Toward improved mechanical, tribological, corrosion and in-vitro bioactivity properties of mixed oxide nanotubes on Ti-6Al-7Nb implant using multi-objective PSO.

Recently, the robust optimization and prediction models have been highly noticed in district of surface engineering and coating techniques to obtain the highest possible output values through least trial and error experiments. Besides, due to necessity of finding the optimum value of dependent variables, the multi-objective metaheuristic models have been proposed to optimize various processes. Herein, oriented mixed oxide nanotubular arrays were grown on Ti-6Al-7Nb (Ti67) implant using physical vapor deposition magnetron sputtering (PVDMS) designed by Taguchi and following electrochemical anodization. The obtained adhesion strength and hardness of Ti67/Nb were modeled by particle swarm optimization (PSO) to predict the outputs performance. According to developed models, multi-objective PSO (MOPSO) run aimed at finding PVDMS inputs to maximize current outputs simultaneously. The provided sputtering parameters were applied as validation experiment and resulted in higher adhesion strength and hardness of interfaced layer with Ti67. The as-deposited Nb layer before and after optimization were anodized in fluoride-base electrolyte for 300min. To crystallize the coatings, the anodically grown mixed oxide TiO2-Nb2O5-Al2O3 nanotubes were annealed at 440°C for 30min. From the FESEM observations, the optimized adhesive Nb interlayer led to further homogeneity of mixed nanotube arrays. As a result of this surface modification, the anodized sample after annealing showed the highest mechanical, tribological, corrosion resistant and in-vitro bioactivity properties, where a thick bone-like apatite layer was formed on the mixed oxide nanotubes surface within 10 days immersion in simulated body fluid (SBF) after applied MOPSO. The novel results of this study can be effective in optimizing a variety of the surface properties of the nanostructured implants.

Appraisal of latex glove proteins in the induction of sensitivity to multiple latex allergens.

Six Hevea brasiliensis latex protein allergens, Hevb 1, Hev b 2, Hev b 3, Hev b 4, and two variants of Hev b 7 (7b and 7c), were purified from Hevea latex, while a seventh protein, Hev b 5, was prepared in recombinant form. The presence of these proteins in glove extracts was indicated by their respective antibodies in the serum of rabbits immunized against the extracts. The relative propensities of IgE binding to the individual latex allergens were compared using sera from latex-allergic patients. IgE recognition of Hev b 4, Hev b 7b, Hev b 5 and Hev b 2 was most frequently encountered, with 75, 61, 31 and 28%, respectively, of the patient sera reacting. Sensitivity to multiple latex proteins was common, and out of the 31 seropositive patients, 23 (74%/ ) had IgE against at least two latex allergens, while 12 (39%) had IgE specific for at least three allergens. Statistical analysis of the data suggested that many patients might have acquired sensitivity to Hev b 2, Hev b 4 and Hev b 7b from a common source. (e.g., from latex products). On the other hand, sensitivity to Hev b 5 and to Hev b 7c were interrelated. It is plausible that sensitivity to these two proteins might have been acquired from sources other than latex products (e.g., from certain foods).

Precipitation of Hevea brasiliensis latex proteins with trichloroacetic acid and phosphotungstic acid in preparation for the Lowry protein assay.

Many proteins derived from the latex of Hevea brasiliensis that remain soluble in trichloroacetic acid (TCA) can be precipitated by phosphotungstic acid (PTA). A combination of 5% TCA and 0.2% PTA precipitates a wide range of proteins effectively even when they are present in low concentrations (below 1 microgram ml-1). In addition to its protein purification function, acid precipitation also increases the sensitivity of the subsequent protein assay by allowing the test sample to be concentrated. Another advantage of protein precipitation by TCA and PTA is that very small amounts of protein (of the order of 10 micrograms) can be repeatably recovered without the use of precipitate-bulking agents such as sodium deoxycholate. This general procedure of protein purification and concentration is simple and rapid, but the use of PTA may not be fully compatible with the Bradford protein assay. A modified Lowry microassay is described which enables about 3 micrograms ml-1 to be quantitated at the photometric absorbance of 0.05. When used in conjunction with protein concentration by precipitating with TCA/PTA, approximately 0.4 microgram ml-1 protein present in 6 ml of solution can be assayed.

cDNA cloning of the 43-kDa latex allergen Hev b 7 with sequence similarity to patatins and its expression in the yeast Pichia pastoris.

IgE-mediated hypersensitivity to latex proteins present in health care products, particularly in latex gloves, has become an important public health problem in recent years. We purified natural Hev b 7, a 43-kDa patatin-like allergen from the latex of Hevea brasiliensis and determined several internal peptide sequences. A heterologous hybridization probe of a patatin gene of potato, to which these peptides could be aligned best, was used to screen a latex cDNA library. The cDNA encoded an acidic protein of 388 amino acids with a molecular mass of 42.9 kDa. The deduced amino acid sequence had 39-42% identity to patatins from Solanum tuberosum. The purified recombinant Hev b 7 expressed in the yeast Pichia pastoris displayed, similarly to patatins from S. tuberosum, esterase activity. Both natural and recombinant Hev b 7 were recognized by IgE from sera of latex-sensitized allergic individuals. In contrast to patatins from S. tuberosum and Nicotiana tabacum, natural Hev b 7 lacked an N-terminal leader peptide for targeting to the endoplasmatic reticulum and was not glycosylated. These results establish the 43-kDa patatin-like protein as a latex allergen and raise the possibility of different cellular localization and function compared to S. tuberosum patatins.