Microbial acidification and pH effects on trace element release from sewage sludge.

Leaching of sludge-borne trace elements has been observed in experimental and field studies. The role of microbial processes in the mobilization of trace elements from wastewater sludge is poorly defined. Our objectives were to determine trace element mobilization from sludge subjected to treatments representing microbial acidification, direct chemical acidification and no acidification, and to determine the readsorption potential of mobilized elements using calcareous sand. Triplicate columns (10-cm diameter) for incubation and leaching of sludge had a top layer of digested dewatered sludge (either untreated, acidified with H2SO4, or limed with CaCO3; all mixed with glass beads to prevent ponding) and a lower glass bead support bed. Glass beads in the sludge layer, support layer or both were replaced by calcareous sand in four treatments used for testing the readsorption potential of mobilized elements. Eight sequential 8-day incubation and leaching cycles were operated, each consisting of 7.6 d of incubation at 28 degrees C followed by 8 h of leaching with synthetic acid rain applied at 0.25 cm/h. Leachates were analyzed for trace elements, nitrate and pH, and sludge layer microbial respiration was measured. The largest trace element, nitrate and S losses occurred in treatments with the greatest pH depression and greatest microbial respiration rates. Cumulative leaching losses from both microbial acidification and direct acidification treatments were > 90% of Zn and 64-80% of Cu and Ni. Preventing acidification with sludge layer lime or sand restricted leaching for all trace elements except Mo. Results suggested that the primary microbial role in the rapid leaching of trace elements was acidification, with results from direct acidification being nearly identical to microbial acidification. Microbial activity in the presence of materials that prevented acidification mobilized far lower concentrations of trace elements, with the exception of Mo. Trace elements mobilized by acidification were readsorbed by calcareous sand when present.

Temperature and microbial activity effects on trace element leaching from metalliferous peats.

Due to geochemical processes, peat soils often have elevated concentrations of trace elements, which are gradually released following drainage for agriculture. Our objectives were to use incubation temperatures to vary microbial activity in two metalliferous peats (M7 acidic peat and M3 neutral peat) from the Elba, New York region, and to use periodic leaching to assess the extent of trace element release from these soils. Dried soils were mixed with glass beads to maintain aeration, moistened, and incubated at 4, 16, 28, and 37 degrees C in 10-cm-diameter x 8-cm-tall columns. Five incubation-leaching cycles were performed, each consisting of 7.3 d of incubation (28 d for the final cycle) followed by 16 h of leaching with synthetic acid rain at 2.5 mm h(-1). Microbial activity was determined initially and after the final leaching by measuring C mineralization following glucose stimulation. Cumulative respiration results were ranked 28 > 16 > 4 > 37 degrees C, with M7 acidic peat respiration values greater than M3 neutral peat at each temperature. Initial leachate pH levels were between 2 and 4, with acidification less pronounced and shorter-lived for the M3 peat. Leachate S, dissolved organic carbon (DOC), NO3-N, and trace elements declined with successive leachings (rebounding slightly in the final M3 leachate), with concentrations typically greater in the M7 leachate. Elemental losses followed the same general ranking (28 > 16 > 4 > 37 degrees C); losses at 28 degrees C were 15 to 22% for As, Cd, Ni, and Zn from the M7 peat; losses from M3 were comparable only for Cu (1%) and Ni (19%). The correlation of respiration with S, DOC, and trace elements losses indicates that microbial processes mediated the release of trace elements in both peat soils. Neutral M3 peat pH levels limited losses of most analytes.

Effect of microbial activity on trace element release from sewage sludge.

The microbial role in mobilization of trace elements from land-applied wastewater sludge is not well-defined. Our study examined the leachability of trace elements (Cd, Cr, Cu, Mo, Ni, P, Pb, S, and Zn) from dewatered sludge as affected by treatments designed to alter microbial activity. Different levels of microbial activity were achieved by incubating sludge columns at 4, 16, 28, and 37 degrees C and by the addition of AgNO3 biocide at each temperature. Columns (with inert glass bead support beds) were subjected to six consecutive incubation-leaching cycles, each consisting of 7.3-d incubation followed by 16-h leaching with synthetic acid rain. Glucose mineralization tests were used to assess overall microbial activity. Significant acidification and trace element leaching occurred when conditions favored microbial activity (16 and 28 degrees C). Extent of mobilization was element-specific with Zn, Ni, and Cu showing the greatest mobilization (99, 67, and 57%, respectively). Mobilization was reduced but still substantial at 4 degrees C. Conditions that best inhibited microbial activity (37 degrees C or biocide at any temperature) resulted in the least mobilization. Characterization of enrichments performed using thiosulfate as the sole energy source revealed the presence of both known and putative S-oxidizing bacteria in the sludge. The results suggest that microbial acidification via S oxidation can mobilize trace elements from sludge. Elemental mobility in field situations would also be governed by other factors, including the capacity of soil to buffer acidification and to adsorb mobilized elements.