supplementation improved (P < 0.001) the apparent total tract digestibility of P from 27.5 to 38.7% and reduced (P < 0.001) P concentration in feces (from 27.5 to 21.4 g/kg DM). In conclusion, the microbial 6-phytase tested increased the apparent total tract digestibility of P in sows and reduced P excretion in feces.

The effects of supplementation of a novel bacterial 6-phytase on mineral digestibility and plasma minerals in lactating sows.

Pigs digest P in plant feedstuffs poorly because pigs do not produce sufficient endogenous phytase to hydrolyze P from phytate (inositol hexaphosphate). Supplementation of phytase to diets of piglets and grower-finisher pigs increased digestibility of minerals including P and Ca; however, data on phytase efficacy in lactating sows are scarce. Therefore, effects of adding a bacterial 6-phytase expressed in a strain of Aspergillus oryzae (Ronozyme HiPhos; DSM Nutritional Products, Basel, Switzerland) on apparent total tract digestibility (ATTD) of P and Ca was assessed in 45 lactating sows. Three diets were prepared: (i) positive control (PC; 0.52% available P), a regular sow diet containing inorganic P, (ii) negative control (NC; 0.20% available P) without inorganic P, and (iii) NC + 500 units of phytase/kg diet. Each diet was fed randomly to 15 sows for 21 d (from 5 d prior to farrowing to 15 d after farrowing). At day 15 after farrowing, ATTD of P did not differ between PC and NC. Phytase supplementation to NC increased (P < 0.05) ATTD of P from 34 to 46% compared to NC but did not affect (P > 0.05) ATTD of CP and Ca. On day 1 after farrowing, plasma P was 0.66 mmol/L lower (P < 0.05) in sows fed NC than PC. Phytase supplementation to NC increased (P < 0.05) plasma P by 0.40 mmol/L on day 1 but not on day 15 after farrowing. In conclusion, phytase supplementation increased P bioavailability in lactating sows.

Effects of a mono-component endo-xylanase supplementation on the nutritive value of wheat-based broiler diets.

1. Two trials were conducted to evaluate the effects of a mono-component thermostable endo-1,4-ß-xylanase derived from Thermomyces lanuginosus on the nutritive value of wheat-based broiler diets. In a 5-week growth trial, the efficacy of xylanase supplementation at 0, 100, 150, 200, 400 and 4000 FXU/kg diet was evaluated. A short-term balance trial was carried out according to a 4 × 2 factorial arrangement of treatments, involving 4 wheat cultivars and endo-xylanase at 0 or 200 FXU/kg. 2. In the growth trial, enzyme supplementation from 0 to 400 FXU/kg reduced feed intake and improved feed conversion linearly. Digesta viscosity was significantly reduced by all enzyme inclusion levels by 49·6-56·9%, in a quadratic manner. 3. In the balance trial, xylanase supplementation resulted in a significant improvement of protein, lipid and dry matter apparent digestibility coefficients of diets, accompanied by improved dietary AME(N) values. There was a significant wheat × enzyme interaction on AME(N) and lipid digestibility. There was a significant effect of wheat cultivar on dry matter digestibility.

Influence of benzoic acid and phytase in low-phosphorus diets on bone characteristics in growing-finishing pigs.

In 2 simultaneous experiments (Exp. 1 and Exp. 2), the effects of benzoic acid (BA) and phytase (Phy) in low-P diets on bone metabolism, bone composition, and bone stability in growing and growing-finishing pigs were examined. Experiment 1 was conducted with 16 crossbred gilts in the BW range of 25 to 66 kg of BW, whereas in Exp. 2, 32 crossbred gilts (25 to 108 kg of BW) were used. All pigs were individually housed in pens and restrictively fed 1 of 4 diets throughout the experiment. Total P content of the wheat-soybean diets was 4 g/kg (all values on an as-fed basis). The experimental diets were 1) unsupplemented control diet; 2) control diet with 0.5% BA; 3) Phy diet with 750 Phy units (FTU) of Phy/kg and no BA; and 4) PhyBA, control diet with 750 FTU of Phy/kg and 0.5% BA. Blood samples were taken at the beginning of the experiment, wk 3 (only for pigs in Exp. 1), wk 6, and before slaughter to determine P and Ca in serum and concentrations of total alkaline phosphatase, serum crosslaps (marker for bone resorption), and osteocalcin (marker for bone formation). Ash, P, and Ca contents of bones and bone stability were examined using the left metatarsal bones and tibia of the pigs after slaughter. Benzoic acid did not influence any of the blood variables (P > 0.09). The addition of Phy increased (P < or =0.03) P concentration in serum from 2.71 +/- 0.08 to 3.03 +/- 0.07 mmol/L at wk 3 and content of serum crosslaps from 0.39 +/- 0.02 to 0.45 +/- 0.02 ng/mL at wk 6 and decreased (P < 0.05) osteocalcin at wk 6 by 160 ng/mL. No long-term effect of diets on serum mineral concentrations, alkaline phosphatase, and bone markers in serum could be detected. Benzoic acid negatively affected (P < or = 0.03) Ca content in bones and distal bone mineral density, especially in the younger pigs. In the control diet with 0.5% BA and the control diet with 750 FTU of Phy/kg and 0.5% BA, the CA content in bones and distal bone mineral density were reduced by 6 and 11%, respectively. Throughout the whole growing and finishing period, Phy increased (P < or =0.02) ash, P, and Ca contents in bones by 29.4, 4.8, and 11.6 g/kg of DM, respectively. Bone mineral density and bone mineral content were greater in diets with Phy (P < or = 0.03), as well as breaking strength of tibia (+22%) and metatarsal bones (+27%; P < 0.01). The results of this study indicate that for a healthy skeleton, BA should not be used in low-P diets without the addition of Phy.

Effect of benzoic acid on growth performance, nutrient digestibility, nitrogen balance, gastrointestinal microflora and parameters of microbial metabolism in piglets.

In order to investigate the effects of benzoic acid on growth performance, nutrient digestibility, nitrogen balance and gastrointestinal microflora of piglets, we conducted a performance experiment and a separate balance study. The performance experiment involved four different dietary treatments: (1) basal diet (negative control); (2) basal diet supplemented with benzoic acid at 5 g/kg; (3) basal diet supplemented with benzoic acid at 10 g/kg; (4) basal diet supplemented with potassium diformate at 12 g/kg. Each dietary treatment was assigned to nine replicate groups, each consisting of two piglets. Live weight, daily weight gain, feed intake and feed conversion ratio were monitored as performance parameters over a 35-day period. Supplementation of the diet with benzoic acid resulted in a dose-dependent increase in feed intake and body weight gain and an improved feed conversion ratio. Piglets fed the diet supplemented with benzoic acid at 10 g/kg outperformed the control piglets in mean feed intake, body weight gain and feed conversion ratio by 9%, 15% and 6% respectively. Growth performance of the piglets fed the diet with benzoic acid at 10 g/kg was similar to that of piglets fed the diet supplemented with potassium diformate. In the balance experiment three groups of six piglets each were fed either a control diet or diets supplemented with benzoic acid at 5 or 10 g/kg respectively. Benzoic acid did not significantly affect nutrient digestibility but increased nitrogen retention. Piglets fed the diets supplemented with benzoic acid at 5 or 10 g/kg retained 5% and 6% more nitrogen, respectively, than control piglets. Supplementation of benzoic acid did not influence the pH value or the concentration of ammonia in the gastrointestinal tract but reduced the number of bacteria in the digesta. In the stomach the number of total aerobic, total anaerobic, lactic acid forming and gram-negative bacteria was reduced; in the duodenum the presence of benzoic acid reduced the number of gram-negative bacteria and in the ileum the number of total aerobic bacteria in a dose-dependent manner. Benzoic acid also considerably reduced the concentration of acetic acid in the duodenum. In conclusion, the data of this study suggest that benzoic acid exerts strong antimicrobial effects in the gastrointestinal tract of piglets and therefore enhances growth performance and nitrogen retention.

Effects of an experimental phytase on performance, egg quality, tibia ash content and phosphorus bioavailability in laying hens fed on maize- or barley-based diets.

A 24-week performance trial was conducted to evaluate the efficacy of an experimental phytase on performance, egg quality, tibia ash content and phosphorus excretion in laying hens fed on either a maize- or a barley-based diet. At the end of the trial, an ileal absorption assay was conducted in order to determine the influence of phytase supplementation on the apparent absorption of calcium and total phosphorus (P). Each experimental diet was formulated either as a positive control containing 3.2 g/kg non-phytate phosphorus (NPP), with the addition of dicalcium phosphate (DCP), or as a low P one, without DCP addition. Both low P diets (containing 1.3 or 1.1 g/kg NPP) were supplemented with microbial phytase at 0, 150, 300 and 450 U/kg. The birds were housed in cages, allocating two hens per cage as the experimental unit. Each of 10 dietary treatments was assigned to 16 replicates. Low dietary NPP (below 1.3 g/kg) was not able to support optimum performance of hens during the laying cycle (from 22 to 46 weeks of age), either in maize or barley diets. Rate of lay, daily egg mass output, feed consumption, tibia ash percentage and weight gain were reduced in hens fed low NPP diets. The adverse effects of a low P diet were more severe in hens on a maize diet than in those on a barley diet. Low dietary NPP reduced egg production, weight gain, feed consumption and tibia ash content and microbial phytase supplementation improved these parameters. Hens given low NPP diets supplemented with phytase performed as well as the hens on positive control diets containing 3.2 g/kg of NPP. A 49% reduction of excreta P content was achieved by feeding hens on low NPP diets supplemented with phytase, without compromising performance. Phytase addition to low NPP diets increased total phosphorus absorption at the ileal level, from 0.25 to 0.51 in the maize diet and from 0.34 to 0.58 in the barley diet. Phosphorus absorption increased linearly with increasing levels of dietary phytase. Mean phosphorus absorption was higher in barley diets than in maize diets (0.49 vs 0.39).

Effect of food enzymes on utilisation of lupin carbohydrates by broilers.

1. The effects of 3 commercial enzyme products on the nutritive value of 2 lupin species were investigated with the emphasis on changes in composition of non-starch polysaccharides (NSPs) along the digestive tract. Enzyme A contained primarily cellulase, beta-glucanase and xylanase activities, enzyme B primarily hemicellulase, pentosanase and xylanase activities, and enzyme C primarily hemicellulase, pectinase and beta-glucanase activities. 2. The enzymes were added to semi-purified diets based on sorghum and casein containing 35% whole seed lupins (Lupinus angustifolius cv Gungurru or Lupinus albus cv Kiev mutant). Control diets contained no lupins. 3. Food conversion ratio (FCR), excreta moisture content and apparent metabolisable energy (AME) were affected by lupin species but not by enzyme supplementation. 4. In diets with L. angustifolius, enzyme C significantly increased digesta viscosity and increased the concentration of soluble NSPs in all sections of the intestine. 5. Digestibility of protein and NSPs in the ileum and microbial fermentation in the ileum and caeca were not affected by adding enzymes to diets containing L. angustifolius. 6. Enzyme addition to diets with L. albus did not affect digesta viscosity nor concentration of soluble NSPs but caused a significantly (P<0.05) reduced concentration of insoluble NSP in the ileum. 7. Enzyme addition to L. albus significantly (P<0.05) increased NSP digestibility in the ileum but had no effects on protein digestibility and fermentation in the ileum and caeca.

The effects of enzyme addition to broiler diets containing high concentrations of canola or sunflower meal.

The effects of two commercial enzyme products on the nutritive value of canola meal (CM) and sunflower meal (SFM) were determined in a classical AME bioassay with special emphasis on the utilization of nonstarch polysaccharides (NSP). The enzymes were added to semi-purified broiler grower diets based on corn and casein containing 35% CM or 35% SFM, respectively. Feed intake, growth, and AME of the diets were significantly (P < 0.001) affected by type of oilseed meal included in the diet. Birds fed the SFM-based diets had a significantly (P < 0.001) higher growth rate and AME and a lower feed conversion ratio (FCR) than did birds fed the CM-based diets. The addition of enzymes to either CM- or SFM-based diets had no significant effects on growth performance and AME; however, the addition of enzymes to CM-based diets resulted in a significant reduction in the concentration of soluble NSP in the jejunum (Enzyme A) or a significant reduction of total NSP in the jejunum (Enzyme B). The AMEn was significantly lower in diets containing CM supplemented with Enzyme B. The addition of enzymes to SFM-based diets significantly improved NSP digestion in the jejunum and protein digestion in the ileum. The results of this study indicate that commercial enzyme products had some effects in diets containing high concentrations of CM or SFM. However, these effects could only be seen after detailed analyses of feed and digesta and did not result in significant improvement in growth performance of broilers.

Effects of supplemental phytase on performance and phosphorus utilisation in broiler chickens fed a low phosphorus diet without addition of inorganic phosphates.

1. Three experiments were conducted to evaluate the effects of the dietary addition of fungal phytase (derived from Aspergillus niger) on the performance and phosphorus utilisation in broiler chickens receiving low phosphorus diets without additional inorganic phosphates. 2. Graded amounts of supplemental phytase (125, 250, or 500 PU/kg diet) resulted in significant increases in both growth rate and food intake. However, only moderate improvements in food conversion were noted. 3. The enhancement of chick performance was related to an improved utilisation of dietary phosphorus, as confirmed by significantly elevated plasma concentrations of inorganic phosphorus and increased tibia ash percentages in birds receiving phytase-treated diets. The apparent availability of phosphorus was markedly improved and its concentration in excreta was reduced (experiment 1, P < 0.05). 4. It was concluded that an inclusion of phytase into practical broiler diet will allow the reduction or omission of additional dietary inorganic phosphorus.

Influence of dietary citric acid and calcium on the bioavailability of orally administered chlortetracycline in piglets.

In a study involving 18 piglets divided into three groups (A, B and C), the effects of dietary calcium and citric acid, and feeding technique on chlortetracycline bioavailability were examined. Groups of 6 animals received a basal diet with either 0.7% (group A) or 1.4% calcium (groups B and C). Citric acid was not included in diets of the first experimental period. In the second period, either 1.5% (groups A and B) or 3.0% (group C) citric acid was added to the diet. In both experimental periods, chlortetracycline was administered once intravenously (7.5 mg/kg b.w.) and once orally (30 mg/kg b.w.). After each administration, blood samples were taken at regular intervals in order to determine chlortetracycline serum concentrations by a microbiological method. Following oral chlortetracycline intake, low dietary calcium or citric acid addition to the diet produced increased chlortetracycline serum concentrations. Chlortetracycline bioavailability was 12.6% at 0.7% dietary calcium, and 9.5% at 1.4% dietary calcium. Enteral chlortetracycline absorption was improved 65% with 1.5% or 3.0% dietary citric acid supplementation. An 8-hour delay of feed intake following oral chlortetracycline intake did not significantly influence chlortetracycline bioavailability.

Incompatibility between lasalocid and chloramphenicol in broiler chicks after a long-term simultaneous administration.

Two growth experiments were conducted to evaluate in broiler chicks the compatibility between lasalocid medication in the feed (at 90 or 125 ppm) and a long-term administration of chloramphenicol either via the feed (500 ppm) or via the drinking water (500 mg/liter). The simultaneous administration of lasalocid and chloramphenicol generally caused severe growth depression, decreased feed intake and impaired feed conversion. Several chicks showed evident symptoms of intoxication, such as ataxia, leg weakness and paralysis. The development and frequency of these symptoms were dependent on the dosage of lasalocid and on the duration of the simultaneous administration. Biochemical examinations (Experiment 2) revealed in the affected chicks significant changes in several parameters, in particular a markedly increased activity of creatine kinase and GOT in the plasma. It confirmed that the observed leg weakness and paralysis were caused by myodegeneration.

Relationships between vitamin A and vitamin E in the chick.

Plasma levels of vitamins A and E were analysed during the dietary administration of two levels of vitamin A (10 000 or 50 000 IU/kg) in combination with four levels of supplemental vitamin E (0, 50, 100, or 150 mg/kg) and with or without a supplement of oil to the diet. Tocopherol levels in plasma were markedly decreased by the higher vitamin A supplementation. In contrast, the various vitamin E intakes had no influence on plasma retinol levels. The addition of oil to the diet did not affect this interaction. The absorption, distribution and elimination of labeled 3H-dl-alpha-tocopheryl acetate after an oral or intravenous administration, in combination with a high oral dose of vitamin A (100 000 IU/chick), were studied. The high oral single dose of vitamin A reduced the levels of radioactivity in all the analysed tissues and organs, when both vitamins were administered orally. However, vitamin A did not affect distribution and elimination of radioactivity, when an interaction in the gastro-intestinal tract was avoided by different routes of administration.