Heat-induced aggregation kinetics of potato protein - Investigated by chromatography, calorimetry, and light scattering.

In this study, the heat-induced aggregation behavior of patatin rich potato protein isolate (PPI) was investigated by reversed-phase high-pressure liquid chromatography (RP-HPLC), differential scanning calorimetry (DSC), and dynamic light scattering. It could be shown that aggregation already occurs at low temperatures, despite low degrees of unfolding. The unfolding temperature, determined by DSC, coincided with a change in the reaction kinetics, which is determined by the unfolding step below a critical temperature up to the point, where the proteins are completely unfolded. The reaction rate k as a function of the absolute temperature T is then determined by diffusion of unfolded proteins forming aggregates. This change can be visualized in the Arrhenius diagram by a change of the slope of the relationship k âˆ¼ 1/T. A change in pH from 7 to 6 shifted the critical temperature towards higher values and resulted in larger aggregate sizes, due to reduced electrostatic repulsion.

Isolation of biofunctional bovine immunoglobulin G from milk- and colostral whey with mixed-mode chromatography at lab and pilot scale.

The aim of the present work was to develop a new scalable and cost-efficient process to isolate bovine immunoglobulin G from colostral whey with high purity and minimal loss of activity. The mixed mode material Mercapto-Ethyl-Pyridine-Hypercel™ was identified appropriate for direct capture of immunoglobulin G. The binding mechanism is primarily based on hydrophobic interactions at physiological conditions. As compared to immunoglobulin G, all other low molecular whey proteins such as α-Lactalbumin or ß-Lactoglobulin, except lactoperoxidase, are more hydrophilic and were therefore found in the flow-through fraction. In order to remove lactoperoxidase as an impurity the column was combined in series with a second mixed mode material (Capto™- with N-benzoyl-homocysteine as ligand) using the same binding conditions. At pH 7.5 the carboxyl group of this ligand is negatively charged and can hence bind the positively charged lactoperoxidase, whose isoelectric point is at pH 9.6. After sample application, the columns were eluted separately. By combining the two columns it was possible to obtain immunoglobulin G with a purity of >96.1% and yield of 65-80%. The process development was carried out using 1 mL columns and upscaling was performed in three steps up to a column volume of 8800 mL for the Hypercel™ column and 3000 mL for the Capto™- column. At this scale it is possible to obtain 130-150 g pure immunoglobulin G from 3 L colostrum within five hours, including the regeneration of both columns. Additionally, the impact of freeze-drying on the isolated immunoglobulin G was studied. The nativity of the freeze dried immunoglobulin was above 95%, which was proven by reversed phase liquid chromatography and validated by differential scanning calorimetry. The activity of immunoglobulin G was preserved over the isolation process and during drying as measured by enzyme-linked immunosorbent assay. In conclusion, by applying the proposed isolation process, it becomes feasible to obtain pure, active and stable imunnunoglobulin G at large scale.

Encapsulation of anthocyanins from bilberries - Effects on bioavailability and intestinal accessibility in humans.

Anthocyanins are flavonoids that have been suggested to provide beneficial health effects. The biological activity of anthocyanins is influenced by their pharmacokinetic properties, but anthocyanins are associated with limited bioavailability in humans. In the presented study, we investigated how the encapsulation of bilberry extract (BE), a source of anthocyanins, with either whey protein or citrus pectin influences the bioavailability and intestinal accessibility of anthocyanins in humans. We performed an intervention study that analyzed anthocyanins and their degradation products in the urine, plasma, and ileal effluent of healthy volunteers and ileostomists (subjects without an intact colon). We were able to show, that whey protein encapsulation modulated short-term bioavailability and that citrus pectin encapsulation increased intestinal accessibility during passage through the small intestine and modulated the formation of the degradation product phloroglucinol aldehyde (PGAL) in human plasma.

Physiological relevance of food grade microcapsules: Impact of milk protein based microcapsules on inflammation in mouse models for inflammatory bowel diseases.

In order to increase beneficial effects of bioactive compounds in functional food and dietary supplements, enormous efforts are put in the technological development of microcapsules. Although these products are often tailor-made for disease susceptible consumer, the physiological impact of microcapsule uptake on the respective target consumer has never been addressed. The present study aimed to assess the relevance of this aspect by analyzing the impact of milk protein based microcapsules on experimental inflammatory bowel disease. Long-term feeding of sodium caseinate or rennet gel microcapsules resulted in significant alterations in the intestinal microbiota of healthy mice. In TNFΔARE/wt mice, a model for chronic ileal inflammation, rennet gel microcapsules resulted in further increased splenomegaly, whereas ileal inflammation was unchanged. In IL10(-/-) mice, a model for chronic colitis, both types of microcapsules induced a local increase of the intestinal inflammation. The present study is the first to demonstrate that, independent of their cargo, microcapsules have the potential to affect the intestinal microbiota and to exert unprecedented detrimental effects on disease-susceptible individuals. In conclusion, the impact of microcapsule uptake on the respective target consumer groups should be thoroughly investigated in advance to their commercial use in functional food or dietary supplements.

Application of confocal Raman microscopy to investigate casein micro-particles in blend casein/pectin films.

Pectin triggers formation of casein micro-particles during solution casting. Confocal Raman microscopy revealed their composition and spatial dimension in resulting films. Peaks in the Raman spectra corresponded to those found in films prepared by either casein or pectin. This suggested that no conformational changes occurred after mixing. Raman images revealed incompatibility of both polymers because particles consisted of casein only and the surrounding matrix of pectin. Deformation of micro-particles into an oblate shape took place during film formation. In dried films, an empty space between casein and pectin was found in lateral dimension. In contrast, casein micro-particles overlapped with the pectin matrix in the vertical dimension.

Is the antioxidative effectiveness of a bilberry extract influenced by encapsulation?

BACKGROUND: Bilberries (Vaccinium myrtillus L.) have been suggested to have preventive properties against diseases associated with oxidative stress such as colon cancer or inflammatory bowel diseases. Therefore the gastrointestinal tract is regarded as a potential target for prevention. In this study the antioxidative properties of a commercially available anthocyanin-rich bilberry extract (BE) were investigated in comparison with four different BE-loaded microcapsule systems. As markers to describe the antioxidant status in this cellular system, intracellular reactive oxygen species (ROS) levels, oxidative DNA damage and total glutathione (tGSH) levels were monitored. RESULTS: Incubations with the BE-loaded capsule systems showed an increase in cellular glutathione levels and reduction of ROS levels at high BE concentrations (100-500 µg mL(-1) ) and a positive effect on the formation of DNA strand breaks (5-10 µg mL(-1) BE). The biological properties of BE-loaded pectin amide core-shell capsules, whey protein matrix capsules and coated apple pectin matrix capsules were comparable to those of the non-encapsulated BE. CONCLUSION: Overall, the BE and the encapsulated BE types tested have antioxidative activity under the studied assay conditions in terms of the prevention of oxidative DNA damage, the reduction of intracellular ROS and the enhancement of cellular tGSH.

Effect of microformulation on the bioactivity of an anthocyanin-rich bilberry pomace extract ( Vaccinium myrtillus L.) in vitro.

In cell culture were compared the different release rates of anthocyanins from a bilberry pomace extract encapsulated either in food grade whey protein-based matrix capsules (WPC) or in pectin amid-based hollow spherical capsules (PHS). The impact of the formulations on typical anthocyanin-associated biological end points such as inhibition of the epidermal growth factor receptor (EGFR) and suppression of cell growth in HT29 colon carcinoma cells was assessed. The purpose was to find whether the release rates are sufficient to maintain biological activity and whether encapsulation affected EGFR inhibitory and growth suppressive properties of the extract. Even though anthocyanin release from extract-loaded capsules was proven under cell culture conditions, the inhibitory potential toward the EGFR was diminished. However, nonencapsulated extract as well as both extract-loaded encapsulation systems diminished the growth of HT29 cells to a comparable extent. The loss of EGFR inhibitory properties by encapsulation despite anthocyanin release indicates substantial contribution of other further constituents not monitored so far. Taken together, both applied encapsulation strategies allowed anthocyanin release and maintained biological activity with respect to growth inhibitory properties. However, the loss of EGFR inhibitory effects emphasizes the need for biological profiling to estimate process-induced changes of plant constituent's beneficial potencies.

Preparation and comparative release characteristics of three anthocyanin encapsulation systems.

Bilberries (Vaccinium myrtillus L.) and their major polyphenolic constituents, anthocyanins, have preventive activities inter alia against colon cancer and inflammatory bowel diseases. However, anthocyanins are sensitive to environmental conditions; thus their bioavailability in the gastrointestinal tract is an important determinant of their in vivo activity. In the study reported here, the potential benefits of encapsulating an anthocyanin rich bilberry extract (BE) on anthocyanin stability were investigated. Nonencapsulated BE and three different BE loaded microcapsule systems were incubated in simulated gastric fluid (SGF) and fed state simulated intestinal fluid (FeSSIF). After exposure to these media, released anthocyanins were identified and quantified by HPLC with UV/Vis detection. Although a rapid release of anthocyanins was observed within the first 20 min, encapsulation of anthocyanins doubled the amount of available anthocyanins after 150 min of incubation. These results illustrate the ability of encapsulation to inhibit early degradation of anthocyanins in the intestinal system.