Hydrogelled emulsion from linseed oil and pea protein as a strategy to produce healthier pork burgers with high technological and sensory quality.

Hydrogelled emulsions (HEs) produced with linseed oil and different levels of pea protein (PP) (0, 5, 10, 15, and 20%) were used to replace 50% of animal fat in burgers. The effect of this lipid reformulation on the nutritional, technological, oxidative, microbiological, and sensory quality of the burgers was evaluated during their refrigerated storage (4 °C for 12 days). The reformulated burgers displayed a reduction of >40% in fat and an increase of up to 10% in protein content. Lipid reformulation also increased the PUFA/SFA ratio and reduced the n-6/n-3 PUFAs ratio and the atherogenicity and thrombogenicity indices of the lipid fraction of the burgers. Including 5 and 10% of PP in the HEs made it possible to obtain burgers of high technological quality and with a sensory profile similar to full-fat products. PP was also efficient in reducing the increase in the lipid oxidation caused by the enrichment with n-3 PUFAs.

Lipid oxidation and sensory characterization of Omega-3 rich buffalo burgers enriched with chlorogenic acids from the mate (Ilex paraguariensis) tree harvesting residues.

A freeze-dried extract from the bark of mate branches (BMBE) containing high chlorogenic acids (CGA) content (30 g 100 g-1) was produced. Then, chia oil was mixed with 7.5% BMBE and sonicated for 0, 10, and 20 min. Chia oil with or without the addition of BMBE was hydrogelled and used to produce buffalo burgers with 50% reduction in animal fat. CGA levels and the nutritional, oxidative, and sensory properties of the burgers were analyzed. A reduction of ~30% fat and an increase above 60% PUFA/SFA ratio was observed for the reformulated raw and cooked burgers. In addition, the Omega-6/Omega-3 PUFA ratio of the burgers decreased from 20.8 (raw) and 31.9 (cooked) to values lower than 2. The addition of BMBE enriched the burgers with CGA, preventing an increase in lipid oxidation caused by chia oil. The addition of BMBE-enriched hydrogelled chia oil not subjected to sonication did not affect the sensory properties of the burgers.

Jabuticaba peel extract obtained by microwave hydrodiffusion and gravity extraction: A green strategy to improve the oxidative and sensory stability of beef burgers produced with healthier oils.

Hydrogelled emulsions (HE) from chia and linseed oils (1:1) were made with different concentrations (0, 6, 8, and 10%) of jabuticaba peel extract (JPE) obtained by microwave hydrodiffusion and gravity (MHG) extraction. Burgers (20% fat) were produced with the replacement of 60% of fat by HEs. The oxidative profile and the sensory quality of raw and cooked burgers were evaluated for 120 days (-18 °C). The JPE exhibited 1.72 mg/mL of phenolic compounds and 57,741.67 µmol TE/mL of antioxidant capacity. In addition, the MHG extraction eliminated the mesophilic bacteria from the jabuticaba peel. The burgers made with HE and without the addition of JPE showed a 5-fold increase in TBARS values when compared to the control. On the other hand, the addition of 10% JPE to HE was effective to maintain the lipid oxidation similar to the control until the 60th day of storage. Besides, the incorporation of JPE into HE reduced the sensory defects caused by the lipid reformulation.

Phytochemical characterization and antimicrobial activity of Cymbopogon citratus extract for application as natural antioxidant in fresh sausage.

The development of natural additives is considered an important research topic. In this work, the use of Cymbopogon citratus (CC) extract as a natural additive for chicken sausage refrigerated was investigated. The CC extract was characterized by electrospray ionization with high-resolution time-of-flight mass spectrometry (ESI-ToF-MS) and the identified compounds were directly related to the antioxidant activity demonstrated by CC in the fresh sausage. In total, 31 phytochemical compounds were identified, and 27 of these still were not described in the literature for CC. The antimicrobial activity showed that CC extract is a potential antibacterial agent. Besides, the results showed that CC extract reduced lipid oxidation compared to synthetic additive. The sensorial characteristics were maintained, demonstrating good acceptability by the consumer. The results confirmed that CC can keep the quality of chicken sausage refrigerated for up to 42 days of storage.

Banana inflorescences: A cheap raw material with great potential to be used as a natural antioxidant in meat products.

The bioactive compounds and the antioxidant activity of extracts made with various parts of banana inflorescences (bracts, male flowers, rachis, and whole inflorescence) were evaluated in the first part of this study. The extract made with male flowers (EMF) had a higher content of phenolics and flavonoids, lower IC50 value, and higher FRAP value. Thus, EMF was selected to be used in sausage formulations at the concentrations of 0, 0.5, 1, 1.5, and 2%. The effect of this reformulation on the physicochemical, oxidative, and sensory characteristics of the sausages was evaluated during the refrigerated storage (28 days). EMF presented an effective antioxidant activity, with no major changes on pH, aw, and color parameters. In addition, the sensory quality of the product was not affected by the addition of up to 2% EMF. Therefore, EMF has great potential to be used as a natural antioxidant in meat products.

Hydrogelled emulsion from chia and linseed oils: A promising strategy to produce low-fat burgers with a healthier lipid profile.

Burgers (20% pork back fat) were produced with the replacement of 0, 20, 40, 60, 80, and 100% of pork back fat by hydrogelled emulsion (HE) from chia and linseed oils. No changes (P > .05) were observed for the moisture retention, diameter reduction, and cooking loss of the treatments, with a significant increase in the lipid retention (P < .05). Hardness increased (P < .05) with increasing the lipid replacement level, and a significant color difference (ΔE) was detected between the treatments and the control. In addition to reducing animal fat, a healthier fatty acid profile was reached after the lipid reformulation of the burgers, thus allowing the burgers to be labeled with health claims. The sensory tests (acceptance and Check-All-That-Apply) indicated that it is possible to replace up to 60% of pork back fat by HE.

Fat replacement by oleogel rich in oleic acid and its impact on the technological, nutritional, oxidative, and sensory properties of Bologna-type sausages.

Bologna-type sausages were made with 25, 50, 75 and 100% replacement of pork back fat by oleogel made with pork skin, water, and high oleic sunflower oil (HOSO) (1.5, 1.5: 1). The technological, nutritional, oxidative, and sensory properties were evaluated. Emulsion stability increased and cooking loss decreased with increasing the pork back fat replacement by oleogel. The reformulation increased the proportion of oleic acid within the lipid fraction by up to 20% and decreased the proportion of linoleic acid by up to 10%, with no changes in the oxidative stability. The acceptance and the sensory profile of the samples were not affected by the substitution of up to 50% of pork back fat by oleogel. Thus, the results showed that it is possible to produce Bologna-type sausages with reduced fat (~16% fat, ~29% reduction), cholesterol (40 mg, ~10% reduction), and energy value (~210 kcal/100 g, ~21% reduction) and with healthier lipid profile using oleogel from HOSO.

Volatile compounds and sensory profile of burgers with 50% fat replacement by microparticles of chia oil enriched with rosemary.

Direct incorporation of rosemary leaves into chia oil (CO) was performed by ultrasound-assisted extraction (UAE) and conventional maceration extraction (CME). CO was microencapsulated and used in burgers, as follows: control (20% pork back fat (PBF)); HCO (10% PBF + 7.5% water +2.5% unencapsulated CO); HM1 (10% PBF + 10% CO microparticles); HM2 (10% PBF + 10% CO microparticles enriched by UAE) and HM3 (10% PBF + 10% CO microparticles enriched by CME). The volatile compounds and the sensory properties (Check-All-That-Apply and overall acceptability) of burgers were evaluated at days 1 and 120 of frozen storage. The control, HCO, and HM1 groups were characterized for volatile compounds produced by lipid and protein oxidation, and sensory descriptors related to lipid oxidation. HM2 and HM3 groups presented an increase in terpenic volatiles and were characterized by the descriptors herbal and pleasant aroma and ideal texture. In addition, liking scores were positively correlated to the descriptors that characterized the HM2 and HM3 groups.

Oxidative stability of burgers containing chia oil microparticles enriched with rosemary by green-extraction techniques.

In the first part of this study, the oxidative stability of chia oils enriched with rosemary by ultrasound-assisted extraction (UAE) and by a conventional maceration extraction (CME) was evaluated. In the second part, chia oil enriched with rosemary by UAE or CME was microencapsulated and used to replace 50% fat in burgers. The oxidative and sensory quality of burgers were evaluated during 120 days of storage at -18 °C. Chia oil enriched with rosemary by UAE presented a higher oxidative stability compared to CME. Higher Eh and TBARS values were found in burgers containing chia oil microparticles without rosemary. The burgers produced with chia oil microparticles enriched with rosemary by UAE showed greater oxidative stability than other treatments, mainly after cooking. Furthermore, the incorporation of rosemary antioxidants to chia oil reduced the sensory defects caused by the lipid reformulation.

Is it possible to produce a low-fat burger with a healthy n-6/n-3 PUFA ratio without affecting the technological and sensory properties?

Burgers subjected to lipid reformulation were made by replacing 50% of the fat component by microparticles containing chia (CO) and linseed (LO) oils obtained by external ionic gelation. The microparticles presented high n-3 PUFAs levels and were resistant to the pH and temperature conditions commonly used in burger processing. The lipid reformulation did not affect hardness and improved important technological properties, such as cooking loss and fat retention. In addition to reducing the fat content of burgers by up to 50%, the lipid reformulation led to healthier PUFA/SFA and n-6/n-3 ratios, and lower atherogenicity and thrombogenicity indices. The burgers with CO microparticles showed a higher lipid oxidation and a lower sensory quality compared to the other treatments. However, the substitution of pork back fat by LO microparticles did not impair the sensory quality of burgers. Therefore, the microencapsulation of n-3 PUFA-rich oils by external ionic gelation can be considered an effective strategy to produce healthier burgers.

Effect of jabuticaba peel extract on lipid oxidation, microbial stability and sensory properties of Bologna-type sausages during refrigerated storage.

This study investigated the lipid oxidation and the microbiological and sensory quality of Bologna-type sausages produced with the addition of jabuticaba peel extract (JPE). Instrumental parameters of color (L*, a* and b*), pH, thiobarbituric acid reactive substance (TBARS) values, microbiological profile, and sensory properties were determined during 35 days of storage. The addition of JPE had an effect on pH and protected the samples from color changes during storage. However, JPE had no positive effect on microbial stability during storage. Samples produced with 0.5, 0.75, and 1% JPE had significantly lower TBARS values (P<0.05) compared with the control group. The addition of up to 0.5% JPE did not affect sensory quality, but prevented the decrease of sensory acceptance during storage. Therefore, due to its antioxidant effect JPE can be used in Bologna-type sausages in order to improve the oxidative stability during the shelf life.

The effect of yeast extract addition on quality of fermented sausages at low NaCl content.

Fermented sausages with 25% or 50% of their NaCl replaced by KCl and supplemented with 1% or 2% concentrations of yeast extract were produced. The sausage production process was monitored with physical, chemical and microbiological analyses. After production, the sausage samples were submitted to a consumer study and their volatile compounds were extracted by solid-phase microextraction and analyzed by GC-MS. The replacement of NaCl by KCl did not significantly influence the physical, chemical or microbiological characteristics. The sensory quality of the fermented sausages with a 50% replacement was poor compared with the full-salt control samples. The use of yeast extract at a 2% concentration increased volatile compounds that arose from amino acids and carbohydrate catabolism. These compounds contributed to the suppression of the sensory-quality defects caused by the KCl introduction, thus enabling the production of safe fermented sausages that have acceptable sensory qualities with half as much sodium content.