Proteomic analysis to elucidate degeneration of Clostridium beijerinckii NCIMB 8052 and role of Ca(2+) in strain recovery from degeneration.

Degeneration of solventogenic Clostridium strains is one of the major barriers in bio-butanol production. A degenerated Clostridium beijerinckii NCIMB 8052 strain (DG-8052) was obtained without any genetic manipulation. Supplementation of CaCO3 to fermentation medium could partially recover metabolism of DG-8052 by more than 50 % increase of cell growth and solvent production. This study investigated the protein expression profile of DG-8052 and its response to CaCO3 treatment. Compared with WT-8052, the lower expressed proteins were responsible for disruption of RNA secondary structures and DNA repair, sporulation, signal transduction, transcription regulation, and membrane transport in DG-8052. Interestingly, accompanied with the decreased glucose utilization and lower solvent production, there was a decreased level of sigma-54 modulation protein which may indicate that the level of sigma-54 activity may be associated with the observed strain degeneration. For the addition of CaCO3, proteomic and biochemical study results revealed that besides buffer capacity, Ca(2+) could stabilize heat shock proteins, increase DNA synthesis and replication, and enhance expression of solventogenic enzymes in DG-8052, which has a similar contribution in WT-8052.

Elucidating and alleviating impacts of lignocellulose-derived microbial inhibitors on Clostridium beijerinckii during fermentation of Miscanthus giganteus to butanol.

Fermentation of liquid hot water (LHW) pretreated Miscanthus giganteus (MG) by Clostridium beijerinckii NCIMB 8052 was investigated towards understanding the toxicity of lignocellulose-derived inhibitors to solventogenic Clostridium species vis-à-vis butanol production. While C. beijerinckii NCIMB 8052 did not grow in undiluted MG hydrolysate-based fermentation medium, supplementation of this medium with Calcium carbonate enabled the growth of C. beijerinckii NCIMB 8052 and production of butanol. Using high-performance liquid chromatography (HPLC) and spectrophotometric assays, LHW-pretreated MG was found to contain lignocellulose-derived microbial inhibitory compounds; some of which were transformed by exponentially growing C. beijerinckii to less inhibitory compounds during fermentation. Contrary to all expectations, the reduction product of furfural, furfuryl alcohol, inhibited butanol production by C. beijerinckii by more than 16 %. Collectively, these results provide new insights into why lignocellulosic biomass hydrolysates are recalcitrant to fermentation to biofuels and chemicals.

Butanol production from agricultural residues: Impact of degradation products on Clostridium beijerinckii growth and butanol fermentation.

During pretreatment and hydrolysis of fiber-rich agricultural biomass, compounds such as salts, furfural, hydroxymethyl furfural (HMF), acetic, ferulic, glucuronic, rho-coumaric acids, and phenolic compounds are produced. Clostridium beijerinckii BA101 can utilize the individual sugars present in lignocellulosic [e.g., corn fiber, distillers dry grain solubles (DDGS), etc] hydrolysates such as cellobiose, glucose, mannose, arabinose, and xylose. In these studies we investigated the effect of some of the lignocellulosic hydrolysate inhibitors associated with C. beijerinckii BA101 growth and acetone-butanol-ethanol (ABE) production. When 0.3 g/L rho-coumaric and ferulic acids were introduced into the fermentation medium, growth and ABE production by C. beijerinckii BA101 decreased significantly. Furfural and HMF are not inhibitory to C. beijerinckii BA101; rather they have stimulatory effect on the growth of the microorganism and ABE production.

Maintenance of DeltapH by a butanol-tolerant mutant of Clostridium beijerinckii.

The isolation of Clostridium beijerinckii mutants that are more tolerant of butanol than the wild-type offered the opportunity to investigate whether the membrane activities which are required for maintaining the transmembrane DeltapH (the difference in pH between the cellular interior and exterior) are sensitive targets of butanol toxicity. The DeltapH was measured by the accumulation of [14C]benzoate using late-exponential-phase cells which were suspended in citrate/phosphate buffer at pH 5 (to maximize the DeltapH component of the protonmotive force) and supplemented with glucose and Mg2+. The DeltapH of the butanol-tolerant tolerant mutant, strain BR54, of C. beijerinckii NCIMB 8052 was found to be significantly more tolerant of added butanol than the wild-type. Thus, in potassium citrate/phosphate buffer the mutant cells maintained a DeltapH of 1.4 when butanol was added to a concentration of 1.5 % (w/v), while the wild-type DeltapH was reduced to 0.1. The DeltapH of both strains was completely dissipated with 1.75 % butanol, an effect attributed to a chaotropic effect on the membrane phospholipids. Similar results were obtained in sodium citrate/phosphate buffer. In the absence of added Mg2+, the DeltapH of the mutant decreased in both sodium and potassium citrate/phosphate buffer, but more rapidly in the former. Interestingly, the addition of butanol at low concentrations (0.8 %) prevented this DeltapH dissipation, but only in cells suspended in sodium citrate/phosphate buffer, and not in potassium citrate/phosphate buffer. In wild-type cells the decrease in DeltapH occurred more slowly than in the mutant, and sparing of the DeltapH by 0.8 % butanol was less pronounced. The authors interpret these data to mean that the DeltapH is dissipated in the absence of Mg2+ by a Na+- or K+-linked process, possibly by a Na+/H+ or a K+/H+ antiporter, and that the former is inhibited by butanol. Apparently, butanol can selectively affect a membrane-associated function at concentrations lower than required for the complete dissipation of transmembrane ion gradients. Additionally, since the butanol-tolerant mutant BR54 is deficient in the ability to detoxify methylglyoxal (MG) and contains higher levels of MG than the wild-type, the higher Na+/H+ antiporter activity of the mutant may be due to the greater degree of protein glycation by MG in the mutant cells. The mechanism of butanol tolerance may be an indirect result of the elevated glycation of cell proteins in the mutant strain. Analysis of membrane protein fractions revealed that mutant cells contained significantly lower levels of unmodified arginine residues than those of the wild-type cells, and that unmodified arginine residues of the wild-type were decreased by exposure of the growing cells to added MG.