Chemical and ecotoxicological indicators for evaluating the treatment of coal mining wastes.

This paper consists of the evaluation in regards to the ecotoxicological effectiveness of a treatment applied to a coal mining waste. The treatment consisted of separating the particles based on gravimetric concentration in spirals, generating three fractions: heavy, intermediate, and light, with high, moderate, and low pyrite content, respectively. The intermediate fraction represents the larger disposal volume of the waste on soils. To evaluate the effectiveness of the treatment, metal determination and bioassays Eisenia andrei, Folsomia candida, Lactuca sativa, Daphnia similis, and Raphidocelis subcapitata were applied to the intermediary fraction. To evaluate the toxicity to aquatic organisms, elutriates were generated from the unprocessed waste and the intermediate fraction. The intermediate fraction showed a decrease of metal concentrations compared to the untreated waste. Metal concentrations in the intermediate fraction were below the Brazilian thresholds for soil quality. Avoidance bioassay with E. andrei and germination tests of L. sativa showed no significant effects. The bioassay with F. candida indicated a significant reduction in reproduction at the highest doses used (24% and 50%). Bioassays with D. similis and R. subcapitata revealed a reduction in toxicity of the intermediate fraction compared to the untreated waste. However, the toxicity levels of the intermediate fraction to aquatic organisms still require attention, especially in regards to pH that played a crucial role in the toxicity. Finally, the results suggest that the treatment performed on the coal waste was efficient, even though significant toxicity have still been detected in the treated waste and additional steps are still required for adequate final disposal.

Ecotoxicological assessment of bauxite residue (red mud) overflow treated by dissolved air flotation (DAF).

In this study, the effluent from the Bayer process of transforming bauxite into alumina, followed by dissolved air flotation (DAF) treatment, was evaluated to identify the best experimental conditions that generate less toxic or nontoxic effluent for discharge. Two freshwater organisms, the Chlorophyceae microalga Raphidocelis subcapitata (96-h algal growth inhibition test), and the microcrustacean Daphnia similis (48-h acute immobility test), were used to analyze the efficiency of effluent treatment by detecting and comparing the toxicity of the treated effluent. Experimental factorial planning used different concentrations of the coagulant ferric chloride and the flocculant Nalco® N-99-005B, and different recycle ratios. The highest recycle ratio (30%) and highest flocculant concentration (150 mg/L) had the best solids removal efficiency, above 90%. Probably the higher concentration of flocculant led to the formation of a more stable froth, promoting an increase in the hydrophobic characteristics of the flocs. Two operating conditions were satisfactory according to acute and chronic bioassays, with removal efficiencies of total suspended solids and turbidity higher than 98%, for both variables. Producers, R. subcapitata microalga, were more sensitive than the primary consumers, D. similis microcrustaceans, indicating the importance of performing tests with different bioindicators.