Nanoemulsion-Based Multilayer Films for Ground Beef Preservation: Antimicrobial Activity and Physicochemical Properties.

This study aimed to improve the physical, mechanical, and biological properties of a monolayer pectin (P) film containing nanoemulsified trans-Cinnamaldehyde (TC) by incorporating it between inner and outer layers of ethylcellulose (EC). The nanoemulsion had an average size of 103.93 nm and a zeta potential of -46 mV. The addition of the nanoemulsion increased the opacity of the film, reduced its moisture absorption capacity, and improved its antimicrobial activity. However, the tensile strength and elongation at break of the pectin films decreased after the incorporation of nanoemulsions. Multilayer films (EC/P/EC) showed a higher resistance to breaking and better extensibility compared to monolayer films. The antimicrobial activity of both mono and multilayer films was effective in inhibiting the growth of foodborne bacteria during storage of ground beef patties at 8 °C for 10 days. This study suggests that biodegradable antimicrobial multilayer packaging films can be effectively designed and applied in the food packaging industry.

Effect of pectin on the properties of nanoemulsions stabilized by sodium caseinate at neutral pH.

The effect of different concentrations of low methoxyl pectin (LMP) on lipid oxidation and physical stability of sodium caseinate (CAS) stabilized nanoemulsions under neutral pH was investigated. The addition of pectin at low concentration (≤ 0.10 wt%) had no significant effect on the average size of nanoemulsions, but a slight size increase and phase separation were observed at higher concentrations of pectin (≥ 0.25 wt%). This result suggests that LMP can not adsorb at the oil/water interfacial CAS membrane at neutral pH. However, in the presence of LMP, the physical stability of nanoemulsions against high salt concentrations and freeze-thaw cycles was significantly enhanced. Moreover, nanoemulsions containing pectin have a better ability to inhibit lipid and protein oxidation than nanoemulsions without pectin after 3 weeks, and the lowest lipid hydroperoxide content was observed for nanoemulsions containing 0.25 wt% pectin.

Plants: A natural solution to enhance raw milk cheese preservation?

Plants have been traditionnally used for centuries in cheese manufacturing, either for their aromatic properties or as technological auxiliaries (e.g. milk-clotting enzyme preparations, cheese wrappers). Some of these plants are known to have antimicrobial and/or antioxidant properties and could also act as natural preservatives for raw milk and derived dairy products. This review examined the traditional uses of plants in dairy processing, and then focuses on known antimicrobial and antioxidant properties of their extracts (e.g. maceration, decoction, essential oil). Known effects of theses plants on technological flora (starter cultures and microorganisms implicated in cheese ripening) were also summarized, and the potential for plant extracts used in combination with hurdle technologies was explored. Then, legal restriction and bioactivity variations from a culture media to a food matrix was reviewed: non-toxic bioactive molecules found in plants, extract preparation modes suitable with foodgrade processing restrictions, the role of the food matrix as a hindrance to the efficiency of bioactive compounds, and a review of food legislation. Finally, some commercial plant extracts for milk preservation were discussed.

Effect of drying and interfacial membrane composition on the antimicrobial activity of emulsified citral.

Citral-in-water emulsions were prepared with two different essential oil concentrations of 2.5 and 5.0% (w/w), then spray-dried in the presence of the same amount of maltodextrins (20%). The microcapsules were prepared with two different emulsifier compositions: monolayer microcapsules (ML) stabilized by sodium caseinate alone and layer-by-layer microcapsules (LBL) stabilized by sodium caseinate and pectin. The encapsulation efficiency was higher for LBL microcapsules (e.g. 99.6 ±â€¯0.4% for 2.5% citral) than that for ML ones (e.g. 78.6 ±â€¯0.6% for 2.5% citral) which confirm that the additional pectin layer was able to protect citral during the spray-drying process whatever citral concentration. Furthermore, our results showed that the antibacterial activity of the obtained microcapsules significantly depends on both citral concentration and interfacial membrane composition. The presence of two layers surrounding the citral droplets may result in a progressive and controlled release of the encapsulated citral.

Spray-drying of protein/polysaccharide complexes: Dissociation of the effects of shearing and heating.

The aim of this study was to dissociate the effect of atomization from that of heating during the spray-drying of Low Methoxyl (LM) pectin/sodium caseinate complexes. The properties of these complexes were studied by measuring turbidity, particle size distribution, zeta-potential, as well as surface hydrophobicity of caseinate within the formed complexes. The results showed that the spraying step had a significant effect on the charge and the size of the complexes. In fact, the application of atomization resulted in the dissociation of caseinate/pectin aggregates especially for high pectin concentrations. Besides, the analysis of the surface hydrophobicity of caseinate indicated that complexation with high concentrations of pectin is able to protect the structure of the protein against heat denaturation. This study allowed a better understanding of the influence of atomization and heat treatment (during the dehydration step) on the molecular interactions within caseinate/pectin complexes.

Effect of emulsification and spray-drying microencapsulation on the antilisterial activity of transcinnamaldehyde.

Spray-dried redispersible transcinnamaldehyde (TC)-in-water emulsions were prepared in order to preserve its antibacterial activity; 5% (w/w) TC emulsions were first obtained with a rotor-stator homogeniser in the presence of either soybean lecithin or sodium caseinate as emulsifiers. These emulsions were mixed with a 30% (w/w) maltodextrin solution before feeding a spray-dryer. The antibacterial activity of TC alone, TC emulsions with and without maltodextrin before and after spray-drying were assayed by monitoring the growth at 30 °C of Listeria innocua in their presence and in their absence (control). Whatever the emulsifier used, antilisterial activity of TC was increased following its emulsification. However, reconstituted spray-dried emulsions stabilised by sodium caseinate had a higher antibacterial activity suggesting that they better resisted to spray-drying. This was consistent with observation that microencapsulation efficiencies were 27.6% and 78.7% for emulsions stabilised by lecithin and sodium caseinate, respectively.

Effect of a Vietnamese Cinnamomum cassia essential oil and its major component trans-cinnamaldehyde on the cell viability, membrane integrity, membrane fluidity, and proton motive force of Listeria innocua.

The antibacterial mechanism of a Cinnamomum cassia essential oil from Vietnam and of its main component (trans-cinnamaldehyde, 90% (m/m) of C. cassia essential oil) against a Listeria innocua strain was investigated to estimate their potential for food preservation. In the presence of C. cassia essential oil or trans-cinnamaldehyde at their minimal bactericidal concentration (2700 µg·mL(-1)), L. innocua cells fluoresced green after staining with Syto9® and propidium iodide, as observed by epifluorescence microscopy, suggesting that the perturbation of membrane did not cause large pore formation and cell lysis but may have introduced the presence of viable but nonculturable bacteria. Moreover, the fluidity, potential, and intracellular pH of the cytoplasmic membrane were perturbed in the presence of the essential oil or trans-cinnamaldehyde. However, these membrane perturbations were less severe in the presence of trans-cinnamaldehyde than in the presence of multicomponent C. cassia essential oil. This indicates that in addition to trans-cinnamaldehyde, other minor C. cassia essential oil components play a major role in its antibacterial activity against L. innocua cells.