Reduction of Mycobacterium avium ssp. paratuberculosis in colostrum: Development and validation of 2 methods, one based on curdling and one based on centrifugation.

The aim of this study was to develop and validate 2 protocols (for use on-farm and at a central location) for the reduction of Mycobacterium avium ssp. paratuberculosis (MAP) in colostrum while preserving beneficial immunoglobulins (IgG). The on-farm protocol was based on curdling of the colostrum, where the IgG remain in the whey and the MAP bacteria are trapped in the curd. First, the colostrum was diluted with water (2 volumes colostrum to 1 volume water) and 2% rennet was added. After incubation (1 h at 32°C), the curd was cut and incubated again, after which whey and curd were separated using a cheesecloth. The curd was removed and milk powder was added to the whey. Approximately 1 log reduction in MAP counts was achieved. A reduction in total proteins and IgG was observed due to initial dilution of the colostrum. After curd formation, more than 95% of the immunoglobulins remained in the whey fraction. The semi-industrial protocol was based on centrifugation, which causes MAP to precipitate, while the IgG remain in the supernatant. This protocol was first developed in the laboratory. The colostrum was diluted with skimmed colostrum (2 volumes colostrum to 1 volume skimmed colostrum), then skimmed and centrifuged (at 15,600 × g for 30 min at room temperature). We observed on average 1.5 log reduction in the MAP counts and a limited reduction in proteins and IgG in the supernatant. To obtain a semi-industrial protocol, dairy pilot appliances were evaluated and the following changes were applied to the protocol: after 2:1 dilution as above, the colostrum was skimmed and subsequently clarified, after which the cream was heat treated and added to the supernatant. To investigate the effect of the colostrum treatment on the nutritional value and palatability of the colostrum and the IgG transfer, an animal experiment was conducted with 24 calves. Six received the dam's colostrum, 6 were given untreated purchased colostrum (control), and 2 groups of 6 calves received colostrum treated according to both of the above-mentioned methods. No significant differences were found between the test groups and the dam's colostrum group in terms of animal health, IgG uptake in the blood serum, milk, or forage uptake. Two protocols to reduce MAP in colostrum (for use on-farm or at a central location) were developed. Both methods preserve the vital IgG.

Localization of Mycobacterium avium subspecies paratuberculosis in artificially inoculated milk and colostrum by fractionation.

The purpose of the study was to determine the distribution of Mycobacterium avium ssp. paratuberculosis (MAP) across the main milk and colostrum fractions (cream, curd, and whey). Raw milk and colostrum were inoculated with 1 of 2 MAP strains, ATCC 19698 or S-23, yielding initial concentrations of 10(6) to 10(7) cfu/mL. After fractionation, for milk as well as for colostrum, 80 to 90% of the recovered MAP cells were found in the curd fraction and 10 to 20% in the cream fraction. Total MAP colony counts in milk whey were 4 to 5 log(10) units lower than colony counts of inoculated milk. In colostrum, colony counts were 2 to 3 log(10) units lower in whey than in inoculated colostrum. Because of the slow growth of MAP and to proceed more smoothly with set-up and optimization of the method, luminescent MAP strains were used. The high correlation coefficient (r=0.960) between colony counts and luminescence measurements showed that the use of luminescent MAP strains during method development was plausible.

Crystallization behavior of milk fat obtained from linseed-fed cows.

Milk with an increased content of unsaturated fatty acids was obtained by incorporating 60% of extruded linseed into the concentrate of cows. Two groups of Holstein cows (3 animals/group) were fed a concentrate (control or linseed enriched) together with the same roughage diet (ad libitum). After an adaptation period of 3 wk, evening and morning milk samples were collected every 7 d for 3 wk. Milk was decreamed and anhydrous milk fat (AMF) was isolated from the fat fraction by using the Bureau of Dairy Industries method. The objective of this study was to investigate if the crystallization mechanism of milk fat changed when the content of unsaturated fatty acids was increased. Therefore, the crystallization behavior of a milk fat enriched with unsaturated fatty acids was compared with that of a control milk fat. Nonisothermal crystallization was investigated with differential scanning calorimetry, and 1-step and 2-step isothermal crystallization behaviors were investigated using pulsed nuclear magnetic resonance, differential scanning calorimetry, and x-ray diffraction. A higher content of unsaturated fatty acids in AMF resulted in an increased proportion of low melting triglycerides. These triglycerides lowered the solid fat content profile, particularly at refrigerator temperatures. Furthermore, they induced some changes in the crystallization and melting behaviors of milk fat compared with a control AMF, although no fundamental changes in the crystallization mechanism could be revealed. Even though a lower melting point could be observed for milk fat with a higher content of unsaturated fatty acids, a similar degree of supercooling was needed to initiate crystallization, resulting in a shift in onset temperature of crystallization toward lower temperatures. In addition, slower crystallization kinetics were measured, such as a lower nucleation rate and longer induction times, although crystallization occurred in a similar polymorphic crystal lattice. During melting, a shift in offset temperature toward lower temperatures could be observed for the 3 melting fractions of AMF in addition to a higher proportion of low melting triglycerides. These results demonstrate that a higher content of unsaturated fatty acids has some effect on the crystallization behavior of milk fat. This knowledge could be used to produce dairy products of similar or superior quality compared with conventional products by intervening in the production process of dairy products.