Effects of protease enzyme supplementation and varying levels of amino acid inclusion on productive performance, egg quality, and amino acid digestibility in laying hens from 30 to 50 weeks of age.

An experiment was conducted to evaluate the effects of protease supplementation and reduced digestible amino acid (dAA)/ crude protein (CP) level on productive performance, AA digestibility, and egg quality parameters in Hy-Line W-36 laying hen from 30 to 50 wk of age. A total of 768 hens (12 replicates of 8 hens per treatment) were equally and randomly allocated into 8 experimental diets in a 4 × 2 factorial arrangement of dAA/CP level (100, 95, 90, and 85% of breeder recommendation) and protease (exclusion or inclusion). Protease was added at 60 g/metric ton of feed in the inclusion group. Hens were housed in raised-wire cages with a stocking density of 870 cm2/bird. The adequate (100%) diet was based on corn and soybean meal and formulated based on the digestible (d) Lys and dAAs (dMet, dThr, dTrp, dTSAA, dIle, and dVal) to meet 100% of the current management guide recommendation. Variations in dAA/CP (95, 90, and 85% diets) were accomplished by reducing the 100% dAA by 5, 10, and 15%, respectively. All diets were supplemented with phytase at 500 phytase units (FTU)/kg. Data were analyzed using PROC GLM of SAS 9.4. There was a main effect of dAA/CP level on 85% diet where it had a lower mean hen-day egg production (HDEP, P < 0.01), egg mass (EM, P < 0.01), and higher feed conversion ratio (FCR, P < 0.001). Higher egg weight (P < 0.01) was observed in 95 and 100% dAA/CP level diets. However, Haugh unit (P < 0.01) and albumen height (P < 0.01) were higher in 85 and 90% diets. The inclusion of protease reduced the feed consumption (P = 0.0247), FCR for dozens of eggs (P = 0.0049) from 30 to 49 wk of age without affecting the HDEP or EM. Protease supplementation and dAA/CP level had an effect on the apparent ileal digestibility (AID) of CP (P = 0.019), Lys (P < 0.01), Thr (P < 0.01), Trp (P = 0.017), and Val (P < 0.01). Addition of protease significantly increased egg income (P = 0.033) and return on investment (P = 0.00223) from 30 to 37 wk of age. At 38 to 50 wk of age, dAA/CP level had a significant effect on egg income (P < 0.001), feed cost (P < 0.001), and return on investment (P < 0.001). This experiment indicates that the inclusion of protease in 90 and 95% lower dAA/CP diets could help improve the digestibility of CP, and key amino acids and maintain productive performance of corn and soybean meal-based diets in Hy-Line W-36 laying hen from 30 to 50 wk of age.

Benefit of feeding dietary calcium and nonphytate phosphorus levels above National Research Council recommendations to tom turkeys in the growing-finishing phases.

This experiment evaluated the effects of feeding various dietary Ca and nonphytate P (nPP) levels to Large White male turkeys from 3 to 17 wk of age. After consuming a common prestarter diet, poults were fed approximate NRC (1994) levels of dietary Ca and nPP from 3 to 9 wk of age or levels approximately 25% higher. From 9 to 17 wk of age, each starter group was fed approximately 75 (low P), 100 (medium P), or 145% (high P) of the NRC (1994) requirements for Ca and nPP. Diets were fed as crumbles to 6 wk of age and as pellets from 6 to 17 wk of age. There were no effects on BW or feed efficiency to 9 wk of age. Litter P was increased by 21% when high Ca and nPP were fed from 3 to 9 wk. High dietary Ca and nPP fed during the growing-finishing period generally improved bone strength and ash. Tibia strength and ash were higher in the medium P group compared with in the low P group. Wing bone strength was greater in the high P group than in both the birds fed low or medium P. Litter P was increased by 23% when High P was fed in the growing-finishing period compared to the birds fed the Medium P diet during the same period. The results show there is a benefit to bone strength and mineralization when Ca and nPP are fed at levels higher than NRC (1994) recommendations.

Effectiveness of twenty-five-hydroxycholecalciferol in the prevention of tibial dyschondroplasia in Ross cockerels depends on dietary calcium level.

Five experiments were conducted to evaluate the efficacy of 25-hydroxycholecalciferol [25-(OH)D3] to minimize the development of tibial dyschondroplasia (TD) and improve phytate phosphorus retention in Ross cockerels during the starter period. In experiment 1, chicks were fed a TD-inducing (0.67% calcium) diet with or without exposure to ultraviolet light and no supplemental cholecalciferol. Dietary 25-(OH)D3 was added at 0, 10, or 70 microg/kg for both light treatments. In experiment 2, 25-(OH)D3 was added at 0, 10, 40, or 70 microg/kg to a TD-inducing diet containing 27.5 microg/kg added cholecalciferol. Experiment 3 was similar to experiment 2 except a diet marginal (0.85%) in calcium was fed, and cholecalciferol was added at 55 microg/kg. In experiments 4 and 5, 25-(OH)D3 was added at 0, 18, 36, 54, 72, or 90 microg/kg to a diet marginal in calcium. Dietary 25-(OH)D3 decreased the incidence of TD similarly at 40 and 70 microg/kg 25-(OH)D3 and improved phytate phosphorus retention when the TD-inducing diet was fed. The incidence of TD was decreased when 70 microg/kg 25-(OH)D3 was added to a diet marginal in calcium in experiment 3 only. Phytate phosphorus retention was generally not affected by dietary 25-(OH)D3 when a diet containing marginal calcium, adequate phosphorus, and high cholecalciferol was fed. The effectiveness of 25-(OH)D3 to reduce the incidence of TD in young broilers was higher when the dietary calcium level was below 0.85%. The incidence of TD in Ross cockerels was low (< 25%) when dietary calcium was greater than 0.85%.

Effect of dietary 1,25-dihydroxycholecalciferol level on broiler performance.

Studies were conducted to evaluate the level of dietary 1,25-dihydroxycholecalciferol [1,25-(OH)2D3] required to decrease the incidence of tibial dyschondroplasia (TD) in male broilers at 3 and 5 wk of age. The birds were reared in floor pens with wood shavings and fed a corn-soybean meal diet supplemented with 0, 3, 6, or 9 micrograms/kg 1,25-(OH)2D3. The diet contained, by averaged analyses, 0.73% calcium, 0.74% total phosphorus, and 0.22% phytate phosphorus. There was no treatment effect on body weight or gain: feed at either age. The incidence and severity of TD and the percentage of severe lesions were decreased and bone ash was increased by 6 micrograms/kg 1,25-(OH)2D3 at 3 wk of age. At 5 wk of age, the incidences of TD and severe lesions were decreased when 6 micrograms/kg 1,25-(OH)2D3 was fed. Bone ash was increased by this level in one of the two experiments. Plasma calcium was increased at 5 wk when 9 micrograms/kg 1,25-(OH)2D3 was fed, but there was no treatment effect on plasma dialyzable phosphorus or 1,25-(OH)2D3. The results indicate that 6 micrograms/kg 1,25-(OH)2D3 is effective for decreasing TD under practical rearing conditions.

The folic acid requirements of starting broiler chicks fed diets based on practical ingredients. 1. Interrelationships with dietary choline.

Five experiments were conducted to evaluate the effect of dietary supplemental folic acid in starting broiler chick diets. In the first two experiments, basal diets based on corn and soybean meal contained 10 micrograms/kg vitamin B12 but no supplemental methionine or choline. Chicks showed curvilinear responses to folic acid supplementation with maximum growth and feed efficiencies from 1.45 mg/kg diet. The liver folic acid response was also curvilinear but reached a plateau at 1.70 mg folic acid/kg diet. The basal diet for three additional experiments contained soybean meal that had been washed with methanol to remove most of the choline. The basal diet contained only 750 mg/kg choline. Chicks exhibited a larger growth response to folic acid at low choline levels as evidenced by a significant folic acid by choline interaction. Choline and folic acid both increased tibia length and width. Folic acid supplementation increased but then decreased valgus deformity. Choline chloride supplementation also decreased the incidences of valgus and varus deformities and decreased bone ash, but increased the incidence of tibial dyschondroplasia. It is concluded that chicks fed practical ingredient-based diets require 1.3 mg folic acid/kg diet with low levels of choline, but only 1.2 mg folic acid/kg when choline is offered near the NRC recommended level of 1,300 mg/kg of choline.

The folic acid requirements of starting broiler chicks fed diets based on practical ingredients. 2. Interrelationships with dietary methionine.

Two experiments were conducted to determine the effects of dietary supplemental folic acid and methionine on the performance of starting broiler chicks for 18 d. Four levels of dietary folic acid (.24, .54, 1.14, and 2.34 mg/kg) and four levels of dietary methionine (.45, .53, .61, and .69%) were fed in a factorial design. There were three replicates of eight chicks each per each treatment. The basal diet was based on corn, isolated soybean protein, meat and bone meal, and fish meal. It contained adequate amounts of all nutrients except methionine and folic acid. Increased growth was observed in chicks fed the basal diet supplemented with either folic acid or methionine. Total dietary folic acid and methionine plus cysteine requirements for maximum growth were estimated to be 1.80 mg/kg and .85% in Experiment 1 and 1.47 mg/kg and .87% in Experiment 2, respectively. There were interactions between dietary folic acid and methionine on weight gain in both experiments. Chicks fed the diet containing 2.34 mg folic acid/kg tended to have depressed growth, as in previous experiments. There was a significant linear feed conversion response to folic acid in Experiment 1 and to methionine in Experiment 2. There were both linear and quadratic liver folic acid responses to dietary folic acid in both experiments. There was no indication that dietary methionine had any effect on liver folic acid content. No differences in bone ash, hemoglobin, hematocrit, or incidence of tibial dyschondroplasia were detected due to methionine or folic acid supplementation.

Effects of dietary calcium and 1,25-dihydroxycholecalciferol on the development of tibial dyschondroplasia in broilers during the starter and grower periods.

Two experiments were conducted to determine whether dietary 1,25-dihydroxycholecalciferol [1,25-(OH)2D3] can prevent tibial dyschondroplasia in broiler chickens throughout the growing period when withdrawn from the grower diet. The birds were reared in floor pens with pine shavings to 6 wk in Experiment 1 and 5 wk of age in Experiment 2. Calcium was fed at .65 or 1.00% and 1,25-(OH)2D3 was fed at 0 or 5 micrograms/kg to 3 wk of age. Half the birds consuming 1,25-(OH)2D3 were then fed 0 microgram/kg until the end of the experiments. The higher level of calcium decreased the incidences of tibial dyschondroplasia and severe lesions and increased bone ash. Dietary 1,25-(OH)2D3 increased bone ash at both levels of calcium at 3 wk and the end of the experiments when supplemented for the duration of the studies. When 1,25-(OH)2D3 was fed, tibial dyschondroplasia was reduced in Experiment 2 only at 3 wk. Tibial dyschondroplasia was decreased at 5 wk in Experiment 2 when .65% calcium was fed with or without 1,25-(OH)2D3 from 3 to 5 wk of age. There were no treatment effects on plasma calcium, dialyzable phosphorus, or 25-hydroxycholecalciferol. Plasma 1,25-(OH)2D3 was decreased at 3 and 5 wk in Experiment 2 when 1.00% calcium was fed. The results of Experiment 2 suggest that 1,25-(OH)2D3 can prevent tibial dyschondroplasia caused by inadequate calcium when fed for only 3 wk. The bone ash observed when 1.00% dietary calcium is fed is equal to that obtained when 5 micrograms/kg 1,25-(OH)2D3 is fed with .65% calcium for the entire growout period.

Effects of 1,25-dihydroxycholecalciferol and phytase on zinc utilization in broiler chicks.

Studies were conducted with corn-soybean meal diets to evaluate the effects of phytate phosphorus utilization on zinc absorption and retention in broiler chicks. In the first two experiments, zinc-65 was used to determine zinc absorption. Experiment 1 was a 2 x 2 factorial with 0 or 5 micrograms/kg dihydroxycholecalciferol and 0 or 40 ppm supplemental zinc. In Experiment 2, 5 micrograms/kg 1,25-dihydroxycholecalciferol [1,25-(OH)2D3] or 750 units/kg phytase or both were added to a diet containing 35 ppm zinc. The diets in Experiment 3 were similar to Experiment 2 except that 600 units/kg phytase was fed. Experiment 4 was similar to Experiment 3 except that dietary phosphorus was decreased by .15%. There were no treatment effects on body weight in Experiments 1 and 2. Zinc absorption was higher in zinc-deficient birds in Experiment 1, but there were no other effects on zinc-65 absorption or retention. Body weight was increased by 1,25-(OH)2D3 in Experiments 3 and 4 and by phytase in Experiment 4. Phytate phosphorus retention was increased by phytase and 1,25-(OH)2D3 and was increased additively when both sources were fed. Dietary 1,25-(OH)2D3 increased zinc retention at times during Experiments 3 and 4, but this response was inconsistent. Phytase did not affect zinc retention. Phytase plus 1,25-(OH)2D3 increased zinc retention synergistically in Experiment 3. Bone zinc was increased by 1,25-(OH)2D3 and phytase, and there was an additive effect in Experiment 3. Plasma zinc and alkaline phosphatase were not affected. The results suggest that supplemental zinc may be decreased in a corn-soybean meal diet when phytate phosphorus utilization is enhanced.

Additive amelioration of tibial dyschondroplasia in broilers by supplemental calcium or feed deprivation.

Two experiments were conducted to determine the effects of mineral nutrition and early growth rate on tibial dyschondroplasia (TD) in broiler chickens. A corn-soybean meal diet with .6% available P (aP) was fed from the day of hatching for 20 days. Experiment 1 had a 2 x 2 x 2 factorial arrangement of treatments with two dietary levels of Ca (1.1 or 1.8% of the diet), two levels of dietary Cl (.22 or .34%), and two feeding systems (ad libitum or deprived of feed for 8 h three times per week on Monday, Wednesday, and Friday beginning at 6 days of age). Experiment 2 was a 3 x 2 factorial arrangement with three levels of Ca (1.14, 1.50, or 1.80%) and two feeding systems (ad libitum or deprivation as in Experiment 1). Nineteen-day BW gain was not affected by treatments in the first experiment. Feed deprivation decreased gain in the second experiment, and gain was increased by the highest Ca level without affecting feed efficiency. Feed deprivation did not affect feed efficiency in either experiment. Dietary Cl level did not affect any variable studied. Supplemental Ca increased bone ash in the first experiment, but not in Experiment 2. Feed deprivation and increasing Ca levels decreased the incidence of TD and the amount of severe lesions. Increasing dietary Ca resulted in a greater accumulation of Ca into the epiphyseal growth plate cartilage. The results suggest that the dietary Ca:aP ratio required for bone integrity in starter chicks may be greater than 2.2:1.