Increased microbial phytase increased phytate destruction, plasma inositol, and feed efficiency of weanling pigs, but reduced dietary calcium and phosphorus did not affect gastric pH or fecal score and reduced growth performance and bone ash.

An experiment was conducted to test two hypotheses: 1) reducing dietary Ca and P reduces gastric pH and diarrhea in weanling pigs; 2) negative effects of low Ca and P on pig growth performance may be overcome if phytase is added to the diets. A total of 320 weanling pigs (6.35 ± 0.87 kg) were allotted to eight corn-soybean meal-based diets in a randomized complete block design with five pigs per pen. Two phase 1 (days 1 to 14) control diets containing 100 or 50% of total Ca and digestible P relative to the requirement, and six diets in which 500, 2,000, or 16,000 units of phytase/kg feed (FTU) were added to each control diet were formulated. Phytase was assumed to release 0.16% total Ca and 0.11% digestible P. Common diets were fed in phases 2 (days 15 to 27) and 3 (days 28 to 42). Growth performance data were recorded within each phase. Data for fecal scores and gastrointestinal pH were recorded for phase 1. Colon content (day 14), the right femur (days 14 and 42), and blood samples (days -1, 14, 27, and 42) were collected from one pig per pen. In phase 1, reducing Ca and P did not reduce gastric pH or fecal score, but pigs fed the 50% diets had reduced (P < 0.05) average daily gain (ADG) and average daily feed intake (ADFI) compared with pigs fed the 100% diets. In both 50% and 100% diets, phytase above 500 FTU increased (P < 0.05) gain:feed ratio (G:F) and tended (P < 0.10) to reduce gastric pH of pigs. From days 1 to 42, pigs fed the 50% diets tended (P < 0.10) to have reduced ADG and ADFI compared with pigs fed the 100% diets, but among the 100% diets, pigs tended (P < 0.10) to have a linear increase in G:F as phytase level increased. Pigs fed the 50% diets had reduced (P < 0.05) concentrations of inositol phosphate esters (IP) in the colon and reduced bone ash (days 14 and 42) compared with pigs fed the 100% diets. Phytase did not affect bone ash or most blood metabolites. Concentrations of IP in the colon decreased, whereas plasma inositol increased (d 14; P < 0.05) in pigs fed diets with phytase (≥ 500 FTU). In pigs fed the 100% diets, IP in the colon linearly decreased (P < 0.05), but plasma inositol linearly increased (P < 0.05) with increasing levels of phytase. In conclusion, reducing Ca and P in diets for weanling pigs did not influence gastric pH or fecal score, but compromised growth performance and bone ash. However, regardless of dietary Ca and P, high doses of phytase increased phytate degradation and inositol absorption, which consequently increased G:F of pigs.

Formulation of diets for pigs based on a ratio between digestible calcium and digestible phosphorus results in reduced excretion of calcium in urine without affecting retention of calcium and phosphorus compared with formulation based on values for total calcium.

An experiment was conducted to test the hypothesis that formulating diets for pigs based on a ratio between standardized total tract digestible (STTD) Ca and STTD P instead of total Ca and STTD P does not decrease Ca retention, but increases P utilization. Forty barrows (59.4 ± 3.8 kg) were individually housed in metabolism crates and allotted to four corn-soybean meal-based diets in a randomized complete block design with two blocks and five pigs per diet in each block. Diets were formulated using a 2 × 2 factorial design with two diet formulation principles (total Ca or STTD Ca) and two inclusion levels of microbial phytase (0 or 500 units per kg of feed). Phytase was assumed to release 0.11% STTD P and 0.16% total Ca. Diets were formulated based on requirements for total Ca and STTD P or a ratio between STTD Ca and STTD P of 1.25:1. Diets were fed for 11 d and fecal and urine samples were collected from feed provided from day 6 to day 10. Interactions (P < 0.05) between diet formulation principle and phytase level were observed for Ca intake, Ca in feces, Ca absorbed, Ca retained, P digestibility, P absorbed, and P in urine. Phytase increased (P < 0.05) the digestibility of Ca in both total Ca and STTD Ca diets. Without phytase, Ca intake, Ca in feces, and Ca absorbed was greater (P < 0.05) from pigs fed total Ca diets than from pigs fed STTD Ca diets, but P absorbed, P digestibility, and P in urine was greater (P < 0.05) from pigs fed STTD Ca diets than from pigs fed total Ca diets. However, in the presence of phytase, no differences between diet formulation principles were observed in these variables. Regardless of phytase, Ca in urine was lower (P < 0.05) from pigs fed STTD Ca diets than from pigs fed total Ca diets. There were no differences in Ca retention between pigs fed STTD Ca diets and total Ca diets, but pigs fed total Ca diets retained less (P < 0.05) Ca if diets contained phytase. No differences in P retention were observed between diet formulation principles, but pigs fed non-phytase diets retained more (P < 0.05) P than pigs fed diets with phytase. In conclusion, because diets formulated based on STTD Ca contain less Ca than total Ca diets, pigs fed STTD Ca diets excreted less Ca in urine, but retention of Ca was not affected. Formulating non-phytase diets based on STTD Ca instead of total Ca increased P absorption, which confirms the detrimental effect of excess Ca on P digestibility. However, P retention was not improved if pigs were fed STTD Ca diets.

Quantities of ash, Ca, and P in metacarpals, metatarsals, and tibia are better correlated with total body bone ash in growing pigs than ash, Ca, and P in other bones.

The objective was to determine correlations between individual bones and total body bone ash to identify the bone that is most representative of total body bone ash in growing pigs. Twenty growing pigs were allotted to 1 of 2 diets that were formulated to contain 60% or 100% of the requirement for standardized total tract digestible (STTD) P. Both diets had an STTD Ca to STTD P ratio of 1.90:1. Growth performance and carcass weights were determined. Metacarpals, metatarsals, femur, tibia, fibula, 3rd and 4th ribs, and 10th and 11th ribs, and all other bones from the left half of the carcass were collected separately. Each bone was defatted and ashed. Pigs fed the diet containing 100% of required Ca and P had greater (P < 0.05) average daily gain, gain to feed, and ash concentration (%) in total and all individual bones except femur and fibula compared with pigs fed the diet containing 60% of required Ca and P. Calcium and P concentrations in bone ash were not affected by dietary treatments. Weights (g) of bone ash, bone Ca, and bone P were greater (P < 0.05) or tended to be greater (P < 0.10) for pigs fed the diet containing 100% of required Ca and P. Correlation coefficients between the weight of ashed metacarpals, metatarsals, and tibia and the weight of total bone ash were >0.95. In conclusion, metacarpals, metatarsals, and tibia were more representative of total body bone ash compared with other bones.

Increasing calcium from deficient to adequate concentration in diets for gestating sows decreases digestibility of phosphorus and reduces serum concentration of a bone resorption biomarker.

The objective of this experiment was to test the hypothesis that the concentration of Ca in diets fed to late gestating sows affects the apparent total tract digestibility (ATTD) and retention of Ca and P, serum concentrations of Ca and P, hormones, and blood biomarkers for bone formation and resorption. Thirty-six sows (average parity = 2.8) were housed in metabolism crates from day 91 to day 104 of gestation and fed 1 of 4 experimental diets containing 25, 50, 75, or 100% of the requirement for Ca. All diets met the requirement for P. The initial 5 d of each period were the adaptation period, which was followed by 4 d of quantitative collection of feces and urine. At the end of the collection period, a blood sample was collected from all sows. Results indicated that feed intake, weights of dried fecal and urine samples, and the ATTD of DM were not affected by dietary Ca, but ATTD of Ca increased (quadratic, P < 0.05) as Ca in diets increased. Urine Ca output was not affected by dietary Ca, but Ca retention increased (quadratic, P < 0.05) as Ca intake increased. Fecal P output increased (linear, P < 0.001) as dietary Ca increased, which resulted in a linear decrease (P < 0.001) in the ATTD of P. Urine P output also decreased (linear, P < 0.001) as dietary Ca increased, but P retention increased (linear, P < 0.05). Regressing the apparent total tract digestible Ca against dietary Ca intake resulted in a regression line with a slope of 0.33, indicating that true total tract digestibility of Ca in calcium carbonate was 33%. Serum concentrations of Ca and P and estrogen, calcitonin, and parathyroid hormone were not affected by dietary Ca. Serum concentration of carboxyterminal cross-linked telopeptide of type I collagen (CTX-I) decreased (linear, P < 0.05) as dietary Ca increased, which is a result of reduced bone resorption as dietary Ca increased. Serum bone-specific alkaline phosphatase tended to decrease (linear, P < 0.10) as Ca in diets increased, but the concentration of osteocalcin (OC) in serum was not affected by dietary Ca. The ratio between OC and CTX-I tended to increase (P < 0.10) as dietary Ca increased, which indicated that there was more bone formation than resorption in sows as dietary Ca increased. In conclusion, P digestibility in late gestating sows decreased, but retention of P increased, as dietary Ca increased from inadequate to adequate levels and blood biomarkers for bone resorption changed as Ca and P retention increased.

Torula yeast has greater digestibility of amino acids and phosphorus, but not energy, compared with a commercial source of fish meal fed to weanling pigs.

Three experiments were conducted to test the hypothesis that the standardized ileal digestibility (SID) of AA, concentrations of DE and ME, and the standardized total tract digestibility (STTD) of P in a source of torula yeast are not different from values obtained in Menhaden fish meal. In experiment 1, six weanling barrows (initial BW: 11.7 ± 0.4 kg) were prepared with a T-cannula in the distal ileum and allotted to a replicated 3 × 3 Latin square design with 3 diets and 3 periods. In each period, there were 5 d of adaptation and 2 d of collection. Two cornstarch-based diets using the torula yeast or fish meal as the sole source of AA and a N-free diet were formulated. The SID of CP and all AA was greater (P < 0.05) in torula yeast than in fish meal. In experiment 2, 24 weanling barrows (initial BW: 14.4 ± 1.1 kg) were individually housed in metabolism crates and allotted to a corn-based diet or 2 diets based on a mixture of corn and torula yeast or corn and fish meal. Feces and urine samples were collected for 4 d following a 5-d adaptation period. There were 8 replicate pigs per diet and fecal and urine materials were collected. Results of this experiment indicated that there were no differences in the concentration of DE and ME (DM basis) between torula yeast and fish meal. In experiment 3, a total of 32 weanling barrows (initial BW: 11.9 ± 1.1 kg) were allotted to 4 diets and 8 replicate pigs per diet. Pigs were placed in individual metabolism crates. The torula yeast or fish meal were used in 2 diets containing either 0 or 500 units of microbial phytase. Feces samples were collected as described for experiment 2. The STTD of P in torula yeast was greater (P < 0.05) than in fish meal, but regardless of ingredient, there was no effect of the inclusion of phytase in the diets. In conclusion, the SID of AA and the STTD of P in torula yeast is greater than in fish meal, but values for the concentration of DE and ME in torula yeast are not different from those in fish meal. Therefore, the torula yeast that was used in the present experiments may be included at the expense of fish meal in diets fed to weanling pigs if the concentration of standardized ileal digestible AA is considered in the formulation.

Basal endogenous loss, standardized total tract digestibility of calcium in calcium carbonate, and retention of calcium in gestating sows change during gestation, but microbial phytase reduces basal endogenous loss of calcium1.

The objective was to test the hypothesis that the standardized total tract digestibility (STTD) of Ca and the response to microbial phytase on STTD of Ca and apparent total tract digestibility (ATTD) of P in diets fed to gestating sows are constant throughout gestation. The second objective was to test the hypothesis that retention of Ca and P does not change during gestation. Thirty-six gestating sows (parity = 3.3 ± 1.5; d of gestation = 7 d) were allotted to 4 diets. Two diets containing 0 or 500 units of microbial phytase per kilogram were based on corn, potato protein concentrate, and calcium carbonate. Two Ca-free diets were also formulated without or with microbial phytase to estimate basal endogenous loss of Ca. Daily feed allowance was 1.5 times the maintenance energy requirement. Sows were housed individually in gestation stalls and fed a common gestation diet, but they were moved to metabolism crates from days 7 to 20 (early gestation), days 49 to 62 (midgestation), and again from days 91 to 104 (late gestation). When sows were in metabolism crates, they were fed experimental diets and feces and urine were quantitatively collected for 4 d after 4 d of adaptation. Results indicated that outcomes were not influenced by the interaction between period of gestation and dietary phytase. The basal endogenous loss of Ca was greater (P < 0.05) by sows in early gestation than by sows in mid- or late-gestation, but supplementation of microbial phytase to the Ca-free diet decreased (P < 0.01) the basal endogenous loss of Ca and tended (P = 0.099) to increase ATTD of P. Supplementation of microbial phytase did not affect ATTD of DM, STTD of Ca, Ca retention, ATTD of P, or P retention in sows fed the calcium carbonate-containing diet. The ATTD of DM was not affected by period of gestation, but the ATTD of Ca, the ATTD of P, and the retention of Ca were least (P < 0.05) in midgestation, followed by early and late gestation, respectively, and the STTD of Ca in midgestation was also reduced (P < 0.05) compared with sows in early or late gestation. Phosphorus retention was greater (P < 0.05) in late gestation than in the earlier periods. In conclusion, Ca retention was less negative and ATTD of P tended to increase with supplementation of microbial phytase to the Ca-free diet regardless of gestation period. The basal endogenous loss, STTD of Ca, ATTD of P, and retention of Ca and P in gestating sows change during gestation with the greatest digestibility values observed in late gestation.

Effects of microbial phytase on mucin synthesis, gastric protein hydrolysis, and degradation of phytate along the gastrointestinal tract of growing pigs.

An experiment was conducted to test the hypothesis that pigs fed diets supplemented with exogenous phytase reduce mucin synthesis in the small intestine, increase protein hydrolysis in the stomach, increase breakdown of phytate along the gastrointestinal tract, and increase mineral and AA digestibility. A diet based on corn, soybean meal, and canola meal was formulated to meet requirements for growing pigs except for Ca and P, which were lower than requirements. Three additional diets were formulated by adding 750, 1,500, or 3,000 units of phytase (FTU) per kilogram to the basal diet. Eight growing barrows (38.45 ± 3.06 kg) were prepared with a T-cannula in the duodenum and another T-cannula in the distal ileum. Pigs were housed individually and allotted to a replicated 4 × 4 Latin square design with four pigs and four periods in each square. Each period lasted 14 d with the initial 7 d being the adaptation period to the diets. Pigs were fed twice daily in combined amounts equal to 3.2 times the estimated requirement for maintenance energy. Results indicated that the apparent ileal digestibility (AID) and the apparent total tract digestibility (ATTD) of Ca and P increased (linear and quadratic, P ≤ 0.05) as phytase inclusion increased. However, values for AID of Ca and P were not different from values for ATTD of Ca and P, indicating that there is no net absorption of Ca and P in the hindgut. The apparent duodenal digestibility (ADD) of Ca and P was ~30% and 10% to 20%, respectively, indicating some digestion in the stomach of both Ca and P. A quadratic increase (P < 0.05) of the AID of GE was observed with the breakpoint around 1,500 FTU, but there was a negative linear (P ≤ 0.001) effect of dietary phytase on the ATTD of GE. Phytase did not affect mucin synthesis in the small intestine, protein hydrolysis in the stomach, or ileal digestibility of dispensable and indispensable AA. However, degradation of higher phytate esters (IP6 and IP5) into lower phytate esters (IP4 and IP3) and inositol increased as dietary phytase increased, indicating that it is possible to completely degrade dietary phytate if microbial phytase is included by at least 3,000 FTU in the diet. In conclusion, supplementing diets with phytase resulted in increased degradation of phytate and phytate esters and improved digestibility of Ca and P, but phytase did not change intestinal mucin synthesis, gastric protein hydrolysis, or the AID of AA.

Non-antibiotic feed additives in diets for pigs: A review.

A number of feed additives are marketed to assist in boosting the pigs' immune system, regulate gut microbiota, and reduce negative impacts of weaning and other environmental challenges. The most commonly used feed additives include acidifiers, zinc and copper, prebiotics, direct-fed microbials, yeast products, nucleotides, and plant extracts. Inclusion of pharmacological levels of zinc and copper, certain acidifiers, and several plant extracts have been reported to result in improved pig performance or improved immune function of pigs. It is also possible that use of prebiotics, direct-fed microbials, yeast, and nucleotides may have positive impacts on pig performance, but results have been less consistent and there is a need for more research in this area.