Multiscale architectures boosting thermoelectric performance of copper sulfide compound.

Owing to their high performance and earth abundance, copper sulfides (Cu2-x S) have attracted wide attention as a promising medium-temperature thermoelectric material. Nanostructure and grain-boundary engineering are explored to tune the electrical transport and phonon scattering of Cu2-x S based on the liquid-like copper ion. Here multiscale architecture-engineered Cu2-x S are fabricated by a room-temperature wet chemical synthesis combining mechanical mixing and spark plasma sintering. The observed electrical conductivity in the multiscale architecture-engineered Cu2-x S is four times as much as that of the Cu2-x S sample at 800 K, which is attributed to the potential energy filtering effect at the new grain boundaries. Moreover, the multiscale architecture in the sintered Cu2-x S increases phonon scattering and results in a reduced lattice thermal conductivity of 0.2 W·m-1·K-1 and figure of merit (zT) of 1.0 at 800 K. Such a zT value is one of the record values in copper sulfide produced by chemical synthesis. These results suggest that the introduction of nanostructure and formation of new interface are effective strategies for the enhancement of thermoelectric material properties. SUPPLEMENTARY INFORMATION: The online version of this article (10.1007/s12598-020-01698-6) contains supplementary material, which is available to authorized users.

The effect of Mg2+ on digestion performance and microbial community structures in sludge digestion systems.

The important criteria in anaerobic digestion is the rate-limiting step which decides the fate of value-added products especially from waste-activated sludge (WAS). Hence, the present study investigated the effect of magnesium (Mg2+) addition on anaerobic digestion of WAS. The lab-scale experiments were conducted at 25 °C with Mg2+ doses ranging from 0.01 to 0.2 mol/L. Maximum total volatile fatty acids (VFAs) production (372.78 mg COD/L) occurred at a Mg2+ dose of 0.2 mol/L, which was about eight times higher than the control tests. Further, Mg2+ addition facilitated sludge dewaterability and phosphorus removal. The mechanism of improved VFAs generation was analyzed from the view of both chemical and biological effects. Chemical effect significantly enhanced the release of calcium and iron in WAS, resulting in the disintegration of WAS, which benefited hydrolysis and acidification processes. Illumina MiSeq sequencing analysis revealed that enrichment of functional bacteria and the increase of bacterial diversity were obtained in the 0.2 mol Mg2+/L experiment, while the influence was negative on the reactor with 0.025 mol/L Mg2+. Meanwhile, methanogens were accordantly inhibited in the experiments with Mg2+ addition.

The key role of biogenic manganese oxides in enhanced removal of highly recalcitrant 1,2,4-triazole from bio-treated chemical industrial wastewater.

The secondary effluent from biological treatment process in chemical industrial plant often contains refractory organic matter, which deserves to be further treated in order to meet the increasingly stringent environmental regulations. In this study, the key role of biogenic manganese oxides (BioMnOx) in enhanced removal of highly recalcitrant 1,2,4-triazole from bio-treated chemical industrial wastewater was investigated. BioMnOx production by acclimated manganese-oxidizing bacterium (MOB) consortium was confirmed through scanning electronic microscopy (SEM), X-ray photoelectron spectroscopy (XPS), and X-ray diffraction (XRD) analysis. Pseudomonas and Bacillus were found to be the most predominant species in acclimated MOB consortium. Mn2+ could be oxidized optimally at neutral pH and initial Mn2+ concentration below 33 mg L-1. However, 1,2,4-triazole removal by BioMnOx produced occurred optimally at slightly acidic pH. High dosage of both Mn2+ and 1,2,4-triazole resulted in decreased 1,2,4-triazole removal. In a biological aerated filter (BAF) coupled with manganese oxidation, 1,2,4-triazole and total organic carbon removal could be significantly enhanced compared to the control system without the participation of manganese oxidation, confirming the key role of BioMnOx in the removal of highly recalcitrant 1,2,4-triazole. This study demonstrated that the biosystem coupled with manganese oxidation had a potential for the removal of various recalcitrant contaminants from bio-treated chemical industrial wastewater.

Bioassay directed identification of toxicants in sludge and related reused materials from industrial wastewater treatment plants in the Yangtze River Delta.

Industrialized development of the Yangtze River Delta, China, has resulted in larger amounts of wastes, including sludges from treatment of these wastes. Methods to manage and dispose, including reuse were urgently needed. Sludge and reused products were collected from two largest factories, KEYUAN and HENGJIA where treated sludges were turned into bricks or sludge cake to be placed in landfills, respectively. Metals and organic compounds were quantified in sludges and leachates assessed by use of toxicity characterized leaching procedure (TCLP) while acute toxicity was determined by Daphnia magna. Nine metals were detected in all raw sludges with concentrations of Cr and Ni exceeding Chinese standards. For sludge leachate, concentrations of metals were all less than Chinese standards, which changed little after being made into cake by HENGJIA, but were significantly less after being made into brick by KEYUAN. Toxicity units (TU) for all samples are greater than 1.0 indicating that they are potentially toxic to aquatic organisms. TUs changed little after being made into filter cake, but were 10-fold less after being made into bricks. Cr and Ni contributed most to the total toxicity followed by Zn and Cu. Making of sludges into K-brick 1 resulted in better inactivation of contaminants, which resulted in less toxic potencies. So that is the recommended method for handling of industrial sludges. To further assure their safe reuse, additional research on identification of key toxicants and potential hazards, based on additional endpoints, by combining bio-tests and chemical analysis should be done for reused sludges.

Enhancing anaerobic digestion of waste activated sludge by the combined use of NaOH and Mg(OH)2: Performance evaluation and mechanism study.

In this study, the combination treatment of NaOH and Mg(OH)2 was applied to anaerobic digestion of waste activated sludge (WAS) for simultaneously enhancement of volatile fatty acids (VFAs) production, nutrients removal and sludge dewaterability. The maximum VFAs production (461mg COD/g VSS) was obtained at the NaOH/Mg(OH)2 ratio of 75:25, which was much higher than that of the blank or sole NaOH. Moreover, nutrients removal and sludge dewaterability were improved by the combined using of NaOH and Mg(OH)2. Mechanism investigations revealed that the presence of Mg(OH)2 could maintain alkaline environment, which contributed to inhibit the activity of methanogens. Also, the bridging between Mg(2+) and extracellular polymeric substances (EPS) plays an important role in the solubilization and dewatering of sludge. High-throughput sequencing analysis demonstrated that the abundance of bacteria involved in sludge hydrolysis and VFAs accumulation was greatly enriched with the mixtures of NaOH and Mg(OH)2.

Utilization of phosphorus loaded alkaline residue to immobilize lead in a shooting range soil.

The alkaline residue generated from the production of soda ash using the ammonia-soda method has been successfully used in removing phosphorus (P) from aqueous solution. But the accumulation of P-containing solid after P removal is an undesirable menace to the environment. To achieve the goal of recycling, this study explored the feasibility of reusing the P loaded alkaline residue as an amendment for immobilization of lead (Pb) in a shooting range soil. The main crystalline phase and micromorphology of amendments were determined using X-ray diffraction (XRD) and scanning electron microscopy-electron dispersion spectroscopy (SEM-EDS) methods. The toxicity characteristic leaching procedure (TCLP), sequential extraction procedure, and physiologically based extraction test (PBET) were employed to evaluate the effectiveness of Pb immobilization in soil after 45 d incubation. Treatment with P loaded alkaline residue was significantly effective in reducing the TCLP and PBET extractable Pb concentrations in contrast to the untreated soil. Moreover, a positive change in the distribution of Pb fractions was observed in the treated soil, i.e., more than 60% of soil-Pb was transformed to the residual fraction compared to the original soil. On the other hand, P loaded amendments also resulted in a drastic reduction in phytoavailable Pb to the winter wheat and a mild release of P as a nutrient in treated soil, which also confirmed the improvement of soil quality.

In vitro anti-viral activity of the total alkaloids from Tripterygium hypoglaucum against herpes simplex virus type 1.

Herpes simplex virus type 1 (HSV-1) is a commonly occurring human pathogen worldwide. There is an urgent need to discover and develop new alternative agents for the management of HSV-1 infection. Tripterygium hypoglaucum (level) Hutch (Celastraceae) is a traditional Chinese medicine plant with many pharmacological activities such as anti-inflammation, anti-tumor and antifertility. The usual medicinal part is the roots which contain about a 1% yield of alkaloids. A crude total alkaloids extract was prepared from the roots of T. hypoglaucum amd its antiviral activity against HSV-1 in Vero cells was evaluated by cytopathic effect (CPE) assay, plaque reduction assay and by RT-PCR analysis. The alkaloids extract presented low cytotoxicity (CC(50) = 46.6 µg/mL) and potent CPE inhibition activity, the 50% inhibitory concentration (IC(50)) was 6.5 µg/mL, noticeably lower than that of Acyclovir (15.4 µg /mL). Plaque formation was significantly reduced by the alkaloids extract at concentrations of 6.25 µg/mL to 12.5 µg/mL, the plaque reduction ratio reached 55% to 75 which was 35% higher than that of Acyclovir at the same concentration. RT-PCR analysis showed that, the transcription of two important delayed early genes UL30 and UL39, and a late gene US6 of HSV-1 genome all were suppressed by the alkaloids extract, the expression inhibiting efficacy compared to the control was 74.6% (UL30), 70.9% (UL39) and 62.6% (US6) respectively at the working concentration of 12.5 µg/mL. The above results suggest a potent anti-HSV-1 activity of the alkaloids extract in vitro.

Biodegradation of 2,4,6-trinitrophenol by Rhodococcus sp. isolated from a picric acid-contaminated soil.

A picric acid-degrading bacterium, strain NJUST16, was isolated from a soil contaminated by picric acid and identified as a member of Rhodococcus sp. based on 16S rRNA sequence. The degradation assays suggested that the strain NJUST16 could utilize picric acid as the sole source of carbon, nitrogen and energy. The isolate grew optimally at 30 degrees C and initial pH 7.0-7.5 in the mineral salts medium supplemented with picric acid. It was basically consistent with degradation of picric acid by the isolate. Addition of nitrogen sources such as yeast extract and peptone accelerated the degradation of picric acid. However, the stimulation was concentration dependent. The degradation was accompanied by release of stoichiometric amount of nitrite and acidification. The degradation of picric acid at relatively high concentrations (>3.93 mM) demonstrated that the degradation was both pH and nitrite dependent. Neutral and slightly basic pH was crucial to achieve high concentrations of picric acid degradation by the NJUST16 strain.

[Effects of nanoscale oxide particles on structure and property of PVDF hollow fiber membrane].

The preparation of nanoscale oxide/polyvinylidene fluoride (PVDF) composite hollow fiber membrane by phase transition process was introduced. The effects of nanoscale titania and alumina particles on structure and property of composite hollow fiber membrane were investigated. The separation property, microstructure and crystalline phase of composite membranes were characterized by bovine serum albumin (BSA) rejection experiment, scanning electron microscopy (SEM), fourier transform infrared spectroscopy (FT-IR), respectively. The results show that the properties of composite membrane are improved greatly compared to the pure PVDF membranes. The BSA rejection ratios of pure PVDF, Al2O3/PVDF and TiO2/PVDF membranes were 3.27%, 67.20% and 86.67%, respectively. The pure water fluxes of Al2O3/PVDF and TiO2/PVDF membranes were 2.3 and 2.6 times higher than that of pure PVDF membranes. Moreover, the pore size and its distribution of composite membrane characterized by nitrogen isothermal absorption measurement are smaller and narrower than pure PVDF membranes.