Evaluation of reproductive/developmental and repeated dose (subchronic) toxicity and cytogenetic effects in rats of a roofing asphalt fume condensate by nose-only inhalation.

A Type III Built-up Roofing Asphalt (BURA) fume condensate was evaluated for subchronic systemic toxicity and reproductive/developmental toxicity screening in Wistar rats, by OECD protocol 422 and OECD cytogenetic protocol 474. Animals were exposed by nose-only inhalation to target concentrations of 30, 100 and 300 mg/m³ total hydrocarbons (actual concentrations, 30.0, 100.1 and 297.3 mg/m³). The study was performed to assess potential hazards from asphalt fumes to which humans could be exposed during application. No adverse effects were seen for spermology, reproductive or developmental parameters or early postnatal development of offspring from day 1 to 4 postpartum. BURA fume condensate did not induce any significant increases in micronucleus frequency in polychromatic erythrocytes of rat bone marrow nor was neurobehavioral toxicity observed at any dose. Systemic effects were slight and seen at doses above those measured at work sites. The systemic NOAEC of 100 mg/m³ for males was based on decreased body weight gain, food consumption and increased absolute and relative lung wet weight correlated with slight histological changes in the lung, primarily adaptive in nature at 300 mg/m³. The female NOAEC of 30 mg/m³ was based on a statistically significant increase in relative wet lung weight at higher doses, correlated with slight histopathologic effects in the lungs at the highest dose. However, no increase in relative lung weight was seen in breeding females at 100 mg/m³.

Luminescence spectroscopy as a screening tool for the potential carcinogenicity of asphalt fumes.

A subset of polycyclic aromatic compounds (PACs), which contain 4-6 annulated rings, has been documented as the source of carcinogenicity in animal skin painting studies of petroleum products and asphalt fumes (M. L. Machado, P. W. Beatty, J. C. Fetzer, A. H. Glickman and E. L. McGinnis, Fundam. Appl. Toxicol., 1993, 21, 492; T. A. Roy, S. W. Johnson, G. R. Blackburn and C. R. Mackerer, Fundam. Appl. Toxicol., 1988, 10, 466). Because of the chemical complexity of these materials, it has been difficult to identify the specific compounds within this broad range of PACs responsible for their carcinogenicity. An alternative approach using luminescence spectroscopy was taken in this study to quantify, without identification, a subset of these compounds that appears to cause cancer. The fluorescence response at a specific wavelength pair was obtained for 39 laboratory asphalt fume condensates from animal skin painting studies, yielding a linear correlation coefficient of R2 = 0.96 between the fluorescence response in these materials and the carcinogenicity found in animal studies. In the absence of other asphalt fume condensates from animal studies, 17 petroleum oils were also evaluated using this method and compared with the available animal skin painting data. The details of the method include a clean-up step that removes the highly polar compounds and spectral subtraction of two- and three-ring PAC interference, both of which add to the fluorescence response, yet were not found to contribute to a carcinogenic response from skin painting studies. Full scan fluorescence plots also produce a fingerprint which can be used to assess contamination, such as coal tar products or mixtures of materials, that are not defined as asphalt, yet may be present in the working environment.