RESUMEN
The anaerobic fermentation of crop straw and animal wastes is increasingly used for the biogas and green energy generation, as well as reduction of the environmental pollution. The anaerobic cofermentation of corn stalks inoculated by cow dung was found to achieve higher biogas production and cellulose biodegradation. In this study, the effect of mixing corn stalks with cow dung at five different fermentation stages (0, 7, 15, 23, and 31 days of the total fermentation cycle of 60 days) on the further cofermentation process was explored, in order to optimize the corn straw utilization rate and biogas production capacity. In addition, the straw microstructure evolution was investigated by the SEM and XRD methods to identify the optimal conditions for the straw biodegradation process enhancement. The five test groups exhibited nearly identical total biogas productivity values but strongly differed by daily biogas yields (the maximal biogas generation rate being 524.3 ml/d). Based on the degradation characteristics of total solids (TS), volatile solids (VS), and lignocellulose, groups #1 and #3 (0 and 15 days) had the most significant degradation rates of VS (43.73%) and TS (42.07%), respectively, while the largest degradation rates of cellulose (62.70%) and hemicellulose (50.49%) were observed in group #4 (23 days) and group #1 (0 days), respectively. The SEM analysis revealed strong microstructural changes in corn stalks after fermentation manifested by multiple cracks and striations, while the XRD results proved the decrease in peak intensity of cellulose ã002ã crystal surface and the reduced crystallinity after cofermentation. The results of this study are assumed to be quite instrumental to the further optimization of the corn stalk anaerobic digestion by inoculation with digested manure for lignocellulose degradation enhancement and biogas productivity improvement.