Fault detection using dynamic time warping (DTW) algorithm and discriminant analysis for swine wastewater treatment.

This paper proposes a diagnosis system using dynamic time warping (DTW) and discriminant analysis with oxidation-reduction potential (ORP) and dissolved oxygen (DO) values for swine wastewater treatment. A full-scale sequencing batch reactor (SBR), which has an effective volume of 20 m(3), was auto-controlled, and the reaction phase was performed by a sub-cycle operation consisting of a repeated short cycle of the anoxic-aerobic step. Using ORP and DO profiles, SBR status was divided into four categories of normal and abnormal cases; these were influent disturbance, aeration controller fault, instrument trouble and inadequate raw wastewater feeding. Through the DTW process, difference values (D) were determined and classified into seven cases. In spite of the misclassification of high loading rates, the ORP profile provided good diagnosis results. However, the DO profiles detected five misclassifications that indicated different statuses. After the DTW process, several statistical values, including maximum value, minimum value, average value, standard deviation value and three quartile values, were extracted and applied to establish the discriminant function. The discriminant analysis allows one to classify seven cases with a percentage of 100% and 92.7% for ORP and DO profiles, respectively. Consequently, the study showed that ORP profiles are more efficient than DO profiles as diagnosis parameters and DTW diagnosis algorithms and discriminants.

Full-cyclic control strategy of SBR for nitrogen removal in strong wastewater using common sensors.

A full-cyclic automatic control strategy for sequencing batch reactors (SBR) was proposed using only common sensors such as ORP, DO and pH. The main objective was to develop a generally applicable and robust control strategy. To accomplish this, various control schemes found in the literature or suggested by authors were examined at diverse ammonia loads and SCOD/NH4(+)-N ratios. Advantages and constraints of each scheme were discussed and compared. Ammonia load was estimated with DO lag time during the aerobic stage, and then the influent pump was manipulated to meet the desired load at the next anoxic stage. A partial denitrification scheme was chosen for the anoxic stage period control, to save anoxic time and external carbon. For external carbon dosage control, intermittent feeding at each anoxic stage was concluded to be a suitable scheme. The anoxic stage period could be successfully controlled by the combination of pH increase and DO increase. Every suggested control scheme was incorporated into a full-cyclic control strategy and tested at 0.02, 0.035, 0.08 kg NH4(+)-N/m3/sub-cycle. From the results, it is expected to perform unmanned automatic SBR operation with this strategy.

Temperature-based rapid toxicity test using Ceriodaphnia dubia.

Toxicants, which may cause the inhibition to the biological process in sewage/wastewater treatment plant, need to be monitored within short time to prevent from serious damage. A new method, Temperature-based rapid toxicity test (TempTox test) using Ceriodaphnia dubia, was developed and compared with the standard 48 hr acute bioassay (Std. 48-hr test). Inorganic toxicants of cadmium, zinc, copper, cyanide, chromium (III), chromium (VI) and organic toxicants of phenol, PCP and pesticides of BPMC, Diazinon, Fenitrothion were tested for TempTox test and Std. 48-hr test. Because the TempTox test is based on just temperature control, C. dubia neonates were exposed to toxicants under high temperature (35.5 degrees C) condition without any complicated pretreatment. After given exposure time of 1, 1.25, 1.5 hours, the number of the live (no toxic effect) or the dead (toxic effect) was counted with eye without the aid of any microscope and median effective concentrations (EC50 values) were determined. From the results for all toxicants, the TempTox test was proved to be as sensitive as the Std. 48-hr test with shorter-time of just 1.25-1.5 hours. Moreover, the TempTox test was further much more sensitive than alternative bioassays such as the 1-hour l.Q. test and 30-minute Microtox. The TempTox test showed a high applicability of toxicity bioassay for real sewage/wastewater treatment plant by its easiness, rapidity and sensitivity. Finally, the prototype for short-term TempTox test was introduced.

Treatment of strong nitrogen swine wastewater in a full-scale sequencing batch reactor.

Treatment of swine wastewater containing strong nitrogen was attempted in a full-scale SBR. The strongest swine wastewater was discharged from a slurry-type barn and called swine-slurry wastewater (SSW). Slightly weaker wastewater was produced from a scraper-type barn and called swine-urine wastewater (SUW). TCOD, NH4+-N and TSS in raw SSW were 23,000-72,000 mg/L, 3,500-6,000 mg/L and 17,000-50,000 mg/L, respectively. A whole cycle of SBR consists of 4 sub-cycles with anoxic period of 1 hr and aerobic period of 3 hr. The maximum loading rates of both digested-SSW and SUW were similar to 0.22 kg NH4+-N/m3/day whereas the maximum loading rates of raw SSW was up to 0.35 TN/m3/day on keeping the effluent quality of 60 TN mg/l. The VFAs portion of SCOD in raw SSW was about more than 60%. The VFAs in SUW and digested-SSW were about 22% and 15%, respectively. NH4+-N and PO4(3-)-P in SSW were removed efficiently compared to those in digested-SSW and DUW because SSW had high a C/N ratio and readily biodegradable organic. High concentration of organic was useful to enhance denitrification and P uptake. Also the amount of external carbon for denitrification was reduced to 5% and 10% of those for digested-SSW and SUW.

External carbon feeding strategy for enhancing nitrogen removal in SBR.

Effective method for feeding an external carbon source (ECS) in SBR was investigated to enhance denitrification based on modifying the anoxic/aerobic sub-cycle for swine wastewater treatment. The wastewater discharged from the scraper-type barns contains relatively low readily biodegradable organic. Therefore NOx-N was accumulated during repeating sub-cycle in SBR operation. When acetic acid was fed as ECS during the final sub-cycle, the maximum nitrogen removal rate was 0.22 kg N/m3/d. This was due to both less denitrification rate during the sub-cycle period and inhibition of denitrification by pH drop during the final cycle. The pH drop was caused by a large amount of ECS feeding to remove high concentration of NOx-N in the final period. To overcome these limitations and achieve higher nitrogen removal rate, the intermittent ECS feeding method with raw wastewater at every anoxic period was developed. Using the modifying ECS feeding method, the removal rate was increased to 0.45 kg N/m3/d without NOx-N accumulation.

Stimulating accumulation of nitrifying bacteria in porous carrier by addition of inorganic carbon in a continuous-flow fluidized bed wastewater treatment reactor.

Porous polyurethane carrier particles have been successfully applied for microbial immobilization to simultaneously remove carbonaceous and nitrogenous substances from wastewater by a fill-and-draw operation. This reactor system was extended to a continuous-flow operation mode, by which inorganic carbon (IC) was supplemented in order to stimulate the growth of autotrophic nitrifying bacteria. By addition of sodium bicarbonate, the ammonia oxidation reaction proceeded remarkably in the porous particle fluidized bed reactor, while a small increase in the nitrification was observed in a reactor with suspended microbes. Dissolved oxygen profile was obtained using an oxygen microelectrode to measure the microbial consumption of oxygen in the porous carrier. The size of ammonia-oxidizing bacterial populations in the carrier was proportional to the volume of the aerobic region of the carrier. The aerobic region decreased with the increase in sodium bicarbonate concentration, which improved the ammonia-oxidizing activity of retained nitrifiers in the carrier. The maximum ammonia oxidation rate was up to 55.6 gN/m3/h within the aerobic region of the carrier under the following feed conditions: 100 mg/l of total organic compound, 55 mg/l of ammonium concentration and 48 mg/l of inorganic carbon.

Differentiation characteristics of cholesteatoma epithelium determined by expression of transglutaminase isoenzymes.

Transglutaminase (TGase) isoenzymes are involved in the process of the differentiation and cornification of keratinocytes in the epidermis. This study investigates the presence and localization of three TGase isoenzymes to elucidate the nature and differentiation status of the squamous epithelium in human aural cholesteatoma. Twenty cholesteatoma specimens were used. The presence and localization of three TGase isoenzymes were studied by reverse transcription-polymerase chain reaction (RT-PCR) and immunohistochemistry. mRNA expression of three TGase isoenzymes were detected in the tested cholesteatomas with variable levels. The immunohistochemical staining patterns of three TGase isoenzymes showed variations within specimens, relating to keratinizing activity. TGase K is the most abundant among three isoenzymes. Keratinizing epithelium of cholesteatoma have similar expression profiles of TGase isoenzymes with those of epidermis of the skin. Other areas, particularly those showing non-keratinizing epithelium, showed weak immunostaining of TGase E and C, suggesting its different maturation status from keratinizing epithelium. The results of this study indicate that epithelium of cholesteatoma undergoes same direction of maturation and differentiation characteristics as the epidermis of skin, evidenced by similar expressions of TGases both in mRNA level and immunohistochemistry.

Engagement of CD99 induces apoptosis through a calcineurin-independent pathway in Ewing's sarcoma cells.

Programmed cell death (PCD) is a prominent feature of the development of the immune and nervous systems. In both systems, widespread PCD occurs in primitive progenitor cells during development. In this study, we demonstrated that Ewing's sarcoma (ES) cells, undifferentiated neural precursors, underwent apoptosis upon engagement of CD99 with anti-CD99 monoclonal antibody. Apoptosis via CD99 occurred only in the undifferentiated state of ES cells, but not in differentiated ES cells. CD99-induced apoptosis in ES cells appeared to require de novo synthesis of RNA and protein as well as caspase activation. Cyclosporin A, known to be a potent inhibitor of both calcineurin activation and mitochondrial permeability transition pore opening, inhibited CD99-mediated apoptosis, whereas FK-506, a specific calcineurin inhibitor, did not, indicating the induction of CD99-mediated apoptosis through a calcineurin-independent pathway. Furthermore, the dying cells displayed the reduction of mitochondrial transmembrane potential (delta psi m). These results suggest that CD99 engagement induce CsA-inhibitable mitochondrial permeability transition pore opening, followed by a reduction of delta psi m and caspase activation, thereby leading to apoptosis. Based on these results, we suggest the possible involvement of CD99 in the apoptotic processes that occur during nervous system development and also its application in immunotherapeutic trials for ES cases.

Titanium oxide film for the bottom antireflective layer in deep ultraviolet lithography.

Titanium oxide thin film, fabricated with tetraisopropyltitanate and oxygen by electron cyclotron resonance-plasma-enhanced chemical vapor deposition, is investigated as a potential candidate for the antireflective layer in KrF excimer laser (248-nm) lithography. The oxygen flow-rate dependence of the optical properties such as the refractive index (n) and the extinction coefficient (k) of the film at the 248-nm wavelength has been characterized, and the films with the expected combinations of n and k values for the antireflective layer have been deposited. Simulation results indicate that reflectance values of less than 4% and as low as 1.2% can be reached at the interface between the photoresist and the film postulating the structures of the photoresist/300-A TiO(x) film/c-Si substrate and the W-Si substrate, respectively, by selected proper combinations of n and k values. Moreover the reflectance can be further reduced to almost zero by changing the film thickness. Thus it is found that titanium oxide thin films can be used as the bottom antireflective layer in KrF excimer laser lithography.

Primary and secondary tumors of the facial nerve. A temporal bone study.

Of 1400 temporal bones in the collection at the University of Minnesota, Minneapolis, 17 temporal bones from 15 patients were found to have tumors involving the facial nerve. The findings were as follows: one case of facial nerve schwannoma; two cases of invasion of the facial nerve by contiguous tumor; and 14 cases of metastatic tumors involving the facial nerve. Facial nerve paralysis was present in half of the cases (nine of 17). Facial nerve paralysis was present in the case of facial nerve schwannoma, in both cases of invasion of the facial nerve by contiguous tumor, and in six of 14 cases of metastatic tumors involving the facial nerve. The presence of the facial nerve paralysis correlated well with the degree of tumor infiltration into the nerve fibers and the segment of the tumor involvement in the facial nerve. In the patients with metastatic tumors, facial nerve paralysis was a sign of extensive intracranial tumor involvement and was usually accompanied by other cranial nerve palsies, most commonly involving the fifth nerve.