Water-activated, pH-controlled patch in transdermal administration of timolol. II. Drug absorption and skin irritation.

The feasibility of the water-activated, pH-controlled silicone reservoir devices for transdermal administration was investigated using timolol maleate as a model drug. Timolol patches were applied to the arm of 12 volunteers for 81 h, two patches per subject. Timolol absorption from patches was compared to that from a peroral timolol tablet formulation (Blocanol((R)) 10 mg). Furthermore, in vivo plasma levels of timolol were compared with those predicted by kinetic simulations. Skin irritation induced by timolol patches was assessed by visual scoring and color reflectance measurements. With water-activated, pH-controlled patches both steady-state concentrations of timolol in plasma and its duration could be controlled. However, a considerable, inter-individual variability in the transdermal absorption of timolol was observed. This is due to the high fractional skin control in timolol delivery. Timolol patches were well tolerated by subjects. Skin irritation induced by the combination of timolol with long-term occlusion was mild, and after removal of the patches, skin changes were practically reversed in 24 h. Simulation model was useful in prediction of timolol levels in plasma after transdermal administration.

Controlled ocular timolol delivery: systemic absorption and intraocular pressure effects in humans.

Timolol eyedrops may cause systemic side-effects in glaucoma patients due to absorption of the drug into systemic circulation. In a previous study, timolol concentrations in plasma were reduced if timolol was administered in ocular inserts instead of eyedrops. We compared the intraocular pressure lowering effect and systemic absorption of timolol inserts to those of 0.5% timolol eyedrops in humans. Inserts of silicone tubing released 90.3 +/- 13.9 micrograms of timolol in 24 hours in vivo. Timolol inserts afforded similar decreases in intraocular pressure in open-angle glaucoma patients as did b.i.d. eyedrops, but produced lower peak timolol concentrations in plasma, 0.70 +/- 0.10 ng/ml and 0.24 +/- 0.05 ng/ml, respectively. After eyedrops, peak concentrations were achieved at 15.0 +/- 2.2 min, while application of an insert resulted in a delayed peak (tmax = 623 +/- 195 min). The insert resulted in a higher systemically absorbed fraction of the timolol dose than the eyedrop, but the peak timolol concentration and daily absorbed amount of timolol were decreased. The release rate of timolol from the inserts in vivo was only slightly less than that in vitro. Silicone devices are useful for clinical testing of controlled delivery properties of ocular drugs.