Evaluation of Processing Conditions and Hydrocolloid Addition on Functional Properties of Aquafaba.

Aquafaba, the cooking water from chickpeas, could replace animal-derived ingredients such as egg whites in systems that require the stabilization of an oil or gas phase. However, little is known about how processing methods and additives affect its functional properties. In this study, aquafaba was prepared via boiling or pressure-cooking at water-to-seed (WSR) ratios of 5:1, 4:1 and 3:1. The effects of preparation method and pH adjustment on viscosity, protein content, solubility and profile were evaluated. Samples were further analyzed for foaming capacity/stability (FC/FS) and emulsifying activity/stability index (EAI/ESI). Foams were also prepared in combination with xanthan gum or hydroxypropyl methylcellulose (HPMC). Solubility was lowest near pH 4 and not affected by cooking method and protein profile was not affected by method or ratio. Samples with pH 3 had high EAI and FS, but low ESI and FC. WSR did not significantly affect interfacial properties. Xanthan gum had a greater effect than HPMC on viscosity and prevented foam liquid drainage for 24 h. While the preparation method affects aquafaba properties, subsequent pH adjustment is of greater relevance for interfacial properties. Foam volumes can be maximized and foam drainage limited by appropriate choice of hydrocolloids and addition levels.

Physicochemical and Nutritional Characterization of Bran-Enriched Products.

The incorporation of cereal bran or bran constituents can improve the nutritional profile of products and serve as a means to utilize milling by-products that otherwise may only go towards feed [...].

Recent Progress on Improving the Quality of Bran-Enriched Extruded Snacks.

The incorporation of milling by-products, in particular bran, into starch-based extruded snacks allows manufacturers to address two consumer demands at once, i.e., those for goods that are more sustainably produced and of higher nutritional value. However, the higher fiber content in bran than in refined cereal flours poses a limit to the amount that can be included without compromising the quality of extruded snacks, which crucially depends on expansion. Thus, several studies have focused on the effect of bran on the physicochemical characteristics of extruded snacks, leading to the need to review the recent findings in this area. Opportunities, challenges, and potential solutions of bran-enriched snacks are addressed, and several current knowledge gaps are highlighted. Specifically, the first part of the review presents the effects of extrusion cooking on bran's compositional aspects, focusing on structural changes and product quality. After summarizing the main quality traits of extruded snacks (e.g., expansion rate, bulk density, and textural attributes), the effects of bran enrichment on the physical and sensory characteristics of the final product are discussed. Finally, bran pre-treatments as well as processing optimization are discussed as approaches to improve the quality of bran-enriched snacks.

Effect of Bran Pre-Treatment with Endoxylanase on the Characteristics of Intermediate Wheatgrass (Thinopyrum intermedium) Bread.

Previous work indicated that bran removal promotes network formation in breads prepared from intermediate wheatgrass (IWG) flour. However, refinement reduces yields as well as contents of nutritionally beneficial compounds such as fiber. This study evaluated xylanase pretreatment of IWG bran as a processing option to enhance the properties of bread made with half of the original bran content. Xylanase pretreatment did not affect stickiness but significantly reduced hardness and increased specific loaf volumes compared to negative (without xylanase) and positive controls (with xylanase but without pretreatment). However, the surface of breads with pretreated bran was uneven due to structural collapse during baking. Fewer but larger gas cells were present due to pretreatment. Addition of ascorbic acid modulated these effects, but did not prevent uneven surfaces. Accessible thiol concentrations were slightly but significantly increased by xylanase pretreatment, possibly due to a less compact crumb structure. Endogenous xylanases (apparent activity 0.46 and 5.81 XU/g in flour and bran, respectively) may have been activated during the pretreatment. Moreover, Triticum aestivum xylanase inhibitor activity was also detected (193 and 410 InU/g in flour and bran). Overall, xylanase pretreatment facilitates incorporation of IWG bran into breads, but more research is needed to improve bread appearance.

A review on mechanistic aspects of individual versus combined uses of enzymes as clean label-friendly dough conditioners in breads.

Numerous dough improvers are used alone or in combination to enhance the quality of baked goods such as breads. While modern consumers demand consistent quality, the expectations for ingredients have changed over the past few years, and reformulations have taken place to provide "clean label" options. However, the effects and mechanisms of blended dough conditioners suitable for such baked products have not been systematically summarized. In this review, dough and bread properties as affected by different improver combinations are examined, with a focus on additive or synergistic interactions between enzymes or between enzymes and ascorbic acid. The combination of enzymes that hydrolyze starch and cell wall polysaccharides has been shown to reduce textural hardness in fresh and stored bakes goods such as breads. Enzymes that hydrolyze arabinoxylans, the main nonstarch polysaccharide in wheat, have synergistic effects with enzymes that result in cross-linking of wheat flour biopolymers. In some studies, the effects of bread improvers varied for wheat flours of different strength. Overall, bread products in which wheat is used in whole grain form or in a blend with other flours especially benefit from multiple improvers that target different flour constituents in doughs.

Capitalizing on a double crop: Recent advances in proso millet's transition to a food crop.

Across the globe, strategies to adapt food production to a changing climate as well as to unforeseen events (such as a pandemic) are needed, for example, if farmers miss planting times due to abnormal weather patterns or harvests are lost. Such food security considerations represent reasons for why proso millet deserves a more prominent place at the table. It has one of the shortest growing seasons and water requirements among cereals and is already grown in rotation with other crops, for example, in the American Midwest. Yet, most consumers in the Western world are unfamiliar with it, which limits its market potential. Introducing proso millet to consumers requires development of products with acceptable textural and sensory attributes as well as convincing selling points. These can be found in its nutritional profile, as it is a gluten-free "ancient" grain and millet-based products frequently have low glycemic indices. This review presents a synthesis of recent studies that utilized processing strategies to advance proso millet functionality. Results are put into the context of the most frequently addressed compositional and functional attributes, organized in clusters. Diversity across varieties in amylose to amylopectin ratios presents an opportunity to utilize proso millet for foods with specific pasting requirements, as in bread versus pasta. Hydrothermal or pressure treatments may further adapt its functionality for baked goods. Bitterness remains an unsolved issue, even when decorticated material is used. In addition, heating dramatically lowers in vitro protein digestibility, whereas starch digestibility appears to be matrix dependent (more than raw material dependent).

Changes in protein structural characteristics upon processing of gluten-free millet pasta.

Proso millet exhibits favorable agronomic and nutritional properties but is currently under-utilized in the northern hemisphere. This study compared processing-induced changes in protein characteristics of commercial pasta to fresh gluten-free pasta from proso millet varieties differing in prolamin profile. Protein solubility, accessible thiols and secondary structures were measured in dough, sheeted and cooked pasta. Relationships between protein conformation and characteristics related to pasta quality were determined. Cooking significantly lowered protein solubility and induced exposure of thiol groups as well as a shift in secondary structure distribution, while sheeting only had a minor effect. Random structures positively and significantly (P < 0.05) correlated with solubility, cooking loss and protein digestibility. In contrast, ß-sheets, the main secondary structure in cooked pasta, negatively correlated with these properties. The utilization of proso millet in gluten-free pasta is promising, however, processing optimization to elicit targeted protein modifications to balance quality and nutritional attributes requires further investigation.

Tempering Improves Flour Properties of Refined Intermediate Wheatgrass (Thinopyrum intermedium).

Progress in breeding of intermediate wheatgrass (Thinopyrum intermedium), a perennial grain with environmental benefits, has enabled bran removal. Thus, determination of optimum milling conditions for production of refined flours is warranted. This study explored the effect of tempering conditions on intermediate wheatgrass flour properties, namely composition, color, solvent retention capacity, starch damage, and polyphenol oxidase activity. Changes in flour attributes were evaluated via a 3 × 3 × 2 factorial design, with factors targeting moisture (comparing un-tempered controls to samples of 12% and 14% target moisture), time (4, 8, and 24 h), and temperature (30 and 45 °C). All investigated parameters were significantly affected by target moisture; however, samples tempered to 12% moisture showed few differences to those tempered to 14%. Similarly, neither tempering time nor temperature exerted pronounced effects on most flour properties, indicating water uptake was fast and not dependent on temperature within the investigated range. Lactic acid retention capacity significantly correlated with ash (r = -0.739, p < 0.01), insoluble dietary fiber (r = -0.746, p < 0.01), polyphenol oxidase activity (r = -0.710, p < 0.01), starch content (r = 0.841, p < 0.01), and starch damage (r = 0.842, p < 0.01), but not with protein (r = 0.357, p > 0.05). In general, tempering resulted in flour with less bran contamination but only minor losses in protein.

Perennial Grain and Oilseed Crops.

Historically, agroecosystems have been designed to produce food. Modern societies now demand more from food systems-not only food, fuel, and fiber, but also a variety of ecosystem services. And although today's farming practices are producing unprecedented yields, they are also contributing to ecosystem problems such as soil erosion, greenhouse gas emissions, and water pollution. This review highlights the potential benefits of perennial grains and oilseeds and discusses recent progress in their development. Because of perennials' extended growing season and deep root systems, they may require less fertilizer, help prevent runoff, and be more drought tolerant than annuals. Their production is expected to reduce tillage, which could positively affect biodiversity. End-use possibilities involve food, feed, fuel, and nonfood bioproducts. Fostering multidisciplinary collaborations will be essential for the successful integration of perennials into commercial cropping and food-processing systems.

Characterization of diferuloylated pectic polysaccharides from quinoa (Chenopodium quinoa WILLD.).

In plants belonging to the order of Caryophyllales, pectic neutral side chains can be substituted with ferulic acid. The ability of ferulic acid to form intra- and/or intermolecular polysaccharide cross-links by dimerization was shown by the isolation and characterization of diferulic acid oligosaccharides from monocotyledonous plants. In this study, two diferulic acid oligosaccharides were isolated from the enzymatic hydrolyzate of seeds of the dicotyledonous pseudocereal quinoa by gel permeation chromatography and preparative HPLC and unambiguously identified by LC-MS(2) and 1D/2D NMR spectroscopy. The isolated oligosaccharides are comprised of 5-5- and 8-O-4-diferulic acid linked to the O2-position of the nonreducing residue of two (1→5)-linked arabinobioses. To get insight into the structure and the degree of phenolic acid substitution of the diferuloylated polysaccharides, polymeric sugar composition, glycosidic linkages, and polysaccharide-bound monomeric phenolic acids and diferulic acids were analyzed. This study demonstrates that diferulic acids are involved into intramolecular and/or intermolecular cross-linking of arabinan chains and may have a major impact on cell wall architecture of quinoa and other dicotyledonous plants of the order of Caryophyllales.

Isolation and characterization of feruloylated arabinoxylan oligosaccharides from the perennial cereal grain intermediate wheat grass (Thinopyrum intermedium).

In comparison to the annual grain crops dominating current agricultural production, perennial grain species require fewer chemical and energy inputs and improve soil health and erosion control. The possibility for producing sustainable grain harvests from marginal land areas is motivating research initiatives to integrate perennial grains into commercial cropping and food processing systems. In this study, the feruloylated arabinoxylans from intermediate wheat grass (Thinopyrum intermedium, IWG), a promising perennial grain candidate in agronomic screening studies, were investigated. Insoluble fiber isolated from IWG whole grain flour was subjected to either mildly acidic (50 mM TFA, 100 °C, 2 h) or enzymatic (Driselase) hydrolysis. The liberated feruloylated arabinoxylan oligosaccharides were concentrated with Amberlite XAD-2, separated with gel chromatography (Sephadex LH-20, water), and purified with reversed-phase HPLC (C18, water-MeOH gradient). Thirteen feruloylated oligosaccharides were isolated (including eight structures described for the first time) and identified by LC-ESI-MS and NMR. Linkage-type analysis via methylation analysis, as well as the monosaccharide and phenolic acid profiles of the IWG insoluble fiber were also determined. IWG feruloylated arabinoxylans have a relatively simple structure with only short feruloylated side chains, a lower backbone substitution rate than annual rye and wheat varieties, and a moderate phenolic acid content.

Neutral Pectin side chains of Amaranth (Amaranthus hypochondriacus) contain long, partially branched Arabinans and short galactans, both with terminal arabinopyranoses.

Amaranth is a pseudocereal of high nutritional value, including a high dietary fiber content. Amaranth dietary fiber was suggested to contain large amounts of neutral rhamnogalacturonan I side chains. In this study, endo-arabinanase and endo-galactanase were used to liberate arabinan and galactan oligosaccharides from amaranth fiber. The liberated oligosaccharides were identified by high-performance anion exchange chromatography with pulsed amperometric detection (HPAEC-PAD) and HPLC-MS(n) using standard compounds, which were isolated from amaranth, sugar beet, potato, and red clover sprouts and characterized by one- and two-dimensional NMR spectroscopy. It was demonstrated that insoluble amaranth arabinans have linear and branched areas, with the O-3 position being the dominant branching point. Minor amounts of branches at position O-2 and double substitution were also found. Amaranth arabinans were also demonstrated to contain terminal α-(1→5)-linked l-arabinopyranose units. In addition, it was evidenced that galactans from amaranth seeds are composed of ß-(1→4)-linked d-galactopyranose units, which can also be terminated with l-arabinopyranose units. In direct comparison to structural elucidation of amaranth fiber by using methylation analysis, the advantage of the enzymatic approach over methylation analysis was demonstrated.

Novel arabinan and galactan oligosaccharides from dicotyledonous plants.

Arabinans and galactans are neutral pectic side chains and an important part of the cell walls of dicotyledonous plants. To get a detailed insight into their fine structure, various oligosaccharides were isolated from quinoa, potato galactan, and sugar beet pulp after enzymatic treatment. LC-MS(2) and one- and two-dimensional NMR spectroscopy were used for unambiguous structural characterization. It was demonstrated that arabinans contain ß-(1→3)-linked arabinobiose as a side chain in quinoa seeds, while potato galactan was comprised of ß-(1→4)-linked galactopyranoses which are interspersed with α-(1→4)-linked arabinopyranoses. Additionally, an oligosaccharide with two adjacent arabinofuranose units O2-substituted with two ferulic acid monomers was characterized. The isolated oligosaccharides gave further insight into the structures of pectic side chains and may have an impact on plant physiology and dietary fiber fermentation.

Antioxidant activity-guided fractionation of blue wheat (UC66049 Triticum aestivum L.).

Antioxidant activity-guided fractionation based on three in vitro antioxidant assays (Folin-Ciocalteu, TEAC, and leucomethylene blue assays) was used to identify major antioxidants in blue wheat (UC66049 Triticum aestivum L.). After consecutive extractions with solvents of various polarities and multiple chromatographic fractionations, several potent antioxidants were identified by NMR spectroscopy and mass spectrometry. Anthocyanins (delphinidin-3-glucoside, delphinidin-3-rutinoside, cyanidin-3-glucoside, and cyanidin-3-rutinoside), tryptophan, and a novel phenolic trisaccharide (ß-D-glucopyranosyl-(1→6)-ß-D-glucopyranosyl-(1→6)-(4-hydroxy-3-methoxyphenyl)-ß-D-glucopyranoside) were the most active water-extractable constituents. However, anthocyanins were found to be major contributors to the overall blue wheat antioxidant activity only when the extraction steps were performed under acidic conditions. Alkylresorcinols were among the most active antioxidants extractable with 80% ethanol in the TEAC assay. However, this may be due to a color change instead of a bleaching of the ABTS radical. Ferulic acid was found to be the major antioxidant in alkaline cell-wall hydrolysates. The contents of the most active antioxidants were determined.

Studying non-covalent enzyme carbohydrate interactions by STD NMR.

Saturation transfer difference NMR spectroscopy is used to study non-covalent interactions between four different glycostructure transforming enzymes and selected substrates and products. Resulting binding patterns represent a molecular basis of specific binding between ligands and biocatalysts. Substrate and product binding to Aspergillus fumigatus glycosidase and to Candida tenuis xylose reductase are determined under binding-only conditions. Measurement of STD effects in substrates and products over the course of enzymatic conversion provides additional information about ligand binding during reaction. Influences of co-substrates and co-enzymes in substrate binding are determined for Schizophyllum commune trehalose phosphorylase and C. tenuis xylose reductase, respectively. Differences between ligand binding to wild type enzyme and a corresponding mutant enzyme are shown for Corynebacterium callunae starch phosphorylase and its His-334-->Gly mutant. The resulting binding patterns are discussed with respect to the possibility that ligands do not only bind in the productive mode.