RESUMEN
In this study, CH4 production capacity of nitrification bacteria (NB) obtained from the submerged biofilter in the laboratory was investigated. Biochemical methane potential (BMP) test was carried out with the NB amount of zero (control, CR), 5% (R1), 10% (R2), and 15% (R3) at a temperature of about 37 ± 0.5°C. Compared to the CR, significantly higher cumulative CH4 volume of about 290, 490, and 715 mL were determined in the R1, R2, and R3, respectively. All the applied kinetic models gave good results (R2 ≥0.97), while the Transference Function and First-order models provided the better R2 values. The delay phase (λ) was not observed in the AD process, and CH4 production started immediately on the first day of operation. The predicted k value of 0.133 day-1 was high in CR, while it was approximately between 0.078 and 0.112 day-1 for the higher amount of NB containing BMP units, which indicated that the AD required long reaction time.
RESUMEN
The waste biological sludge disintegration by using microwave irradiation was investigated at a ramping rate of 2°C/min and 5 min holding time at various target temperatures. Significant disintegration of biosludge was observed and the highest disintegration degree was determined about 82% at the temperature of 110°C. Increase of target temperature elevated the energy needs to 98, 123 and 148 kWh/kg TS at the temperatures of 75°C, 90°C and 110°C, respectively. The gradual increase of sugar and protein in the sludge slurry with increasing temperatures indicates successful degradation. The microwave pretreatment increased the specific surface area of the sludge by particle size reduction. The specific surface area of raw sludge was 70 m2/kg and rose to approximately 253.7 m2/kg at 110°C with an increment ratio of 260%. Although a significant NH4-N release was not observed, PO4-P concentrations increased from 11.0 mg/L to 16.3, 20.7 and 29.2 mg/L at the temperatures of 75°C, 90°C, 110°C, respectively. While the specific filter resistance of waste biological sludge was about 1.0 × 1013, increasing the microwave target temperature, the ability of dewatering decreased and the highest SFR value of 5.1 × 1014 was observed at the temperature of 110°C.