RESUMEN
AIMS: This study aimed to determine the survival and growth of Listeria innocua on hot and cold beef carcass surfaces. METHODS AND RESULTS: Four sites, the neck, outside round, brisket and foreshank/brisket, were inoculated with L. innocua (i) immediately after dressing while hot and (ii) when cold after chilling. After inoculation, all carcasses were stored at 4 degrees C for 72 h. Survival of L. innocua on cold surfaces declined during storage and was less than on hot carcasses at all times. Data on the survival of L. innocua in broth (maximum recovery diluent) indicated that counts could not be compared with those on carcasses, in particular on cold carcasses. CONCLUSIONS: The results indicate that L. innocua survives on hot carcass surfaces during chilling, but declines over time on cold surfaces. The decrease in L. innocua counts on cold surfaces may be related to a synergy between the combined stresses of low available water (a(w)) and low temperature. SIGNIFICANCE AND IMPACT OF THE STUDY: This study is the first to determine the effect of chilling on the survival and growth of Listeria on beef carcass surfaces. The information can potentially be used to determine the survival and growth of the pathogen, L. monocytogenes on beef surfaces.
Asunto(s)
Frío , Microbiología de Alimentos , Listeria/fisiología , Carne/microbiología , Animales , Recuento de Colonia Microbiana , Deshidratación , Manipulación de Alimentos , Viabilidad Microbiana , Factores de TiempoRESUMEN
This study investigated the influence of attachment to beef surfaces on the survival, injury and death of stationary phase cells of Salmonella enterica serovar Typhimurium DT104, compared to cells free in solution. The effects on cells are considered at different a(w) values and low temperatures in relation to osmotic and cold temperature shock effects. Attachment of cells to meat surfaces prevented cell injury and death from hyperosmosis and low temperatures, compared to meat solutions. Storage of cells for 72h resulted in higher levels of cell death on cells attached to meat surfaces. The improved survival of cells in solutions was considered to be related to adaptation to osmotic stress as a result of exposure to a previous hyperosmotic shock and the ability of the cells to produce cold shock proteins. Pathogen cell growth at low temperatures is discussed in relation to the presence of low levels of NaCl. Finally the data is discussed in relation to pathogen survival on beef carcass surfaces during refrigeration.
Asunto(s)
Contaminación de Alimentos/análisis , Carne/microbiología , Salmonella typhimurium/fisiología , Temperatura , Agua/metabolismo , Animales , Adhesión Bacteriana , Recuento de Colonia Microbiana , Medios de Cultivo , Microbiología de Alimentos , Cinética , Concentración Osmolar , Salmonella typhimurium/crecimiento & desarrollo , Factores de TiempoRESUMEN
Commercially slaughtered and dressed beef carcass sides (n=30) were followed through a standard commercial chill unit fitted with a new "Jasca" air humidification system adjusted to provide intermittent water spraying of carcass sides (spray cycle 2 min on, 1 min off) for 15 h. Immediately after dressing, and after 24h in the chill unit, the surface water activity, and the weight of each side was measured, and 5 cm2 samples were recovered from four locations, i.e. rump, flank, brisket and neck on the surface of each side. These samples, and similar samples from control sides (n=30) processed in a standard commercial chill unit, were subjected to microbiological examination by direct and resuscitation counts on plate count agar (PCA), MacConkey agar (MAC) and violet red bile glucose agar (VRBGA). No significant differences were observed between bacterial numbers on test and control samples on each of the above agars, at each sample point/occasion. Comparison of direct and resuscitation counts suggested the presence of substantial numbers of injured cells, at both stages (pre- and post-chill), on test and control sides. After 24 h in chill units, test sides exhibited an average weight loss of 1.36% (+/-0.36%), which is significantly less (P<0.001) than the average weight loss (1.55%+/-0.24%) from control sides. These results suggest that the Jasca spray-chilling system can limit carcass shrinkage (on average by 0.19%) without significantly increasing the surface populations of selected bacterial groups.
Asunto(s)
Mataderos/normas , Bacterias/crecimiento & desarrollo , Bovinos/microbiología , Manipulación de Alimentos/métodos , Industria de Procesamiento de Alimentos/métodos , Agua/metabolismo , Animales , Frío , Recuento de Colonia Microbiana , Seguridad de Productos para el Consumidor , Microbiología de Alimentos , Industria de Procesamiento de Alimentos/instrumentación , Industria de Procesamiento de Alimentos/normas , Factores de Tiempo , Pérdida de PesoRESUMEN
A survey of the prevalence of Salmonella species infection was conducted on 59 Irish farrow-to-finish pig herds. Faecal samples were collected from the pens of first-stage weaners (growing pigs approximately three to 10 weeks of age), second-stage weaners (approximately 10 to 17 weeks of age) and fatteners, and from the dry sow and farrowing sow houses. The prevalence of infection was estimated to within 5 per cent with a 95 per cent confidence interval. Thirty of the 59 herds were infected, 12 with Salmonella Typhimurium only, eight with Salmonella Derby only and seven with both S Typhimurium and S Derby; serotypes London, Livingstone and Infantis were each isolated from a single herd. Farms in Ireland are assigned to one of three infection categories on the basis of the antibody levels in samples of meat juice taken at slaughter. When a herd was classified as either positive or negative on the basis of the isolation of Salmonella from at least one faecal sample there was no association between the herd's category as determined by meat juice serology and the probability of the isolation of Salmonella from the faecal samples. However, there were differences in prevalence between pigs at different stages of production in herds of different categories. Farrowing sow houses in moderately infected (category 2) herds had significantly lower infection rates (P < or = 0.05) than other herd categories and other stages of production. Pigs from first-stage weaner pens in slightly infected (category 1) herds were more likely to be infected with Salmonella than pigs at any other stage of production or category of herd.