Polymeric Nanotubes as Drug Delivery Vectors─Comparison of Covalently and Supramolecularly Assembled Constructs.

Rod-shaped nanoparticles have been identified as promising drug delivery candidates. In this report, the in vitro cell uptake and in vivo pharmacokinetic/bio-distribution behavior of molecular bottle-brush (BB) and cyclic peptide self-assembled nanotubes were studied in the size range of 36-41 nm in length. It was found that BB possessed the longest plasma circulation time (t1\2 > 35 h), with the cyclic peptide system displaying an intermediate half-life (14.6 h), although still substantially elevated over a non-assembling linear control (2.7 h). The covalently bound BB underwent substantial distribution into the liver, whereas the cyclic peptide nanotube was able to mostly circumvent organ accumulation, highlighting the advantage of the inherent degradability of the cyclic peptide systems through their reversible aggregation of hydrogen bonding core units.

Lymphatic Uptake of Liposomes after Intraperitoneal Administration Primarily Occurs via the Diaphragmatic Lymphatics and is Dependent on Liposome Surface Properties.

Drugs are commonly administered via the intraperitoneal (IP) route to treat localized infections and cancers in patients and to test drug efficacy and toxicity in preclinical studies. Despite this, there remain large gaps in our understanding of drug absorption routes (lymph vs blood) and pharmacokinetics following IP administration. This is particularly true when drugs are administered in complex delivery systems such as liposomes which are the main marketed formulation for several drugs that are administered intraperitoneally. This study investigated the impact of liposome surface properties (charge and PEGylation) on absorption into lymph and blood, and lymphatic disposition patterns, following IP administration. To achieve this, stable 3H-dipalmitoyl-phosphatidylcholine (DPPC) and 14C-sucrose-radiolabeled liposomes of 100-150 nm diameter with negative, neutral, or positive surface charge, or a PEGylated surface, were prepared and administered intraperitoneally to rats. Radiolabel concentrations were measured in lymph, blood, and lymph nodes (LNs). Lymph was collected from the thoracic lymph duct at either the abdomen (ABD) or the jugular-subclavian junction (JSJ). The lymphatic recovery of the radiolabels was substantially lower after administration in positively charged compared to the neutral, negative, or PEGylated liposomes. Radiolabel recovery was substantially greater (up to 18-fold) in the thoracic lymph collected at the JSJ when compared to that at the ABD, suggesting that liposomes entered the lymphatics at the diaphragm. Consistent with this, the concentration of the liposome labels was substantially higher (up to seven-fold) in mediastinal than in mesenteric LNs. Overall, this study shows how the peritoneal absorption and lymphatic disposition of drugs administered intraperitoneally can be manipulated through a careful selection of the drug delivery system and may thus be optimized to treat localized conditions such as cancers, infections, inflammatory diseases, and acute and critical illness.

Polymeric Precipitation Inhibitors Promote Fenofibrate Supersaturation and Enhance Drug Absorption from a Type IV Lipid-Based Formulation.

The ability of lipid-based formulations (LBFs) to increase the solubilization, and prolong the supersaturation, of poorly water-soluble drugs (PWSDs) in the gastrointestinal (GI) fluids has generated significant interest in the past decade. One mechanism to enhance the utility of LBFs is to prolong supersaturation via the addition of polymers that inhibit drug precipitation (polymeric precipitation inhibitors or PPIs) to the formulation. In this work, we have evaluated the performance of a range of PPIs and have identified PPIs that are sufficiently soluble in LBF to allow the construction of single phase formulations. An in vitro model was first employed to assess drug (fenofibrate) solubilization and supersaturation on LBF dispersion and digestion. An in vitro-in situ model was subsequently employed to simultaneously evaluate the impact of PPI enhanced drug supersaturation on drug absorption in rats. The stabilizing effect of the polymers was polymer specific and most pronounced at higher drug loads. Polymers that were soluble in LBF allowed simple processing as single phase formulations, while formulations containing more hydrophilic polymers required polymer suspension in the formulation. The lipid-soluble polymers Eudragit (EU) RL100 and poly(propylene glycol) bis(2-aminopropyl ether) (PPGAE) and the water-soluble polymer hydroxypropylmethyl cellulose (HPMC) E4M were identified as the most effective PPIs in delaying fenofibrate precipitation in vitro. An in vitro model of lipid digestion was subsequently coupled directly to an in situ single pass intestinal perfusion assay to evaluate the influence of PPIs on fenofibrate absorption from LBFs in vivo. This coupled model allowed for real-time evaluation of the impact of supersaturation stabilization on absorptive drug flux and provided better discrimination between the different PPIs and formulations. In the presence of the in situ absorption sink, increased fenofibrate supersaturation resulted in increased drug exposure, and a good correlation was found between the degree of in vitro supersaturation and in vivo drug exposure. An improved in vitro-in vivo correlation was apparent when comparing the same formulation under different supersaturation conditions. These observations directly exemplify the potential utility of PPIs in promoting drug absorption from LBF, via stabilization of supersaturation, and further confirm that relatively brief periods of supersaturation may be sufficient to promote drug absorption, at least for highly permeable drugs such as fenofibrate.

Reducing Dendrimer Generation and PEG Chain Length Increases Drug Release and Promotes Anticancer Activity of PEGylated Polylysine Dendrimers Conjugated with Doxorubicin via a Cathepsin-Cleavable Peptide Linker.

PEGylation typically improves the systemic exposure and tumor biodistribution of polymeric drug delivery systems, but may also restrict enzyme access to peptide-based drug linkers. The impact of dendrimer generation (G4 vs G5) and PEG length (570 vs 1100 Da) on the pharmacokinetics, tumor biodistribution, drug release kinetics, and anticancer activity of a series of PEGylated polylysine dendrimers conjugated with doxorubicin via a cathepsin-B cleavable valine-citrulline linker was therefore investigated in rodents. Although the smallest G4 PEG570 dendrimer showed the most efficient cathepsin-mediated doxorubicin release, systemic exposure and tumor uptake were limited. The largest G5 PEG1100 dendrimer showed good tumor uptake and retention but restricted drug liberation and therefore limited anticancer activity. Superior anticancer activity was achieved using an intermediate sized dendrimer that showed better drug release kinetics, systemic exposure, tumor uptake, and retention. The data suggest that balancing PEG molecular weight and dendrimer size is critical when designing chemotherapeutic dendrimers.

An Evaluation of Optimal PEGylation Strategies for Maximizing the Lymphatic Exposure and Antiviral Activity of Interferon after Subcutaneous Administration.

Interferon α2 is an antiviral/antiproliferative protein that is currently used to treat hepatitis C infections and several forms of cancer. Two PEGylated variants of interferon α2 (containing 12 and 40 kDa PEGs) are currently marketed and display longer plasma circulation times than that of unmodified interferon. With increasing realization that the lymphatic system plays an important role in the extrahepatic replication of the hepatitis C virus and in the metastatic dissemination of cancers, this study sought to evaluate PEGylation strategies to optimally enhance the antiviral activity and plasma and lymphatic exposure of interferon after subcutaneous administration in rats. The results showed that conjugation with a linear 20 kDa PEG provided the most ideal balance between activity and plasma and lymph exposure. A linear 5 kDa PEG variant also exhibited excellent plasma and lymph exposure to interferon activity when compared to those of unmodified interferon and the clinically available linear 12 kDa PEGylated construct.

Lymphatic transport and lymph node targeting of methotrexate-conjugated PEGylated dendrimers are enhanced by reducing the length of the drug linker or masking interactions with the injection site.

Drug conjugation to dendrimer-based delivery systems has been shown to enhance delivery to the lymphatic system after subcutaneous administration. Dendrimer interaction with components of the interstitium at the injection site, however, may prevent drainage from the injection site. The current study sought to vary the length of a linker employed to conjugate methotrexate (MTX) to a PEGylated dendrimer, in an attempt to reduce MTX interaction with interstitial binding sites and enhance lymphatic drainage. Dendrimers with shorter linkers resulted in higher lymphatic drainage, presumably via shielding of interaction sites by the PEG mantle, but were not retained in lymph nodes. Improved drainage of dendrimers with longer linkers was achieved through coadministration with dextran to mask interactions at the injection site while maintaining retention within the node. Enhanced drug exposure to the lymph node has the potential to enhance the treatment of lymph-node resident cancer metastases.

Conjugation of 10 kDa Linear PEG onto Trastuzumab Fab' Is Sufficient to Significantly Enhance Lymphatic Exposure while Preserving in Vitro Biological Activity.

The lymphatic system is a major conduit by which many diseases spread and proliferate. There is therefore increasing interest in promoting better lymphatic drug targeting. Further, antibody fragments such as Fabs have several advantages over full length monoclonal antibodies but are subject to rapid plasma clearance, which can limit the lymphatic exposure and activity of Fabs against lymph-resident diseases. This study therefore explored ideal PEGylation strategies to maximize biological activity and lymphatic exposure using trastuzumab Fab' as a model. Specifically, the Fab' was conjugated with single linear 10 or 40 kDa PEG chains at the hinge region. PEGylation led to a 3-4-fold reduction in binding affinity to HER2, but antiproliferative activity against HER2-expressing BT474 cells was preserved. Lymphatic pharmacokinetics were then examined in thoracic lymph duct cannulated rats after intravenous and subcutaneous dosing at 2 mg/kg, and the data were evaluated via population pharmacokinetic modeling. The Fab' displayed limited lymphatic exposure, but conjugation of 10 kDa PEG improved exposure by approximately 11- and 5-fold after intravenous (15% dose collected in thoracic lymph over 30 h) and subcutaneous (9%) administration, respectively. Increasing the molecular weight of the PEG to 40 kDa, however, had no significant impact on lymphatic exposure after intravenous (14%) administration and only doubled lymphatic exposure after subcutaneous administration (18%) when compared to 10 kDa PEG-Fab'. The data therefore suggests that minimal PEGylation has the potential to enhance the exposure and activity of Fab's against lymph-resident diseases, while no significant benefit is achieved with very large PEGs.

A Comparison of the Pharmacokinetics and Pulmonary Lymphatic Exposure of a Generation 4 PEGylated Dendrimer Following Intravenous and Aerosol Administration to Rats and Sheep.

PURPOSE: Cancer metastasis to pulmonary lymph nodes dictates the need to deliver chemotherapeutic and diagnostic agents to the lung and associated lymph nodes. Drug conjugation to dendrimer-based delivery systems has the potential to reduce toxicity, enhance lung retention and promote lymphatic distribution in rats. The current study therefore evaluated the pharmacokinetics and lung lymphatic exposure of a PEGylated dendrimer following inhaled administration. METHODS: Plasma pharmacokinetics and disposition of a 22 kDa PEGylated dendrimer were compared after aerosol administration to rats and sheep. Lung-derived lymph could not be sampled in rats and so lymphatic transport of the dendrimer from the lung was assessed in sheep. RESULTS: Higher plasma concentrations were achieved when dendrimer was administered to the lungs of rats as a liquid instillation when compared to an aerosol. Plasma pharmacokinetics were similar between sheep and rats, although some differences in disposition patterns were evident. Unexpectedly, less than 0.5% of the aerosol dose was recovered in pulmonary lymph. CONCLUSIONS: The data suggest that rats provide a relevant model for assessing the pharmacokinetics of inhaled macromolecules prior to evaluation in larger animals, but that the pulmonary lymphatics are unlikely to play a major role in the absorption of nanocarriers from the lungs.

Addition of 20-kDa PEG to Insulin Lispro Alters Absorption and Decreases Clearance in Animals.

PURPOSE: Determine the pharmacokinetics of insulin peglispro (BIL) in 5/6-nephrectomized rats and study the absorption in lymph duct cannulated (LDC) sheep. METHODS: BIL is insulin lispro modified with 20-kDa linear PEG at lysine B28 increasing the hydrodynamic size to 4-fold larger than insulin lispro. Pharmacokinetics of BIL and insulin lispro after IV administration were compared in 5/6-nephrectomized and sham rats. BIL was administered IV or SC into the interdigital space of the hind leg, and peripheral lymph and/or serum samples were collected from both LDC and non-LDC sheep to determine pharmacokinetics and absorption route of BIL. RESULTS: The clearance of BIL was similar in 5/6-nephrectomized and sham rats, while the clearance of insulin lispro was 3.3-fold slower in 5/6-nephrectomized rats than in the sham rats. In non-LDC sheep, the terminal half-life after SC was about twice as long vs IV suggesting flip-flop pharmacokinetics. In LDC sheep, bioavailability decreased to <2%; most of the dose was absorbed via the lymphatic system, with 88% ± 19% of the dose collected in the lymph after SC administration. CONCLUSION: This work demonstrates that increasing the hydrodynamic size of insulin lispro through PEGylation can impact both absorption and clearance to prolong drug action.

Pluronic-Functionalized Silica-Lipid Hybrid Microparticles: Improving the Oral Delivery of Poorly Water-Soluble Weak Bases.

A Pluronic-functionalized silica-lipid hybrid (Plu-SLH) microparticle system for the oral delivery of poorly water-soluble, weak base drugs is reported for the first time. A highly effective Plu-SLH microparticle system was composed of Labrasol as the lipid phase, Pluronic F127 as the polymeric precipitation inhibitor (PPI), and silica nanoparticles as the solid carrier. For the model drug cinnarizine (CIN), the Plu-SLH delivery system was shown to offer significant biopharmaceutical advantages in comparison with unformulated drug and drug in the silica-lipid hybrid (SLH) system. In vitro two-phase dissolution studies illustrated significantly reduced pH provoked CIN precipitation and an 8- to 14-fold improvement in the extent of dissolution in intestinal conditions. In addition, under simulated intestinal digesting conditions, the Plu-SLH provided approximately three times more drug solubilization than the SLH. Oral administration in rats resulted in superior bioavailability for Plu-SLH microparticles, i.e., 1.6- and 2.1-fold greater than the SLH and the unformulated CIN, respectively. A physical mixture of Pluronic and SLH (Plu&SLH), having the same composition as Plu-SLH, was also evaluated, but showed no significant increase in CIN absorption when compared to unmodified CIN or SLH. This work represents the first study where different methods of incorporating PPI to formulate solid-state lipid-based formulations were compared for the impact on the biopharmaceutical performance. The data suggest that the novel physicochemical properties and structure of the fabricated Plu-SLH microparticle delivery system play an important role in facilitating the synergistic advantage of Labrasol and Pluronic F127 in preventing drug precipitation, and the Plu-SLH provides efficient oral delivery of poorly water-soluble weak bases.

PEGylation does not significantly change the initial intravenous or subcutaneous pharmacokinetics or lymphatic exposure of trastuzumab in rats but increases plasma clearance after subcutaneous administration.

The lymphatic system plays a major role in the metastatic dissemination of cancer and has an integral role in immunity. PEGylation enhances drainage and lymphatic uptake following subcutaneous (sc) administration of proteins and protein-like polymers, but the impact of PEGylation of very large proteins (such as antibodies) on subcutaneous and lymphatic pharmacokinetics is unknown. This study therefore aimed to evaluate the impact of PEGylation on the sc absorption and lymphatic disposition of the anti-HER2 antibody trastuzumab in rats. PEG-trastuzumab was generated via the conjugation of a single 40 kDa PEG-NHS ester to trastuzumab. PEG-trastuzumab showed a 5-fold reduction in HER2 binding affinity, however the in vitro growth inhibitory effects were preserved as a result of changes in cellular trafficking when compared to native trastuzumab. The lymphatic pharmacokinetics of PEG-trastuzumab was evaluated in thoracic lymph duct cannulated rats after iv and sc administration and compared to the pharmacokinetics of native trastuzumab. The iv pharmacokinetics and lymphatic exposure of PEG-trastuzumab was similar when compared to trastuzumab. After sc administration, initial plasma pharmacokinetics and lymphatic exposure were also similar between PEG-trastuzumab and trastuzumab, but the absolute bioavailability of PEG-trastuzumab was 100% when compared to 86.1% bioavailability for trastuzumab. In contrast to trastuzumab, PEG-trastuzumab showed accelerated plasma clearance beginning approximately 7 days after sc, but not iv, administration, presumably as a result of the generation of anti-PEG IgM. This work suggests that PEGylation does not significantly alter the lymphatic disposition of very large proteins, and further suggests that it is unlikely to benefit therapy with monoclonal antibodies.

Methotrexate-conjugated PEGylated dendrimers show differential patterns of deposition and activity in tumor-burdened lymph nodes after intravenous and subcutaneous administration in rats.

The current study sought to explore whether the subcutaneous administration of lymph targeted dendrimers, conjugated with a model chemotherapeutic (methotrexate, MTX), was able to enhance anticancer activity against lymph node metastases. The lymphatic pharmacokinetics and antitumor activity of PEGylated polylysine dendrimers conjugated to MTX [D-MTX(OH)] via a tumor-labile hexapeptide linker was examined in rats and compared to a similar system where MTX was α-carboxyl O-tert-butylated [D-MTX(OtBu)]. The latter has previously been shown to exhibit longer plasma circulation times. D-MTX(OtBu) was well absorbed from the subcutaneous injection site via the lymph, and 3 to 4%/g of the dose was retained by sentinel lymph nodes. In contrast, D-MTX(OH) showed limited absorption from the subcutaneous injection site, but absorption was almost exclusively via the lymph. The retention of D-MTX(OH) by sentinel lymph nodes was also significantly elevated (approximately 30% dose/g). MTX alone was not absorbed into the lymph. All dendrimers displayed lower lymph node targeting after intravenous administration. Despite significant differences in the lymph node retention of D-MTX(OH) and D-MTX(OtBu) after subcutaneous and intravenous administration, the growth of lymph node metastases was similarly inhibited. In contrast, the administration of MTX alone did not significantly reduce lymph node tumor growth. Subcutaneous administration of drug-conjugated dendrimers therefore provides an opportunity to improve drug deposition in downstream tumor-burdened lymph nodes. In this case, however, increased lymph node biodistribution did not correlate well with antitumor activity, possibly suggesting constrained drug release at the site of action.

Molecular weight (hydrodynamic volume) dictates the systemic pharmacokinetics and tumour disposition of PolyPEG star polymers.

Herein we report for the first time the biological fate of poly[(oligoethylene glycol) acrylate] (POEGA) star polymers synthesised via a versatile arm-first reversible addition-fragmentation chain transfer (RAFT) polymerisation approach. The biopharmaceutical behaviour of three different molecular weight (49, 64 and 94kDa) POEGA stars was evaluated in rats and nude mice bearing human MDA MB-231 tumours after intravenous administration. The 94kDa star polymer exhibited a longer plasma exposure time than the 49kDa or 64kDa star polymer; an observation attributable to differences in the rates of both polymer biodegradation and urinary excretion. Tumour biodistribution also correlated with molecular weight and was greatest for the longest circulating 94kDa star. Different patterns of liver and spleen biodistribution were observed between mice and rats for the different sized polymers. The polymers were also well-tolerated in vivo and in vitro at therapeutic concentrations. FROM THE CLINICAL EDITOR: Advances in nanotechnology has enabled scientists to produce nanoparticle as drug carriers in cancer therapeutics. In this article, the authors studied the biological fate of poly[(oligoethylene glycol) acrylate] (POEGA) star polymers of different size, after intravenous injections. This would allow the subsequent comparison to other drug delivery systems for better drug delivery.

Evaluation of the structural determinants of polymeric precipitation inhibitors using solvent shift methods and principle component analysis.

The presence of polymers within solid dose forms, such as solid dispersions, or liquid or semisolid formulations, such as lipid-based formulations, can promote the maintenance of drug supersaturation after dissolution or dispersion/digestion of the vehicle in the gastrointestinal tract. Transiently stable supersaturation delays precipitation, increases thermodynamic activity, and may enhance bioavailability and reduce variability in exposure. In the current study a diverse range of 42 different classes of polymers, with a total of 78 polymers across all classes, grades, and molecular weights were examined, to varying degrees, as potential polymeric precipitation inhibitors (PPIs) using a solvent shift method to initiate supersaturation. To provide a deeper understanding of the molecular determinants of polymer utility the data were also analyzed, along with a range of physicochemical descriptors of the polymers employed, using principle component analysis (PCA). Polymers were selectively tested for their ability to stabilize supersaturation for nine poorly water-soluble model drugs, representing a range of nonelectrolytes, weak acids, and weak bases. In general, the cellulose-based polymers (and in particular hydroxypropylmethyl cellulose, HPMC, and its derivatives) provided robust precipitation inhibition across most of the drugs tested. Subsequent PCA indicate that there is consistent PPI behavior of a given polymer for a given drug type, with clear clustering of the performance of polymers with each of the nonelectrolytes, weak bases, and weak acids. However, there are some exceptions to this, with some specific drug type-polymer interactions also occurring. Polymers containing primary amine functional groups should be avoided as they are prone to enhancing precipitation rates. An inverse relationship was also documented for the number of amide, carboxylic acid, and hydroxyl functional groups; therefore for general good PPI performance the number of these contained within the polymer should be minimized. Molecular weight is a poor predictor of performance, having only a minor influence, and in some cases a higher molecular weight enhances the precipitation process. The importance of ionic interactions to the ability of a PPI to stabilize the supersaturated state was demonstrated by the advantage of choosing a polymer with an opposite charge with respect to the drug. Additionally, when the polymer charge is the same as the supersaturated drug, precipitation is likely to be enhanced. A PCA model based on polymer molecular properties is presented, which has a central oval region where the polymer will general perform well across all three drug types. If the polymer is located outside of this region, then they either show compound-specific inhibition or enhance precipitation. Incomplete separation of the PPI performance based on the molecular properties on the polymers indicates that there are some further molecular properties that might improve the correlation.

Pulmonary administration of PEGylated polylysine dendrimers: absorption from the lung versus retention within the lung is highly size-dependent.

The systemic delivery of drugs via the inhaled route is an attractive, needle-free means of improving the systemic exposure of molecules such as peptides and proteins that are poorly absorbed after oral administration. Directed delivery into the lungs also provides a means of increasing drug concentrations at the site of action for lung-specific disease states such as pulmonary infections and lung cancer. The current study has examined the potential utility of PEGylated polylysine dendrimers as pulmonary delivery agents and in particular sought to explore the relationship between dendrimer size and absorption of the intact construct (as a potential systemic delivery mechanism) versus retention within the lungs (as a potential pulmonary depot for controlled local release). Dendrimer absorption from the lungs was inversely correlated with molecular weight, with approximately 20-30% of the dose of relatively small (<22 kDa) dendrimers systemically absorbed compared to only 2% absorption for a larger (78 kDa) PEGylated dendrimer. Increasing the molecular weight of the dendrimers led to slower absorption and more prolonged retention in the lung tissue and bronchoalveolar lavage fluid. Oral administration of the two smaller dendrimers confirmed that oral bioavailability of the PEGylated dendrimers was essentially zero and did not contribute to exposure after pulmonary administration. The smaller PEGylated dendrimers were also degraded in the lungs to low molecular weight products that were subsequently absorbed and excreted via the urine, while the larger constructs showed good stability in the lungs. The data suggest first, that small PEGylated dendrimer-based drug delivery systems may be delivered to the blood via inhalation, providing a more attractive alternative to injections, and second that larger PEGylated dendrimers may be retained in the lungs providing the potential for controlled delivery of medications to the blood or lung tissue.

Computational prediction of drug solubility in lipid based formulation excipients.

PURPOSE: To investigate if drug solubility in pharmaceutical excipients used in lipid based formulations (LBFs) can be predicted from physicochemical properties. METHODS: Solubility was measured for 30 structurally diverse drug molecules in soybean oil (SBO, long-chain triglyceride; TGLC), Captex355 (medium-chain triglyceride; TGMC), polysorbate 80 (PS80; surfactant) and PEG400 co-solvent and used as responses during PLS model development. Melting point and calculated molecular descriptors were used as variables and the PLS models were validated with test sets and permutation tests. RESULTS: Solvation capacity of SBO and Captex355 was equal on a mol per mol scale (R (2) = 0.98). A strong correlation was also found between PS80 and PEG400 (R (2) = 0.85), identifying the significant contribution of the ethoxylation for the solvation capacity of PS80. In silico models based on calculated descriptors were successfully developed for drug solubility in SBO (R (2) = 0.81, Q (2) = 0.76) and Captex355 (R (2) = 0.84, Q (2) = 0.80). However, solubility in PS80 and PEG400 were not possible to quantitatively predict from molecular structure. CONCLUSION: Solubility measured in one excipient can be used to predict solubility in another, herein exemplified with TGMC versus TGLC, and PS80 versus PEG400. We also show, for the first time, that solubility in TGMC and TGLC can be predicted from rapidly calculated molecular descriptors.

Lipid digestion as a trigger for supersaturation: evaluation of the impact of supersaturation stabilization on the in vitro and in vivo performance of self-emulsifying drug delivery systems.

The generation of supersaturation in the gastrointestinal (GI) tract is an increasingly popular means of promoting oral absorption for poorly water-soluble drugs. The current study examined the impact of changes to the quantities of medium-chain (MC) lipid (Captex 300:Capmul MCM), surfactant (Cremophor EL) and cosolvent (EtOH), and the addition of polymeric precipitation inhibitors (PPI), on supersaturation during the dispersion and digestion of MC self-emulsifying drug delivery systems (SEDDS) containing danazol. The data suggest that digestion acts as a "trigger" for enhanced supersaturation and that solubilization/precipitation behavior is correlated with the degree of supersaturation on dispersion (S(M)DISP) or digestion (S(M)DIGEST). The ability of the formulation to maintain solubilization in vitro decreased as the S(M) of the formulation increased. PPI significantly increased supersaturation stabilization and precipitation was inhibited where S(M)DISP < 3.5 and S(M)DIGEST < 4. In the presence of polymer, some degree of supersaturation was maintained up to S(M)DIGEST ∼ 8. Differentiation in the ability of SEDDS to maintain drug solubilization stems from the ability to stabilize supersaturation and for MC SEDDS, utilization of lower drug loads, higher surfactant levels (balanced against increases in S(M)DISP), lower cosolvent and the addition of PPI enhanced formulation performance. In vivo studies confirmed the ability of PPI to promote drug exposure at moderate drug loads (40% of saturated solubility in the formulation). At higher drug loads (80% saturation) and in lipid-free SEDDS, this effect was lost, suggesting that the ability of PPIs to stabilize supersaturation in vitro may, under some circumstances, overestimate utility in vivo.

Doxorubicin-conjugated PEGylated dendrimers show similar tumoricidal activity but lower systemic toxicity when compared to PEGylated liposome and solution formulations in mouse and rat tumor models.

PEGylated polylysine dendrimers show promise as novel drug delivery systems with the potential to direct site specific deposition patterns and to reduce toxicity at nontarget sites. Here the activity and toxicity profiles of a generation 5 polylysine dendrimer with 50% surface conjugation of PEG1100 and 50% surface conjugation of doxorubicin (via an acid labile 4-hydrazinosulfonyl benzoic acid linker) have been compared in a Walker 256 rat tumor model and a human MDA-MB231 xenograft in mice. A direct comparison was also made to a PEGylated liposomal formulation of doxorubicin and a doxorubicin solution. In both rat and mouse breast cancer models, the dendrimer formulation gave equivalent antitumor efficacy when compared to the liposomal or solution doxorubicin formulations and administration of all three doxorubicin formulations resulted in a significant reduction (>75%) in tumor growth in both models at doses ranging from 2 to 10 mg/kg doxorubicin equivalents. The dendrimer formulation, however, was better tolerated by both rats and mice, and approximately 2-fold higher doses were required to induce similar levels of toxicity (as assessed by organ weight, peripheral white cell counts, body weight and survival curves) when compared to administration of the doxorubicin solution or PEGylated liposomal doxorubicin. In rats the appearance of palmar plantar erythematosis (PPE), or hand foot syndrome, was also less evident after administration of dendrimer doxorubicin when compared to the liposome. Finally, even after administration to mice at 2-fold higher doses, dendrimer-doxorubicin resulted in a reduced incidence of cardiotoxicity when compared with a simple solution formulation of doxorubicin. The data suggest that dendrimer-based doxorubicin formulations may provide advantage over solution and liposomal formulations of doxorubicin via a reduction in systemic toxicity.

A comparison of changes to doxorubicin pharmacokinetics, antitumor activity, and toxicity mediated by PEGylated dendrimer and PEGylated liposome drug delivery systems.

The pharmacokinetics, biodistribution, and antitumor efficacy of three doxorubicin formulations (doxorubicin in saline, conjugated to a polylysine dendrimer, and encapsulated within a stealth liposome) were investigated in Walker 256 tumor-bearing rats. Liposomal and dendrimer-based delivery systems resulted in more prolonged plasma exposure of total doxorubicin when compared to administration of doxorubicin in saline, although concentrations of free doxorubicin remained low in both cases. Biodistribution profiles revealed enhanced accumulation of dendrimer- and liposome-associated doxorubicin in tumors when compared to doxorubicin alone, although all three doxorubicin formulations reduced tumor growth to a similar extent. Markers of systemic toxicity (spleen weight, white blood cell counts, body weight, and cardiotoxicity) were more pronounced in rats that received doxorubicin and liposomal doxorubicin when compared to dendrimer-doxorubicin. The data provide preliminary evidence that dendrimer-doxorubicin displays similar antitumor efficacy to PEGylated liposomal doxorubicin, but with lower systemic toxicity (resulting from reduced drug exposure to nontarget organs). FROM THE CLINICAL EDITOR: In this manuscript, three different doxorubicin preparations are compared and preliminary evidence suggests that dendrimer-doxorubicin displays similar antitumor efficacy to PEGylated liposomal doxorubicin, but with lower systemic toxicity.

Capping methotrexate α-carboxyl groups enhances systemic exposure and retains the cytotoxicity of drug conjugated PEGylated polylysine dendrimers.

A generation 5 PEGylated (PEG 1100) polylysine dendrimer, conjugated via a stable amide linker to OtBu protected methotrexate (MTX), was previously shown to have a circulatory half-life of 2 days and to target solid tumors in both rats and mice. Here, we show that deprotection of MTX and substitution of the stable linker with a matrix metalloproteinase (MMP) 2 and 9 cleavable linker (PVGLIG) dramatically increased plasma clearance and promoted deposition in the liver and spleen (50-80% of the dose recovered in the liver 3 days post dose). Similar rapid clearance was also seen using a scrambled peptide suggesting that clearance was not dependent on the cleavable nature of the linker. Surprisingly, dendrimers where OtBu capped MTX was linked to the dendrimer surface via the hexapeptide linker showed equivalent in vitro cytotoxicity against HT1080 cells when compared to the uncapped dendrimer and also retained the long circulating characteristics of the stable constructs. The OtBu capped MTX conjugated dendrimer was subsequently shown to significantly reduce tumor growth in HT1080 tumor bearing mice compared to control. In contrast the equivalent dendrimer comprising uncapped MTX conjugated to the dendrimer via the same hexapeptide linker did not reduce tumor growth, presumably reflecting very rapid clearance of the construct. The results are consistent with the suggestion that protection of the α-carboxyl group of methotrexate may be used to improve the circulatory half-life and reduce the liver accumulation of similar MTX-conjugated dendrimers, while still retaining antitumor activity in vivo.