Effect of saline water ionic strength on phosphorus recovery from synthetic swine wastewater.

Declining worldwide phosphate rock reserves has driven a growing interest in exploration of alternative phosphate supplies. This study involved phosphorus recovery from swine wastewater through precipitation of struvite, a valuable slow-release fertiliser. The economic feasibility of this process is highly dependent on the cost of magnesium source. Two different magnesium sources were used for phosphorus recovery: pure magnesium chloride and nanofiltration (NF) saline water retentate. The paper focuses on the impact of ionic strength on phosphorus recovery performance that has not been reported elsewhere. Experimental design with five numerical variables (Mg/P molar ratio, pH, PO43--P, NH4+-N, and Ca2+ levels) and one categorical variable (type of magnesium source) was used to evaluate the effect of ionic strength on phosphorus removal and struvite purity. The experimental data were analysed using analysis of variance (ANOVA) and principal component analysis (PCA). Results indicated that a magnesium source obtained from NF retentate was as effective as MgCl2 for struvite precipitation. It was also revealed that ionic strength had a more positive effect on struvite purity than on phosphorus removal. Within the range of parameters studied in this research, high ionic strength, high pH and wastewater with high phosphate, high ammonium and low calcium contents were found to be the most favourable conditions for struvite precipitation. Findings from this study will be beneficial to determine the feasibility of using high ionic strength saline water, such as NF seawater retentate, as a magnesium source for phosphorus recovery from wastewater that is rich in ammonium-nitrogen and phosphate.

Effect of acetic acid on struvite precipitation: An exploration of product purity, morphology and reaction kinetics using central composite design.

Phosphorus recovery has attracted increasing interest due to the potential depletion of phosphorus resources. One promising solution is to recover phosphorus via struvite precipitation from wastewater or other waste that is in rich of phosphate. However, product quality control during such process is always challenging due to the variation and complexity of wastewater compositions. For example, subcritical wet oxidation (SCWO) effluent is rich in phosphorus and nitrogen but contains a large amount of acetic acid, while its effect on struvite recovery is hardly known. Therefore, central composite design (CCD), considering pH, acetic acid level, Mg level and Ca level, was used to evaluate the effect of acetic acid on struvite purity, phosphorus removal, morphology and reaction kinetics. The experimental data were statistically analysed by analysis of variance (ANOVA) and principal components analysis (PCA). The results indicate that pH and Mg level have a significant impact on phosphorus removal (pH: p-value < 0.0001, Mg: p-value < 0.0001) and struvite purity (pH: p-value = 0.0410, Mg: p-value < 0.0001), Ca level only affects the struvite purity (p-value = 0.0333). The presence of acetic acid, within the studied range (8.77-34.53 mM), has a negligible effect on struvite morphology, phosphorus removal and reaction kinetics, but a slightly positive effect on struvite purity. Findings of this research would be beneficial to determine the feasibility of acetic acid-rich wastewater as a phosphorus source for struvite recovery.

Mercury in Ringed Seals (Pusa hispida) from the Canadian Arctic in Relation to Time and Climate Parameters.

Mercury is found in Arctic marine mammals that are important in the diet of northern Indigenous peoples. The objectives of the present long-term study, spanning a 45-yr period, were to 1) investigate the temporal trends of total mercury (THg; muscle and liver) and selenium (Se; liver) in ringed seals (Pusa hispida) from different regions of the Canadian Arctic; and 2) examine possible relationships with age, diet, and climate parameters such as air temperature, precipitation, climatic indices, and ice-coverage. Ringed seals were collected by hunters in northern communities in the Beaufort Sea, Central Arctic, Eastern Baffin Island, Hudson Bay, and Ungava/Nunatsiavut regions (Canada) between 1972 and 2017. Mercury levels did not change through time in seal liver, but THg levels in muscle decreased in seals from Hudson Bay (-0.91%/yr) and Ungava/Nunatsiavut (-1.30%/yr). Carbon stable isotope values in seal muscle decreased significantly through time in 4 regions. Selenium-to-THg ratios were found to be >1 for all years and regions. Variation partitioning analyses across regions indicated that THg trends in seals were mostly explained by age (7.3-21.7%), climate parameters (3.5-12.5%), and diet (up to 9%); climate indices (i.e., Arctic and North Atlantic Oscillations, Pacific/North American pattern) explained the majority of the climate portion. The THg levels had a positive relationship with Arctic Oscillation for multiple regions. Associations of THg with air temperature, total precipitation, and sea-ice coverage, as well as with North Atlantic Oscillation and Pacific/North American pattern were found to vary with tissue type and geographical area. Environ Toxicol Chem 2020;39:2462-2474. © 2020 Her Majesty the Queen in Right of Canada. Environmental Toxicology and Chemistry published by Wiley Periodicals LLC on behalf of SETAC. Reproduced with the permission of the Minister of Fisheries and Oceans Canada.

Phosphorus recovery through struvite crystallisation: Recent developments in the understanding of operational factors.

Phosphorus is an essential element for life and is predicted to deplete within the next 100 years. Struvite crystallization is a potential phosphorus recovery technique to mitigate this problem by producing a slow release fertilizer. However, complex wastewater composition and a large number of process variables result in process uncertainties, making the process difficult to predict and control. This paper reviews the research progress on struvite crystallization fundamentals to address this challenge. The influence of manipulated variables (e.g. seed material, magnesium dosage and pH) and sources of variation on phosphorus removal efficiency (e.g. organics and heavy metal concentration) and product purity were investigated. Recently developed models to describe, control and optimize those variables were also discussed. This review helps to identify potential challenges in different wastewater streams and provide valuable information for future phosphorus recovery unit design. It therefore paves the way for commercialization of struvite crystallization in the future.

A new thermodynamic approach for struvite product quality prediction.

Struvite precipitation has drawn much attention in the last decade as a green chemical process for phosphorus removal and recovery. Product purity affects the usefulness, and thus price, of the product when recovered struvite is sold as fertilizer. However, there is currently little research on struvite quality, as well as on models for accurately predicting. This paper presents an alternative approach to the traditional thermodynamic model where the solid with the largest positive saturation index precipitates first, depleting the concentrations of constituent ions before the next solid can precipitate. In the new thermodynamic approach, all solids with a positive saturation index precipitate simultaneously, and deplete the common pool of available ions in tandem. It was validated against experimental data, compared with the traditional thermodynamic models and a previously developed empirical model. The proposed new approach was more accurate than other models, except when both the ammonium nitrogen and magnesium concentrations were very low, a condition not likely to be encountered in industry. Therefore, this model is more suited for predicting the performance of struvite precipitation under varying wastewater conditions.

Phosphate recovery from hydrothermally treated sewage sludge using struvite precipitation.

New technologies are needed to recover phosphate from organic wastes, such as sewage sludge. Sewage sludge can be hydrothermally treated to make it safe but this process is expensive. Recovering a valuable by-product, such as phosphate, could improve the economics of hydrothermal treatment. Therefore, the technical and preliminary differential cost analysis of combining hydrothermal treatment with phosphate recovery (by precipitation of magnesium ammonium phosphate (struvite)) was investigated. The effects of pH, magnesium ion dose, and either wet oxidation or thermal hydrolysis hydrothermal treatment were examined. Phosphate recovery was more sensitive to pH than magnesium ion concentration, with diminishing rates of recovery at high levels of both. Also, more struvite was recovered following wet oxidation treatment than thermal hydrolysis. Preliminary differential cost analysis showed that wet oxidation combined with precipitation at an optimal pH and magnesium ion dose could generate revenue.