RESUMEN
The solid product of sewage sludge (SS) pyrolysis, called SS biochar (SSB), is rich in carbon and nutrients, such as phosphorus (P), nitrogen (N), calcium (Ca), and zinc (Zn). However, SSB has a low potassium (K) concentration because it is released with water during the final stage of sewage treatment. The enrichment of SSB with mineral sources of K can solve the low supply of K in SSB and produce an organomineral fertilizer with a slow release of K. However, the dynamics of K release from these enriched fertilizers in different soil types remain unclear. This study investigated the dynamics of K release from biochar-based fertilizer (BBF) in the form of pellets and granules in two soil types (clayey and sandy) and natural silica. An incubation experiment was conducted for 60 days, and replicates were evaluated at prescribed time intervals. After the incubation period, the levels of K available in the solid fraction were determined, and the dynamics of K release were evaluated using four nonlinear regression models. BBFs achieved a slower release of K than the mineral KCl. The dynamics of K release were affected by the physical form of BBF, such that the pelleted BBF exhibited the slowest K release. Furthermore, regarding the concentration detected in the solid phase, the total released was highest in clayey soil, followed by sandy soil and natural silica. The enriched BBFs reduced K release throughout the experimental period, behaving as slow-release fertilizers with the potential to optimize K uptake by plants throughout the growth cycle. Further studies are required to evaluate K leaching and retention in the soil profile when biochar-based fertilizers are applied.
Asunto(s)
Potasio , Suelo , Fertilizantes , Aguas del Alcantarillado , Carbón Orgánico , Minerales , Arcilla , Dióxido de SilicioRESUMEN
Enrichment of biochars to produce slow nutrient release fertilizers with minimal losses to the environment is a promising strategy. However, the release of potassium (K) from biochar-based fertilizer produced from sewage sludge (SS) is still poorly studied. In the present 30-day incubation study, the dynamics of K release were evaluated from SS biochar-based fertilizers enriched with potassium chloride (KBF) in different forms, subjected to two levels of silica sand moisture (10 and 20%). The KBF was evaluated in the form of granules, pellets and powder, in addition to pure KCl mineral fertilizer. During the incubation period water-soluble K extractions were performed, where the K contents were adjusted to K release kinetic models. An additional experiment was performed to assess the effect of KBFs and KCl on K leaching. In general, at both moisture levels all KBFs presented a slower K release compared to pure KCl mineral fertilizer, reducing the release rate by up to 77%. The K release dynamics were affected by the type of biochar fertilizer (granule, pellet and powder) and the silica sand moisture level. The behavior of KBFs as slow-release fertilizers is strongly dependent on the silica sand moisture level. At the 10% moisture level, biochar fertilizers in the form of pellets and granules can be classified as slow-release fertilizers with the potential to increase the efficiency of K use in agriculture. Furthermore, compared to the chemical fertilizer, KBF reduced the amount of leached K, diminishing the risk of this nutrient polluting the groundwater. Our results must be further assessed in real conditions using soil as a suitable medium for agronomic and environmental evaluation. Therefore, future studies should consider the dynamic of K and other nutrients from KBFs in distinct soil types.
Asunto(s)
Fertilizantes , Aguas del Alcantarillado , Carbón Orgánico/química , Fertilizantes/análisis , Minerales , Potasio/análisis , Polvos , Arena , Dióxido de Silicio , Suelo/químicaRESUMEN
Sewage sludge biochar (SSB) is a multi-nutrient fertilizer with very low K concentration. This study presents a novel K-enriched SSB fertilizer with the potential to increase K use efficiency by crops. The object of this work was therefore to evaluate the physical-chemical, morphological and mineralogical characteristics of a SSB organomineral fertilizer (OSSB) enriched with K. SSB was enriched with KCl and K2SO4 using three technological methods (granules, pellets and powders). The enrichment of SSB with K ensured a K2O content about 75 times higher than the pure SSB. Organominerals in powder form had higher levels of total nitrogen, calcium, sulfur, phosphorus and higher pH than granules and pellets. The morphology and physical characteristics of enriched OSSBs were more influenced by the form of the fertilizer than by the source of K. In general, the enriched OSSBs are influenced by the quantities of feedstocks and the enrichment technology.
Asunto(s)
Fertilizantes , Aguas del Alcantarillado , Carbón Orgánico , FósforoRESUMEN
Abstract The sewage sludge (SS) use in agriculture has been limited by the Brazilian legislation to a few situations, mainly as a precautionary measure due to inorganic pollutants and pathogens. Thus, a large amount of SS has been accumulated in landfills, with no prospect of use, generating great concern for governments and society. Thermal treatment via pyrolysis has stood out as an option for SS recycling, transforming it into a carbon-rich product known as SS biochar (SSB). Biochar from SS showed good potential to be used for agricultural and environmental purposes. The present study aimed to evaluate the influence of pyrolysis at 300°C on the physical, chemical, morphological and mineralogical characteristics of SSB. In general, pyrolysis increased total carbon, total nitrogen, macro and micronutrient contents, except potassium. Pyrolysis also increased heavy metals (HMs) concentration in SSB. However, HMs values remained below the maximum limits allowed according to the legislation on SS agricultural use. X-ray analysis showed that both SS and SSB present silica (SiO2) as the main mineral. Pyrolysis also increased the SS surface area (SA) and porosity. In general, results of the present study prove showed that pyrolysis is a technological alternative to enable SS use as a sustainable input in agriculture.