Impact of Crude Oil Quality on the Refining Conditions and Composition of Nutraceuticals in Refined Palm Oil.

Palm oil is the major vegetable oil used worldwide due to its unique properties. The effect of crude palm oil acidity on the final free fatty acids (FFA) content, neutral oil loss (NOL), and nutraceutical compounds, such as carotenes, total tocols (tocopherols and tocotrienols), squalene, and phytosterols was investigated. A central composite design was employed to study the influence of the refining conditions: temperature (200 to 260 °C), steam percentage (0.5% to 3.5%), and initial FFA content (2.2% to 6.0%) on the quality of the refined product. The results revealed that initial palm oil acidity is a statistically important parameter to obtain commercially acceptable values for final FFA content. The increase of temperature presented the most important effect on the reduction of all nutraceutical compounds. The highest tocopherols (88%), phytosterols (98%), and squalene retention (84%) was obtained when applying the mildest temperature (200 °C). From the experimental results, 3 equations were generated enabling the prediction of the free fatty acids content, the tocols content, and the losses of neutral oil. Therefore, this work contributes to the understanding and optimization of the process for the production of palm oil with high nutraceutical quality and low free fatty acid contents.

Effect of rosemary extract dose on lipid oxidation, colour stability and antioxidant concentrations, in reduced nitrite liver pâtés.

The oxidative stability of liver pâté was investigated in relation to different doses of rosemary extract (RE) and sodium nitrite. Colour stability, lipid oxidation (TBARS) and concentrations of ascorbic acid, α-tocopherol, carnosic acid and nitrite were measured on the batters before cooking and on the cooked liver pâté before and after exposure to light and air for 48 h at 4°C. Results showed that the use of RE significantly reduced lipid oxidation, whereas it had no effect on colour stability. Ascorbic acid and nitrite concentrations were significantly higher and lower respectively when RE was added. RE dose-dependently increased the concentration of carnosic acid. Lower sodium nitrite doses resulted in significantly lower nitrite concentrations and slightly lower TBARS values. It was concluded that in liver pâté sodium nitrite levels may be lowered to 80 mg/kg without negatively affecting colour and lipid stability and that the use of RE may help in maintaining lipid stability.

Absorption, distribution and elimination of carnosic acid, a natural antioxidant from Rosmarinus officinalis, in rats.

The absorption, distribution and elimination of carnosic acid, the main antioxidant found in rosemary was studied, in vivo, in rats. Therefore, carnosic acid was administrated in a single dose, intravenously (20.5 ± 4.2 mg/kg) and orally (64.3 ± 5.8 mg/kg), to four and nine rats, respectively. Blood samples were collected at different time points, and plasma concentrations of carnosic acid were determined using LC-MS. Furthermore, total collection of urine and feces was done during 4 h and 24 h for the intravenous and oral administrations, respectively. After euthanizing the rats, intestinal content, liver and muscle tissue were sampled to determine carnosic acid concentrations. The bioavailability of carnosic acid, after 360 min, was 40.1%. Traces of carnosic acid were found in the rats intestinal content, liver and muscle tissue of abdomen and legs. The recovery of carnosic acid in the feces, 24 h after oral administration, was 15.6 ± 8.2%. Carnosic acid is absorbed into the bloodstream after oral administration in rats and is therefore bioavailable. It was found that carnosic acid in vivo is present in its free form and that its main elimination route is the fecal route.

Correlations of the phenolic compounds and the phenolic content in some Spanish and French olive oils.

The total content of phenolic compounds (TAP) in 29 different monocultivar olive oil samples from France (Aglandau and Tanche) and Spain (Cornicabra, Picual, and Verdial) was assessed by the colorimetric Folin-Ciocalteu method. Also, individual phenolic compounds were determined and quantified by liquid chromatography coupled to mass spectrometry (LC-MS). The French olive oil samples had a lower TAP compared to Spanish samples. The quantity of individual phenolics was similar except for pinoresinol, which was lower in the French olive oil samples. TAP moderately correlated to the sum of quantified compounds (r = 0.64 and p < 0.01) Partial least-squares (PLS) regression analysis emphasized the importance of hydroxytyrosol and the total amount of quantified phenolic compounds by LC-MS in the prediction of the total amount of phenolic compounds as determined by the Folin-Ciocalteu method. The amount of alpha-tocopherol was generally different among the cultivars (Tanche > Picual > Verdial > Aglandau > Cornicabra). Of all quantified phenolic compounds in French olive oil samples, only luteolin correlated well to the altitude of the olive orchards (r = 0.76, p < 0.01).

Characterization of two unknown compounds in methanol extracts of rosemary oil.

In this study, two unknown compounds in rosemary oil, containing 3% carnosic acid and 0.3% carnosol, were identified and characterized. After methanol extraction, purification, and analysis by reversed-phase HPLC and LC-MS, a recovery of 92% (+/-8%) of carnosic acid was obtained, but no carnosol was found. However, two unknown compounds with a molecular weight of 330.2 and 302.2 were consistently detected. From additional LC-MS-MS, (1)H NMR, and elemental analyses, it became clear that the first compound (M(w) = 330.2) could not be carnosol. It was hypothesized that it originated from the breakdown of the intramolecular bond of carnosol, followed by the addition of a water molecule. Possibly, an unsaturated double bond was formed after dehydration. Assuming that this compound was an intermediate in the conversion to rosmanol, the second unknown compound (M(w) = 302.2) may have resulted from the breakdown of the intramolecular bond of rosmanol. Similarly, an unsaturated double bond may have been formed. After splitting off carbon oxide, a detectable molecule with a molecular weight of 302.2 was observed.

Selection criteria for potato tubers to minimize acrylamide formation during frying.

A number of parameters linked to the selection of potato tubers were evaluated with regard to their potential to influence acrylamide formation in French fries. The formation of acrylamide, which is a potential human carcinogen, can be minimized for a big extent by the selection of an appropriate tuber. This study focused on the following selection criteria: variety as influenced by storage time and soil type, underwater weight, and tuber size. A total of 16 varieties were compared, concerning their potential for acrylamide formation. From that survey, certain varieties, such as Tebina and Quincy, could be appointed as unsuitable for frying. The differences in the potential of acrylamide formation between the varieties could mainly be explained by the reducing sugar content of the potato (R2 = 0.82, n = 96). The investigated type of soil and storage time at 8 degrees C appeared to have a minor influence on the acrylamide formation during frying. On the other hand, the tuber size of the potato did contribute in a significant manner to the acrylamide formation. Smaller tubers were more susceptible to acrylamide formation and should be avoided in the frying process. The last selection parameter, the underwater weight, appeared to be of minor importance in the acrylamide formation. On the basis of these simple selection criteria, it is possible to make a first screening of potatoes to reduce the acrylamide formation during frying.

Influence of fertilization on acrylamide formation during frying of potatoes harvested in 2003.

The quality of the potato has been found to vary, when grown under different agricultural and environmental conditions, such as the level of fertilization. Consequently these factors may influence the acrylamide formation during the preparation of French fries. These assumptions were studied on three varieties: Bintje, Ramos, and Saturna from the harvest of 2003. Decreasing N fertilization caused increases in the reducing sugar concentration from 60% up to 100% on DM for all varieties studied. Due to a high correlation between the reducing sugar content and the generation of acrylamide during frying, this resulted in a parallel increase in the acrylamide concentration of the French fries. Thus by lowering the amount of N fertilizer, an increase of 30-65% of the acrylamide generation during frying could be observed. It seems of extreme importance to find an appropriate balance between the level of N fertilizer in order to diminish acrylamide formation but on the other hand to obtain an acceptable tuber and to consider the environmental impact. All results reported should be seen in the perspective of the warm growing season of 2003.

Influence of storage practices on acrylamide formation during potato frying.

A number of parameters linked to storage of potatoes were evaluated with regard to their potential to influence the acrylamide formation in French fries. Acrylamide, which is a potential human carcinogen, is reported to be formed during the frying of potatoes as a result of the reactions between asparagine and reducing sugars. This study was conducted using three potato varieties (Bintje, Ramos, and Saturna) typically used in Belgium, The Netherlands, and the northern part of France for French fry and crisp production. Saturna, mainly used in crisp production, appeared to be the least susceptible for acrylamide formation during frying. Especially storage at low temperatures (4 degrees C) compared to storage at 8 degrees C seemed to enhance acrylamide formation due to a strong increase in reducing sugars caused by low-temperature storage. Because of the reversible nature of this physiological reaction, it was possible to achieve a significant reduction of the reducing sugars after a reconditioning of the cold-stored potatoes for 3 weeks at 15 degrees C. All changes in acrylamide concentrations could mainly be explained by the reducing sugar content of the potato (R2 = 0.84, n = 160). This means that, by ensuring a low reducing sugar content of the potato tuber, the risk for acrylamide formation will largely be reduced. Finally the use of a sprout inhibitor did not influence the composition of the potato, and thus acrylamide formation was not susceptible to this treatment.