Natural antioxidants (rosemary and parsley) in microwaved ground meat patties: effects of in vitro digestion.

BACKGROUND: Minimizing food oxidation remains a challenge in several environments. The addition of rosemary extract (150 mg kg-1) and lyophilized parsley (7.1 g kg-1) at equivalent antioxidant activity (5550 µg Trolox equivalents kg-1) to meat patties was assessed in terms of their effect during microwave cooking and after being subjected to an in vitro digestion process. RESULTS: Regardless of the use of antioxidants, cooking caused a decrease of the fat content as compared to raw samples, without noticing statistical differences in the fatty acid distribution between raw and cooked samples [44%, 47% and 6.8%, of saturated fatty acid (SFA), monounsaturated fatty acid (MUFA) and polyunsaturated fatty acid (PUFA), respectively]. However, the bioaccessible lipid fraction obtained after digestion was less saturated (around 34% SFA) and more unsaturated (35% MUFA +30% PUFA). Cooking caused, in all types of samples, an increased lipid [thiobarbituric acid reactive substances (TBARS)] and protein (carbonyls) oxidation values. The increase of TBARS during in vitro digestion was around 7 mg malondialdehyde (MDA) kg-1 for control and samples with parsley and 4.8 mg MDA kg-1 with rosemary. The addition of parsley, and particularly of rosemary, significantly increased the antioxidant activity (DPPH) of cooked and digested microwaved meat patties. CONCLUSION: Whereas rosemary was effective in minimizing protein oxidation during cooking and digestion as compared to control samples, parsley could only limit it during digestion. Lipid oxidation was only limited by rosemary during in vitro digestion. © 2024 The Authors. Journal of The Science of Food and Agriculture published by John Wiley & Sons Ltd on behalf of Society of Chemical Industry.

Olive and echium oil gelled emulsions: Simulated effect of processing temperature, gelling agent and in vitro gastrointestinal digestion on oxidation and bioactive compounds.

The impact and relative relevance of in vitro gastrointestinal digestion, processing temperature (room temperature or 180 °C), and gelling agent (GA) (carrageenan and alginate) on the bioactive compounds and oxidation status of olive and echium oils gelled formulations with 40% lipid incorporation was assessed. In vitro digestion was not affected by the GA, with >90% lipolysis in all formulations, but was the most relevant variable, promoting oxidation (MDA) regardless of the oil type, GA or temperature applied. Tocopherols and phenolic decreased with digestion, which could be interpreted as a protective response to pro-oxidative conditions during digestion. Temperature decreased olive oil phenolics. Gelification of echium oil using alginate reduced secondary oxidation products formation in comparison with carrageenan, with oxidation degrees after digestion equivalent to those shown with olive oil. The use of alginate with olive oil resulted in the most stable formulations, although not protecting its minor bioactive compounds from thermal degradation.

Fatty acid profile, sterols, and squalene content comparison between two conventional (olive oil and linseed oil) and three non-conventional vegetable oils (echium oil, hempseed oil, and moringa oil).

New sources of bioactive compounds are constantly explored for reformulating healthier foods. This work aimed to explore and characterize the fatty acid profile and sterol content of three non-conventional oils used in functional food products (hempseed oil, moringa oil, and echium oil) and to compare them with two conventional ones (extra virgin olive oil [EVOO] and linseed oil). Oxidative stability was assessed by determining their acidity value and peroxide content. All oils showed adequate values for acidity and oxidation status. Echium and hempseed oils showed a high content of polyunsaturated fatty acids (>70%), especially omega-3 fatty acids, while moringa oil was rich in oleic acid. Echium oil, hempseed oil, and moringa oil presented higher sterol content than EVOO, but lower than that of linseed oil. Sitosterol was the most abundant sterol in all samples (97.88-275.36 mg/100 g oil), except in echium oil, where campesterol (170.62 mg/100 g oil) was the major sterol. Squalene was only found in significant amounts in EVOO. In conclusion, non-conventional oils seem to be interesting sources of bioactive compounds and have great potential for the food industry. PRACTICAL APPLICATION: Non-conventional vegetable oils can be used as alternative sources of lipids in a variety of food products. Additionally, these oils have great potential to be included in the formulation of functional ingredients for the delivery of omega-3 fatty acids, antioxidants, fiber, among others.

Gels as fat replacers in bakery products: a review.

Several strategies have been studied to replace or decrease fat content in bakery products aiming improving their nutritional profile. This paper reviewed the effect of different vehiculization systems (hydrogels, emulgels and oleogels) as fat replacers in different types of bakery goods, focusing on technological and nutritional properties of the reformulated products. The most commonly used fat source for replacement purposes were vegetable oils with high monounsaturated fatty acid content, such as olive oil and canola oil (44% of the revised papers used them), whereas high polyunsaturated fatty acid content oils were used in 34% of papers. Oleogelation was the most frequent used method of oil structuring, using waxes and fibers as stabilizers. Reductions of total fat between 19% and 46% and saturated fatty acid between 33% and 87% were achieved, enough to reach the minimum legal limit to state nutrition claims, under the EU legislation, on several products. Sensory evaluation results showed that partially replaced products (<75% replacement) were more appreciated by panelists than fully replaced ones. This review highlights the wide range of alternatives within gel-like fat replacers, that have potential to be applied in different bakery products and the challenge to produce nutritionally enhanced foods and technologically and sensory acceptable.

Flax and hempseed oil functional ingredient stabilized by inulin and chia mucilage as a butter replacer in muffin formulations.

The addition of different amounts of a functional ingredient composed of water, inulin, chia seeds, and hemp or flaxseed oil was examined as butter replacer to improve the nutritional value of muffins. Nutritional, technological, and sensory characteristics of the reformulated products were assessed, as well as the stability under storage at room temperature. One control and six modified formulations with three levels of butter replacement (50%, 75%, and 100%) were analyzed. Modified muffins improved their nutritional profile, reducing up to 78% of fat and increasing fiber (up to 62.5%) and omega-3 fatty acids content (from 0.12 g/100 g of product to 0.62 g and 1.55 g in hemp and flaxseed oil samples, respectively). Sensory analysis revealed that flaxseed oil samples were indistinguishable from the control in all evaluated attributes, even in the highest level of replacement. During storage, texture of modified samples behaved similar to the control and no oxidation problems were observed in any of the formulations. Therefore, the functional ingredient proved to be a feasible alternative for replacing butter in muffins, preserving the quality attributes and making them healthier foods. PRACTICAL APPLICATION: Functional ingredients including fiber and low amounts of good-quality sources of fat have a simple manufacturing process, do not require heating, and perform well once incorporated to the matrix. They are versatile and could be incorporated in other bakery products to substitute butter or even oil, to obtain a reduced calorie product and with an enhanced nutritional profile and good sensory properties.

Using canola oil hydrogels and organogels to reduce saturated animal fat in meat batters.

Conventional canola oil and structured canola oil systems, consisting of oil in water hydrogelled emulsions (with 1.5% or 3% kappa carrageenan) and ethylcellulose organogels (12%, with 0%, 1.5% or 3% glycerol monostearate), were used to replace beef fat in emulsion type meat batters. Replacement with regular canola oil increased hardness and lightness (P < .05) of the reformulated products as compared to those with beef fat. Structuring the oil resulted in similar color and texture (P > .05), and lower oxidation values (P < .05) of meat batters. Reformulated products also gave rise to a healthier fatty acid profile, evidenced by a decrease in saturated fatty acids (SFA) from 11.8% to ≈ 2% and an increase in polyunsaturated fatty acids (PUFA) from 0.3% to ≈ 5%. Omega-6 to omega-3 ratio also decreased (16.2 to ≈ 2) when incorporating canola oil into meat batters. Batters formulated with organogels showed improved matrix stability compared to those with hydrogelled emulsions, which showed some coalescence of fat globules and fat losses during cooking, resulting in a reduction of fat content (P < .05).

DHA rich algae oil delivered by O/W or gelled emulsions: strategies to increase its bioaccessibility.

BACKGROUND: The bioaccessibility of bioactive compounds for functional food deserves evaluation. An in vitro gastrointestinal digestion model was applied to provide information about the extent of lipid hydrolysis, oxidative stability and bioaccessibility of algae oil (42% of docosahexaenoic acid; DHA), comparing three lipid delivery systems: bulk oil, soy protein stabilized O/W emulsion and carrageenan gelled emulsion. RESULTS: Lipid digestion kinetics was slightly influenced by the delivery systems. Nevertheless, at the end of intestinal digestion, lipolysis in the three samples ranged between 49% and 52%, showing a partial oil digestion. Lipid oxidation, measured by malondialdehyde, was significantly lower (P < 0.01) in both emulsified oils after intestinal digestion compared to the bulk oil. Bioaccessibility of DHA was 58%, 71% and 84% for bulk oil, O/W emulsion and gelled emulsion, respectively. CONCLUSION: These results suggest that both emulsified delivery systems used in the present study enhanced the solubilization of free fatty acids, in particular omega-3 fatty acids, and therefore their potential intestinal absorption. © 2018 Society of Chemical Industry.

Influence of a gel emulsion containing microalgal oil and a blackthorn (Prunus spinosa L.) branch extract on the antioxidant capacity and acceptability of reduced-fat beef patties.

The addition of a blackthorn branch extract (Prunus spinosa L.) to a gel emulsion system containing microalgal oil was examined in order to obtain a functional ingredient (APG), for use as fat replacer in beef patties. Chromatographic analysis indicated that catechins were the major polyphenols present in the Prunus spinosa L. extract. The antioxidant capacity increased as a result of the extract addition, as shown by the comparison of the gel emulsions, with and without it (APG and AG, respectively). Beef patties containing APG as fat replacer (modified patties) had a lower fat content (5.3% versus 10.75%), doubled the antioxidant activity and the DHA content, and improved the stability against oxidation by reducing the peroxide content more than two fold when compared to control patties. In addition, instrumental color measured by the CIE L*a*b* system showed no significant difference between control and modified raw patties. Moreover, the sensory acceptability of the new formulation was confirmed by a like/dislike hedonic test.

Effects of EPA and lipoic acid supplementation on circulating FGF21 and the fatty acid profile in overweight/obese women following a hypocaloric diet.

FGF21 has emerged as a key metabolism and energy homeostasis regulator. Dietary supplementation with eicosapentaenoic acid (EPA) and/or α-lipoic acid (LIP) has shown beneficial effects on obesity. In this study, we evaluated EPA and/or LIP effects on plasma FGF21 and the fatty acid (FA) profile in overweight/obese women following hypocaloric diets. At the baseline, FGF21 levels were negatively related to the AST/ALT ratio and HMW adiponectin. The weight loss did not cause any significant changes in FGF21 levels, but after the intervention FGF21 increased in EPA-supplemented groups compared to non-EPA-supplemented groups. EPA supplementation decreased the plasma n-6-PUFA content and increased n-3-PUFAs, mainly EPA and DPA, but not DHA. In the LIP-alone supplemented group a decrease in the total SFA and n-6-PUFA content was observed after the supplementation. Furthermore, EPA affected the desaturase activity, lowering Δ4D and raising Δ5/6D. These effects were not observed in the LIP-supplemented groups. Besides, the changes in FGF21 levels were associated with the changes in EPA, n-3-PUFAs, Δ5/6D, and n-6/n-3 PUFA ratio. Altogether, our study suggests that n-3-PUFAs influence FGF21 levels in obesity, although the specific mechanisms implicated remain to be elucidated.

The effect of low-fat beef patties formulated with a low-energy fat analogue enriched in long-chain polyunsaturated fatty acids on lipid oxidation and sensory attributes.

A new low-energy gelled emulsion containing algae oil was developed as animal fat replacer. Its stability was evaluated under different storage conditions: 4V (4°C/vacuum), 4NV (4°C/no vacuum), 25V (25°C/vacuum) and 25NV (25°C/no vacuum). According to moisture, hardness, color and lipid oxidation data, 4°C under vacuum (4V) was selected as the best condition. Once the gelled emulsion was characterized, its effectiveness as fat analogue was demonstrated in beef patties. Reformulated patties were produced with 100% of animal fat replacement and compared to conventional patties (9%fat). A 70%fat reduction was achieved in the new patties, mainly due to a reduction in the saturated fatty acids. Also, decreased n-6 (76%lower content) and increased eicosapentaenoic and docosahexaenoic acids (55%higher content) were noticed in the new formulation. The incorporation of the gelled emulsion containing reduced amount of n-6 fatty acids and increased amounts of long chain n-3 fatty acids (EPA+DHA) reduced the oxidation status of the patties and their sensory evaluation resulted in acceptable scores.

Margarines and Fast-Food French Fries: Low Content of trans Fatty Acids.

The lipid fraction of margarines and fast food French fries, two types of foods traditionally high in trans fatty acids (TFA), is assessed. TFA data reported worldwide during the last 20 years have been gathered and show that some countries still report high TFA amounts in these products. The content of TFA was analysed in margarines (two store and four premium brands) and French-fries from fast-food restaurants (five chains). All samples were collected in Pamplona (Navarra, Spain). The margarines showed mean values of 0.68% and 0.43% (g TFA/100 g fat) for the store and premium brands, respectively. The French fries' values ranged from 0.49% to 0.89%. All samples were lower than the 2% set by some European countries as the maximum legal content of TFA in fats, and contained less than 0.5 g/serving, so they could also be considered "trans free products". This work confirmed that the presence of TFA is not significant in the two analysed products and contributes updated food composition tables, key tools for epidemiological and nutrition studies.

Linseed oil gelled emulsion: A successful fat replacer in dry fermented sausages.

Different levels of animal fat replacement by a high omega-3 content carrageenan gelled emulsion in dry fermented sausages were studied in order to improve their fatty acid composition. Percentages of fat replacement were 26.3% (SUB1), 32.8% (SUB2) and 39.5% (SUB3). α-linolenic acid (ALA) content increased up to 1.81, 2.19 and 2.39g/100g (SUB1, SUB2, and SUB3 products) as compared to the Control (0.35g/100g), implying an increment in polyunsaturated fatty acids (PUFA) supply (up to 10.3%) and reductions in omega-6/ omega-3 ratio (75, 82 and 84%, respectively). Peroxides and TBARs values were not affected (P>0.05) by the fat modification and a slight low formation of volatile aldehydes derived from lipid oxidation was detected. Fat replacement did not cause relevant modifications on the instrumental color properties and no sensory differences (P>0.05) were found between Control and SUB2 products (32.8%) for taste and juiciness, pointing out the viability of this formulation for human consumption.

Cholesterol and stigmasterol within a sunflower oil matrix: Thermal degradation and oxysterols formation.

The characteristics of the lipid matrix surrounding sterols exert a great influence in their thermal oxidation process. The objective of this work was to assess the oxidation susceptibility of equal amounts of cholesterol and stigmasterol within a sunflower oil lipid matrix (ratio 1:1:200) during heating (180°C, 0-180min). Remaining percentage of sterols was determined and seven sterol oxidation products (SOPs) were analysed for each type of sterol along the heating treatment. Evolution of the fatty acid profile and vitamin E content of the oil was also studied. Overall oxidation status of the model system was assessed by means of Peroxides Value (PV) and TBARS. PV remained constant from 30min onwards and TBARS continued increasing along the whole heating treatment. Degradation of both cholesterol and stigmasterol fitted a first order curve (R(2)=0.937 and 0.883, respectively), with very similar degradation constants (0.004min(-1) and 0.005min(-1), respectively). However, higher concentrations of oxidation products were found from cholesterol (79µg/mg) than from stigmasterol (53µg/mg) at the end of the heating treatment. Profile of individual oxidation products was similar for both sterols, except for the fact that no 25-hydroxystigmasterol was detected. 7α-Hydroxy and 7-keto-derivatives were the most abundant SOPs at the end of the treatment. PUFA and vitamin E suffered a significant degradation along the process, which was correlated to sterols oxidation.

Optimization of a gelled emulsion intended to supply ω-3 fatty acids into meat products by means of response surface methodology.

The optimization of a gelled oil-in-water emulsion was performed for use as fat replacer in the formulation of ω-3 PUFA-enriched cooked meat products. The linseed oil content, carrageenan concentration and surfactant-oil ratio were properly combined in a surface response design for maximizing the hardness and minimizing the syneresis of the PUFA delivery system. The optimal formulation resulted in a gelled emulsion containing 40% of oil and 1.5% of carrageenan, keeping a surfactant-oil ratio of 0.003. The gel was applied as a partial fat replacer in a Bologna-type sausage and compared to the use of an O/W emulsion also enriched in ω-3. Both experimental sausages contributed with higher ω-3 PUFA content than the control. No sensory differences were found among formulations. The selected optimized gelled oil-in-water emulsion was demonstrated to be a suitable lipophilic delivery system for ω-3 PUFA compounds and applicable in food formulations as fat replacer.

Healthy reduced-fat Bologna sausages enriched in ALA and DHA and stabilized with Melissa officinalis extract.

Reduced-energy and reduced-fat Bologna products enriched with ω-3 polyunsaturated fatty acids were formulated by replacing the pork back-fat by an oil-in-water emulsion containing a mixture of linseed-algae oil stabilized with a lyophilized Melissa officinalis extract. Healthier composition and lipid profile was obtained: 85 kcal/100 g, 3.6% fat, 0.6 g ALA and 0.44 g DHA per 100 g of product and ω-6/ω-3 ratio of 0.4. Technological and sensory problems were not detected in the new formulations. Reformulation did not cause oxidation problems during 32 days of storage under refrigeration. The results suggest that it is possible to obtain reduced-fat Bologna-type sausages rich in ALA and DHA and stabilized with natural antioxidants, applying the appropriate technology without significant effects on the sensory quality, yielding interesting products from a nutritional point of view.

Reduced-fat bologna sausages with improved lipid fraction.

BACKGROUND: This applied research was done in order to obtain cooked products (bologna sausages) with significantly lower amounts of energy, total fat and saturated fat and higher amounts of ω-3 fatty acids than conventional ones. Two subsequent experiments were performed. RESULTS: Experiment 1 aimed at pork back-fat reduction and enabled sausages to be obtained with 84 g kg⁻¹ fat and 1334 kcal kg⁻¹, without significant negative effects on sensory quality. Carrageenan was used as fat replacer. Experiment 2 aimed at improving the lipid profile of the 'energy-reduced' sausages previously developed, by a partial substitution of the pork back-fat with a linseed oil-in water emulsion (substitution levels: 25-100%). Using the 100% substitution level gave rise to products with 27 g kg⁻¹ α-linolenic acid, and low saturated fat content (13.5 g kg⁻¹), showing good sensory results regarding taste, smell and texture. The use of antioxidant maintained low TBARs (thiobarbituric acid reactive substances) values in all formulations. CONCLUSION: It is possible to obtain cooked meat products (bologna sausages) with low energy, low saturated fat and a high amount of ω-3 fatty acids simultaneously, applying a combination of the use of carrageenan, linseed oil emulsion and increment of water, without significant effects on sensory quality. Functional products, interesting from a nutritional standpoint, were achieved.

Reduction of sodium and increment of calcium and ω-3 polyunsaturated fatty acids in dry fermented sausages: effects on the mineral content, lipid profile and sensory quality.

BACKGROUND: A combined technological approach was applied in the development of healthier dry fermented sausages: a partial substitution of the pork back fat by pre-emulsified linseed oil and a partial replacement of sodium chloride with calcium ascorbate at two different levels, leading to low amounts of salt (14gSalt and 10gSalt, with 14 g and 10 g NaCl per kg of mixture, respectively). RESULTS: The developed products (14gSalt and 10gSalt) showed adequate results for a(w) (0.85 and 0.87) and pH (4.98 and 5.21), and low lipid oxidation values (1.4 × 10(-4) and 1.5 × 10(-5) g malondialdehyde (MDA) kg(-1)). The lipid modification led to a significantly higher supply of ω-3 (23.3 g kg(-1) ) compared to the control (3.2 g kg(-1) ). Simultaneously, reductions of 38% and 50% in sodium content and a calcium supply of 4 and 5.2 g kg(-1) were achieved in the 14gSalt and 10gSalt formulations, respectively, compared to the control products (26 g salt and 0.87 g kg(-1) Ca). Instrumental analysis of colour and texture and sensory studies demonstrated that the organoleptic quality of the new formulations was similar to that of traditional products. CONCLUSIONS: The developed dry fermented sausages showed healthier properties than traditional ones owing to their reduced sodium and higher calcium content and a significant supply of ω-3 fatty acids.

2012: no trans fatty acids in Spanish bakery products.

Trans fatty acids (TFA) are strongly correlated with an increased risk of cardiovascular and other chronic diseases. Current dietary recommendations exclude bakery products from frequent consumption basically due to their traditionally high content of TFA. The aim of this work was to analyse the lipid profile of different bakery products currently commercialised in Spain and with a conventionally high fat and TFA content. Premium and store brands for each product were included in the study. No significant amounts of TFA were found in any of the analysed products, regardless the brand. TFA content ranged between 0.17 g and 0.22 g/100 g product (mean=0.19 g/100 g product). Expressed on percentage of fatty acids, the maximum value was 0.87 g/100 g fatty acids and the mean value was 0.68%. These data are significantly lower than those observed in previously published papers for these types of products, and highlighted the importance of updating food composition databases in order to accurately estimate the real and current intake of TFA.

Stability of avocado oil during heating: comparative study to olive oil.

The stability of the saponifiable and unsaponifiable fractions of avocado oil, under a drastic heating treatment, was studied and compared to that of olive oil. Avocado and olive oil were characterised and compared at time 0h and after different times of heating process (180°C). PUFA/SFA (0.61 at t=0) and ω-6/ω-3 (14.05 at t=0) were higher in avocado oil than in olive oil during the whole experiment. Avocado oil was richer than olive oil in total phytosterols at time 0h (339.64; 228.27mg/100g) and at 9h (270.44; 210.30mg/100g) of heating. TBARs was higher in olive oil after 3h, reaching the maximum values in both oils at 6h of heating treatment. Vitamin E was higher in olive oil (35.52 vs. 24.5mg/100g) and it disappeared earlier in avocado oil (at 4 vs. 5h). The stability of avocado oil was similar to that of olive oil.

Anti-proliferative effect of Melissa officinalis on human colon cancer cell line.

Melissa officinalis L. (Lamiaceae) is consumed as a traditional herbal tea in the Mediterranean region. The cytotoxic effect of the 50% ethanolic and aqueous extract, determined by the MTT and NR assays, was evaluated in vitro on Human Colon Cancer Cell Line (HCT-116), using Triton 10% as positive control. The 50% ethanolic extract showed significant differences after 72 h of treatment, reducing cell proliferation to values close to 40%, even the lowest dose tested (5 µg/ml). In the MTT assay, the same extract caused the lowest cell viability with 13% at a concentration of 1,000 µg/ml after 72 h of treatment, being a value lower than Triton 10%. The antioxidant activity was also confirmed evaluating the capacity of the extracts to scavenge ABTS and DPPH radicals, and IC(50) values were highly correlated with the total phenolic and flavonoid content. Bioassay guided fractionation led to the isolation of an anti-proliferative compound, rosmarinic acid. Its structural elucidation was performed by HPLC/DAD/ESI/MS analysis. High dose of rosmarinic acid (1,000 µg/ml) was clearly cytotoxic against HCT-116 cells, with a significant decrease in cell number since the earliest time point (24 h).