Effects of CaCO3 treatment on the morphology, crystallinity, rheology and hydrolysis of gelatinized maize starch dispersions.

Using calcium salts instead of lime allows for an ecological nixtamalization of maize grains, where the negative contamination impact of the traditional lime nixtamalization is reduced. This work assessed the effects of calcium carbonate (0.0-2.0%w/w CaCO3) on the morphology, crystallinity, rheology and hydrolysis of gelatinized maize starch dispersions (GMSD). Microscopy analysis showed that CaCO3 changed the morphology of insoluble remnants (ghosts) and decreased the degree of syneresis. Analysis of particle size distribution showed a slight shift to smaller sizes as the CaCO3 was increased. Also, X-ray patterns indicated that crystallinity achieved a minimum value at CaCO3 concentration in the range of 1%w/w. GMSD with higher CaCO3 concentrations exhibited higher thixotropy area and complex viscoelastic behavior that was frequency dependent. A possible mechanism involved in the starch chain modification by CaCO3 is that starch may act as a weak acid ion exchanger capable of exchanging alcoholic group protons for cations (Ca(+2)).

Functional properties of corn, banana and potato starch blends.

Potato, corn and banana starches were blended in various combinations and ratios. Stability and clarity, freeze-thaw stability, water retention capacity and apparent viscosity of the pastes (prepared with a hydrothermic treatment using 100 degrees C for 30 min) were evaluated. In general, the samples stored at room temperature (28 degrees C) presented stability as well as low retrogradation rate. However, in the samples stored at 4 degrees C the propagation and maturation of crystals in the amylopectin component were favored, increasing sample retrogradation. A synergistic effect was shown in some starch blends. The blends had poor stability to freeze-thaw cycle, but a high synergestic effect was presented in water retention capacity. Potato:banana and corn:potato blends showed a synergistic effect in the apparent viscosity and in general, starch blends had stability during the 30-min test.