Development of a self-microemulsifying drug delivery system to deliver delamanid via a pressurized metered dose inhaler for treatment of multi-drug resistant pulmonary tuberculosis.

Tuberculosis (TB) is a serious health issue that contributes to millions of deaths throughout the world and increases the threat of serious pulmonary infections in patients with respiratory illness. Delamanid is a novel drug approved in 2014 to deal with multi-drug resistant TB (MDR-TB). Despite its high efficiency in TB treatment, delamanid poses delivery challenges due to poor water solubility leading to inadequate absorption upon oral administration. This study involves the development of novel formulation-based pressurized metered dose inhalers (pMDIs) containing self-microemulsifying mixtures of delamanid for efficient delivery to the lungs. To identify the appropriate self-microemulsifying formulations, ternary diagrams were plotted using different combinations of surfactant to co-surfactant ratios (1:1, 2:1, and 3:1). The combinations used Cremophor RH40, Poly Ethylene Glycol 400 (PEG 400), and peppermint oil, and those that showed the maximum microemulsion region and rapid and stable emulsification were selected for further characterization. The diluted self-microemulsifying mixtures underwent evaluation of dose uniformity, droplet size, zeta potential, and transmission electron microscopy. The selected formulations exhibited uniform delivery of the dose throughout the canister life, along with droplet sizes and zeta potentials that ranged from 24.74 to 88.99 nm and - 19.27 to - 10.00 mV, respectively. The aerosol performance of each self-microemulsifying drug delivery system (SMEDDS)-pMDI was assessed using the Next Generation Impactor, which indicated their capability to deliver the drug to the deeper areas of the lungs. In vitro cytotoxicity testing on A549 and NCI-H358 cells revealed no significant signs of toxicity up to a concentration of 1.56 µg/mL. The antimycobacterial activity of the formulations was evaluated against Mycobacterium bovis using flow cytometry analysis, which showed complete inhibition by day 5 with a minimum bactericidal concentration of 0.313 µg/mL. Moreover, the cellular uptake studies showed efficient delivery of the formulations inside macrophage cells, which indicated the potential for intracellular antimycobacterial activity. These findings demonstrated the potential of the Delamanid-SMEDDS-pMDI for efficient pulmonary delivery of delamanid to improve its effectiveness in the treatment of multi-drug resistant pulmonary TB.

Thinking "Green" When Treating "Pink Puffers" and "Blue Bloaters"-Reducing Carbon Footprint When Prescribing Inhalers.

The impact of man-made climate change is already affecting millions of people worldwide. The health care sector in the US is a relevant contributor, accounting for about 8 to 10% of national greenhouse gas emissions. This special communication describes the harmful impact of propellant gases in metered dose inhalers (MDI) on the climate and summarizes and discusses current knowledge and recommendations from European countries. Dry powder inhalers (DPI) are a good alternative to MDIs and are available for all inhaler drug classes recommended in current asthma and COPD guidelines. Changing an MDI to PDI can significantly reduce carbon footprints. The majority of the US population is willing to do more to protect the climate. Primary care providers can engage in this by addressing the impacts of drug therapy on climate change in medical decision making.

Economic Evaluation of Triple Therapy with Budesonide/Glycopyrrolate/Formoterol Fumarate for the Treatment of Moderate to Very Severe Chronic Obstructive Pulmonary Disease in China Using a Semi-Markov Model.

BACKGROUND: Chronic obstructive pulmonary disease (COPD) is a highly prevalent chronic respiratory disease with considerable clinical and socioeconomic impact. Budesonide/glycopyrrolate/formoterol fumarate (BGF) is a newly approved pharmacotherapy for COPD in China that has been shown to improve lung function and reduce the risk of exacerbations, but the cost-effectiveness of BGF remains unknown. The objective of this study was to evaluate the cost-effectiveness of BGF in patients with moderate to very severe COPD from a Chinese healthcare system perspective. METHODS: A semi-Markov model was developed to compare the costs and benefit of treatment with BGF versus a composite comparator of long-acting muscarinic antagonist/long-acting ß2-agonist (LAMA/LABA) therapies. Clinical inputs for BGF and the composite comparator were based on the KRONOS study (NCT02497001) and a network meta-analysis. Cost inputs were derived from published literature and Chinese government documents, supplemented by expert opinion where necessary. Health-related quality-of-life inputs were also obtained based on the KRONOS study. Lifetime costs, number of exacerbations, quality-adjusted life-years (QALYs), and incremental cost-effectiveness ratios (ICERs) were estimated. Costs were measured in 2020 Chinese Yuan (CN¥) and converted into US dollars (US$). Scenario analyses and sensitivity analyses were conducted. RESULTS: Over the lifetime horizon, BGF treatment led to fewer moderate and severe exacerbations (4.01 and 0.87, respectively) versus the composite comparator (8.42 and 2.04, respectively), with a base-case ICER of CN¥13,685.94 (US$1983.47) per QALY gained. Scenario analyses considering different population and utilities resulted in ICERs ranging from dominant to CN¥13,673.91 (US$1981.73). Extensive sensitivity analyses indicated robust base-case results since all analyses yielded ICERs below the conservative cost-effectiveness threshold of one times the Chinese per capita gross domestic product (CN¥72,447.00 [US$10,499.57], 2020). CONCLUSION: Triple therapy with BGF was predicted to improve outcomes and be a cost-effective treatment option compared with LAMA/LABA therapies for patients with moderate to very severe COPD in China.

[Fixed combination of budesonide, formoterol, glycopyrronium for the treatment of severe COPD : Trixeo Aerosphere®]. / Le médicament du mois. Combinaison fixe budésonide, formotérol, glycopyronium pour le traitement de la BPCO modérée à sévère : Trixeo Aerosphère®.

Here we present pharmacological and clinical properties of a new fixed triple inhaled combination including an inhaled corticoid, a long acting ?2 agonist and a long acting anticholinergic for the treatment of severe chronic obstructive pulmonary disease (COPD). Trixeo Aerosphere® is the name of this triple combination which contains 160 µg budesonide, 4,8 µg formoterol and 9 µg glycopyrronium delivered by a pMDI. As compared to a budesonide/formoterol combination, Trixeo Aerosphere® improves forced expiratory volume in the first second (FEV1). As compared to glycopyrronium/formoterol combination, Trixeo Aerosphere® reduces exacerbation rate, improved quality of life and most importantly reduces mortality with a benefit increasing with blood eosinophil count. Trixeo Aerosphere® 320/18/9.6 is delivered twice daily 2 inhalations and is indicated in moderate to severe COPD insufficiently controlled by LABA/LAMA (long-acting ?2-adrenergic receptor agonist/ long-acting ?2-muscarinic receptor agonist) or ICS/LABA (inhaled corticosteroid/long-acting ?2-adrenergic receptor agonist).

Nous présentons dans cet article les propriétés pharmacologiques et les effets cliniques d'une nouvelle triple combinaison fixe inhalée comprenant un corticoïde inhalé, un ?2 mimétique à longue durée d'action et un anticholinergique à longue durée d'action, destinée au traitement de la bronchopneumopathie chronique obstructive (BPCO) sévère. Cette combinaison qui porte le nom de Trixeo Aerosphere® regroupe, dans le même dispositif, 160 µg de budésonide, 4,8 µg de formotérol et 18 µg de glycopyrronium. Par rapport à une combinaison budésonide/formotérol, le Trixeo Aerosphere® améliore la valeur du volume expiratoire maximum par seconde (VEMS). Par rapport à une combinaison formotérol/glycopyrronium, le Trixeo Aerosphere® réduit la fréquence des exacerbations et réduit la mortalité avec un bénéfice qui augmente avec le taux des éosinophiles circulants. Le Trixeo Aerosphere®, à la dose de 2X2 bouffées/24h, est indiqué dans le traitement des patients BPCO modérés à sévères insuffisamment contrôlés par une bithérapie LABA/LAMA (long-acting ?2-adrenergic receptor agonist/ long-acting ?2-muscarinic receptor agonist) ou ICS/LABA (inhaled corticosteroid/long-acting ?2-adrenergic receptor agonist).

Budesonide/Glycopyrronium/Formoterol: A Review in COPD.

Budesonide/glycopyrronium/formoterol (BREZTRI AEROSPHERE™; TRIXEO AEROSPHERE™) is an inhaled fixed-dose combination of the inhaled corticosteroid (ICS) budesonide, the long-acting muscarinic antagonist (LAMA) glycopyrronium bromide and the long-acting ß2-agonist (LABA) formoterol fumarate approved for the maintenance treatment of chronic obstructive pulmonary disease (COPD). It is delivered via a pressurized metered-dose Aerosphere inhaler and is formulated using co-suspension delivery technology. In two pivotal phase III trials of 24-52 weeks' duration, budesonide/glycopyrronium/formoterol reduced the rates of moderate/severe COPD exacerbations and improved lung function to a greater extent than budesonide/formoterol and/or glycopyrronium/formoterol. Budesonide/glycopyrronium/formoterol also demonstrated beneficial effects on dyspnoea, rescue medication requirements and health-related quality of life (HR-QOL), and reduced the risk of all-cause mortality. Budesonide/glycopyrronium/formoterol was generally well tolerated, with the tolerability profile being generally similar to that of the individual components. Budesonide/glycopyrronium/formoterol provides a useful and convenient option for the maintenance treatment of COPD, including for patients whose disease is inadequately controlled with dual ICS/LABA or LAMA/LABA therapy.

Chronic obstructive pulmonary disease (COPD) is an inflammatory lung disease that is characterized by chronic airflow limitation and persistent respiratory symptoms. A step-up treatment approach combining an inhaled corticosteroid (ICS), a long-acting muscarinic antagonist (LAMA) and a long-acting ß₂-agonist (LABA) may provide clinical benefits in patients with COPD whose disease is inadequately controlled by dual therapies (ICS/LABA or LAMA/LABA). Budesonide/glycopyrronium/formoterol (BREZTRI AEROSPHERE™; TRIXEO AEROSPHERE™) is a fixed-dose ICS/LAMA/LABA combination approved for the maintenance treatment of COPD. It is administered twice daily via a single pressurized metered-dose Aerosphere inhaler. Patients with moderate to very severe COPD receiving budesonide/glycopyrronium/formoterol had fewer moderate or severe COPD exacerbations and improved lung function, respiratory symptoms and quality of life compared with patients receiving ICS/LABA or LAMA/LABA therapy. The risk of death was reduced compared with that of patients receiving LAMA/LABA therapy. Budesonide/glycopyrronium/formoterol was generally well tolerated, with similar rates of adverse events to dual therapy. Budesonide/glycopyrronium/formoterol is a useful and convenient option for the maintenance treatment of COPD.

Can we minimize carbon footprint by using "greener" inhalers and improve clinical outcome at the same time in asthma therapy?

The treatment of patients with obstructive airway diseases is based on the use of inhalation preparations. Some of them, mainly including pressurized metered dose inhalers (pMDIs), contain compressed gases - hydrofluoroalkanes, which generate carbon dioxide emissions, creating the so-called carbon footprint. AIM: The aim of the study was to evaluate the consumption of individual active substances, the types of inhalers used and calculation of the carbon footprint of therapies in patients with asthma in 2018 and 2019 in Poland. MATERIALS AND METHODS: The ratio of pMDI vs DPI (dry powder inhaler) data and the data on using in patients with asthma long-acting ß2-agonists (LABAs), short-acting ß2-agonists antagonists (SABAs), long-acting muscarinic antagonists (LAMAs), LAMA+LABAs, LAMA+LABA+ICSs (inhaled corticosteroids) on Polish market during 2018 and 2019 were analyzed. The carbon footprint of such therapies was counted. Then, we studied the reduction of the carbon footprint for scenario A (reducing pMDI by 50%) and scenario B (reducing pMDI by 80%) in the following steps of analysis. RESULTS: The general structure of pMDI/DPI in Poland in asthma patients was not changed in 2019 vs 2018. The carbon footprint is primarily created by pMDI SABAs. In 2019 in Poland pMDI SABAs were 1.9 mio units (the same as in 2018), which generated 36.8 kt CO2e annually. Scenario A gives us a benefit of 17.4 kt CO2e reduction and scenario B brings us a benefit of 28.0 kt CO2e reduction of emissions. CONCLUSIONS: Despite Poland's ratification the Kigali amendment did not affect pMDI consumption by asthma patients and did not reduce the carbon footprint. The lower carbon footprint of DPIs should be considered alongside other factors when choosing inhalation devices.

Improvements in lung function with budesonide/glycopyrrolate/formoterol fumarate metered dose inhaler versus dual therapies in patients with COPD: a sub-study of the ETHOS trial.

BACKGROUND: In the phase III, 52-week ETHOS study in patients with moderate to very severe chronic obstructive pulmonary disease (COPD), triple therapy with budesonide/glycopyrrolate/formoterol fumarate (BGF), at two inhaled corticosteroid dose levels, resulted in significantly lower moderate/severe exacerbation rates versus glycopyrrolate/formoterol fumarate (GFF) and budesonide/formoterol fumarate (BFF). Here, we report results from the ETHOS pulmonary function test (PFT) sub-study, which assessed lung function in a subset of ETHOS patients. METHODS: ETHOS (NCT02465567) was a randomized, double-blind, multi-center, parallel-group study in patients with moderate to very severe COPD who had experienced ⩾1 moderate/severe exacerbation in the previous year. Patients received BGF 320/18/9.6 µg, BGF 160/18/9.6 µg, GFF 18/9.6 µg, or BFF 320/9.6 µg twice daily via a single metered dose Aerosphere inhaler for 52 weeks. A subset of patients participated in the 4-hour PFT sub-study; primary endpoints were change from baseline in morning pre-dose trough forced expiratory volume in one second (FEV1) versus GFF and FEV1 area under the curve from 0 to 4 hours (AUC0-4) versus BFF at week 24. RESULTS: The PFT modified intent-to-treat population included 3088 patients (mean age 64.4 years; mean reversibility post-albuterol 16.7%; mean post-albuterol FEV1% predicted 42.8). BGF 320/18/9.6 µg and 160/18/9.6 µg significantly improved morning pre-dose trough FEV1 at week 24 versus GFF (p ⩽ 0.0035 for both). Improvements in trough FEV1 were also observed at week 52 for BGF 320/18/9.6 µg and 160/18/9.6 µg versus GFF (p ⩽ 0.0005 for both). For FEV1 AUC0-4 at week 24, BGF 320/18/9.6 µg and 160/18/9.6 µg showed significant improvements versus BFF (p < 0.0001 for both). Improvements were maintained at week 52 (p < 0.0001). CONCLUSIONS: BGF 320/18/9.6 µg and 160/18/9.6 µg significantly improved trough FEV1versus GFF and FEV1 AUC0-4versus BFF at week 24. The lung function benefits with both doses of BGF were maintained following 52 weeks of treatment.The reviews of this paper are available via the supplemental material section.

Development and in vitro characterization of a novel pMDI diclofenac formulation as an inhalable anti-inflammatory therapy for cystic fibrosis.

Anti-inflammatory treatment options for cystic fibrosis (CF) patients are currently limited and as such, there is an imperative need to develop new anti-inflammatory agents to reduce the persistent inflammation present within CF lungs. This study explored the potential of Diclofenac (DICLO) as a novel inhaled anti-inflammatory drug for CF treatment. The anti-inflammatory activity of DICLO on an air-liquid interface (ALI) cell culture model of healthy (NuLi-1) and CF (CuFi-1) airways showed a significant reduction in the secretion of pro-inflammatory cytokines, IL-6 and IL-8. Therefore, pressurized metered dose inhaler (pMDI) DICLO formulations were developed to allow targeted DICLO delivery to CF airways. As such, two pMDI DICLO formulations with varying ethanol concentrations: 5% (w/w) equating to 150 µg of DICLO per dose (Low dose), and 15% (w/w) equating to 430 µg of DICLO per dose (High dose) were developed and characterized to determine the optimum formulation. The Low dose pMDI DICLO formulation showed a significantly smaller particle diameter with uniform distribution resulting in a greater aerosol performance when compared to High dose formulation. Consequently, the Low dose pMDI DICLO formulation was further evaluated in terms of in vitro transport characteristics and anti-inflammatory activity. Importantly, the DICLO pMDI displayed anti-inflammatory activity in both healthy and CF in vitro models, highlighting the potential of an aerosolized low-dose DICLO formulation as a promising inhaled anti-inflammatory therapy for CF treatment.

Global Quality Statements on Reliever Use in Asthma in Adults and Children Older than 5 Years of Age.

INTRODUCTION: Widespread misuse of short-acting beta-agonists (SABAs) may contribute to asthma-related morbidity and mortality. Recognizing this, the Global Initiative for Asthma neither recommends SABA monotherapy nor regards this formulation as a preferred reliever. Many health systems and healthcare professionals (HCPs) experience practical issues in implementing guidelines. Clear quality standards can drive improvements in asthma care and encourage implementation of global and national medical guidelines. METHODS: A steering group of global asthma experts came together between May and September 2019 to develop quality statements codifying the minimum elements of good quality asthma care. These statements were either evidence based (when robust evidence was available) or reflected a consensus based on clinical expertise and experience of the group. RESULTS: The quality statements (and associated essential criteria) developed emphasize key elements concerning (1) objective diagnosis specific to individual symptoms, (2) treatment appropriate to the long-term management of asthma as an inflammatory disease, consistent with evidence-based recommendations, (3) controlled dispensing of SABA canisters and monitoring to prevent overuse, (4) regular review of patients after treatment initiation or change, and (5) follow-up of patients in primary care after treatment for an exacerbation in a hospital or an emergency department. CONCLUSIONS: The steering group proposes quality statements that national and local clinical groups can implement as quantitative quality standards that are appropriate to their local circumstances, including during the coronavirus disease 2019 (Covid-19) pandemic. By translating these statements into locally relevant quality standards, primary care physicians and HCPs can encourage optimal management and reduce preventable healthcare interactions. The evidence-based evolution of care encapsulated in these statements will further engender high-quality, patient-centered holistic management that addresses asthma as an inflammatory disease. In particular, the statements empower self-management by patients and encourage health-promoting behaviors, which are essential to reduce exacerbations, the primary goal of asthma management.

Long-acting dual bronchodilator therapy (indacaterol/glycopyrronium) versus nebulized short-acting dual bronchodilator (salbutamol/ipratropium) in chronic obstructive pulmonary disease: A double-blind, randomized, placebo-controlled trial.

INTRODUCTION: Most guidelines recommend long-acting bronchodilators over short-acting bronchodilators for patients with chronic obstructive pulmonary disease (COPD). The available evidence for the guidelines was based on dry powder or pressurized metered dose inhalers, but not nebulizations. Nevertheless, there is considerable, poorly evidenced based, use of short acting nebulized bronchodilators. METHODS: This was an investigator initiated, randomized, active controlled, cross-over, double-blind and double-dummy single centre study in patients with stable COPD. The active comparators were indacaterol/glycopyrronium 110/50 µg as Ultibro® via Breezhaler® (IND/GLY) and salbutamol/ipratropium 2,5/0,5 mg via air driven nebulization (SAL/IPR), both given as a single dose on separate days. The primary end point was the area under the FEV1 curve from baseline till 6 h. Secondary end points included change in Borg dyspnoea score, adverse events and change in hyperinflation measured by the inspiratory capacity. RESULTS: A total of 33 COPD patients completed the trial and were evaluable, most of them were ex-smokers. The difference between the tested regimens for the primary endpoint, FEV1 AUC 0-6 h, 2965 ± 1544 mL (mean ± SD) for IND/GLY versus 3513 ± 1762 mL for SAL/IPR, was not significant (P = 0.08). The peak in FEV1 was higher and was reached faster with SAL/IPR compared to IND/GLY. No other significant differences were detected for the secondary endpoints including the Borg score, or adverse events. CONCLUSION: Among patients with stable COPD, dry powder long-acting single inhalation of a LABA and a LAMA (IND/GLY) was not superior compared to nebulized short-acting salbutamol plus ipratropium (SAL/IPR) in its bronchodilating effects over 6 h.The effects of the nebulization kicked in faster and peaked higher. The observed differences may be caused by the difference in dosing between the two regimens. The improvement in Borg dyspnoea score did not favour the nebulization. Long-term outcomes were not assessed in this study.

Pharmacotherapeutic management of asthma in the elderly patient.

INTRODUCTION: Asthma is a heterogeneous syndrome with variable phenotypes. Reversible airway obstruction and airway hyper-responsiveness often with an atopic or eosinophilic component is common in the elderly asthmatic. Asthma chronic obstructive pulmonary disease overlap syndrome (ACOS), a combination of atopy-mediated airway hyper-responsiveness and a history of smoking or other environmental noxious exposures, can lead to some fixed airway obstruction and is also common in elderly patients. Little specific data exist for the treating the elderly asthmatic, thus requiring the clinician to extrapolate from general adult data and asthma treatment guidelines. AREAS COVERED: A stepwise approach to pharmacotherapy of the elderly patient with asthma and ACOS is offered and the literature supporting the use of each class of drugs reviewed. EXPERT OPINION: Inhaled, long-acting bronchodilators in combination with inhaled corticosteroids represent the backbone of treatment for the elderly patient with asthma or ACOS . Beyond these medications used as direct bronchodilators and topical anti-inflammatory agents, a stepwise approach to escalation of therapy includes multiple options such as oral leukotriene receptor antagonist or 5-lipoxygense inhibitor therapy, oral phosphodiesterase inhibitors, systemic corticosteroids, oral macrolide antibiotics and if evidence of eosinophilic/atopic component disease exists then modifying monoclonal antibody therapies.

Efficacy of Budesonide/Glycopyrronium/Formoterol Fumarate Metered Dose Inhaler (BGF MDI) Versus Other Inhaled Corticosteroid/Long-Acting Muscarinic Antagonist/Long-Acting ß2-Agonist (ICS/LAMA/LABA) Triple Combinations in COPD: A Systematic Literature Review and Network Meta-analysis.

INTRODUCTION: Triple inhaled corticosteroid/long-acting muscarinic antagonist/long-acting ß2-agonist (ICS/LAMA/LABA) combination therapy is recommended for patients with chronic obstructive pulmonary disease (COPD) who experience further exacerbations/symptoms on dual LAMA/LABA or ICS/LABA therapy. The relative efficacy of budesonide/glycopyrronium/formoterol fumarate metered dose inhaler 320/18/9.6 µg (BGF MDI) in COPD was compared with other ICS/LAMA/LABA fixed-dose and open combination therapies in a network meta-analysis (NMA). METHODS: A systematic literature review was conducted to identify randomized controlled trials of at least 10-week duration, including at least one fixed-dose or open combination triple therapy arm, in patients with moderate to very severe COPD. Studies were assessed for methodological quality and risk of bias. A three-level hierarchical Bayesian NMA model was used to determine the exacerbation rate per patient per year as well as the following outcomes at week 24: changes from baseline in pre-dose trough forced expiratory volume in 1 s (FEV1), post-dose peak FEV1, and St. George's Respiratory Questionnaire (SGRQ) total score; proportion of SGRQ responders; and Transition Dyspnea Index focal score. Change from baseline in rescue medication use over weeks 12-24 was also analyzed. Meta-regression and sensitivity analyses were used to assess heterogeneity across studies. RESULTS: Eighteen studies (n = 29,232 patients) contributed to the NMA. ICS/LABA dual combinations were combined as a single treatment group to create a connected network. Across all outcomes, there were no statistically significant differences between BGF MDI and other triple ICS/LAMA/LABA fixed-dose (fluticasone furoate/umeclidinium/vilanterol and beclomethasone dipropionate/glycopyrronium/formoterol fumarate) and open combinations with data available within the network. Results from sensitivity analyses and meta-regression were consistent with the base-case scenario. CONCLUSION: This NMA suggested that BGF MDI has comparable efficacy to other ICS/LAMA/LABA fixed-dose and open triple combination therapies in reducing exacerbations and improving lung function and symptoms in patients with moderate to very severe COPD. Further research is warranted as additional evidence regarding triple therapies, especially fixed-dose combinations, becomes available.

Efficacy And Safety Of Glycopyrrolate/Formoterol Fumarate Metered Dose Inhaler (GFF MDI) Formulated Using Co-Suspension Delivery Technology In Chinese Patients With COPD.

Background: Glycopyrrolate/formoterol fumarate metered dose inhaler (GFF MDI) is a long-acting muscarinic antagonist/long-acting ß2-agonist fixed-dose combination therapy delivered by MDI, formulated using innovative co-suspension delivery technology. The PINNACLE-4 study evaluated the efficacy and safety of GFF MDI in patients with moderate-to-very severe chronic obstructive pulmonary disease (COPD) from Asia, Europe, and the USA. This article presents the results from the China subpopulation of PINNACLE-4. Methods: In this randomized, double-blind, placebo-controlled, parallel-group Phase III study (NCT02343458), patients received GFF MDI 18/9.6 µg, glycopyrrolate (GP) MDI 18 µg, formoterol fumarate (FF) MDI 9.6 µg, or placebo MDI (all twice daily) for 24 weeks. The primary endpoint was change from baseline in morning pre-dose trough forced expiratory volume in 1 second at Week 24. Secondary lung function endpoints and patient-reported outcome measures were also assessed. Safety was monitored throughout the study. Results: Overall, 466 patients from China were included in the intent-to-treat population (mean age 63.6 years, 95.7% male). Treatment with GFF MDI improved the primary endpoint compared to GP MDI, FF MDI, and placebo MDI (least squares mean differences: 98, 104, and 173 mL, respectively; all P≤0.0001). GFF MDI also improved daily total symptom scores and time to first clinically important deterioration versus monocomponents and placebo MDI, and Transition Dyspnea Index focal score versus placebo MDI. Rates of treatment-emergent adverse events were similar across the active treatment groups and slightly higher in the placebo MDI group. Conclusion: GFF MDI improved lung function and daily symptoms versus monocomponents and placebo MDI and improved dyspnea versus placebo MDI. All treatments were well tolerated with no unexpected safety findings. Efficacy and safety results were generally consistent with the global PINNACLE-4 population, supporting the use of GFF MDI in patients with COPD from China.

Carbon footprint of inhalers in COPD therapy in 2018 and 2019 in Poland in response to the Kigali amendment.

The treatment of patients with obstructive airway diseases is based on the use of inhalation preparations. Some of them, mainly including pressurized metered dose inhalers (pMDIs), contain compressed gases - hydrofluoroalkanes, which generate carbon dioxide emissions, creating the so-called carbon footprint. AIM: The aim of the study was to evaluate the consumption of individual active substances, the types of inhalers used and calculation of the carbon footprint of popular therapies in 2018 and 2019 in Poland. MATERIALS AND METHODS: The ratio of pMDI vs DPI (dry powder inhaler) data and the data on using long-acting ß2-agonists (LABAs), shortacting muscarinic antagonists (SAMAs), long-acting muscarinic antagonists (LAMAs), LAMA+LABAs, LAMA+LABA+ICSs (inhaled corticosteroids) on Polish market during 2018 and 2019 were analyzed. The carbon footprint of such therapies was counted. Then, we studied the reduction of the carbon footprint for scenario A (reducing pMDI by 50%) and scenario B (reducing pMDI by 80%) in the following steps of analysis. RESULTS: The general structure of pMDI/DPI in Poland in COPD area was not changed in 2019 vs 2018. The carbon footprint is primarily created by pMDI SAMAs. In 2019 in Poland pMDI SAMAs were 1.6 mio units (the same as in 2018), which generated 33.5 kt CO2e annually, but the whole category generates 40.8 kt CO2e. Scenario A gives us a benefit of 18.8 kt CO2e reduction and scenario B brings us a benefit of 29.9 kt CO2e reduction of emissions. CONCLUSIONS: Despite Poland's ratification the Kigali amendment did not affect pMDI consumption and did not reduce the carbon footprint. The lower carbon footprint of DPIs should be considered alongside other factors when choosing inhalation devices.

100 Years of Drug Delivery to the Lungs.

Inhalation therapy is one of the oldest approaches to the therapy of diseases of the respiratory tract. It is well recognised today that the most effective and safe means of treating the lungs is to deliver drugs directly to the airways. Surprisingly, the delivery of therapeutic aerosols has a rich history dating back more than 2,000 years to Ayurvedic medicine in India, but in many respects, the introduction of the first pressurised metered-dose inhaler (pMDI) in 1956 marked the beginning of the modern pharmaceutical aerosol industry. The pMDI was the first truly portable and convenient inhaler that effectively delivered drug to the lung and quickly gained widespread acceptance. Since 1956, the pharmaceutical aerosol industry has experienced dramatic growth. The signing of the Montreal Protocol in 1987 to reduce the use of CFCs as propellants for aerosols led to a surge in innovation that resulted in the diversification of inhaler technologies with significantly enhanced delivery efficiency, including modern pMDIs, dry powder inhalers and nebuliser systems. There is also great interest in tailoring particle size to deliver drugs to treat specific areas of the respiratory tract. One challenge that has been present since antiquity still exists, however, and that is ensuring that the patient has access to the medication and understands how to use it effectively. In this article, we will provide a summary of therapeutic aerosol delivery systems from ancient times to the present along with a look to the future.

A phase III study of triple therapy with budesonide/glycopyrrolate/formoterol fumarate metered dose inhaler 320/18/9.6 µg and 160/18/9.6 µg using co-suspension delivery technology in moderate-to-very severe COPD: The ETHOS study protocol.

BACKGROUND: Single inhaler triple therapies providing an inhaled corticosteroid, a long-acting muscarinic antagonist, and a long-acting ß2-agonist (ICS/LAMA/LABAs) are an emerging treatment option for chronic obstructive pulmonary disease (COPD). Nevertheless, questions remain regarding the optimal patient population for triple therapy as well as the benefit:risk ratio of ICS treatment. METHODS: ETHOS is an ongoing, randomized, double-blind, multicenter, parallel-group, 52-week study in symptomatic patients with moderate-to-very severe COPD and a history of exacerbation(s) in the previous year. Two doses of single inhaler triple therapy with budesonide/glycopyrrolate/formoterol fumarate metered dose inhaler (BGF MDI 320/18/9.6 µg and 160/18/9.6 µg) will be compared to glycopyrrolate/formoterol fumarate (GFF) MDI 18/9.6 µg and budesonide/formoterol fumarate (BFF) MDI 320/9.6 µg, all formulated using co-suspension delivery technology. Outcomes include the rate of moderate/severe (primary endpoint) and severe COPD exacerbations, symptoms, quality of life, and all-cause mortality. Sub-studies will assess lung function and cardiovascular safety. STUDY POPULATION: From June 2015-July 2018, 16,044 patients were screened and 8572 were randomized. Preliminary baseline demographics show that 55.9% of patients had experienced ≥2 moderate/severe exacerbations in the previous year, 79.1% were receiving an ICS-containing treatment at study entry, and 59.9% had blood eosinophil counts ≥150 cells/mm3. CONCLUSIONS: ETHOS will provide data on exacerbations, patient-reported outcomes, mortality, and safety in 8572 patients with moderate-to-very severe COPD receiving triple and dual fixed-dose combinations. For the first time, ICS/LAMA/LABA triple therapy with two different doses of ICS will be compared to dual ICS/LABA and LAMA/LABA therapies. CLINICAL TRIAL REGISTRATION NUMBER: NCT02465567.

Triple versus dual inhaler therapy in moderate-to-severe COPD: A systematic review and meta-analysis of randomized controlled trials.

INTRODUCTION: Treatment of chronic obstructive pulmonary disease (COPD) is evolving specially with triple inhaler therapy. OBJECTIVES: To perform a meta-analysis to ascertain the safety and efficacy of triple inhaler therapy consisting of an inhaled-glucocorticoid (ICS), long-acting muscarinic antagonist (LAMA) and long-acting beta2-agonist (LABA) when compared with dual therapy (ICS-LABA or LAMA-LABA). METHODS: We performed an electronic database search to include randomized controlled trials (RCTs) comparing between triple and dual inhalers. Pooled rate-ratio (RR) or odds-ratio (OR) for dichotomous data and weighted mean difference (MD) for continuous data were calculated with their corresponding 95% confidence interval (CI). RESULTS: Our study included 12 RCTs totaling 19,322 patients, mean age of 65 ± 8.2 years and 68.2% were male. Pooled analysis demonstrated a significant reduction in moderate-to-severe COPD exacerbations with triple therapy (RR 0.75; 95% CI 0.69-0.83; P < 0.01). Additionally, triple therapy caused significant increase in trough FEV1 (MD 0.09 L; 95% CI 0.07-0.12; P < 0.01), significant reduction in the mean St. George's Respiratory Questionnaire (SGRQ) score (MD -1.67; 95% CI -2.02- -1.31; P < 0.01), and more patients experienced ≥ 4 points reduction of SGRQ score (OR 1.27; 95% CI 1.19-1.35; P < 0.01). Triple therapy was associated with an increased risk of pneumonia when compared to LABA/LAMA (OR 1.25; 95% 1.03-1.97; P = 0.03) but there were no significant differences in other adverse events between triple and dual inhalers. CONCLUSIONS: Among patients with moderate-to-severe COPD, triple inhaler therapy was associated with a reduction of moderate-to-severe COPD exacerbations, improved lung function and improved quality of life when compared to dual inhaler therapy but with an increased pneumonia risk.

Characterization of the suspension stability of pharmaceuticals using a shadowgraphic imaging method.

A new shadowgraphic imaging method and an associated instrument for analyzing the physical stability of pharmaceutical suspensions are introduced in this paper. The new suspension tester consists mainly of a high-resolution camera that takes sequential shadowgraphic images of emulsions or suspensions and a 2D collimated LED for simultaneous whole-sample illumination in bright field. A built-in ultrasonic bath provides controlled initial agitation to the samples of interest. Sequential images acquired by the experimental setup were used to derive normalized transmission profiles from which an instability index was developed for quantitative stability comparison between samples. Instrument performance was verified by measuring the stability of a series of oil-in-water emulsions prepared with surfactant mixtures of different ratios. The new instrument correctly determined the required hydrophilic-lipophilic balance for sunflower oil to be 7.0. The stability of a pressurized suspension of spray dried lipid (DSPC) particles was monitored for 5 days after propellant filling. Although stable for the first 24 h, the lipid suspension was found to decrease in stability from day 1 to day 4. Morphological and spectroscopic analysis revealed that the suspended DSPC particles had reformed into large thin sheets of lipid, thereby causing the gradual stability decrease during the aging study. The effects of initial agitation on the stability of suspensions were demonstrated by agitating a suspension of micronized fluticasone propionate in propellant using a wrist action shaker and an ultrasonic bath respectively. A significant improvement of suspension stability was achieved by replacing the wrist action shaker method with ultrasonic agitation. Simultaneous illumination of the complete suspension, a high image acquisition rate, and controlled initial agitation are features that make this new suspension tester a suitable and more reliable instrument for investigating the stability of pressurized pharmaceutical suspensions.

The comparative effectiveness of initiating fluticasone/salmeterol combination therapy via pMDI versus DPI in reducing exacerbations and treatment escalation in COPD: a UK database study.

Chronic obstructive pulmonary disease (COPD), a complex progressive disease, is currently the third leading cause of death worldwide. One recommended treatment option is fixed-dose combination therapy of an inhaled corticosteroid (ICS)/long-acting ß-agonist. Clinical trials suggest pressurized metered-dose inhalers (pMDIs) and dry powder inhalers (DPIs) show similar efficacy and safety profiles in COPD. Real-world observational studies have shown that combination therapy has significantly greater odds of achieving asthma control when delivered via pMDIs. Our aim was to compare effectiveness, in terms of moderate/severe COPD exacerbations and long-acting muscarinic antagonist (LAMA) prescriptions, for COPD patients initiating fluticasone propionate (FP)/salmeterol xinafoate (SAL) via pMDI versus DPI at two doses of FP (500 and 1,000 µg/d) using a real-life, historical matched cohort study. COPD patients with ≥2 years continuous practice data, ≥2 prescriptions for FP/SAL via pMDI/DPI, and no prescription for ICS were selected from the Optimum Patient Care Research Database. Patients were matched 1:1. Rate of moderate/severe COPD exacerbations and odds of LAMA prescription were analyzed using conditional Poisson and logistic regression, respectively. Of 472 patients on 500 µg/d, we observed fewer moderate/severe exacerbations in patients using pMDI (99 [42%]) versus DPI (115 [49%]) (adjusted rate ratio: 0.71; 95% confidence interval: 0.54, 0.93), an important result since the pMDI is not licensed for COPD in the UK, USA, or China. At 1,000 µg/d, we observed lower LAMA prescription for pMDI (adjusted odds ratio: 0.71; 95% confidence interval: 0.55, 0.91), but no difference in exacerbation rates, potentially due to higher dose of ICS overcoming low lung delivery from the DPI.