Biorelevant in vitro performance testing of orally administered dosage forms-workshop report.

Biorelevant in vitro performance testing of orally administered dosage forms has become an important tool for the assessment of drug product in vivo behavior. An in vitro performance test which mimics the intraluminal performance of an oral dosage form is termed biorelevant. Biorelevant tests have been utilized to decrease the number of in vivo studies required during the drug development process and to mitigate the risk related to in vivo bioequivalence studies. This report reviews the ability of current in vitro performance tests to predict in vivo performance and generate successful in vitro and in vivo correlations for oral dosage forms. It also summarizes efforts to improve the predictability of biorelevant tests. The report is based on the presentations at the 2013 workshop, Biorelevant In Vitro Performance Testing of Orally Administered Dosage Forms, in Washington, DC, sponsored by the FIP Dissolution/Drug Release Focus Group in partnership with the American Association of Pharmaceutical Scientists (AAPS) and a symposium at the AAPS 2012 Annual meeting on the same topic.

Qualitative screening for adulterants in weight-loss supplements by ion mobility spectrometry.

Ion mobility spectrometry (IMS) served as a rapid, qualitative screening tool for the analysis of adulterated weight-loss products. We have previously shown that sibutramine extracted into methanol from dietary supplements can be detected at low levels (2ng) using a portable IMS spectrometer, and have adapted a similar method for the analysis of additional weight-loss product adulterants. An FDA collaborative study helped to define the limits for fluoxetine with a limit of detection of 2ng. We also evaluated more readily available, less toxic extraction solvents and found isopropanol and water were comparable to methanol. Isopropanol was favored over water for two reasons: (1) water increases the analysis time and (2) aqueous solutions were more susceptible to pH change, which affected the detection of sibutramine. In addition to sibutamine and fluoxetine, we surveyed 11 weight-loss adulterants; bumetanide, fenfluramine, furosemide, orlistat, phenolphthalein, phentermine, phenytoin, rimonabant, sertraline and two sibutramine analogs, desmethylsibutramine and didesmethylsibutramine, using portable and benchtop ion mobility spectrometers. Out of these 13 active pharmaceutical ingredients (APIs), portable and benchtop ion mobility spectrometers were capable of screening products for 10 of these APIs. The developed procedure was applied to two weight-loss dietary supplements using both portable and benchtop instruments. One product contained didesmethylsibutramine while the other contained didesmethylsibutramine and phenolphthalein.

Using a portable ion mobility spectrometer to screen dietary supplements for sibutramine.

In response to recent incidents of undeclared sibutramine, an appetite suppressant found in dietary supplements, we developed a method to detect sibutramine using hand-held ion mobility spectrometers with an analysis time of 15 s. Ion mobility spectrometry is a high-throughput and sensitive technique that has been used for illicit drug, explosive, volatile organic compound and chemical warfare detection. We evaluated a hand-held ion mobility spectrometer as a tool for the analysis of supplement extracts containing sibutramine. The overall instrumental limit of detection of five portable ion mobility spectrometers was 2 ng of sibutramine HCl. When sample extractions containing 30 ng/µl or greater of sibutramine were analyzed, saturation of the ionization chamber of the spectrometer occurred and the instrument required more than three cleaning cycles to remove the drug. Hence, supplement samples suspected of containing sibutramine should be prepared at concentrations of 2-20 ng/µl. To obtain this target concentration range for products containing unknown amounts of sibutramine, we provided a simple sample preparation procedure, allowing the U.S. Food and Drug Administration or other agencies to screen products using the portable ion mobility spectrometer.

Detection of undeclared erectile dysfunction drugs and analogues in dietary supplements by ion mobility spectrometry.

An ion mobility spectrometry (IMS) method was developed to screen for the presence of undeclared synthetic erectile dysfunction (ED) drugs or drug analogues in herbal dietary supplements claiming to enhance male sexual performance. Ion mobility spectra of authenticated reference materials including three FDA approved drugs (sildenafil citrate, tadalafil, vardenafil hydrochloride trihydrate) and five previously identified synthetic analogues (methisosildenafil, homosildenafil, piperidenafil, thiosildenafil, thiomethisosildenafil) were measured to determine their reduced ion mobilities (K(0)). All eight compounds exhibited reduced mobilities between 0.8257 and 1.2876 cm(2)/(Vs). Twenty-six herbal products were then screened for the presence of these compounds, and 15 of the 26 products tested positive for the presence of ED drug or drug analogue adulterants based on their reduced ion mobilities. IMS results were compared against the results obtained from an independent LC/MS reference method for the identical samples. Herbal dietary supplements containing adulterants were classified with 100% accuracy and most of the adulterants were correctly identified by a comparison of the K(0) of the adulterant to the K(0) of the authenticated reference material. The results demonstrate that IMS is a viable method for screening herbal dietary supplements for the presence of ED drug or drug analogue adulterants.

Contaminated heparin associated with adverse clinical events and activation of the contact system.

BACKGROUND: There is an urgent need to determine whether oversulfated chondroitin sulfate (OSCS), a compound contaminating heparin supplies worldwide, is the cause of the severe anaphylactoid reactions that have occurred after intravenous heparin administration in the United States and Germany. METHODS: Heparin procured from the Food and Drug Administration, consisting of suspect lots of heparin associated with the clinical events as well as control lots of heparin, were screened in a blinded fashion both for the presence of OSCS and for any biologic activity that could potentially link the contaminant to the observed clinical adverse events. In vitro assays for the activation of the contact system and the complement cascade were performed. In addition, the ability of OSCS to recapitulate key clinical manifestations in vivo was tested in swine. RESULTS: The OSCS found in contaminated lots of unfractionated heparin, as well as a synthetically generated OSCS reference standard, directly activated the kinin-kallikrein pathway in human plasma, which can lead to the generation of bradykinin, a potent vasoactive mediator. In addition, OSCS induced generation of C3a and C5a, potent anaphylatoxins derived from complement proteins. Activation of these two pathways was unexpectedly linked and dependent on fluid-phase activation of factor XII. Screening of plasma samples from various species indicated that swine and humans are sensitive to the effects of OSCS in a similar manner. OSCS-containing heparin and synthetically derived OSCS induced hypotension associated with kallikrein activation when administered by intravenous infusion in swine. CONCLUSIONS: Our results provide a scientific rationale for a potential biologic link between the presence of OSCS in suspect lots of heparin and the observed clinical adverse events. An assay to assess the amidolytic activity of kallikrein can supplement analytic tests to protect the heparin supply chain by screening for OSCS and other highly sulfated polysaccharide contaminants of heparin that can activate the contact system.

Oversulfated chondroitin sulfate is a contaminant in heparin associated with adverse clinical events.

Recently, certain lots of heparin have been associated with an acute, rapid onset of serious side effects indicative of an allergic-type reaction. To identify potential causes for this sudden rise in side effects, we examined lots of heparin that correlated with adverse events using orthogonal high-resolution analytical techniques. Through detailed structural analysis, the contaminant was found to contain a disaccharide repeat unit of glucuronic acid linked beta1-->3 to a beta-N-acetylgalactosamine. The disaccharide unit has an unusual sulfation pattern and is sulfated at the 2-O and 3-O positions of the glucuronic acid as well as at the 4-O and 6-O positions of the galactosamine. Given the nature of this contaminant, traditional screening tests cannot differentiate between affected and unaffected lots. Our analysis suggests effective screening methods that can be used to determine whether or not heparin lots contain the contaminant reported here.