Measurement of Diacetyl and Related Compounds in Coffee Roasteries and Breweries.

α-Diketones such as diacetyl (2,3-butanedione) and 2,3-pentanedione are generated during the roasting and fermentation of foods and are also used as flavoring compounds. Exposure to these compounds has been associated with obliterative bronchiolitis in workers. We report indoor air concentrations of diacetyl and 2,3-pentanedione, as well as acetoin (3-hydroxy-2-butanone), in several small coffee roasteries and breweries using standard integrated air sampling sorbent tubes followed by gas chromatography tandem mass spectrometry as well as the first use of on-site continuous real-time proton-transfer reaction time-of-flight mass spectrometry (PTR-ToF-MS). Diacetyl and 2,3-pentanedione were detected in most of the sorbent samples at concentrations between 0.02 and 8 ppbv, and in general were higher in coffee roasteries compared with breweries. Three integrated air samples, all from the barista area at one facility, exceeded the NIOSH recommended exposure limit (REL) of 5 ppbv for diacetyl. 2,3-Pentanedione concentrations in these three samples were greater than 50% of its REL, but did not exceed it. Acetoin, a precursor to diacetyl, was also detected at concentrations between 0.03 and 5 ppbv in most sorbent tube samples, with concentrations generally higher in breweries. PTR-ToF-MS measurements exhibited similar trends and provided continuous real-time volatile organic compound data that showed episodic excursions with peak concentrations of diacetyl and 2,3-pentanedione between 15 and 20 ppbv. Examination of the time series data identified specific activities associated with peak diketone emissions, including transfer of freshly roasted coffee beans to the cooling tray, or the opening of a brew kettle. Additional indoor air quality parameters including CO2, NO2, and PM2.5 were also assessed on-site. Airway inflammation was assessed in 19 workers before and after each work shift using online measurements of fractional exhaled nitric oxide (FENO). The pre-shift mean FENO was 3.7 (95% confidence interval: -3.6, 11.0) ppbv higher and the post-shift FENO was 7.1 (-1.9, 16.1) ppbv higher for workers at coffee roasteries compared with breweries. The cross-shift change in FENO was 3.4 (-2.8, 9.6) ppbv higher for workers at coffee roasteries compared with breweries. However, none of these differences were statistically significant, and the cross-shift change in FENO was not statistically different from zero for either group of workers. The findings from this pilot study demonstrate that α-diketones and related compounds are present in the indoor air of both breweries and coffee roasteries and may exceed health protective guidelines in coffee roasteries. Additional studies are required to fully characterize worker exposures in these settings and to identify specific work activities and processes associated with high exposures. Engineering controls, including targeted exhaust ventilation and the use of low-cost sensors, are recommended as an approach to protect workers from exposure to hazardous levels of α-diketones.

Characterization of Naturally Occurring Alpha-Diketone Emissions and Exposures at a Coffee Roasting Facility and Associated Retail Café.

BACKGROUND: Alpha-diketones such as diacetyl and 2,3-pentanedione have been used as artificial flavorings in a variety of industries and are produced naturally when food products such as coffee beans are roasted. Exposure to these compounds has been associated with bronchiolitis obliterans, a rare and severe respiratory disease. In the current paper, we (i) evaluate which steps in the coffee production process are associated with the highest alpha-diketone emissions at a small craft coffee roaster and associated café, (ii) determine the extent to which direct-reading measurements of CO, CO2, and total volatile organic compounds (VOCs) can serve as lower-cost surrogate indicators for diacetyl concentrations, and (iii) conduct a limited emissions study to quantify the effect that the process variable of roast type has on diacetyl emissions from grinding beans. METHODS: Exposure and area concentration data for diacetyl and 2,3-pentanedione were collected over 4 days of sampling at a single coffee roaster and associated café. Additional measurements of café patrons' exposure to diacetyl were collected in seven other craft roastery/cafes in Seattle, WA. For the emissions experiments, integrated area air samples for diacetyl were collected using sorbent tubes over 30-min intervals for each roast type with the sorbent tubes positioned next to a grinder placed in an exposure chamber. Sorbent tubes were analyzed for alpha-diketones using gas chromatography-mass spectrometry. A photoionization detector (PID) was also used to measure continuous total VOC concentrations at the coffee roastery, and during each grinding experiment. RESULTS: Diacetyl concentrations in five of the seven personal samples from the craft roastery were above the United States National Institute of Occupational Safety and Health (NIOSH) Recommended Exposure Limit (REL) of 5 ppb as an 8-h time-weighted average (TWA)-and one of the seven personal samples exceeded the NIOSH REL for 2,3-pentanedione-9.3 ppb as an 8-h TWA. Median diacetyl and 2,3-pentanedione emissions were highest at the bagging machine followed by the grinder, roaster, barista, and background areas. The arithmetic mean diacetyl concentrations from the seven personal samples collected from café patrons was 3.96 ppb, suggesting that diacetyl exposure poses a negligible health risk to café patrons. Correlations between diacetyl and total VOCs, CO, and CO2 showed that diacetyl was well correlated with total VOCs, but poorly correlated with CO and CO2. Based on our limited emissions study, French roast was associated with the highest mass emission factor of diacetyl. CONCLUSIONS: Results from the exposure assessment study indicated that coffee production workers at this facility had elevated exposures to diacetyl and 2,3-pentanedione compared to recommended guidelines, whereas baristas and café patrons received lower exposures. Area sampling showed that the areas with the highest alpha-diketone emissions were the grinder and the bagging machine, which are both areas associated with tasks involving ground roasted coffee. Future research could focus on designing and evaluating effective engineering controls, in the form of local exhaust ventilation, with the goal of reducing alpha diketone exposures, as well as conducting similar studies at other small-scale craft coffee roasters and cafés to better understand the variability in these emissions and exposures within these types of facilities.

Close-coupled pacing to identify the "functional" substrate of ventricular tachycardia: Long-term outcomes of the paced electrogram feature analysis technique.

BACKGROUND: The conduction delay and block that compose the critical isthmus of macroreentrant ventricular tachycardia (VT) is partly "functional" in that they only occur at faster cycle lengths. Close-coupled pacing stresses the myocardium's conduction capacity and may reveal late potentials (LPs) and fractionation. Interest has emerged in targeting this functional substrate. OBJECTIVE: The purpose of this study was to assess the feasibility and efficacy of a functional substrate VT ablation strategy. METHODS: Patients with scar-related VT undergoing their first ablation were recruited. A closely coupled extrastimulus (ventricular effective refractory period + 30 ms) was delivered at the right ventricular apex while mapping with a high-density catheter. Sites of functional impaired conduction exhibited increased electrogram duration due to LPs/fractionation. The time to last deflection was annotated on an electroanatomic map, readily identifying ablation targets. RESULTS: A total of 40 patients were recruited (34 [85%] ischemic). Median procedure duration was 330 minutes (interquartile range [IQR] 300-369), and ablation time was 49.4 minutes (IQR 33.8-48.3). Median functional substrate area was 41.9 cm2 (IQR 22.1-73.9). It was similarly distributed across bipolar voltage zones. Noninducibility was achieved in 34 of 40 patients (85%). Median follow-up was 711 days (IQR 255.5-972.8), during which 35 of 39 patients (89.7%) did not have VT recurrence, and 3 of 39 (7.5%) died. Antiarrhythmic drugs were continued in 53.8% (21/39). CONCLUSION: Functional substrate ablation resulted in high rates of noninducibility and freedom from VT. Mapping times were increased considerably. Our findings add to the encouraging trend reported by related techniques. Randomized multicenter trials are warranted to assess this next phase of VT ablation.

Organizational diagnostics: a systematic approach to identifying technology and workflow issues in clinical settings.

OBJECTIVES: Healthcare organizations need to rapidly adapt to new technology, policy changes, evolving payment strategies, and other environmental changes. We report on the development and application of a structured methodology to support technology and process improvement in healthcare organizations, Systematic Iterative Organizational Diagnostics (SIOD). SIOD was designed to evaluate clinical work practices, diagnose technology and workflow issues, and recommend potential solutions. MATERIALS AND METHODS: SIOD consists of five stages: (1) Background Scan, (2) Engagement Building, (3) Data Acquisition, (4) Data Analysis, and (5) Reporting and Debriefing. Our team applied the SIOD approach in two ambulatory clinics and an integrated ambulatory care center and used SIOD components during an evaluation of a large-scale health information technology transition. RESULTS: During the initial SIOD application in two ambulatory clinics, five major analysis themes were identified, grounded in the data: putting patients first, reducing the chaos, matching space to function, technology making work harder, and staffing is more than numbers. Additional themes were identified based on SIOD application to a multidisciplinary clinical center. The team also developed contextually grounded recommendations to address issues identified through applying SIOD. DISCUSSION: The SIOD methodology fills a problem identification gap in existing process improvement systems through an emphasis on issue discovery, holistic clinic functionality, and inclusion of diverse perspectives. SIOD can diagnose issues where approaches as Lean, Six Sigma, and other organizational interventions can be applied. CONCLUSION: The complex structure of work and technology in healthcare requires specialized diagnostic strategies to identify and resolve issues, and SIOD fills this need.

Ventricular substrate identification using close-coupled paced electrogram feature analysis.

AIMS: Substrate based catheter ablation strategies are widely employed for treatment of scar-related ventricular tachycardia (VT). We analysed intracardiac electrograms (EGMs) from close-coupled paced extrastimuli extracted from the EnSite Precision mapping system. We sought to characterize EGM responses of ventricular myocardium to varying coupling intervals from the right ventricular apex (RVA) in both healthy individuals and patients presenting with VT for catheter ablation. METHODS AND RESULTS: Extrastimuli were delivered from the RVA after estimation of the ventricular effective refractory period. Electrograms were recorded from high-density mapping catheters in the left ventricle and exported for analysis to MATLAB. Observational data were collected from 14 patients with ischaemic VT (mean age 72.4 ± 6.3 years, one female) and five controls (mean age 59.4 ± 7.4 years, one female). These derived data were used to inform an interventional strategy on a further 10 patients (mean age 64.7 ± 10.0 years; two female). Significant differences were observed in EGM duration (ED) and latency (LT) at all coupling intervals between VT patients and controls. Significant increases in ED and LT with decreased RVA coupling interval were observed at VT isthmuses. Abnormal responses derived from control subject data were used to classify four types of ventricular EGM response. Targeting sites with abnormal LT and ED significantly reduced VT inducibility (5/14 derivation patients to 0/10 intervention patients; P = 0.03). CONCLUSION: Paced electrogram feature analysis is a novel tool to characterize the ischaemic substrate. Association with VT isthmuses and early ablation results suggest a possible role in substrate ablation for ischaemic VT.

Unipolar voltage threshold of 5.0 mV is optimal to localize critical isthmuses in post-infarction patients presenting with ventricular tachycardia.

INTRODUCTION: Bipolar voltage mapping is useful to delineate post-infarct endocardial scar and guide ablation of ischemic VT. The role of unipolar mapping is not yet well defined. The aim of this study was to assess the correlation between electrophysiological findings in patients with ischemic VT and unipolar voltage maps using different cut-offs. METHODS: We included 10 patients (age 67 ± 7 years, ejection fraction 33 ± 10%) with ischemic cardiomyopathy undergoing catheter ablation for recurrent VT. Patients with right-sided VTs were excluded. In all patients a unipolar voltage map was constructed during right ventricular pacing. Ablation was performed guided by activation and entrainment mapping in hemodynamically stable VTs and by pace-mapping and abnormal (late/split/fractionated) potentials in unstable VTs. Subsequently, the unipolar voltage maps were analyzed off-line using cutoffs from 1.0 to 8.0 mV and correlated with the isthmus sites. RESULTS: A total of 17 sustained VTs were induced in the 10 patients and non-inducibility of the clinical VT was achieved in 90% of patients by endocardial ablation. The optimal cutoff was 5.0 mV. By using this value, the mean surface area of abnormal unipolar voltage was 43.8% and 95% of all VT isthmuses were located within the area of scar, as well as 81% of abnormal potentials. In addition, 71% of isthmuses were at less than 1cm from the scar border. CONCLUSION: Unipolar voltage mapping showed good correlation with areas of isthmuses and abnormal electrograms in patients with scar-related VT, with a cut-off of 5.0 mV allowing the best delineation of ablation targets.

National Particle Component Toxicity (NPACT) initiative report on cardiovascular effects.

Epidemiologic and toxicologic studies were carried out in concert to provide complementary insights into the compositional features of ambient particulate matter (PM*) that produce cardiovascular effects. In the epidemiologic studies, we made use of cohort data from two ongoing studies--the Multi-Ethnic Study of Atherosclerosis (MESA) and the Women's Health Initiative--Observational Study (WHI-OS)--to investigate subclinical markers of atherosclerosis and clinical cardiovascular events. In the toxicologic study, we used the apolipoprotein E null (ApoE(-/-)) hypercholesterolemic mouse model to assess cardiovascular effects of inhalation exposure to various atmospheres containing laboratory-generated pollutants. In the epidemiologic studies, individual-level residential concentrations of fine PM, that is, PM with an aerodynamic diameter of 2.5 microm or smaller (PM2.5), PM2.5 components (primarily elemental carbon [EC] and organic carbon [OC], silicon, and sulfur but also sulfate, nitrate, nickel, vanadium, and copper), and the gaseous pollutants sulfur dioxide and nitrogen dioxide were estimated using spatiotemporal modeling and other exposure estimation approaches. In the MESA cohort data, evidence for associations with increased carotid intima-media thickness (CIMT) was found to be strongest for PM2.5, OC, and sulfur, as well as for copper in more limited analyses; the evidence for this was found to be weaker for silicon, EC, and the other components and gases. Similarly, in the WHI-OS cohort data, evidence for associations with incidence of cardiovascular mortality and cardiovascular events was found to be good for OC and sulfur, respectively, and for PM2.5; the evidence for this was found to be weaker for EC and silicon. Source apportionment based on extensive monitoring data in the six cities in the MESA analyses indicated that OC represented secondary formation processes as well as primary gasoline and biomass emissions, that sulfur represented largely secondary inorganic aerosols, and that copper represented brake dust and diesel emissions. In the toxicologic study, hypercholesterolemic mice were exposed for 50 days to atmospheres containing mixed vehicular engine emissions (MVE) consisting of mixed gasoline and diesel engine exhaust or to MVE-derived gases only (MVEG). Mice were also exposed to atmospheres containing sulfate, nitrate, or road dust, either alone or mixed with MVE or MVEG. Sulfate alone or in combination with MVE was associated with increased aortic reactivity. All exposures to atmospheres containing MVE (including a combination of MVE with other PM) were associated with increases in plasma and aortic oxidative stress; exposures to atmospheres containing only sulfate or nitrate were not. Exposure to MVE and to MVEG combinations except those containing road dust resulted in increased monocyte/macrophage sequestration in aortic plaque (a measure of plaque inflammation). Exposure to all atmospheres except those containing nitrate was associated with enhanced aortic vasoconstriction. Exposure to the MVEG was an independent driver of lipid peroxidation, matrix metalloproteinase (MMP) activation, and vascular inflammation. The epidemiologic and toxicologic study designs were intended to complement each other. The epidemiologic studies provided evidence in real-world human settings, and the toxicologic study directly assessed the biologic effects of various pollutant mixtures (in a way that is not possible in epidemiologic studies) by examining endpoints that probably underlie the subclinical and clinical cardiovascular endpoints examined in the epidemiologic studies. The epidemiologic studies were not suited to determining whether the observed associations were caused by direct effects of individual pollutants or by the mixtures in which individual pollutants are found. These studies were consistent in finding that OC and sulfate had the strongest evidence for associations with the cardiovascular disease endpoints, with much weaker evidence for EC and silicon. Both OC and sulfate reflected a large secondary aerosol component. Results from the toxicologic study indicated, for the most part, that MVE and mixtures of MVE and MVEG with other PM pollutants were important in producing the toxic cardiovascular effects found in the study. Further work on the effects of pollutant mixtures and secondary aerosols should allow better understanding of the pollution components and sources most responsible for the adverse cardiovascular effects of air pollution exposure.

Validation of a novel algorithm for quantification of the percentage of signal fractionation in atrial fibrillation.

AIMS: Catheter ablation for paroxysmal atrial fibrillation (AF) is rapidly becoming a standard practice. There is literature to support that catheter ablation of persistent AF requires additional 'substrate modification'. In clinical practice, operators rely on automated fractionation maps created by three-dimensional anatomic mapping systems to rapidly assess complex 'fractionated' signals (CFAE). These systems use differing algorithms to automate the process. The agreement between operators and contemporary algorithms has not been examined. We sought to assess the agreement between operators and a novel method of quantification calculating percentage fractionation (PF). METHODS AND RESULTS: Expert opinion on 80 atrial electrogram 4 s signals of varying levels of activity were gathered and pooled for comparison. Twelve independent experts visually quantified the signal fractionation and offered a threshold level for ablation. We developed an algorithm to find sites with high continuous electrical activity, or high PF. Correlation between experts and PF was 0.78 [P < 0.01, 95% confidence interval (CI) (0.68-0.86)]. Receiver operating characteristics curve sensitivity and specificity for PF were 0.7727 and 0.8103 at the optimal cut-off point of 58.45 PF with area under curve 0.89 CI (0.80-0.99). CONCLUSION: The PF statistic represents a more robust and intuitive measure to represent fractionated atrial activity; importantly it demonstrates excellent agreement with expert users and presents a new standard for algorithm assessment. Use of a PF statistic should be considered in automated mapping systems.

The right ventricular septum presents the optimum site for maximal electrical separation during left ventricular pacing.

UNLABELLED: Cardiac resynchronization therapy (CRT) benefits selected heart failure (HF) patients. The optimal placement of the right ventricle (RV) lead during biventricular pacing has not been assessed. Greater electrical separation (ES) between left ventricle (LV) and RV leads has been associated with better clinical outcomes. The site of maximal electrical separation(MES) in the RV is unknown. METHODS: Prospective study of 50 CRT patients. The LV lead was placed in a postero-lateral branch of the coronary sinus. ES was recorded at 6 sites within the RV during LV pacing at 600 milliseconds cycle length (CL). The median ES was recorded with a roving deflectable catheter at the RV outflow tract (RVOT), high septum, inflow septum, mid-septum, apical septum and apex. RESULTS: Mean age was 67 ± 7 years, 39 were male (78%). Thirty had ischemic etiology (60%). Mean left ventricular ejection fraction (LVEF) was 25 ± 7%, QRS duration pre and post was 165 ± 26 milliseconds and 138.5 ± 15.6 milliseconds (P < 0.001). Mapping ES showed a difference between 20 and 50 milliseconds distributed across the RV in the majority of patients (40/49). However, 7 subjects demonstrated delay distribution of between 50 and 82 milliseconds. ES was significant greater in the RV mid-septum (161.2 ± 23.7 milliseconds) compared with RVOT (154.1 ± 20.8 milliseconds) and apex (148.0 ± 25.5 milliseconds; P < 0.001). The site of Maximal ES was most commonly found at the mid-septum (40 patients, 80%) and only rarely at the RVOT (5, 10%) and apex (5, 10%; P < 0.01). CONCLUSION: MES was observed most commonly at the RV septum and rarely at the RV apex. Better correction of electrical and mechanical dyssynchrony by CRT may be achieved by placing the RV lead in a site outside of the apex in the majority of patients. Clinical studies exploring RV septal pacing in CRT seem warranted.

Professional satisfaction among new osteopathic family physicians: a survey-based investigation of residency-trained graduates.

CONTEXT: Progressively more osteopathic graduates are seeking training opportunities in programs accredited by the Accreditation Council on Graduate Medical Education (ACGME). OBJECTIVE: To determine if family medicine residency training program choice (ie, allopathic [ACGME], osteopathic, or dually accredited) has an impact on professional satisfaction levels among recent osteopathic medical school graduates. METHODS: The authors designed a survey instrument to gather data on professional satisfaction levels. Osteopathic family physicians who completed residency training from 1999-2003 were asked to participate in the study. RESULTS: The survey was sent to 2284 individuals with an adjusted response rate of 37%. One hundred and one (15.8%) of the osteopathic family physicians who responded reported completing residency training programs approved by the American Osteopathic Association (AOA); 335 (52.3%), ACGME-accredited programs; 198 (30.9%), dually accredited programs. One hundred forty-three surveyed osteopathic physicians (22.3%) were less than happy with their career choice. In addition, 219 (34.2%) reported that they were "thinking of changing...specialty," and 30 (4.7%) reported that they were not "currently practicing family medicine." Individuals trained in ACGME programs reported slightly higher levels of professional satisfaction than individuals trained in AOA-approved or dually accredited programs--though these differences were deemed trivial (ie, low effect size, 0.01; P>.05). CONCLUSION: The authors found no statistically significant differences in professional satisfaction levels among osteopathic family physicians who were recent medical school graduates regardless of residency training program choice.

Complications associated with defibrillation threshold testing: the Canadian experience.

BACKGROUND: Defibrillation threshold (DFT) testing has traditionally been a routine part of implantable cardioverter-defibrillator (ICD) implantation, despite a lack of compelling evidence that it predicts or improves outcomes. In the past, when devices were much less reliable, DFT testing seemed prudent; however, modern ICD systems have such a high rate of successful defibrillation that many electrophysiologists now question whether DFT testing is still worthwhile, particularly since DFT testing may now be the highest acute risk component of ICD implantation. OBJECTIVE: The purpose of this study was to systematically document complications directly attributable to intraoperative DFT testing. METHODS: We obtained data on DFT-related complications from all 21 adult ICD implant centers in Canada, covering the period from January 1, 2000, to September 30, 2006. RESULTS: There were a total of 19,067 ICD implants in Canada during the study period. There were three DFT testing-related deaths, five DFT testing-related strokes, and 27 episodes that required prolonged resuscitation. Two patients had significant clinical sequelae after prolonged resuscitation. CONCLUSIONS: The risk of severe complications from intraoperative DFT testing appears small, even allowing for the underestimation of its true rate with the current study methodology. These slight but measurable risks must be considered when assessing the risk-benefit ratio of the procedure. Additional data from ongoing prospective ICD registries and/or clinical trials are required.

Universal access -- but when? Treating the right patient at the right time: access to electrophysiology services in Canada.

The Canadian Cardiovascular Society Access to Care Working Group has published a series of commentaries on access to cardiovascular care in Canada. The present article reviews the evidence for timely access to electrophysiology services. Using the best available evidence along with expert consensus by the Canadian Heart Rhythm Society, the panel proposed a series of benchmarks for access to the full scope of electrophysiology services, from initial consultation through to operative procedures. The proposed benchmarks are presented herein.