Upcycling of recycled minerals from sewage sludge through black soldier fly larvae (Hermetia illucens): Impact on growth and mineral accumulation.

Phosphorous (P) resources are finite. Sewage sludge recyclates (SSR) are not only of interest as plant fertilizer but also as potential source of minerals in animal nutrition. However, besides P and calcium (Ca), SSR contain heavy metals. Under EU legislation, the use of SSR derivatives in animal feed is not permitted, but given the need to improve nutrient recycling, it could be an environmentally sound future mineral source. Black soldier fly larvae (BSFL) convert low-grade biomass into valuable proteins and lipids, and accumulate minerals in their body. It was hypothesized that BSFL modify and increase their mineral content in response to feeding on SSR containing substrates. The objective was to evaluate the upcycling of minerals from SSR into agri-food nutrient cycles through BSFL. Growth, nutrient and mineral composition were compared in BSFL reared either on a modified Gainesville fly diet (FD) or on FD supplemented with either 4% of biochar (FD + BCH) or 3.6% of single-superphosphate (FD + SSP) recyclate (n = 6 BSFL rearing units/group). Larval mass, mineral and nutrient concentrations and yields were determined, and the bioaccumulation factor (BAF) was calculated. The FD + SSP substrate decreased specific growth rate and crude fat of BSFL (P < 0.05) compared to FD. The FD + SSP larvae had higher Ca and P contents and yields but the BAF for Ca was lowest. The FD + BCH larvae increased Ca, iron, cadmium and lead contents compared to FD. Larvae produced on FD + SSP showed lower lead and higher arsenic concentration than on FD + BCH. Frass of FD + BCH had higher heavy metal concentration than FD + SSP and FD (P < 0.05). Except for cadmium and manganese, the larval heavy metal concentration was below the legally permitted upper concentrations for feed. In conclusion, the SSR used could enrich BSFL with Ca and P but at the expense of growth. Due to the accumulation of Cd and Mn, BSFL or products thereof can only be a component of farmed animal feed whereas in BSFL frass heavy metal concentrations remained below the upper limit authorized by EU.

Mineral Phosphorus Supply in Piglets Impacts the Microbial Composition and Phytate Utilization in the Large Intestine.

A sufficient supply of phosphorus (P) to pigs in livestock farming is based on the optimal use of plant-based phytate and mineral P supplements to ensure proper growth processes and bone stability. However, a high P supplementation might bear the risk of higher environmental burden due to the occurrence of excess P and phytate degradation products in manure. In this context, the intestinal microbiota is of central importance to increase P solubility, to employ non-mineral P by the enzymatic degradation of phytate, and to metabolize residual P. A feeding experiment was conducted in which piglets were fed diets with different P levels, resulting in three groups with low, medium (covering requirements), and high concentrations of available P. Samples from caecum and colon digesta were analysed for microbial composition and phytate breakdown to estimate the microbial contribution to metabolize P sources. In terms of identified operational taxonomic units (OTU), caecum and colon digesta under the three feeding schemes mainly overlap in their core microbiome. Nevertheless, different microbial families correlate with increased dietary P supply. Specifically, microbes of Desulfovibrionaceae, Pasteurellaceae, Anaerovoracaceae, and Methanobacteriaceae were found significantly differentially abundant in the large intestine across the dietary treatments. Moreover, members of the families Veillonellaceae, Selenomonadaceae, and Succinivibrionaceae might contribute to the observed phytate degradation in animals fed a low P diet. In this sense, the targeted manipulation of the intestinal microbiota by feeding measures offers possibilities for the optimization of intestinal phytate and P utilization.

Effects of increasing dietary rye levels on physicochemical characteristics of digesta and its impact on stomach emptying as well as the formation of 'doughballs' in stomachs of young pigs.

Despite quite similar contents of starch and crude fibre of wheat and rye, the unique non-starch-polysaccharide fraction of rye (e.g. high levels of arabinoxylans and fructans) might have an impact on physicochemical properties of the digesta in pigs. Forty pigs (age: 46.8 ± 5.28 days; bodyweight: 16.1 ± 4.13 kg) were divided into four treatment groups. During four weeks, the pigs received diets consisting of wheat and/or rye, barley, soy, potato protein and a mineral supplement. The sum of wheat and rye was 69% in all diets, whereby the compound feed of each group was characterized by a different ratio (%) of wheat/rye (69/0; 46/23; 23/46; 0/69, respectively). In the stomach, 'doughballs' occurred more frequently with increasing dietary rye levels (9/10; 69% rye). With higher DM content and extract-viscosity of gastric digesta, the stomach emptying tended to be retarded in rye groups. Compared to the control group (69% wheat), maximum dietary rye levels (69%) resulted in significantly higher concentrations of lactic acid in digesta of the stomach and small intestine. With increasing lactic acid concentrations, the pH tended to be lower in small intestinal digesta. With an intensified formation of lactic acid, effects against Gram-negative bacteria, for example Salmonella, can be expected. Moreover, because of higher viscosity and the retarded stomach emptying, there could be advantages of including rye in compound feeds when a longer lasting satiety is intended, for example when feeding pregnant sows (regularly fed restrictively).

Effects of excessive or restricted phosphorus and calcium intake during early life on markers of bone architecture and composition in pigs.

Sufficient supply of pigs with calcium (Ca) and phosphorus (P) is essential for animal health and welfare during the growth period. However, the P content in animal manure is considered as a cause of massive environmental problems in soil and aquatic ecosystems. To complement previous findings, the objective of this study is the investigation of effects of a reduced and increased Ca and P supplementation on bone mineralization and bone structure compared with the current dietary recommendation. Another aim is to find possible serum markers that would allow the assessment of adequacy of P supply for bone health during growth. The result validated that the recommended Ca and P supply is sufficient, without the addition of microbial phytases. However, addition of P has no further beneficial effects on bone stability, while P supplementation below the recommended level affects bone development and growth performance. Reduced P levels have consequences for cancellous bone density and trabecular architecture. Further fine-tuning of the P supply in conjunction with an appropriate Ca supply will contribute to a reduction in P waste and associated environmental impact while maintaining animal health and welfare.

Reduced phosphorus intake throughout gestation and lactation of sows is mitigated by transcriptional adaptations in kidney and intestine.

BACKGROUND: The environmental impact of pig farming need to be reduced, with phosphorus (P) being of particular interest. Specified dietary regimens and management systems contribute to meet environmental concerns and reduce economic constrains. However, pregnant and lactating sows represent vulnerable individuals, whose reproductive potential and metabolic health status relies on adequate supply of macro- and micronutrients. The aim of this study was to investigate, whether sows fed with a dietary P content that is below or above current recommendations are capable to maintain mineral homeostasis during the reproduction cycle and which endogenous mechanisms are retrieved therefore in kidney and jejunum. Nulliparous gilts were fed iso-energetic diets with recommended (M), reduced (L), or high (H) amounts of mineral P supplements throughout gestation and lactation periods. Blood metabolites and hormones referring to the P homeostasis were retrieved prior to term (110 days of gestation) and at weaning (28 days of lactation). Transcriptional responses in kidney cortex and jejunal mucosa were analyzed using RNA sequencing. RESULTS: The variable dietary P content neither led to an aberration on fertility traits such as total weaned piglets nor to an effect on the weight pattern throughout gestation and lactation. Serum parameters revealed a maintained P homeostasis as reflected by unaltered inorganic P and calcium levels in L and H fed groups. The serum calcitriol levels were increased in lactating L sows. The endocrine responses to the dietary challenge were reflected at the transcriptional level. L diets led to an increase in CYP27B1 expression in the kidney compared to the H group and to an altered gene expression associated with lipid metabolism in the kidney and immune response in the jejunum. CONCLUSIONS: Our results suggest that current P requirements for gestating and lactating sows are sufficient and over supplementation of mineral P is not required. Shifts in renal and jejunal expression patterns between L and H groups indicate an affected intermediate metabolism, which long-term relevance needs to be further clarified.

Lower dietary phosphorus supply in pigs match both animal welfare aspects and resource efficiency.

Dietary phosphorus frequently exceeds age-specific requirements and pig manure often contains high phosphorus load which causes environmental burden at regional scales. Therefore, feeding strategies towards improved phosphorus efficiency and reduced environmental phosphorus load have to be developed. A 5-week feeding trial was conducted: piglets received medium, lower (-25%), or higher (+25%) amounts of phosphorus and calcium. Dietary responses were reflected by performance parameters, bone characteristics, and molecular data retrieved from serum, intestinal mucosa, and kidney cortex (p < 0.05). Transcripts associated with vitamin D hydroxylation (Cyp24A1, Cyp27A1, Cyp27B1) were regulated by diet at local tissue sites. Low-fed animals showed attempts to maintain mineral homoeostasis via intrinsic mechanisms, whereas the high-fed animals adapted at the expense of growth and development. Results suggest that a diet containing low phosphorus and calcium levels might be useful to improve resource efficiency and to reduce phosphorus losses along the agricultural value chain.

Effect of a fermented dietary supplement containing chromium and zinc on metabolic control in patients with type 2 diabetes: a randomized, placebo-controlled, double-blind cross-over study.

BACKGROUND: For the increasing development of type 2 diabetes dietary habits play an important role. In this regard, dietary supplements are of growing interest to influence the progression of this disease. OBJECTIVE: The aim of this study was to investigate the effect of a cascade-fermented dietary supplement based on fruits, nuts, and vegetables fortified with chromium and zinc on metabolic control in patients with type 2 diabetes mellitus. METHODS: This was a randomized, placebo-controlled, double-blind, intervention study under free-living conditions using a cross-over design. Thirty-six patients with type 2 diabetes mellitus were enrolled and randomized either to receive a cascade-fermented dietary supplement enriched with chromium (100 µg/d) and zinc (15 mg/d) or a placebo similar in taste but without supplements, over a period of 12 weeks. After a wash-out period of 12 weeks, the patients received the other test product. The main outcome variable was the levels of glycated hemoglobin (HbA1c). Other outcome variables were fasting blood glucose, fructosamine, and lipid parameters. RESULTS: Thirty-one patients completed the study. HbA1c showed no relevant changes during both treatment periods, nor was there a relevant difference between the two treatments (HbA1c: p=0.48). The same results were found for fructosamine and fasting glucose (fructosamine: p=0.9; fasting glucose: p=0.31). In addition, there was no effect on lipid metabolism. CONCLUSION: This intervention study does not provide evidence that a cascade-fermented plant-based dietary supplement enriched with a combination of chromium and zinc improves glucose metabolism in patients with type 2 diabetes mellitus under free-living conditions.

Toward improved phosphorus efficiency in monogastrics-interplay of serum, minerals, bone, and immune system after divergent dietary phosphorus supply in swine.

Phosphorus (P) is of vital importance for many aspects of metabolism, including bone mineralization, blood buffering, and energy utilization. In order to identify molecular routes affecting intrinsic P utilization, we address processes covering P intake, uptake, metabolism, and excretion. In particular, the interrelation of bone tissue and immune features is of interest to approximate P intake to animal's physiology and health status. German Landrace piglets received different levels of digestible phosphorus: recommended, higher, or lower amounts. At multiple time points, relevant serum parameters were analyzed and radiologic studies on bone characteristics were performed. Peripheral blood mononuclear cells were collected to assess differential gene expression. Dietary differences were reflected by serum phosphorus, calcium, parathyroid hormone, and vitamin D. Bone reorganization was persistently affected as shown by microstructural parameters, cathepsin K levels, and transcripts associated with bone formation. Moreover, blood expression patterns revealed a link to immune response, highlighting bidirectional loops comprising bone formation and immune features, where the receptor-activator of NF-κB ligand/receptor-activator of NF-κB kinase system may play a prominent role. The modulated P supplementation provoked considerable organismal plasticity. Genes found to be differentially expressed due to variable P supply are involved in pathways relevant to P utilization and are potential candidate genes for improved P efficiency.

Ovine pulmonary adenocarcinoma as an animal model of progressive lung cancer and the impact of nutritional selenium supply.

Jaagsiekte sheep retrovirus (JSRV) is known to induce ovine pulmonary adenocarcinoma (OPA). Several studies have suggested an influence of selenium (Se) status on cancer progression. Thus, combining OPA with a defined Se supply might serve as a suitable animal model to study the impact of Se on lung cancer progression. 16 naturally JSRV-infected sheep were divided into 2 treatment groups receiving (a) <0.05 and (b) 0.2 mg Se/kg dry matter in diet, respectively. Computed tomography (CT) was performed repeatedly and evaluated using a CT-OPA-score system. Liver biopsies were taken three-monthly, blood samples were collected biweekly to study treatment effects on Se concentrations and glutathione peroxidase (GPx) activity. Cell pellets from bronchoalveolar lavage fluid (BALF) were tested for JSRV by PCR to approve the infection. To date, four animals of the ongoing study have been euthanised. Autopsy and histopathology were performed and correlated to CT analysis. JSRV was detected in BALF cell pellets. Progression of lung tumours was monitored successfully by repeated CT examinations, enabling the detection of even small nodules or increased lung density. Histopathology revealed bronchioloalveolar adenocarcinoma in lung areas suspicious to be OPA from CT evaluation. Score-based analysis of CT images for quantifying tumour progression proved as a valuable tool. Se concentration and GPx activity increased in liver and serum of group b and verified the efficiency of different feeding regime. In conclusion, OPA along with CT, autopsy/histopathology, trace element and enzyme activity analysis provide a suitable large animal model to examine the impact of Se supply on lung tumourigenesis.

Peracute selenium toxicosis followed by sudden death in growing and finishing pigs.

Fattening pigs (n = 751) showed progressive apathy, paralysis, and sudden death after accidental ingestion of excessive concentrations of selenium in mineral feed. Selenium concentrations of 1.09 to 1.32 mg/L in the serum confirmed the diagnosis. Within 3 d all pigs had died spontaneously or were euthanized due to the grave prognosis and on welfare grounds.

Estimation of inevitable macro mineral losses in amazons (Amazona spp.) as basis for the calculation of maintenance requirement.

To determine the endogenous losses of macro minerals via excrements, adult amazons (Amazona spp., n=5) were fed a purified diet supplemented with vitamins, trace elements and amino acids according to recommendations for poultry, but almost free of calcium, phosphorus, magnesium, sodium and potassium. The diet was offered ad libitum for nine days and was compared to mineral excretion when fed a commercial seed mixture. Daily dry matter (DM) intake was 22.2 g DM/bird (16.3 MJ ME/kg DM) compared to 8.18 g DM/bird when offered a commercial seed mixture (20.0 MJ ME/kg DM). Daily amounts of excreta corresponded to the physiological amounts of this species (5.2 g DM/bird). The digestibility of organic matter was similar for the purified diet and seeds (75% and 77%, respectively). Inevitable losses of major elements reached a basal level latest after five days and amounted to 10.6 mg calcium, 2.9 mg phosphorus, 1.3 mg magnesium, 1.7 mg sodium and 10.8 mg potassium (values per kg BW(0.75)). Feeding a diet almost free of major elements resulted in a decrease in blood content for magnesium (24.4%), potassium (21.8%) and sodium (4.5%), whereas the calcium and phosphorus content in plasma stayed constant or did not show unidirectional changes in all animals.