Enhancing bauxite residue properties for plant growth: Gypsum and organic amendment effects on chemical properties of soil and leachate.

Here, we assess the effects of gypsum and local organic waste as amendments to non-weathered, filter-pressed bauxite residue (BR) to improve its properties and support plant growth. In addition, we monitored the leachate quality of the amended BR under progressive leaching that simulated precipitation conditions in Northern Brazil. Free-draining column tests consisting of BR amended with gypsum and organic waste, at 5% and 10% w/w, respectively, were leached for 8 weeks to assess the effects on the chemical composition of BR and the leachates. Adding gypsum to BR reduced the exchangeable sodium (Na) percentage (ESP) from approximately 79%-48%, whereas adding only organic waste had smaller effects on ESP (from ∼79% to âˆ¼ 70%). The mean leachate pH ranged from 8.7 to 9.4 for the gypsum, and organic waste amended BR, while this was 10.3 in the leachate of the unamended BR. The treatments had similar trends of electrical conductivity throughout the experiments and were below 2 dS/cm after 8 weeks, when ∼1.700 mm simulated precipitation had leached. Aluminium (Al), Arsenic (As), and Vanadium (V) concentrations in leachates of BR with gypsum, either alone or in combination with organic waste, were significantly lowered than in leachate of non-amended BR. By contrast, metal concentrations increased if organic waste was added to BR. We conclude that amending BR with gypsum, in combination with organic waste, significantly improves the chemical properties of the solid phase and achieved rehabilitation goals for SAR and EC of the leachates after 8 weeks of leaching. However, despite high leaching rates, rehabilitation goals for pH and ESP were not achieved with gypsum either alone or combined with organic waste.

An Investigation into the Growth of Lolium perenne L. and Soil Properties Following Soil Amendment with Phosphorus-Saturated Bauxite Residue.

Reuse options for bauxite residue include treatment of phosphorus (P)-enriched wastewaters where the P-saturated media offers fertiliser potential. However, few studies have assessed the impact on soil properties. Two types of spent P-saturated bauxite residue were applied to soil and compared to conventional superphosphate fertiliser as well as a control soil. Soil physico-chemical properties, worm Eisenia fetida L. choice tests, and Lolium perenne L. growth and elemental uptake were examined. Comparable biomass and plant content for L. perenne in the P-saturated bauxite residue treatments and those receiving superphosphate, indicated no phytotoxic effects. E. fetida L. showed a significant preference for the control soil (58 %± 2.1%) over the amended soils, indicating some form of salt stress. Overall, P-saturated bauxite residue was comparable to the superphosphate fertiliser in terms of the plant performance and soil properties, indicating the potential recycling of P from wastewaters using bauxite residue as a low-cost adsorbent.

Plant available Al and Na in rehabilitated bauxite residue: a field study assessment.

Bauxite residue is a high volume by-product generated during the extraction of alumina from bauxite ore (Bayer process). The long-term containment of residue is associated with environmental risks due to potential dusting and surface run-off. While rehabilitation of residue is viewed as a suitable approach for minimizing this risk, there is need for completion criteria. In particular, elevated sodium and aluminium are cited as inhibitory to plant growth and guideline values for satisfactory exchangeable sodium percentage (ESP) vary. Further, there is little information on the efficiency of standard soil assessment techniques in predicting plant available amounts of Al and Na for rehabilitated residue. This work aimed to evaluate the efficiency of soil extractants (NH4OAC and NH4Cl for cation; KCl for Al) for determining cation and Al content in field rehabilitated bauxite residue after 1 and 8 years. Depending on the method used, the ESP of residue varied significantly, and all were above the standard guideline values. Successful establishment of Holcus lanatus L. (Yorkshire fog) over 8 years together with absence of nutrient deficiency or elevated uptake of Na and Al indicates that the proposed ESP target of < 9.5 is both stringent and difficult to achieve under field conditions. Findings indicate that at ESP of ca. 20% (determined using NH4OAc) and 30-40% (using NH4Cl) may be more realistic target values for establishing vegetation in rehabilitated bauxite residue.

Exposure of earthworm (Eisenia fetida) to bauxite residue: Implications for future rehabilitation programmes.

Bauxite residue is typically alkaline, has high sodium content and elevated concentrations of trace elements. Effective rehabilitation strategies are needed to mitigate potential environmental risks from its disposal and storage. Increasingly, the importance of viable soil faunal populations as well as establishment of vegetation covers is recognized as key components of successful rehabilitation. Inoculation with earthworms is a strategy for accelerating mine site rehabilitation, but little is known on the effects of bauxite residue properties on earthworm survival and viability. In the current study, earthworms (Eisenia fetida) were exposed for 28 days to a series of bauxite residue/soil treatments (0, 10, 25, 35, 50, 75 and 100% residue) to evaluate possible toxic effects on earthworms, investigate the bioavailability of relevant elements (e.g. As, Cr, V), and assess the risk of element transfer. Results showed that soil containing ≥25% residue (pH ≥ 9.8; ESP ≥ 18.5%; extractable Na ≥ 1122 mg/kg) significantly impacted survival (mortality ≥28%) and reproduction (cocoon production inhibition ≥76%) of the exposed earthworms. Alkalinity, sodicity and bioavailable Na were identified as major factors causing toxicity and some earthworms were observed to adopt compensative response (i.e. swollen body) to cope with osmotic stress. Conversely, soil containing 10% residue (pH = 9.1; ESP = 9.2%; extractable Na = 472 mg/kg) did not elicit significant toxicity at the organism level, but biomarker analysis (i.e. superoxide dismutase and catalase) in earthworm coelomocytes showed an oxidative stress. Furthermore, earthworms exposed to soil containing ≥10% residue took up and accumulated elevated concentrations of Al, As, Cr and V in comparison to the control earthworms. We concluded that earthworm inoculation could be used in future rehabilitation programmes once the key parameters responsible for toxicity are lowered below specific target values (i.e. pH = 9.1, ESP = 18.5%, extractable Na = 1122 mg/kg for Eisenia fetida). Nonetheless, trace element uptake in earthworms should be regularly monitored and the risk to the food chain further investigated.

Ecotoxicological risk assessment of revegetated bauxite residue: Implications for future rehabilitation programmes.

Around 3 billion tonnes of bauxite residue (BR), the by-product of alumina extraction, have been produced and stockpiled worldwide, representing a potential risk for the environment due to the high alkalinity and the presence of relatively high concentrations of trace elements. Phytoremediation (or simply revegetation) is regarded as the most promising in situ remediation option to mitigate the environmental risk that might arise from the land-disposal of BR. Rehabilitation strategies (including the incorporation of amendments such as gypsum and organic matter) have been employed to address the main limitations to plant establishment and growth on BR, typically the high alkalinity, salinity and sodicity. However, the potential for trace element uptake and phytotoxicity have been largely unreported in revegetated BRs. In order to assess the ecotoxicological risk, samples of previously revegetated BR were collected from the field, characterized in the laboratory, and used to conduct ex-situ plant bioassays (Phytotoxkit™ and the RHIZOtest). Without rehabilitation, fresh BR severely inhibits seed germinationand root/shoot development in test species Lepidium sativum, Sinapis alba and Sorghum saccharatum. Plant uptake for Al, As, Cr, V was assessed with RHIZOtest bioassay trials with Lolium perenne and demonstrated that plants exposed to fresh BR take up and translocated trace elements to their shoots at concentrations (As = 4.13 mg/kg dm; Cr = 3.29 mg/kg dm; V = 85.66 mg/kg dm) exceeding phytotoxic levels (vanadium) or maximum levels specified for animal feed (arsenic), showing visible stress symptoms in the seedlings. Conversely, revegetated BR show improved chemical properties, allow seed germination, and permits seedling growth with no evidence of trace element phytotoxicity. However, Na can be taken up at concentrations that could elicit phytotoxicity and impair the success of revegetation. For future rehabilitation programmes, direct revegetation on BR after the incorporation of amendments such as gypsum and organic matter is recommended.

Soil properties and earthworm populations associated with bauxite residue rehabilitation strategies.

It is recognised that the establishment and function of soil biota is critical for successful mine residue rehabilitation. Bauxite residues are alkaline, saline and sodic and, whilst methods for establishing vegetation are well studied, little is known about key soil fauna such as earthworms. At a bauxite residue disposal area in Ireland, a 12-year-old rehabilitated residue was examined for evidence of earthworm populations. Five species of earthworm, dominated by Allolobophora chlorotica, were recorded in the rehabilitated residue representing the endogeic, epigeic and epi-anecic ecological groups. To further understand the potential for rehabilitated residues to support earthworm communities, a series of exposure tests was conducted. Whilst unamended residues (pH 10.2, EC 0.629 mS cm-1, ESP 54) was hostile to A. chlorotica survival, 100% survival was observed after 90 days for gypsum and organic-amended residue at salinity of up to 2.9 mS cm-1, possibly due to calcium becoming the dominant cation. Survival of earthworms at salinities higher than anticipated tolerance levels suggests that specific ion dominance plays a role in earthworm survival in saline soils. Percent mass change was negatively correlated with pH, EC and sodium content of the residues. Residue from the 12-year-old site also supported the anecic species Aporrectodea longa over 100 days. Percent mass change in residue samples retrieved from the 12-year-old site was significantly greater (p < 0.05) to that observed for a control soil. Capability of the rehabilitated residue to support earthworm populations indicates the development of a functioning soil system in rehabilitated residues.

The use of rapid, small-scale column tests to determine the efficiency of bauxite residue as a low-cost adsorbent in the removal of dissolved reactive phosphorus from agricultural waters.

Bauxite residue, the by-product produced in the alumina industry, is a potential low-cost adsorbent in the removal of phosphorus (P) from aqueous solution, due to its high composition of residual iron oxides such as hematite. Several studies have investigated the performance of bauxite residue in removing P; however, the majority have involved the use of laboratory "batch" tests, which may not accurately estimate its actual performance in filter systems. This study investigated the use of rapid, small-scale column tests to predict the dissolved reactive phosphorus (DRP) removal capacity of bauxite residue when treating two agricultural waters of low (forest run-off) and high (dairy soiled water) phosphorus content. Bauxite residue was successful in the removal of DRP from both waters, but was more efficient in treating the forest run-off. The estimated service time of the column media, based on the largest column studied, was 1.08 min g-1 media for the forest run-off and 0.28 min g-1 media for the dairy soiled water, before initial breakthrough time, which was taken to be when the column effluent reached approximately 5% of the influent concentration, occurred. Metal(loid) leaching from the bauxite residue, examined using ICP-OES, indicated that aluminium and iron were the dominant metals present in the treated effluent, both of which were above the EPA parametric values (0.2 mg L-1 for both Al and Fe) for drinking water.

The potential for constructed wetland mechanisms to treat alkaline bauxite residue leachate: carbonation and precipitate characterisation.

Leachates emanating from bauxite residue disposal areas are alkaline and require neutralisation prior to discharge. The use of passive technologies such as constructed wetlands has received increasing interest as possible treatments for alkaline leachates, including bauxite residues. Mechanisms proposed for wetland effectiveness have included calcite precipitation but it is not clear if such a pathway is feasible in the relatively low Ca residue leachates. Carbonation of Ca-spiked residue leachate treatments was conducted to observe rates of pH decrease and precipitate formation. For all treatments, carbonation effectively decreased pH to ca. 10.5 which remained stable following aeration. Decreases in Al content of 83-93% were also observed. Precipitates retrieved from carbonation experiments and from a constructed wetland trial were characterised using XRD, SEM, XPS and EDX. Calcium carbonates formed in Ca-spiked treatments and dawsonite precipitation occur in the absence of Ca. Rinsing of precipitates removes surface calcium indicating soluble forms adsorbed on precipitates. The results demonstrate that carbonation of bauxite residue leachate is an important component of passive treatments and neutralisation.

Sustained Bauxite Residue Rehabilitation with Gypsum and Organic Matter 16 years after Initial Treatment.

Bauxite residue is a high volume byproduct of alumina manufacture which is commonly disposed of in purpose-built bauxite residue disposal areas (BRDAs). Natural waters interacting with bauxite residue are characteristically highly alkaline, and have elevated concentrations of Na, Al, and other trace metals. Rehabilitation of BRDAs is therefore often costly and resource/infrastructure intensive. Data is presented from three neighboring plots of bauxite residue that was deposited 20 years ago. One plot was amended 16 years ago with process sand, organic matter, gypsum, and seeded (fully treated), another plot was amended 16 years ago with process sand, organic matter, and seeded (partially treated), and a third plot was left untreated. These surface treatments lower alkalinity and salinity, and thus produce a substrate more suitable for biological colonisation from seeding. The reduction of pH leads to much lower Al, V, and As mobility in the actively treated residue and the beneficial effects of treatment extend passively 20-30 cm below the depth of the original amendment. These positive rehabilitation effects are maintained after 2 decades due to the presence of an active and resilient biological community. This treatment may provide a lower cost solution to BRDA end of use closure plans and orphaned BRDA rehabilitation.

Plant assays and avoidance tests with collembola and earthworms demonstrate rehabilitation success in bauxite residue.

Bauxite residues are a by-product of alumina manufacture from bauxite ore and are commonly disposed of in purpose-built bauxite residue disposal areas (BRDAs). Revegetation is viewed as the most effective way to landscape and rehabilitate closed BRDAS and physicochemical assessment remains the primary indicator of rehabilitation success. Little is known about the ability of keystone mesofaunal species to colonise and establish in these environments yet the long-term success of rehabilitation is dependent on residues becoming suitable habitats for such groups. Using six different residue treatments (untreated, leached, organic application, organic amended, and two revegetated field treatments) together with OECD test soil, this study assessed the characteristics of residues with plant germination and seedling development using the Rhizotest™ approach with Lepidium sativum, Sinapis alba, and Sorghum bicolor. Avoidance tests with soil mesofauna Eisenia foetida together with growth and reproduction tests for Folsomia candida were conducted to determine possibility of inhibition in residue soils. Unamended residue is inhibitory to plant growth and mesofaunal establishment. Amendment improves the physicochemical properties of the residue, and data revealed that both gypsum and organic addition is required to promote conditions favourable to plant growth and mesofauna establishment. Earthworms avoid residues with elevated Na content but will choose substrate with high soluble Ca content. F. candida preferentially moves to residues from field treatments, and both mortality and reproduction rates are comparable or superior to OECD soil. On the basis of these assays, we propose that bauxite residue can be transformed to a soil-like medium capable of supporting keystone species.

Effectiveness of a constructed wetland for treating alkaline bauxite residue leachate: a 1-year field study.

Increasing volumes of bauxite residues and their associated leachates represent a significant environmental challenge to the alumina industry. Constructed wetlands have been proposed as a potential approach for leachate treatment, but there is limited data on field-scale applications. The research presented here provides preliminary evaluation of a purpose-built constructed wetland to buffer leachate from a bauxite residue disposal site in Ireland. Data collected over a 1-year period demonstrated that the pH of bauxite residue leachates could be effectively reduced from ca. pH 10.3 to 8.1 but was influenced by influent variability and temporal changes. The wetland was also effective in decreasing elemental loading, and sequential extractions suggested that the bulk of the sediment-bound metal inventory was in hard-to-leach phases. Elemental analysis of Phragmites australis showed that although vegetation displayed seasonal variation, no trace elements were at concentrations of concern.

Bacterial communities established in bauxite residues with different restoration histories.

Bauxite residue is the alkaline byproduct generated when alumina is extracted from bauxite ores and is commonly deposited in impoundments. These sites represent hostile environments with increased salinity and alkalinity and little prospect of revegetation when left untreated. This study reports the establishment of bacterial communities in bauxite residues with and without restoration amendments (compost and gypsum addition, revegetation) in samples taken in 2009 and 2011 from 0 to 10 cm depth. DNA fingerprint analysis of bacterial communities based on 16S rRNA gene fragments revealed a significant separation of the untreated site and the amended sites in both sampling years. 16S amplicon analysis (454 FLX pyrosequencing) revealed significantly lower alpha diversities in the unamended in comparison to the amended sites and hierarchical clustering separated the unamended site from the amended sites. The taxonomic analysis revealed that the restoration resulted in the accumulation of bacterial populations typical for soils including Acidobacteriaceae, Nitrosomonadaceae, and Caulobacteraceae. In contrast, the unamended site was dominated by taxonomic groups including Beijerinckiaceae, Xanthomonadaceae, Acetobacteraceae, and Chitinophagaceae, repeatedly associated with alkaline salt lakes and sediments. While bacterial communities developed in the initially sterile bauxite residue, only the restoration treatments created diverse soil-like bacterial communities alongside diverse vegetation on the surface.