Upcycling Romaine lettuce outer leaves by infrared blanching and hot air drying.

Romaine lettuce outer leaves, as opposed to the more commonly marketed heart, are typically discarded and present an opportunity for upcycling as dried powders. Duquesne Romaine lettuce was evaluated to quantify and compare quality attributes of fresh outer and heart leaves, dried powders following hot air drying, and dried powders following an infrared (IR) blanching pretreatment before drying. Attributes measured for fresh leaves included moisture, water activity (Aw), color, total soluble phenolics (TSP), and antioxidant capacity (AC). Drying kinetics and time/energy saving through IR blanching were evaluated. Attributes measured for dried powders included moisture, Aw, color, true density, water vapor isotherms, TSP, AC, cadmium (Cd) content, and pesticide residues. TSP, AC, Cd, and pesticide residues were higher, whereas moisture content and Aw were lower in fresh outer versus heart leaves. Hot air drying reduced TSP and AC to 63.6% and 35.2% of fresh values, respectively, whereas IR blanching further reduced TSP and AC to 37.3% and 25.4% in outer leave powders. On the other hand, TSP and AC increased 237% and 151%, respectively, for unblanched heart powders. Higher increase of TSP than AC in heart leaf powder may indicate synthesis of phenolic compounds activated by abiotic stresses such as cutting and high temperatures at the initial drying stage. IR blanching resulted in significant time/energy savings for drying of outer leaves. Microbial loads were substantially reduced during drying, although microbial population on outer leaves were more resistant. Safe to eat outer leaf Romaine lettuce powders can be produced, assuming appropriate agricultural practices.

Screening of antimicrobial synergism between phenolic acids derivatives and UV-A light radiation.

The objective of this study was to investigate synergistic antibacterial activity based on a combination of UV-A light and three classes of food grade compounds: benzoic acid derivatives, cinnamic acid derivatives, and gallates. By using Escherichia coli O157:H7 as the model strain, it was observed that three cinnamic acid derivatives (ferulic acid, coumaric acid, and caffeic acid) and one benzoic acid derivative (2,5-dihydroxybenzoic acid) presented strong synergistic antibacterial activity with UV-A light radiation, where 1 mM levels of these compounds plus with 15 min of UV-A light (total light dose of 6.1 cm-2) led to more than 7-log CFU mL-1 of bacterial inactivation. In contrast, synergistic antibacterial activity between UV-A light and most benzoic acid derivatives (benzoic acid, gallic acid, vanillic acid, and 2,5-dimethoxybenzoic acid) were only observed after higher concentrations of these compounds were applied (10 mM). Lastly, from the three gallates tested (methyl gallate, ethyl gallate, and propyl gallate), only propyl gallate showed strong antibacterial synergism with UV-A light, where 10 mM of propyl gallate plus 15 min of UV-A light led to approximately 6.5-log of bacterial reduction. Presence of antioxidant compounds mitigated the light-mediated antibacterial activity of gallic acid, 2,5-dihydroxybenzoic acid, and propyl gallate. Similarly, the light-mediated antibacterial activity of these compounds was significantly (P < 0.05) reduced against metabolic-inhibited bacterial cells (sodium azide pretreatment). On the other hand, the antibacterial synergism between ferulic acid and UV-A light was not affected by the presence of antioxidants or the metabolic state of the bacterial cells. Due to the increasing concerns of antimicrobial resistant (AMR) pathogens, the study also investigated the proposed synergistic treatment on AMR Salmonella. Combinations of 1 mM of ferulic acid or 1 mM of 2,5-dihydroxybenzoic acid with UV-A light radiation was able to inactivate more than 6-log of a multi-drug resistant Salmonella Typhimurium strain.

A framework for developing research protocols for evaluation of microbial hazards and controls during production that pertain to the application of untreated soil amendments of animal origin on land used to grow produce that may be consumed raw.

Application of manure or soil amendments of animal origin (untreated soil amendments; UTSAs) to agricultural land has been a long-standing practice to maintain or improve soil quality through addition of organic matter, nitrogen, and phosphorus. Much smaller quantities of these types of UTSAs are applied to land used for food crops than to land used for animal grain and forage. UTSAs can harbor zoonotic enteric pathogens that may survive for extended periods after application. Additional studies are needed to enhance our understanding of preharvest microbial food safety hazards and control measures pertaining to the application of UTSAs especially for land used to grow produce that may be consumed raw. This document is intended to provide an approach to study design and a framework for defining the scope and type of data required. This document also provides a tool for evaluating the strength of existing data and thus can aid the produce industry and regulatory authorities in identifying additional research needs. Ultimately, this framework provides a means by which researchers can increase consistency among and between studies and facilitates direct comparison of hazards and efficacy of controls applied to different regions, conditions, and practices.