High Risk ECMO Cannula to Circuit Connection.

ABSTRACT: A patient with a percutaneously inserted cardiopulmonary bypass cannula into the right internal jugular vein, connected to an extracorporeal membrane oxygenation (ECMO) circuit using tape, was referred for transport to our ECMO center. We describe management, quality improvement, and lessons learned.

Designing an experimental method for assessing biocompatibility of circuit coatings using biomarkers for platelet activation during cardiopulmonary bypass.

INTRODUCTION: Cardiopulmonary bypass is an essential component of cardiothoracic surgeries. However, significant complications such as systemic inflammatory response syndrome (SIRS) resulting from cardiopulmonary bypass (CPB) are a common occurrence due to contact between circulating blood and foreign surfaces that leads to platelet activation. It is suggested that different available CPB circuit coatings can potentially reduce platelet activation. However, there have been no published evidence-based reports confirming these claims. In addition, there is no well-established protocol for studying platelet activation biomarkers during CPB in vitro in a laboratory setting. METHODS: CPB was simulated in the laboratory using bovine blood in two different types of coated CPB circuits: Trillium® Biosurface by Medtronic, and XcoatingTM Surface by Terumo. Fresh bovine blood samples were collected and circulated through the CPB circuit following the standard protocol used in the operation rooms. Blood samples were then collected at 5 min, 30 min, and 55 min during the circulation. Blood plasmas were separated and subjected to enzyme-linked immunosorbent assay to measure most established platelet activation markers P-selectin, Platelet Factor 4 (PF4), Glycoprotein IIb/IIIa (GPIIb/IIIa), and ß-thromboglobulin (ß-TG) at different time points. RESULTS: The biomarker values at 30 min and 55 min were compared to the base values at 5 min for each type of CPB circuit. The results of the means from all measured biomarkers showed data measurements that indicated no significant variability within each coating. All collected data points fell within ±2 SD of the means, which was considered acceptable variations across technical replicates.  Conclusion: In this study, we were able to establish an in vitro protocol in the laboratory setting that is precise and reliable with minimum intra-variability. This established protocol will allow for future studies in which different coated CPB circuits can be compared for their effectiveness in blocking platelet activation during the CPB.

Perfusion Measures and Outcomes (PERForm) registry: First annual report.

BACKGROUND: The Perfusion Measures and Outcomes (PERForm) registry was established in 2010 to advance cardiopulmonary bypass (CPB) practices and outcomes. The registry is maintained through the Michigan Society of Thoracic and Cardiovascular Surgeons Quality Collaborative and is the official registry of the American Society of Extracorporeal Technology. METHODS: This first annual PERForm registry report summarizes patient characteristics as well as CPB-related practice patterns in adult (≥18 years of age) patients between 2019 and 2022 from 42 participating hospitals. Data from PERForm are probabilistically matched to institutional surgical registry data. Trends in myocardial protection, glucose, anticoagulation, temperature, anemia (hematocrit), and fluid management are summarized. Additionally, trends in equipment (hardware/disposables) utilization and employed patient safety practices are reported. RESULTS: A total of 40,777 adult patients undergoing CPB were matched to institutional surgical registry data from 42 hospitals. Among these patients, 54.9% underwent a CABG procedure, 71.6% were male, and the median (IQR) age was 66.0 [58.0, 73.0] years. Overall, 33.1% of the CPB procedures utilized a roller pump for the arterial pump device, and a perfusion checklist was employed 99.6% of the time. The use of conventional ultrafiltration decreased over the study period (2019 vs. 2022; 27.1% vs. 24.9%) while the median (IQR) last hematocrit on CPB has remained stable [27.0 (24.0, 30.0) vs. 27.0 (24.0, 30.0)]. Pump sucker termination before protamine administration increased over the study period: (54.8% vs. 75.9%). CONCLUSION: Few robust clinical registries exist to collect data regarding the practice of CPB. Although data submitted to the PERForm registry demonstrate overall compliance with published perfusion evidence-based guidelines, noted opportunities to advance patient safety and outcomes remain.

Effect of Nitric Oxide via Cardiopulmonary Bypass on Ventilator-Free Days in Young Children Undergoing Congenital Heart Disease Surgery: The NITRIC Randomized Clinical Trial.

Importance: In children undergoing heart surgery, nitric oxide administered into the gas flow of the cardiopulmonary bypass oxygenator may reduce postoperative low cardiac output syndrome, leading to improved recovery and shorter duration of respiratory support. It remains uncertain whether nitric oxide administered into the cardiopulmonary bypass oxygenator improves ventilator-free days (days alive and free from mechanical ventilation). Objective: To determine the effect of nitric oxide applied into the cardiopulmonary bypass oxygenator vs standard care on ventilator-free days in children undergoing surgery for congenital heart disease. Design, Setting, and Participants: Double-blind, multicenter, randomized clinical trial in 6 pediatric cardiac surgical centers in Australia, New Zealand, and the Netherlands. A total of 1371 children younger than 2 years undergoing congenital heart surgery were randomized between July 2017 and April 2021, with 28-day follow-up of the last participant completed on May 24, 2021. Interventions: Patients were assigned to receive nitric oxide at 20 ppm delivered into the cardiopulmonary bypass oxygenator (n = 679) or standard care cardiopulmonary bypass without nitric oxide (n = 685). Main Outcomes and Measures: The primary end point was the number of ventilator-free days from commencement of bypass until day 28. There were 4 secondary end points including a composite of low cardiac output syndrome, extracorporeal life support, or death; length of stay in the intensive care unit; length of stay in the hospital; and postoperative troponin levels. Results: Among 1371 patients who were randomized (mean [SD] age, 21.2 [23.5] weeks; 587 girls [42.8%]), 1364 (99.5%) completed the trial. The number of ventilator-free days did not differ significantly between the nitric oxide and standard care groups, with a median of 26.6 days (IQR, 24.4 to 27.4) vs 26.4 days (IQR, 24.0 to 27.2), respectively, for an absolute difference of -0.01 days (95% CI, -0.25 to 0.22; P = .92). A total of 22.5% of the nitric oxide group and 20.9% of the standard care group developed low cardiac output syndrome within 48 hours, needed extracorporeal support within 48 hours, or died by day 28, for an adjusted odds ratio of 1.12 (95% CI, 0.85 to 1.47). Other secondary outcomes were not significantly different between the groups. Conclusions and Relevance: In children younger than 2 years undergoing cardiopulmonary bypass surgery for congenital heart disease, the use of nitric oxide via cardiopulmonary bypass did not significantly affect the number of ventilator-free days. These findings do not support the use of nitric oxide delivered into the cardiopulmonary bypass oxygenator during heart surgery. Trial Registration: anzctr.org.au Identifier: ACTRN12617000821392.

The Efficacy of Resin Hemoperfusion Cartridge on Inflammatory Responses during Adult Cardiopulmonary Bypass.

AIM: This study aimed to evaluate the efficacy of the resin hemoperfusion device (HA380 hemoperfusion cartridge) on inflammatory responses during adult cardiopulmonary bypass (CPB). METHODS: Sixty patients undergoing surgical valve replacement were randomized into the HP group (n = 30) with an HA380 hemoperfusion cartridge in the CPB circuit or the control group (n = 30) with the conventional CPB circuit. The results of routine blood tests, blood biochemical indexes, and inflammatory factors were analyzed at V0 (pre-CPB), V1 (CPB 30 min), V2 (ICU 0 h), V3 (ICU 6 h), and V4 (ICU 24 h). RESULTS: The HP group had significantly lower levels of IL-6, IL-8, and IL-10. Significant estimation of group differences in the generalized estimating equation (GEE) models was also observed in IL-6 and IL-10. The HP group had significantly lower levels of creatinine (Cr), aminotransferase (AST), and total bilirubin (TBil) compared to the control group. The estimation of differences of Cr, AST, and TBil all reached statistical significance in GEE results. The HP group had significantly less vasopressor requirement and shorter mechanical ventilation time and ICU stay time as compared to the control group. CONCLUSION: The HA380 hemoperfusion cartridge could effectively reduce the systemic inflammatory responses and improve postoperative recovery of patients during adult CPB.

Device-Induced Hemostatic Disorders in Mechanically Assisted Circulation.

Mechanically assisted circulation (MAC) sustains the blood circulation in the body of a patients undergoing cardiac surgery with cardiopulmonary bypass (CPB) or on ventricular assistance with a ventricular assist device (VAD) or on extracorporeal membrane oxygenation (ECMO) with a pump-oxygenator system. While MAC provides short-term (days to weeks) support and long-term (months to years) for the heart and/or lungs, the blood is inevitably exposed to non-physiological shear stress (NPSS) due to mechanical pumping action and in contact with artificial surfaces. NPSS is well known to cause blood damage and functional alterations of blood cells. In this review, we discussed shear-induced platelet adhesion, platelet aggregation, platelet receptor shedding, and platelet apoptosis, shear-induced acquired von Willebrand syndrome (AVWS), shear-induced hemolysis and microparticle formation during MAC. These alterations are associated with perioperative bleeding and thrombotic events, morbidity and mortality, and quality of life in MCS patients. Understanding the mechanism of shear-induce hemostatic disorders will help us develop low-shear-stress devices and select more effective treatments for better clinical outcomes.

Nitric oxide added to the sweep gas of the oxygenator during cardiopulmonary bypass in infants: A pilot randomized controlled trial.

Our objective was to assess the effect of nitric oxide added to the sweep gas of the oxygenator during cardiopulmonary bypass (CPB) in infants on platelet count, platelet function, clinical outcomes, and safety. A randomized, double-blinded, placebo-controlled clinical trial in infants less than a year of age undergoing cardiac surgery requiring CPB was undertaken. Nitric oxide at a dose of 20 ppm was added to the sweep gas in the treatment group. Blood was collected at baseline and prior to separation from CPB to measure platelet count and function as determined by responsiveness to specific agonists. Clinical outcomes were observed through hospital discharge. Methemoglobin levels were measured preoperatively, at the conclusion of CPB, and upon admission to the ICU. Forty patients consented and were randomized in the trial. Eighteen patients were randomized to the treatment group and 22 were included in the placebo group. The groups were similar in terms of age, weight, gender, and surgical complexity. No significant differences were found in measures of platelet count, platelet response to agonist, or clinical outcomes. Patients in the treatment group had higher methemoglobin levels after receiving nitric oxide, but no levels approached toxicity (maximum 2.4%). Nitric oxide added to the sweep gas of the oxygenator during CPB in infants did not have an appreciable effect on the preservation of platelet count, platelet responsiveness to agonist, or clinical outcomes. Methemoglobin levels were increased after receiving nitric oxide but were far below a toxic level of 15%.

Development and accuracy evaluation of a degree of occlusion visualization system for roller pumps used in cardiopulmonary bypass.

In roller pumps used for cardiopulmonary bypass (CPB), the degree of blockage within the tube resulting from compression of the tube by the rollers, or the degree of occlusion, is closely related to hemolysis, with both tight occlusive and non-occlusive degrees promoting hemolysis. There are as yet no international standards regarding methods of adjusting occlusiveness, and the amount of mechanical stress exerted upon blood remains unknown. To prevent hemolysis during CPB using roller pumps, there is a need to clarify and quantitatively assess the mechanical stress of the occlusiveness of the roller pump. In this study, we have developed a degree of occlusion quantification system which constructs the flow channel shape within an occluded tube from red optical density images, and we have verified the validity of this system. Utilizing a linear actuator, an acrylic roller and raceway, a solution colored with simulated blood powder, and a 3/8-inch vinyl chloride tube, this system uses a camera to capture red optical density images within an occluded tube and constructs the tube flow channel shape using a formula manipulation system. To verify the accuracy of this system, we compared the thickness of a cross-section of the flow channel constructed with the degree of occlusion quantification system with the thickness of a cross-section of silicone cured under the same occlusion conditions. Our experiments indicated that for areas with a small tube gap, this system can construct highly accurate three-dimensional shapes and obtain quantitative indicators assessing the degree of occlusion.

Development of a real-time blood damage monitoring device for cardiopulmonary bypass system using near-infrared spectroscopy.

The optical properties of hemoglobin could indicate the degree of hemolysis. We aimed to utilize this to develop a real-time blood damage monitoring device for cardiopulmonary bypass (CPB) systems. The real-time blood damage monitoring device comprised a near-infrared spectroscopy optical module with a fiber spectrometer and monitoring platform and computer software developed using LabVIEW 2017. The fiber spectrometer operated at wavelengths of 545, 660, and 940 nm and contained a detector fiber bundle (source-detector distance = 1.0-2.5 cm). CPB operation was simulated using an artificial heart-lung machine with a flow rate of 3, 4, or 5 L/min. Four hundred milliliter of anticoagulated porcine blood was continuously rotated for 4 h. The transmittance, reflectivity, and absorbance of the blood were measured using the optical device at a frequency of 25 Hz and then digitally averaged into 1-s interval. Samples of damaged blood were collected at regular intervals for in vitro hemolysis tests to calculate the normalized index of hemolysis (NIH). All experiments were repeated three times. We prepared 28 blood bags containing 400 ml of anticoagulant. Paired t test was used to examine the test-retest reliability of the differences between the three methods and control samples. Statistical tests revealed significant differences in the mean values between the test and control groups over time (P < 0.01). Relationship was established between the real-time monitoring results and the NIH values. An effective blood damage detection method that combined in vitro hemolysis tests and near-infrared spectroscopy was achieved. The results demonstrate the clinical potential of a real-time, low-cost, and reliable blood damage monitoring device to improve the safety of CPB operation.

The impact of roller pump-assisted cardiotomy suction unit on hemolysis.

Hemolysis in cardiac surgery is often related to the contact of blood with air or artificial surfaces. Variations of negative pressure in the suction cannulas may represent an additional factor. Limited data exist on the contribution of a roller pump-assisted (RPA) cardiotomy suction unit to hemolysis. Elevation of free hemoglobin (fHb) following air suction (AS) or suction tip occlusion (STO) events of a pump-assisted cardiotomy suction unit was investigated in a mock circuit filled with blood from slaughtered domestic pigs. AS-associated hemolysis was measured over 240 minutes with 2 minutes of AS occurring every 10 minutes. STO-associated hemolysis was analyzed over 80-minute periods: configuration 1 (c1) comprised a cycle of 20 minutes (min) occlusion and 60 minutes RPA flow (20/60 minutes); c2 comprised 20 cycles of 1/3 minutes; c3 comprised 40 cycles of 0.5/1.5 minutes; and c4 comprised 80 cycles of 0.25/0.75 minutes. The AS setup did not lead to significant hemolysis after 2 (P = .97), 3 (P = .40) or 4 (P = .11) hours. The STO setup showed the greatest hemolysis (ΔfHb of 30 mg/dL) in c1 after 20 minutes. ΔfHb was different in c1 from all other configurations at 20 minutes (P < .0001) and 80 minutes (P < .05). Ex vivo generation of large negative pressures by STO events is the main cause of cardiotomy suction-associated hemolysis. The clinical relevance of this mechanism needs further investigations.

Long-term results of endoclamping in patients undergoing minimally invasive mitral valve surgery where external aortic clamping cannot be used - a propensity matched analysis.

BACKGROUND: Minimally invasive mitral valve surgery is standard of care in many centres and it is commonly associated with the need for cardiopulmonary bypass. Conventional external aortic clamping (exoclamping) is not always feasible, so endoaortic clamping (endoclamping) has evolved as a viable alternative. The aim of this study is to compare endoclamping (Intraclude™, Edwards Lifesciences) with exoclamping (Chitwood) during minimally invasive mitral valve procedures. METHODS: This single-centre study included 822 consecutive patients undergoing minimally invasive mitral valve procedures. The endoclamp was used in 64 patients and the exoclamp in 758. Propensity-score (PS) matching was performed resulting in 63 patients per group. Outcome measures included procedural variables, length of intensive care unit (ICU) and hospital stay, major adverse cardiac and cerebrovascular events (MACCE) and repeat surgery. RESULTS: The mean age was similar in the two group (62.2 [endoclamp] vs. 63.5 [exoclamp] years; p = 0.554), as were the cardiopulmonary bypass (145 vs. 156 min; p = 0.707) and the procedure time (203 vs. 211 min; p = 0.648). The X-clamp time was significantly shorter in the endoclamp group (88 vs. 99 min; p = 0.042). Length of ICU stay (25.0 vs. 23.0 h) and length of hospital stay (10.0 vs. 9.0 days) were slightly longer in the endoclamp group, but without statistical significance. There were nominal but no statistically significant differences between the groups in the rates of stroke, vascular complications, myocardial infarction or repeat mitral valve surgery. The conversion rate to open sternotomy approach was 2.4% without difference between groups. The estimated 7-year survival rate was similar for both groups (89.9% [endoclamp]; 84.0% [exoclamp]) with a hazard ratio of 1.291 (95% CI 0.453-3.680). CONCLUSIONS: Endoaortic clamping is an appropriate and reasonably safe alternative to the conventional Chitwood exoclamp for patients in which the exoclamp cannot be used because the ascending aorta cannot be safely mobilised.

Direct true lumen cannulation in type A acute aortic dissection: A review of an 11 years' experience.

OBJECTIVES: Direct true lumen cannulation (DTLC) of the aorta is an alternative cardiopulmonary bypass cannulation technique in the context of type A acute aortic dissection (A-AAD). DTLC has been reported to be effective in restoring adequate perfusion to jeopardized organs. This study reports and compares operative outcomes with DTLC or alternative cannulation techniques in a large cohort of patients with A-AAD. METHODS: All patients who underwent surgery for A-AAD between January 2006 and January 2017 in Mainz university hospital were reviewed. The choice of cannulation technique was left to the operating surgeon, however DTLC was our preference in patients who were in state of shock or showed signs of tamponade or hypoperfusion, in cases of potential cerebral malperfusion, as well as in patients who were under resuscitation. RESULTS: A total of 528 patients (63% males, mean age 64±13.8 years) underwent emergency surgery for A-AAD. The DTLC technique was used in 52.4% of patients. The DTLC group of patients had worse clinical status at the time of presentation with more shock, tamponade, true lumen collapse, cerebral and other malperfusion states. New neurologic events were diagnosed in around 8% of patients in each group following surgery, but there was a trend for quicker neurological recovery in the DTLC-group. Early mortality rates, short-term and long-term survival rates did not differ between the two groups. CONCLUSIONS: DTLC is a safe cannulation technique that enables effective antegrade true lumen perfusion in complicated A-AAD scenarios, and is an advantageous addition to the aortic surgeons' armamentarium.

Water condensation from gas outlet of oxygenator.

Condensation and water loss from gas output of the cardiopulmonary bypass (CPB) oxygenator has been the study object of several research. However, little is known about the propagation of the condensation formed at the level of oxygenator and how potentially it can contaminate the surrounding environment. We aimed to document the moment of formation of the 'gas steam' derived from the CPB oxygenator during cardiac surgery with thermography imaging. Thermographic camera is a device that creates an image using infrared radiation, similar to a common camera that forms an image using visible light. The brightest (warmest) parts of the image are customarily colored white, the intermediate temperatures reds and yellows, and the dimmest (coolest) parts black. Thermal image captures the condensation phenomenon around the oxygenator perimeter with the same color/temperature code (yellow) of gas outlet. The use of aspiration at the level of the gas outlet could also favor the elimination of the condensation, improve gas exchanges, and potentially reduce the spread of hazardous substances in the operating room.

Cardiopulmonary bypass and internal thoracic artery: Can roller or centrifugal pumps change vascular reactivity of the graft? The IPITA study: A randomized controlled clinical trial.

BACKGROUND: Cardiopulmonary bypass (CPB) induces a systemic inflammatory response (SIRS) and affects the organ vascular bed. Experimentally, the lack of pulsatility alters myogenic tone of resistance arteries and increases the parietal inflammatory response. The purpose of this study was to compare the vascular reactivity of the internal thoracic arteries (ITAs) due to the inflammatory response between patients undergoing coronary artery bypass grafting (CABG) under CPB with a roller pump or with a centrifugal pump. METHODS: Eighty elective male patients undergoing CABG were selected using one or two internal thoracic arteries under CPB with a roller pump (RP group) or centrifugal pump (CFP group). ITA samples were collected before starting CPB (Time 1) and before the last coronary anastomosis during aortic cross clamping (Time 2). The primary endpoint was the endothelium-dependent relaxation of ITAs investigated using wire-myography. The secondary endpoint was the parietal inflammatory response of arteries defined by the measurements of superoxide levels, leukocytes and lymphocytes rate and gene expression of inflammatory proteins using. Terminal complement complex activation (SC5b-9) and neutrophil activation (elastase) analysis were performed on arterial blood at the same times. RESULTS: Exposure time of ITAs to the pump flow was respectively 43.3 minutes in the RP group and 45.7 minutes in the CFP group. Acetylcholine-dependent relaxation was conserved in the two groups whatever the time. Gene expression of C3 and C4a in the artery wall decreased from Time 1 to Time 2. No oxidative stress was observed in the graft. There was no difference between the groups concerning the leukocytes and lymphocytes rate. SC5b-9 and elastase increased between Time 1 and Time 2. CONCLUSION: Endothelium-dependent relaxation of the internal thoracic arteries was preserved during CPB whatever the type of pump used. The inflammatory response observed in the blood was not found in the graft wall within this time frame. TRIAL REGISTRATION: Name of trial study protocol: IPITA Registration number (ClinicalTrials.gov): NCT04168853.

Efficiency of Minimized Circuits of a Heart Roller Pump on Systemic Inflammatory Response Syndrome and Multiorgan Effects in a Rat Model.

BACKGROUND: The aim of this study is to compare the effects of tubing length on systemic inflammatory response syndrome and myocardial protection in a rat model of cardiopulmonary bypass (CPB) from a histological standpoint. METHODS: Twelve adult male Wistar Albino rats weighing >180 g were randomly selected and divided into 2 groups. In 1 group, the pump lines were kept 1 m shorter than standard. The right jugular vein and tail artery were cannulated using a 16-gauge catheter. Animals received 500 IU/kg intravenous heparin. Cardiac index and rectal temperature were set at 2.4 mL and 36°C, respectively. Total line volume was maintained at 8 mL. A roller pump was adjusted to supply a blood flow of 6 to 28 mL/min (mean 10 mL/min), similar to the typical cardiac output of rats. CPB duration was 15 minutes throughout the experiment. After sacrifice, tissue samples were collected from heart, liver, and kidney for histomorphologic examination. RESULTS: All histochemical and histomorphologic analyses, performed by 2 blinded researchers, revealed band loss in cardiomyocytes, mononuclear (MNL) cell infiltration, and impaired fibrillar organization in the standard-line group. Additionally in that group, sinusoidal dilatation in the liver, low-level congestion, focal necrosis, and periportal MNL infiltration were noted. In the shorter-line group, on the other hand, MNL cell infiltration, band loss in myofibrils, and cardiomyocyte degeneration were rarely observed. Higher liver congestion and lower MNL cell infiltration were observed in the shorter-line group. No significant differences were found in kidney samples. CONCLUSION: In a shorter-line roller pump test model, less multiorgan damage and fewer systemic inflammatory responses were observed. It may be applicable to keep CPB lines as close to the table as possible, especially in pediatric cardiac surgery cases.