Production of High-Quality Red Fruit Juices by Athermal Membrane Processes.

Membrane-based processes are increasingly used to clarify and concentrate thermo-sensitive fruit juices and plant extracts as alternatives to conventional processes. This work aimed to evaluate the quality of red fruit juices clarified and concentrated by an integrated membrane process with special regard to the preservation of valuable compounds. A red fruit juice obtained from a blend of pomegranate, cactus pear, and red orange juices of Sicilian origin was clarified by microfiltration (MF) and then pre-concentrated up to 33 °Brix by nanofiltration (NF). The pre-concentrated juice was finally concentrated by osmotic distillation (OD) up to 50 and 60 °Brix. Samples of clarified, pre-concentrated, and concentrated juice were analyzed for their physico-chemical composition and in terms of the antioxidant activity and inhibitory activity against α-amylase and lipase. The results clearly confirmed the assumption of a mild fruit juice processing method, allowing us to preserve the original nutritional and functional properties of the fresh juice. In particular, the OD retentate at 60 °Brix resulted the most active sample against pancreatic lipase and α-amylase inhibitory activity with IC50 values of 44.36 and 214.65 µg/mL, respectively.

Coupling Ultrafiltration-Based Processes to Concentrate Phenolic Compounds from Aqueous Goji Berry Extracts.

In this work, a membrane-based process for the purification and concentration of antioxidant compounds from aqueous Goji (Lycium barbarum L.) berry extracts was investigated. The aqueous extract was previously clarified with hollow fiber ultrafiltration (UF) membranes in order to remove suspended solids and ß-carotene and to produce a clarified extract enriched in phenolic compounds. Then, three UF flat sheet polyamide membranes with a molecular weight cut-off (MWCO) in the range 1000-3500 Da were tested to purify and concentrate phenolic compounds from the clarified extract. The effect of MWCO and transmembrane pressure (TMP) on the performance of selected membranes in terms of productivity and selectivity towards total dissolved solids (TDS), total phenolic compounds (TPC), total carbohydrates (TC) and total antioxidant activity (TAA) was evaluated. Experimental results indicated that the 2500 Da membrane exhibited a lower fouling index, higher cleaning efficiency, lower rejection towards carbohydrates (lower than 30%) and higher rejection towards phenolic compounds (higher than 50%) in comparison to the other investigated membranes. The inclusion of a diafiltration process in the treatment of the clarified extract with this membrane in a spiral-wound configuration improved the concentration of sugar compounds in the permeate stream and increased the purification of phenolic compounds in the retentate fraction.

Biologically Active Compounds from Goji (Lycium Barbarum L.) Leaves Aqueous Extracts: Purification and Concentration by Membrane Processes.

Goji (Lycium barbarum L.) leaves and fruits have been described as a valuable source of bioactive compounds with a great potential for the development of health-promoting formulations. The present study aimed to evaluate the potential of a sustainable process for the recovery of phenolic compounds from Goji leaves through a combination of aqueous extraction and membrane-based operations. Water was used as a safe, cheap, and non-hazardous extraction solvent, and parameters of extraction of dried Goji leaves were optimized in order to maximize the yield of polyphenols, total soluble solids (TSS), and total antioxidants simultaneously. The aqueous extract was clarified by ultrafiltration and then processed with three flat-sheet polyethersulphone (PES) membranes with molecular weight cut-off (MWCO) values in the range of 0.3-4.0 kDa, in order to remove sugar compounds from polyphenols and improve the antioxidant activity of the produced fractions. Among the selected membranes, a 1 kDa membrane exhibited the best performance in terms of purification of polyphenols from the clarified aqueous extract. The rejection by this membrane of TSS and total carbohydrates was in the range of 15.8-25.3%, and was decreased by increasing the volume reduction factor (VRF). On the other hand, the retention values for total polyphenols and total antioxidant activity (TAA) were in the range of 73-80%, and were increased by increasing the VRF.

A two-step nanofiltration process for the production of phenolic-rich fractions from artichoke aqueous extracts.

Commercial nanofiltration (NF) membranes in spiral-wound configuration (NP030 from Microdyn Nadir and Desal DK from GE Water & Process Technologies) were used in a sequential design in order to produce a separated fraction of phenolic and sugar compounds from an aqueous artichoke extract. For both membranes, the effect of transmembrane pressure (TMP) on the permeation flux was evaluated. In optimized conditions of TMP, the NP030 membrane exhibited high rejections of apigenin, cynarin and chlorogenic acid (higher than 85%); on the other hand, very low rejections of fructose, glucose and sucrose (lower than 4%) were measured. Starting from an extract with a total antioxidant activity (TAA) of 5.28 mM trolox a retentate fraction with a TAA of 47.75 mM trolox was obtained. The NF permeate from the NP030 membrane was processed with the Desal DK membrane in optimized conditions of TMP producing a permeate stream free of phenolic and sugar compounds. Accordingly, as most part of phenolic compounds was removed in the first NF step, the concentration of sugar compounds in the NF retentate had much higher results than that of phenolic compounds.