RESUMEN
The development of biodegradable packaging is a challenge, as conventional plastics have many advantages in terms of high flexibility, transparency, low cost, strong mechanical characteristics, and high resistance to heat compared with most biodegradable plastics. The quality of biodegradable materials and the research needed for their improvement for meat packaging were critically evaluated in this study. In terms of sustainability, biodegradable packagings are more sustainable than conventional plastics; however, most of them contain unsustainable chemical additives. Cellulose showed a high potential for meat preservation due to high moisture control. Polyhydroxyalkanoates and polylactic acid (PLA) are renewable materials that have been recently introduced to the market, but their application in meat products is still limited. To be classified as an edible film, the mechanical properties and acceptable control over gas and moisture exchange need to be improved. PLA and cellulose-based films possess the advantage of protection against oxygen and water permeation; however, the addition of functional substances plays an important role in their effects on the foods. Furthermore, the use of packaging materials is increasing due to consumer demand for natural high-quality food packaging that serves functions such as extended shelf-life and contamination protection. To support the importance moving toward biodegradable packaging for meat, this review presented novel perspectives regarding ecological impacts, commercial status, and consumer perspectives. Those aspects are then evaluated with the specific consideration of regulations and perspective in the European Union (EU) for employing renewable and ecological meat packaging materials. This review also helps to highlight the situation regarding biodegradable food packaging for meat in the EU specifically.
Asunto(s)
Embalaje de Alimentos , Poliésteres , Unión Europea , Poliésteres/química , Carne , Celulosa , PlásticosRESUMEN
In the present investigation, the cape gooseberry (Physalis peruviana L.) was preserved by the application of osmotic dehydration (sugar solution) with ultrasonication. The experiments were planned based on central composite circumscribed design with four independent variables and four dependent variables, which yielded 30 experimental runs. The four independent variables used were ultrasonication power (XP) with a range of 100-500 W, immersion time (XT) in the range of 30-55 min, solvent concentration (XC) of 45-65 % and solid to solvent ratio (XS) with range 1:6-1:14 w/w. The effect of these process parameters on the responses weight loss (YW), solid gain (YS), change in color (YC) and water activity (YA) of ultrasound assisted osmotic dehydration (UOD) cape gooseberry was studied by using response surface methodology (RSM) and adaptive neuro-fuzzy inference system (ANFIS). The second order polynomial equation successfully modeled the data with an average coefficient of determination (R2) was found to be 0.964 for RSM. While for the ANFIS modeling, Gaussian type membership function (MF) and linear type MF was used for the input and output, respectively. The ANFIS model formed after 500 epochs and trained by hybrid model was found to have average R2 value of 0.998. On comparing the R2 value the ANFIS model found to be superior over RSM in predicting the responses of the UOD cape gooseberry process. So, the ANFIS was integrated with a genetic algorithm (GA) for optimization with the aim of maximum YW and minimum YS, YC and YA. Depending on the higher fitness value of 3.4, the integrated ANFIS-GA picked the ideal combination of independent variables and was found to be XP of 282.434 W, XT of 50.280 min, XC of 55.836 % and XS of 9.250 w/w. The predicted and experimental values of response at optimum condition predicted by integrated ANN-GA were in close agreement, which was evident by the relative deviation less than 7%.
RESUMEN
In the present research study, the impact of digestion process on the levels of total phenols, flavonoids, vitamin C as well as anti-oxidant activity in freeze dried powders of mustard greens (MG) and roselle leaves (RL) was investigated. In addition, physicochemical and functional properties of MG and RL samples also evaluated. The digestion of freeze-dried vegetable powders was achieved through in vitro digestive procedure using various enzymes. From the study, it was observed that the digestion process increased the availability of phenols in both powders, where the digested vegetable powders possessed higher levels of total phenols and flavonoids. In contrast, the levels of vitamin C and anti-oxidant activity of vegetable powders (MG & RL) was found to be decreased minimally. Our research study suggests that in vitro digestion could enhance the TPC and TFC in mustard greens and roselle leaves. Therefore, MG and RL can be considered as a functional ingredient in the development of new products with better nutritional and functional characteristics. Further, the data on the physicochemical, functional and bioactive compounds in MG and RL may be used as reference for the enhancement of quality of products developed from MG and RL.
RESUMEN
The effect of gastro intestinal digestion on total phenolic contents (TPC), total flavonoid contents (TFC), radical scavenging activity (RSA) and vitamin C levels of apple (Malus domestica) pomace and a local variety of jujube (Ziziphus mauritiana) pomace was evaluated after drying at 110 °C for 3 h in a hot air oven. The physicochemical properties and functional properties of apple and jujube pomaces were also assessed. Prior to digestion, apple pomace displayed greater levels of TPC, RSA and vitamin C (17.30 ± 0.59 GAE/g DW, 81.16 ± 3.27%, 0.078 ± 0.01 g/L, respectively) in comparison with jujube pomace (16.90 ± 0.66 GAE/g DW, 54.65 ± 2.09%, 0.069 ± 0.01 g/L, respectively), whereas, TFC level was found to be higher in jujube pomace (19.22 ± 0.87 QE/g DW). After digestion, both samples showed an increase in TPC (56.17 ± 2.14 and 52.01 ± 2.18 GAE/g DW for apple and jujube pomaces) and TFC levels (48.45 ± 1.87 and 53.82 ± 2.34 QE/g DW for apple and jujube pomaces) and it was perceived almost 3 to 4 times higher than the TPC and TFC of the samples before digestion. But, RSA of the fruit pomaces were found to be affected by the in vitro digestion which was observed as 54.65 ± 2.09 and 81.16 ± 3.27% respectively for apple and jujube pomaces. It may be suggested that the fruit powders may be incorporated in developing new functional foods rich in bio active compounds and thus can be utilized in different food applications.