Effect of methionine chelated Zn and Mn and corn particle size on Large White male turkey live performance and carcass yields.

Most turkey research has been conducted with a regular corn particle size set through phase-feeding programs. This study's first objective was to determine the effect of increasing corn particle size through the feed phases on performance, processing yield, and feed milling energy usage in Large White commercial male turkey production. Zinc (Zn) and manganese (Mn) are essential microminerals for animals' healthy growth. The source in which these elements are supplied to the bird will determine their bioavailability, effect on bird growth, and subsequent environmental impact. This study's second objective was to measure both inorganic and chelated Zn and Mn sources on turkey performance, turkey carcass processing yields, and subsequent litter residues. Twelve hundred Nicolas Select male poults were randomly assigned to 48 concrete; litter-covered floor pens. The experimental design was a completely randomized block design with a 2 × 2 factorial arrangement of 2 sources of minerals (organic blend vs. inorganic) formulated to match breeder recommendations and 2 types of corn mean particle size (coarse corn [1,000-3,500 µm] vs. fine corn [276 µm]). The ASABE S319.4 standard was used to measure corn mean particle size. Bird performance, carcass processing yield, litter content of Zn and Mn, and pellet mill energy consumption were analyzed in SAS 9.4 in a mixed model. There was a reduction of pellet mill energy usage of 36% when coarse corn was added post-pelleting. Birds fed increasing coarse corn mean particle size were 250 g lighter on average in body weight (BW) than birds fed a constant control mean particle size. No difference was found in feed intake (FI) or feed conversion ratio (FCR). Birds fed methionine chelated Zn and Mn blended with inorganic mineral sources were 250 g heavier on average than birds fed only an inorganic source of minerals. In addition, feeding an organic blend of Zn and Mn resulted in greater breast meat yield. Litter from birds fed the control corn mean particle size, and inorganic minerals had a higher concentration of Zn in the litter but were not different when the chelated Zn/Mn were fed. In conclusion, increasing the corn mean particle size and adding it post pellet could save money during feed milling; however, birds might have a slightly lower BW. A combination of inorganic and chelated Zn and Mn may improve performance and increase total breast meat yields.

Feeding low dietary levels of organic trace minerals improves broiler performance and reduces excretion of minerals in litter.

1. This experiment was conducted to evaluate the effect of organic and inorganic trace minerals in diets fed to 1872, one-day-old male Ross 708 broiler chicks. Two sources of supplemental trace minerals (inorganic or organic) and four trace minerals levels (12.5%, 25.0%, 37.5% or 50.0%) plus a positive control containing inorganic minerals at 100% of recommended levels according to Brazilian industry standards, were used in the diets. 2. When analysed with mineral source as the main factor, broilers fed diets containing organic minerals had better feed conversion (FCR) throughout the trial, until 48 d of age (1.754 organic vs. 1.783 inorganic; P < 0.05), improved liveability at 48 d (95.8% organic vs. 93.6% inorganic; P < 0.05) and higher weight gain at 48 d (3.941 kg organic vs. 3.881 kg inorganic; P < 0.05) compared to the inorganic trace mineral diets. At lower dietary inclusion levels (12.5% and 25%) the organic mineral-fed birds had a four-point improvement in FCR (P < 0.05). 3. Feeding organic minerals improved tibial ash at 48 d from 49.5% to 51.25% (P < 0.05). The P and Ca in the tibia at 48 d were significantly (P < 0.05) higher for the birds fed organic minerals (Ca: 17.4% vs. 18.7%; P: 8.8% vs. 9.4%, respectively). The lower levels of trace minerals in feed reduced the mineral concentration of Zn, Cu and Mn in the faeces and, hence, in the litter (P < 0.05). 4. Feeding organic minerals promoted a small, but statistically significant, drop in pH of breast meat compared to inorganic minerals at 48 d (5.83 vs. 5.86, respectively; P < 0.05). The organic mineral diets reduced drip loss in breast meat compared to inorganic trace mineral supplementation at 32 d of age, but not in older birds (2.46% vs. 3.77%, respectively; P < 0.05). 5. Oxidation status, measured by superoxide dismutase activity in breast muscle at 48 d of age, significantly increased with mineral inclusion levels (P < 0.001), irrespective of source. 6. It was concluded that the use of organic minerals, even at low levels in the diet, is beneficial for broiler performance and reduces the excretion of minerals in litter.

Dietary amino acids under hypoxic conditions exacerbates muscle myopathies including wooden breast and white stripping.

The occurrence of wooden breast (WB) and white striping (WS) of broiler breast myopathies may be associated with least-cost feed formulations and the inclusion of greater amounts of synthetic amino acids. Two experiments were conducted to evaluate the effects of supplemental glutamine (Gln-/+, 0 and 1%) and arginine (Arg-/+, 0 and 0.25%) in a 2 × 2 factorial arrangement. Experiment 1 consisted of 8 replicates using 32 pens and focused on live performance to 44 d of age, carcass yield, and meat quality evaluations at 45 d of age. Live performance parameters including feed intake, BW gain, mortality, and feed conversion were evaluated. Post-harvest carcass yield, breast muscle quality (including WB and WS), proximate analysis, and mineral analysis of breast muscle and tibia bone were also evaluated. Experiment 2 comprised 4 replicates using 8 pens with weekly measurements of blood physiology and muscle myopathy development from 21 to 45 d of age. Broilers fed supplemental Gln and Arg (Gln+/Arg+) produced broilers with greater BW and improved FCR. The WB and WS severity increased with Gln+ diets, while only WB increased using Arg+ diets. Weekly observations revealed the greatest increase in WB myopathies occurred between 28 to 35 d, while WS significantly increased one week later (35 to 42 d). When comparing broilers of similar BW at 45 d, Gln+ diets resulted in greater WS scores and percentage breast muscle fat. Further analysis of WB and WS scores (independent of treatment affect) revealed that increased myopathy scores were associated with increased blood CO2, H2CO3, and reduced O2 with increased meat pH, moisture content, and Ca concentration. These results indicated that increased muscle Ca is associated with increased WB, while increased dietary glutamine and lack of oxygen may have resulted in a reverse flux of the citric acid cycle and reduced electron transport chain activity resulting in increased WS.

Effects of supplemental L-methionine on growth performance and redox status of turkey poults compared with the use of DL-methionine.

This study was conducted to test the effects of dietary supplementation of feed grade L-Met on growth performance and redox status of turkey poults compared with the use of conventional DL-Met. Three hundred and eighty five newly hatched turkey poults were weighed and allotted to 5 treatments in a completely randomized design and the birds were fed dietary treatments for 28 d, including a basal diet (BD), the BD + 0.17 or 0.33% DL-Met or L-Met (representing 60, 75, and 90% of the requirement by National Research Council (NRC) for S containing AA, respectively). Increasing Met supplementation from 0 to 0.33% increased (P < 0.05) weight gain (690 to 746 g) and feed intake (1,123 to 1,248 g) of turkey poults. Supplementing L-Met tended (P = 0.053) to reduce feed to gain ratio (1.70 to 1.63) compared with DL-Met. The relative bioavailability of L-Met to DL-Met was 160% based on a multilinear regression analysis of weight gain. Supplementing Met regardless of its sources decreased (P < 0.05) malondialdehyde (3.29 to 2.47 nmol/mg protein) in duodenal mucosa compared with birds in the BD. Supplementing L-Met tended (P = 0.094) to decrease malondialdehyde (1.27 to 1.16 nmol/mg protein) and increase glutathione (3.21 to 3.45 nmol/mg protein) in the liver compared with DL-Met. Total antioxidant capacity, protein carbonyl, and morphology of duodenum and jejunum were not affected by Met sources. In conclusion, dietary supplementation of 0.33% Met to a diet with S containing AA meeting 60% of the NRC requirement enhanced weight gain, feed intake, and redox status by reducing oxidative stress in the gut and liver of turkey poults during the first 28 d of age. Use of L-Met tended to enhance feed efficiency and was more effective in reducing oxidative stress and increasing glutathione in the liver compared with the use of DL-Met. The use of L-Met as a source of Met replacing DL-Met seems to be beneficial to turkey poults during the first 28 d of age.

Effect of natural betaine and ractopamine HCl on whole-body and carcass growth in pigs housed under high ambient temperatures.

Betaine is an osmolyte that helps to maintain water homeostasis and cell integrity, which is essential during heat stress. We hypothesized that supplemental betaine can improve growth during heat stress and may further improve the response to ractopamine. Two studies were conducted to determine: 1) the effects of betaine in combination with ractopamine; and 2) the optimum betaine level for late finishing pigs during heat stress. Heat stress was imposed by gradually increasing temperatures over 10 d to the target high temperature of 32°C. In Exp. 1, pigs ( = 1477, BW = 91.6 ± 3 kg) were assigned within BW blocks and sex to 1 of 4 diets arranged in a 2 × 2 factorial RCB design (68 pens; 20 to 23 pigs/pen). Treatments consisted of diets without or with ractopamine (5 mg/kg for 21 d followed by 8.8 mg/kg to market) and each were supplemented with either 0 or 0.2% of betaine. Betaine reduced ( ≤ 0.05) BW (123.1 vs. 124.3 kg), ADG (0.780 vs. 0.833 kg/d), and ADFI (2.800 vs. 2.918 kg/d), but did not impact carcass characteristics. Ractopamine increased ( < 0.01) BW (125.5 vs. 121.9 kg), ADG (0.833 vs. 0.769 kg/d), G:F (0.295 vs. 0.265), HCW (94.1 vs. 90.0 kg), carcass yield (74.8 vs. 73.8%), loin depth (63.6 vs. 60.0 mm), and predicted lean percentage (53.2 vs. 51.7%) and reduced ADFI (2.822 vs. 2.896 kg/d, = 0.033) and backfat depth ( < 0.001; 20.2 vs. 22.5 mm). In Exp. 2, pigs ( = 2193, BW = 95.5 ± 3.5 kg) were allocated within BW blocks and sex to 1 of 5 treatments in a RCB design (100 pens; 20 to 24 pigs/pen). Treatments consisted of diets with 0, 0.0625, 0.125, 0.1875% of betaine, and a positive control diet with ractopamine, but not betaine. Betaine tended to decrease carcass yield quadratically ( = 0.076; 74.1, 73.5, 73.8, and 73.9 for 0, 0.0625, 0.125, 0.1875% of betaine, respectively), but did not impact other responses. Ractopamine improved ( < 0.001) BW (121.6 vs. 118.5 kg), G:F (0.334 vs. 0.295), carcass yield (74.7 vs. 73.8%), loin depth (61.7 vs. 59.0 mm), and predicted lean percentage (53.2 vs. 52.6%), and reduced backfat (18.7 vs. 20.4 mm). Collectively, data indicate that under commercial conditions, betaine did not improve performance of pigs housed under high ambient temperatures, regardless of ractopamine inclusion. Ractopamine improved whole-body growth and especially carcass growth of pigs raised under high ambient temperatures. The ability of ractopamine to stimulate growth during heat stress makes it an important production technology.

Effects of dietary supplementation of the osmolyte betaine on growing pig performance and serological and hematological indices during thermoneutral and heat-stressed conditions.

The present study was designed to evaluate the effects of dietary betaine on pig performance and serological and hematological indices during thermoneutral and heat-stressed conditions. Individually housed pigs ( = 64; 39.0 ± 1.5 kg BW) were assigned within weight blocks and sex to 1 of 8 treatments. Treatments consisted of 2 environmental conditions (thermoneutral or heat-stressed) and 4 levels of betaine (0, 0.10, 0.15, and 0.20%). Room temperatures followed a daily pattern with a low of 14°C and a high of 21°C for the thermoneutral environment and a low of 28°C and a high of 35°C for the heat-stressed environment. Experimental diets were fed from d -7 (7 d prior to imposing temperature treatments; constant 21°C) until 28. Respiration rate and rectal temperature were measured on d 0, 1, 2, 3, 7, 14, 21, and 28, and blood samples were collected on d 3 and 28. Heat stress reduced ( ≤ 0.008) ADG (0.710 vs. 0.822 kg/d) and ADFI (1.81 vs. 2.27 kg/d) and increased G:F ( = 0.036; 0.391 vs. 0.365). Betaine tended to quadratically increase G:F ( = 0.071; 0.377, 0.391, 0.379, and 0.366 for 0, 0.10, 0.15, and 0.20% betaine, respectively), regardless of environment. Heat stress increased ( ≤ 0.001) respiration rate (48 vs. 23 breaths/30 s) and rectal temperature (39.47 vs. 38.94°C) throughout d 1 to 28. Betaine at 0.10% reduced rectal temperature in heat-stressed pigs but not in control pigs (interaction, = 0.040). Heat stress increased serum cysteine and triglycerides and reduced Ca, alkaline phosphatase, and lipase, regardless of day of sampling ( ≤ 0.048). Heat stress increased serum creatine phosphokinase (CPK) and K and reduced osmolarity, Na, urea N, methionine, homocysteine, the albumin:globulin ratio, and blood eosinophil count on d 3 but not on d 28 (interaction, ≤ 0.013). Heat stress increased serum Mg, globulin, creatinine, amylase, and γ-glutamyltranspeptidase and reduced , the urea N:creatinine ratio, alanine aminotransferase, NEFA, hemoglobin, hematocrit, and red blood cells on d 28 but not on d 3 (interaction, ≤ 0.034). Betaine increased serum osmolarity and NEFA and reduced CPK and K on d 3 but not on d 28 (interaction, ≤ 0.060) and increased serum creatinine and reduced amylase on d 28 but not on d 3 (interaction ≤ 0.057). Heat stress reduced growth, disturbed ion balance, and increased markers of muscle damage. Betaine had a minor impact on alleviating heat stress with the possible exception of early days of heat exposure. The beneficial effect of betaine was diminished by pig adaptation.

Effects of dietary organic zinc and α-tocopheryl acetate supplements on growth performance, meat quality, tissues minerals, and α-tocopherol deposition in broiler chickens.

The aim of this study was to evaluate the effects of different dietary levels of zinc (Zn) and α-tocopheryl acetate (α-TOA) on broilers performance, meat quality, Zn, selenium (Se), and α-tocopherol (α-TO) tissue depositions. A total of 1,080 one-day-old Ross 308 broiler chickens (mixed-sex) were allocated to nine dietary treatments. Three levels of supplemental Zn (0, 60, and 120 mg/kg of diet) and three levels of α-TOA (0, 150, and 300 mg/kg of diet) were combined as a completely randomized design with 3 × 3 factorial arrangement. Chicks were penned in groups of 20 with six pens per treatment. The ADFI, ADG, feed conversion ratio (FCR), mortality rate, and European production efficiency factor (EPEF) were not affected by dietary treatments. In addition, supplementation of Zn and α-TOA and their interaction did not affect carcass parts yield. Drip loss of the breast and thigh muscles were significantly reduced 1.27 and 1.47% by α-tocopheryl acetate (α-TOA) supplementation, respectively (P < 0.01). Deposition of Zn in liver, breast, and thigh muscles were linearly increased by dietary Zn supplementation. Furthermore, supplementation of Zn increased Se content in the breast and thigh muscles and liver. Supplementation of either α-TOA or Zn increased deposition of α-TO in liver and the muscles. The Thiobarbituric acid reactive substances (TBARS) values in the breast and thigh muscles and the liver were diminished by supplementation of α-TOA (P = 0.0001) and there was positive interaction between Zn and α-TOA (P < 0.01), in which within each increase in Zn supplementation level, α-TOA supplementation resulted in a reduction of TBARS values. In conclusion, 300 mg/kg dietary supplementation of α-TOA could improve drip loss, nutritional content, and oxidation stability of muscle without any adverse effect on growth performance of chickens. In addition, 120 mg/kg dietary supplementation of Zn could fortify α-TOA effect to improve oxidation stability of the breast and thigh muscles as well as it resulted to higher muscles Zn enrichment.

Enzyme supplementation to improve the nutritional value of fibrous feed ingredients in swine diets fed in dry or liquid form.

This study evaluated the effect of xylanase supplementation (with or without), feeding method (dry or liquid), and feedstuff (corn distiller's dried grains with solubles [DDGS] or wheat middlings) on apparent total tract digestibility (ATTD) and apparent ileal digestibility (AID) of GE and nutrients, intestinal morphology, ileal and cecal pH, and VFA concentrations. Sixty-four growing pigs (25.87 ± 0.38kg initial BW) were blocked by BW and sex and randomly assigned to 8 dietary treatments. Within each feedstuff, diets were fed either liquid or dry, without or with xylanase (24,000 birch xylan units/kg feed), for 16 d. Diets contained 3.32 and 3.19 Mcal/kg ME for DDGS- and wheat middlings-based diets, respectively. Pigs were fed restricted at 3 times maintenance ME requirements. Liquid diets were prepared by steeping DDGS or wheat middlings with water (1:3, wt/vol) with or without xylanase for 24 h followed by mixing with a basal ingredient mixture and water to achieve a final ratio of 1:2.5 (wt/vol). During steeping of wheat middlings, some fiber degradation occurred. When xylanase was added in dry wheat middlings diets, AID of GE ( < 0.10) and NDF ( < 0.05) increased compared with dry wheat middlings diets without xylanase (64.50 vs. 54.67% and 52.88 vs. 31.69%, respectively), but supplementation of xylanase did not impact AID of GE and NDF when liquid wheat middlings diets were fed. Xylanase in liquid DDGS diets increased ( < 0.05) the AID of NDF compared with liquid DDGS diets without xylanase, but xylanase did not affect AID of NDF in dry DDGS diets. Xylanase in wheat middlings diets improved ( < 0.05) ATTD of GE and N compared with wheat middlings diets without xylanase (80.37 vs. 78.07% and 80.23 vs. 77.94%, respectively). However, there was no effect of xylanase in DDGS diets. Pigs fed DDGS diets had greater concentrations of butyrate in the cecum ( = 0.001) than pigs fed wheat middlings diets (27.6 vs. 20.4 mmol/L). Pigs fed DDGS diets with xylanase had deeper crypts ( < 0.05) in the jejunum than pigs fed DDGS diets without xylanase (98.20 vs. 86.16 µm), but xylanase had no effect in pigs fed wheat middlings diets. Results suggest that liquid feeding and xylanase supplementation had limited potential to enhance nutrient digestibility in pigs fed DDGS-based diets. However, xylanase supplementation in dry wheat middlings-based diets improved the AID of NDF and ATTD of GE and N, but liquid feeding as pretreatment did not further enhance the nutritional value of wheat middlings-based diets.

Effects of feed grade L-methionine on intestinal redox status, intestinal development, and growth performance of young chickens compared with conventional DL-methionine.

This study was conducted to test the effects of supplemental L-Met on redox status, gut development, and growth performance of young broiler chickens compared with DL-Met. A total of 888 (half male and half female) 1-d-old Ross 308 chickens were weighed and randomly allotted to 7 treatments in a randomized complete block design for 21 d, including a basal diet (BD), the BD + 0.095% L-Met or DL-Met, the BD + 0.190% L-Met or DL-Met, and the BD + 0.285% L-Met or DL-Met (representing 60, 70, 80, and 90% of the Met + Cys requirement). Feed disappearance and BW were recorded every 7 d. Liver and duodenum samples were collected on d 0, 7, and 21 to measure redox status and intestine morphology. On d 7, chicks fed a diet supplemented with either 0.285% L-Met or 0.285% DL-Met had increased (P < 0.05) concentrations of glutathione (GSH) and reduced (P < 0.05) protein carbonyl (PC) and malonedialdehyde contents in duodenum mucosa compared with chicks fed the BD. Chicks fed a diet supplemented with 0.285% L-Met had greater (P < 0.05) villus width compared with chicks fed a diet supplemented with 0.285% DL-Met. Chicks fed a diet supplemented with 0.285% L-Met had lower (P < 0.05) crypt depth and greater (P < 0.05) villus height:crypt depth ratio compared with chicks fed a diet supplemented with 0.285% DL-Met or the BD. On d 21, chicks fed a diet supplemented with 0.285% L-Met had increased (P < 0.01) concentrations of GSH and total antioxidant capacity (TAC) but reduced (P < 0.05) PC content in duodenum mucosa compared with chicks fed a diet supplemented with 0.285% DL-Met and the BD. Chicks fed a diet supplemented with 0.285% L-Met had greater (P < 0.05) villus height compared with chicks fed the BD. During the entire 21-d supplementation of either L-Met or DL-Met, ADG and G:F were enhanced (P < 0.01) compared with chicks fed the BD. Chicks fed diets supplemented with L-Met had greater (P < 0.05) ADG and G:F than chicks fed diets supplemented with DL-Met. The relative bioavailability of L-Met to DL-Met for ADG and G:F was 138.2 and 140.7%, respectively. Overall, supplementation of either L-Met or DL-Met has beneficial effects on villus development in association with increased GSH production and levels of TAC and reduced protein oxidation in duodenum. Supplementation of L-Met served a better function on redox status and development of the gut of chicks compared with DL-Met. Chicks fed diets with L-Met had better growth response than chicks fed diets with DL-Met.

Effect of chito-oligosaccharide on growth performance, intestinal barrier function, intestinal morphology and cecal microflora in weaned pigs.

A total of 180 weanling pigs (21 ± 3 d of age; 5.98 ± 0.04 kg) were used to investigate the effect of chito-oligosaccharide (COS) on growth performance, intestinal barrier function, intestinal morphology, and cecal microflora. Based on initial BW, gender and litter, the pigs were given 5 treatments during a 14-d feeding experiment, including a basal diet (control), 3 diets with COS supplementation (200, 400, or 600 mg/kg), and a diet with colistin sulfate (CSE) supplementation (20 mg/kg). Six randomly selected pigs from each treatment were used to collect serum, duodenal, jejunal, ileal, and cecal samples on d 7 and 14 postweaning. From d 1 to 7 postweaning, pigs fed COS or CSE had greater ADG and ADFI compared with the control pigs. From d 1 to 14, diets with either 400 or 600 mg/kg COS, or 20 mg/kg CSE increased (P < 0.05) ADG and G:F compared with the control diet. No significant differences were observed in ADG, ADFI, and G:F between the pigs fed COS and CSE. Pigs fed either 400 or 600 mg/kg COS, or 20 mg/kg CSE had less (P < 0.05) diamine oxidase (DAO) in the serum, but greater concentration of (P < 0.05) DAO in jejunal mucosa, than the control pigs on d 7 postweaning. Treatments did not affect villous height and crypt depth of the duodenum, jejunum, or ileum. Pigs fed COS at 400 mg/kg had greater (P < 0.05) concentration of Bifidobacteria and Lactobacilli in the cecum than pigs fed the control diet and CSE diet on d 7 postweaning. Supplementation of COS or CSE decreased (P < 0.05) the population of cecal Staphylococcus aureus compared with the control diet on d 7 postweaning. The number of cecal Bifidobacteria in pigs fed 600 mg/kg COS was greater (P < 0.05) than that of pigs fed the control diet or CSE diet on d 14 postweaning. No significant differences were observed in Escherichia coli counts in the cecum among treatments. The present results indicate that dietary supplementation of COS at 400 or 600 mg/kg promotes growth performance and improves gut barrier function, increases the population of Bifidobacteria and Lactobacilli, and decreases S. aureus in the cecum of weanling pigs.

Organic trace minerals and 25-hydroxycholecalciferol affect performance characteristics, leg abnormalities, and biomechanical properties of leg bones of turkeys.

Leg problems and resulting mortality can exceed 1% per week in turkey toms starting at approximately 15 wk of age. Dietary supplementation of organic trace minerals (MIN) and 25-hydroxycholecalciferol (HyD) may improve performance, decrease incidence of leg abnormalities, and increase bone strength. Nicholas 85X700 toms were assigned to 4 treatments consisting of a factorial arrangement of 2 concentrations of MIN (0 and 0.1% of Mintrex P(Se), which adds 40, 40, 20, and 0.3 mg/kg of Zn, Mn, Cu, and Se, respectively) and 2 concentrations of HyD (0 and 92 microg/kg of HyD). Diets were formulated to be equal in nutrient content and fed ad libitum as 8 feed phases. Feed intake and BW were measured at 6, 12, 15, 17, and 20 wk of age. Valgus, varus, and shaky leg defects were determined at 12, 15, 17, and 20 wk of age. Tibia and femur biomechanical properties were evaluated by torsion and bending tests at 17 wk of age. There were no treatment effects on BW. Only MIN significantly improved feed conversion ratio through to 20 wk of age. Cumulative mortality at 3 wk of age was greater among the MIN birds, but it was lower by 20 wk (P = 0.085). The MIN decreased the incidence of varus defects at 17 wk of age; shaky leg at 12, 15, and 17 wk of age; and valgus defects at 15, 17, and 20 wk of age. There were no MIN x HyD interaction effects on individual gait problems. Maximum load and the bending stress required for tibias to break in a 4-point assay were increased with MIN supplementation, especially when HyD was also added. Maximum shear stress at failure of femoral bones in a torsion assay was increased by supplementation with both MIN and HyD together. Dietary supplementation of MIN and HyD may improve biomechanical properties of bones. Dietary MIN supplementation may improve feed conversion of turkeys, likely by decreasing leg problems.

Determination of nitrogen balance in goats fed a meal produced from hydrolyzed spent hen hard tissues.

To provide an economically viable and environmentally sound method for disposing of spent laying hens, we manufactured a proteinaceous meal from the hard tissue fraction of mechanically deboned laying hens (primarily feathers, bones, and connective tissue). We hydrolyzed the hard tissue and coextruded it with soybean hulls to create a novel feather and bone meal (FBM) containing 94.2% DM, 23.1% CP, 54.5% NDF, and 7.3% fat (DM basis). We evaluated the FBM in supplements for meat goats in which it provided 0, 20, 40, or 60% of the N added to the supplement compared with a negative control supplement with no added N source. The remainder of the N was contributed by soybean meal (SBM). Supplementation of N resulted in greater DMI than the negative control (P = 0.005), and DMI changed quadratically (P = 0.11) as FBM increased in the supplement. Digestibility of DM was similar in all diets, including the negative control (P > 0.10). Fiber digestibility increased linearly as dietary inclusion of FBM increased (P = 0.04 for NDF, P = 0.05 for ADF), probably as a result of the soybean hulls in the FBM. Nitrogen digestibility declined linearly from 60.5% with 0% FBM to 55.6% with 60% FBM (P = 0.07), but N retention changed by a quadratic function as FBM replaced SBM (P = 0.06). Negative control goats had less N digestibility (P < 0.001) and N retention (P = 0.008) than N-supplemented goats. Feather and bone meal had a greater proportion of ruminally undegradable B(3) protein than SBM (23.1 vs. 0.3% of CP, respectively). Ruminal VFA and pH were unaffected by replacing SBM with FBM, but supplying no source of N in the concentrate resulted in reduced total VFA in ruminal fluid (P = 0.04). Ruminal ammonia concentration increased quadratically (P = 0.07) as FBM increased, reflecting increased intake, and it was much less in unsupplemented goats (P < 0.001). Serum urea had less variation between 0 and 4 h after feeding in goats receiving 40 or 60% of added N as FBM in comparison with those receiving only SBM or 20% FBM. Feather and bone meal promoted a more stable rumen environment, possibly because of reduced rates of protein degradation within the rumen. A palatable by-product meal for ruminants can be made from spent laying hen hard tissue, one that supports N metabolism similar to that of traditional protein sources.

Change in the ileal bacterial population of turkeys fed different diets and after infection with Salmonella as determined with denaturing gradient gel electrophoresis of amplified 16s ribosomal DNA.

Changes in ileal bacterial populations of Salmonella-infected turkeys fed different diets were analyzed by using 16S-V3 PCR denaturing gradient gel electrophoresis. Turkeys raised on litter flooring were fed wheat- and corn-based diets with and without enzyme preparations (XY1 and XY2, respectively) from 0 to 126 d. Preparation XY1 contained exclusively endoxylanase, whereas preparation XY2 contained endoxylanase, protease, and alpha-amylase (Danisco, , Wiltshire, UK). The dietary activity levels of XY1 and XY2 were 2,500 and 650 endo-1,4-beta-xylanase units/kg of feed, respectively. Microbial DNA was extracted from the ileal content of 16-wk-old turkeys, and the 16S rDNA gene was amplified by PCR and analyzed by denaturing gradient gel electrophoresis. Diversity indexes, including richness (number of species, S), evenness (relative distribution of species, EH), diversity (using Shannon's index, H'), and Sorenson's pairwise similarities coefficient (measures the species in common between different habitats, Cs) were calculated. Additionally, diversity indexes were associated with Salmonella prevalence determined from fresh fecal droppings collected from each pen. On the basis of contrast analysis, the wheat-based diets resulted in higher microbial diversity indexes than the corn-based diets (S = 10 vs. 12; EH = 0.9 vs. 0.8; H' = 2.2 vs. 1.9, P < 0.05). Likewise, enzyme supplementation stimulated growth of the microbiota and increased the diversity indexes in comparison with unsupplemented treatments (S = 13 vs. 10; EH = 0.9 vs. 0.8; H' = 2.2 vs. 1.9, P < 0.05). Salmonella prevalence was higher (P < 0.05) at 15 wk in turkeys fed the corn-based diet (Salmonella prevalence = 50%) than in turkeys fed the corn-enzyme (Salmonella prevalence = 13%) and wheat-based (Salmonella prevalence = 0%) dietary treatments. Therefore, contrast analysis showed that birds fed the corn control diet had lower microbiota diversity but higher Salmonella prevalence than birds fed the enzyme-supplemented and wheat-based diets. In contrast, birds fed the wheat-based diets had higher diversity but lower Salmonella prevalence than birds fed the corn-based diets. High dietary nonstarch polysaccharides from wheat and dietary exogenous enzyme supplementation promoted microbial community diversity and apparently discouraged Salmonella colonization through competitive exclusion. Nonstarch polysaccharides and dietary exogenous enzyme supplementation may be practical tools to control enteric pathogens and benefit the intestinal health and food safety of the birds.

The effect of early nutrition on satellite cell dynamics in the young turkey.

Early posthatch satellite cell mitotic activity is an important aspect of muscle development. An understanding of the interplay between nutrition and satellite cell mitotic activity will lead to more efficient meat production. The objective of this study was to test the influence of the leucine metabolite, beta-hydroxy beta-methylbutyrate (HMB), and feed deprivation on muscle development in the early posthatch poult. Male Nicholas poults were placed on 1 of 4 treatments: immediately fed a starter diet with 0.1% HMB (IF-HMB), immediately fed a starter diet containing 0.1% Solka-Floc for a control (IF-No HMB), feed and water withheld for 48 h immediately posthatch and then fed the HMB diet (WF-HMB), and feed and water withheld for 48 h immediately posthatch and then fed the control starter diet (WF-No HMB). 5-bromo-2'-deoxyuridine (BrdU) was injected intra-abdominally into all poults to label mitotically active satellite cells. The pectoralis thoracicus was harvested 2 h after the BrdU injection. Immunohistochemistry for BrdU, Pax7, and laminin along with computer-based image analysis was used to study muscle development. IF-HMB poults had higher body weights (P < 0.01) at 48 h and 1 wk of age and had higher satellite cell mitotic activity at 48 h of age (P < 0.01) compared with the IF-No HMB and WF poults. Therefore, dietary supplementation of HMB may have an anabolic effect on early posthatch muscle.

Effects of virginiamycin and a mannanoligosaccharide-virginiamycin shuttle program on the growth and performance of large white female turkeys.

Shuttle programs involving dietary supplementation of mannanoligosaccharides (MOS) and virginiamycin (VM) were evaluated in turkeys by their effects on growth performance, body weight uniformity, and carcass yield characteristics. Diets containing no growth promoter (control), VM (22 mg/kg), or a shuttle program (MOS-VM) of MOS (0 to 6 wk of age at 500 mg/ kg) and VM (6 to 14 wk of age at 22 mg/kg) were fed to Hybrid female turkeys. All diets were formulated to exceed NRC nutrient requirements. Each treatment was assigned to 8 replicate floor pens containing 20 birds that were reared from 1 to 98 d of age. Body weights and feed consumption were recorded at 3-wk intervals, and mortality and culled birds were recorded daily. At the conclusion of the trial, 2 birds per pen were randomly chosen for carcass yield analysis. Feeding VM alone significantly (P < 0.05) increased body weight compared with control fed birds during all periods. The MOS-VM shuttle program resulted in early growth depression for birds less than 3 wk of age, possibly influenced by an unplanned cold stress, but better growth than the nonmedicated control birds after 6 wk of age. Birds fed VM had superior (P < 0.05) feed conversion ratio from 0 to 3 wk, which persisted until 14 wk (P < 0.10). There were no treatment effects on overall feed consumption, uniformity, mortality, or cull rate. Processing yields or weight of various parts were also unaffected by treatment.

Glucose and electrolyte supplementation of drinking water improve the immune responses of poults with inanition.

Enteric disorders predispose poultry to malnutrition. The objectives of this paper were 1) to simulate the inanition of poult enteritis mortality syndrome by restricting feed intake and 2) to develop a drinking water supplement that supports the immune functions of poults with inanition. Poults were restricted to 14 g of feed/d for 7 d beginning at 14 d of age then fed ad libitum until 36 d (recovery). The control was fed ad libitum. During the feed-restriction period, duplicate groups of 6 poults received 1 of 5 drinking water treatments: 1) restricted feed, unsupplemented water; 2) restricted feed + electrolytes (RE); 3) RE + glucose + citric acid (REGC); 4) REGC + betaine (REGCB); or 5) REGCB + zinc-methionine (REGCBZ). Immunological functions were assessed by inoculating poults with SRBC and B. abortus (BA) antigen at 15, 22, and 29 d of age. Antibody (Ab) titers were determined 7 d later for primary, secondary, and recovery responses. The primary and secondary total Ab titers to SRBC for restricted feed were 4.71 and 6.16 log3, which where lower (P < 0.05) than for controls (8.00 and 9.66 log3) and the other treatments. The recovery Ab titer for controls was 10.7, significantly higher than restricted feed (8.71) and RE (8.10) groups but not different from other treatments. The primary total Ab responses to BA were significantly lower in the restricted feed and RE groups as compared with the control and other treatments. Although feed restriction of poults to maintenance reduces the humoral immune responses, these responses can be significantly improved by drinking water containing electrolytes and especially sources of energy such as glucose and citric acid.

Effect of mannan-endo-1,4-beta-mannosidase on the growth performance of turkeys fed diets containing 44 and 48% crude protein soybean meal.

Soybean meal (SBM) contains heat-resistant mannans. Domesticated turkeys are sensitive to mannans because of the high inclusion rate of SBM in their diets, causing increased chyme viscosity, wet droppings, and reduced feed conversion. Three experiments of similar design were conducted to determine the effect of mannan-endo-1,4-f'-mannosidase supplementation of corn-SBM diets on market turkeys. Experiment 1 was conducted at North Carolina State University using Nicholas hens raised from 1 to 98 d of age. Experiments 2 and 3 were conducted at PARC Institute Inc. using Large White turkey toms raised from 1 to 126 d of age. In each experiment, birds were randomly assigned to litter floor pens. Each pen was assigned to one of four experimental treatments in 2 x 2 factorial arrangement of two basal diets containing 44% CP and 48% CP SBM (SBM-44 and SBM-48, respectively) with or without 100 million units (MU) Hemicell/tonne (1 MU = 106 enzyme activity U). Birds fed SBM-44 had lower final BW (14.9 vs. 14.56 kg 18 wk BW / tom; 7.66 vs. 7.46 kg 14 wk BW/hen, P < 0.05) and higher final cumulative feed/gain than those fed the SBM-48. Hemicell supplementation generally improved performance of all birds, with a greater response in birds fed SBM-44. Hemicell improved BW and feed/gain by 1% (P = 0.779) and 3% (P = 0.377) in hens and 2.5% (P = 0.0016) and 4% (P = 0.0001) in toms, respectively. The results of these experiments indicate that some of the adverse effects of antinutritional factors of SBM of on turkey growth performance can be alleviated by dietary mannan-endo-1,4-beta-mannosidase supplementation.

Effect of wheat enzyme preparation on the performance characteristics of Tom turkeys fed wheat-based rations.

Wheat contains 5 to 8% nonstarch polysaccharides (NSP). The NSP complex forms a viscous mass when fully hydrated, which impedes the absorption of nutrients from chyme and causes reduced growth performance and osmotic diarrhea and associated wet litter. These adverse effects can be alleviated by appropriate enzyme supplementation. The objective of this experiment was to evaluate the efficacy of endoxylanase and beta-glucanase enzyme mixtures supplemented to wheat-based diets on growth performance characteristics of turkeys. Seven-day-old Large White male turkeys were randomly assigned to 40 litter floor pens of 12 poults each as a completely randomized block design arrangement of four experimental treatments and were raised to 140 d. The dietary treatment consisted of a control treatment (no supplemental enzyme) and three dietary enzyme treatments: 1) Lyxasan forte, 2) Natugrain Blend, and 3) Natugrain. Body weight, feed consumption, and mortality were recorded weekly. Feather condition was evaluated at 98 d of age. Natugrain Blend improved BW at 84 d (P < 0.075) and 112 d (P < 0.01) in comparison to the unsupplemented control diet. Lyxasan forte had the best feed/gain ratio throughout the experiment. Subjective feather condition score was significantly improved (P < 0.05) by all the three enzyme treatments and corresponded with reduced incidence of neck and back picking behavior. The enzyme treatment groups had lower mortality than the control group with the Natugrain blend treatment having the lowest mortality rate through the experiment. The results of this experiment demonstrate marginal improvement in growth performance of turkeys depending upon enzyme formulation.

The effect of mannanoligosaccharides, bambermycins, and virginiamycin on performance of large white male market turkeys.

A study was conducted to evaluate the effects of mannanoligosaccharides (MOS), bambermycins (BAM), and virginiamycin (VIR) on the growth performance of male turkeys. Hybrid Large White male poults were assigned to six dietary treatments: control, MOS, BAM, VIR, MOS+BAM (MB), and MOS+VIR (MV). All diets were formulated to meet NRC (1994) nutrient requirements. There were eight replicate floor pens per treatment with 20 birds per pen reared from 1 to 140 d. Body weight and feed conversion (FC) were collected at 3-wk intervals and at 20 wk of age. Mortality and culled birds were recorded daily. All treatments except MV significantly (P < 0.05) increased 20 wk BW. Body weight was increased at 12 wk by BAM, whereas VIR increased BW at Weeks 12 and 15. All treatments improved FC for Weeks 0 to 3, whereas VIR, MB, and MV improved FC for Weeks 0 to 12 and 0 to 18. There were no treatment effects on cumulative mortality or cull rate. Dietary supplemental MOS, BAM, and VIR resulted in improved growth performance of Large White turkeys. These results indicate that MOS may be utilized as an alternative to antibiotic growth promotants to improve turkey performance.

Interaction between ambient temperature and supplementation of synthetic amino acids on performance and carcass parameters in commercial male turkeys.

An experiment with male turkeys was conducted to test the hypothesis that turkey production performance responds positively to extra crystalline amino acid supplementation (lysine, methionine, and threonine) when subjected to a high ambient temperature regimen (HT) in the grower period. Two diets were formulated to provide lysine, methionine, and threonine concentrations that either 1) met the breeder recommendations or 2) contained 10% higher lysine and methionine concentrations from 22 to 134 d of age and 10% higher threonine concentration from 22 to 68 d of age. Both diets were fed at two temperatures (15 or 25 C) from 42 d of age onward. At 134 d of age, turkeys on the HT had generally lower BW than those on the low temperature regimen (LT). Up to 68 d of age and from 106 to 134 d of age, feed intake of turkeys on the HT was significantly lower than that of turkeys on the LT. Up to 42 d of age, feed conversion ratio (FCR) of turkeys on the HT were significantly lower than those of turkeys on the LT. Significant treatment interactions were observed from 22 to 41 d of age. Turkeys fed the amino acid-supplemented diets on the LT had significantly reduced FCR, whereas those on the HT did not respond. From 69 to 105 d of age, turkeys on the HT that were fed the supplemented diets had significantly increased FCR, but there were no dietary effects among turkeys on the LT. There were no consistent diet effects on growth performance or carcass yields. Breast meat yields of turkeys on the LT were higher (33.5 vs 32.1%), and drum yields were lower (12.7 vs 13.0%), than those of turkeys on the HT. There were no significant amino acid balance x ambient temperature effects on processing yields. The hypothesis of this experiment could be rejected as production performance did not respond positively to extra supplementation of lysine, methionine, and threonine when subjected to an HT.