RESUMEN
Oxygen is crucial for converting glucose to gluconic acid catalyzed by glucose oxidase (Gox). However, industrial gluconic acid production faces oxygen supply limitations. To enhance Gox efficiency, Vitreoscilla hemoglobin (VHb) has been considered as an efficient oxygen transfer carrier. This study identified GoxA, a specific isoform of Gox in the industrial gluconic acid-producing strain of Aspergillus niger. Various forms of VHb expression in A. niger were tested to improve GoxA's catalytic efficiency. Surprisingly, the expression of free VHb, both intracellularly and extracellularly, did not promote gluconic acid production during shake flask fermentation. Then, five fusion proteins were constructed by linking Gox and VHb using various methods. Among these, VHb-GS1-GoxA, where VHb's C-terminus connected to GoxA's N-terminus via the flexible linker GS1, demonstrated a significantly higher Kcat/Km value (96% higher) than GoxA. Unfortunately, the expression of VHb-GS1-GoxA in A. niger was limited, resulting in a low gluconic acid production of 3.0 g/L. To overcome the low expression problem, single- and dual-strain systems were designed with tools of SpyCatcher/SpyTag and SnoopCatcher/SnoopTag. In these systems, Gox and VHb were separately expressed and then self-assembled into complex proteins. Impressively, the single-strain system outperformed the GoxA overexpression strain S1971, resulting in 23% and 9% higher gluconic acid production under 0.6 vvm and 1.2 vvm aeration conditions in the bioreactor fermentation, respectively. The successful construction of Gox and VHb fusion or complex proteins, as proposed in this study, presents promising approaches to enhance Gox catalytic efficiency and lower aerodynamic costs in gluconic acid production. KEY POINTS: ⢠Overexpressing free VHb in A. niger did not improve the catalytic efficiency of Gox ⢠The VHb-GS1-GoxA showed an increased Kcat/Km value by 96% than GoxA ⢠The single-strain system worked better in the gluconic acid bioreactor fermentation.
Asunto(s)
Aspergillus niger , Glucosa Oxidasa , Aspergillus niger/genética , Glucosa Oxidasa/genética , Catálisis , OxígenoRESUMEN
BACKGROUND: Kojic acid (KA) is a widely used compound in the cosmetic, medical, and food industries, and is typically produced by Aspergillus oryzae. To meet increasing market demand, it is important to optimize KA production through seeking alternatives that are more economic than current A. oryzae-based methods. RESULTS: In this study, we achieved the first successful heterologous production of KA in Aspergillus niger, an industrially important fungus that does not naturally produce KA, through the expression of the kojA gene from A. oryzae. Using the resulting KA-producing A. niger strain as a platform, we identified four genes (nrkA, nrkB, nrkC, and nrkD) that negatively regulate KA production. Knocking down nrkA or deleting any of the other three genes resulted in a significant increase in KA production in shaking flask cultivation. The highest KA titer (25.71 g/L) was achieved in a pH controlled batch bioreactor using the kojA overexpression strain with a deletion of nrkC, which showed a 26.7% improvement compared to the KA titer (20.29 g/L) that was achieved in shaking flask cultivation. CONCLUSION: Our study demonstrates the potential of using A. niger as a platform for studying KA biosynthesis and regulation, and for the cost-effective production of KA in industrial strain development.
Asunto(s)
Aspergillus niger , Aspergillus oryzae , Aspergillus niger/genética , Aspergillus niger/metabolismo , Aspergillus oryzae/genética , Aspergillus oryzae/metabolismo , Pironas/metabolismoRESUMEN
Hyaluronic acid (HA) is a multiple-function biopolymer that is widely used in food, cosmetic, and biomedical fields. In group C streptococci, the major workhorse of HA production in industry, the HA biosynthetic pathway has been proposed, while how HA synthesis is regulated is unclear. In this study, we identified twenty-five putative transcriptional repressors in S. zooepidemicus and studied whether they regulate HA synthesis or not. The individual gene deletion strain was firstly constructed, and the phenotypic changes of the corresponding deletion strains in stress tolerance and HA production were detected. The hrcA deletion strain is more sensitive to high temperature, and the rex deletion strain is more resistant to the oxidative stress. Three transcriptional repressor deletions resulted significantly decreased transcriptional levels of hasA, among which the scrR deletion strain shows most dramatical decrease in HA production. The regulatory mechanism of how ScrR affects the production of HA was further explored by transcriptional expression analysis of scrA and scrB, two direct target genes of ScrR regulon. Our results indicates that the deficiency of ScrR results in the unbalanced expression of scrA and scrB, which might also partly account for the decreasing production of HA. In agreement with the speculation, overexpression of scrB in ΔscrR genetic background results in 80% improvement in HA production. Taken together, the systemic genetic study of transcriptional repressors expands our understanding for the physiological regulation process of S. zooepidemicus and should help in the development of high-performance industrial strains for the efficient production of HA. KEY POINTS: ⢠Twenty-two transcriptional repressor genes in S. zooepidemicus were deleted individually, and the phenotypes of corresponding mutants on a variety of conditions were characterized. ⢠HrcA deficiency showed inferior cell tolerance to high temperature, and Rex deficiency showed superior cell tolerance to reactive oxygen stress, and four repressors deficiency showed inferior hyaluronic acid synthesis, among which the transcriptional levels of hasA of three mutants decreased significantly. ⢠Optimizing sucrose metabolic flux can enhance hyaluronic acid synthesis significantly.
Asunto(s)
Streptococcus equi , Vías Biosintéticas , Eliminación de Gen , Ácido Hialurónico , Regulón , Streptococcus equi/genéticaRESUMEN
BACKGROUND: Genome reduction and metabolic engineering have emerged as intensive research hotspots for constructing the promising functional chassis and various microbial cell factories. Surfactin, a lipopeptide-type biosurfactant with broad spectrum antibiotic activity, has wide application prospects in anticancer therapy, biocontrol and bioremediation. Bacillus amyloliquefaciens LL3, previously isolated by our lab, contains an intact srfA operon in the genome for surfactin biosynthesis. RESULTS: In this study, a genome-reduced strain GR167 lacking ~ 4.18% of the B. amyloliquefaciens LL3 genome was constructed by deleting some unnecessary genomic regions. Compared with the strain NK-1 (LL3 derivative, ΔuppΔpMC1), GR167 exhibited faster growth rate, higher transformation efficiency, increased intracellular reducing power level and higher heterologous protein expression capacity. Furthermore, the chassis strain GR167 was engineered for enhanced surfactin production. Firstly, the iturin and fengycin biosynthetic gene clusters were deleted from GR167 to generate GR167ID. Subsequently, two promoters PRsuc and PRtpxi from LL3 were obtained by RNA-seq and promoter strength characterization, and then they were individually substituted for the native srfA promoter in GR167ID to generate GR167IDS and GR167IDT. The best mutant GR167IDS showed a 678-fold improvement in the transcriptional level of the srfA operon relative to GR167ID, and it produced 311.35 mg/L surfactin, with a 10.4-fold increase relative to GR167. CONCLUSIONS: The genome-reduced strain GR167 was advantageous over the parental strain in several industrially relevant physiological traits assessed and it was highlighted as a chassis strain for further genetic modification. In future studies, further reduction of the LL3 genome can be expected to create high-performance chassis for synthetic biology applications.
Asunto(s)
Bacillus amyloliquefaciens/genética , Bacillus amyloliquefaciens/metabolismo , Genoma Bacteriano , Lipopéptidos/biosíntesis , Ingeniería Metabólica , Péptidos Cíclicos/biosíntesis , Bacillus amyloliquefaciens/crecimiento & desarrollo , Proteínas Bacterianas/genética , Proteínas Bacterianas/metabolismo , Lipopéptidos/química , Operón , Oxidación-Reducción , Péptido Sintasas/genética , Péptido Sintasas/metabolismo , Péptidos Cíclicos/química , Regiones Promotoras Genéticas , Tensoactivos , Transformación BacterianaRESUMEN
BACKGROUND: Genome streamlining is a feasible strategy for constructing an optimum microbial chassis for synthetic biology applications. Genomic islands (GIs) are usually regarded as foreign DNA sequences, which can be obtained by horizontal gene transfer among microorganisms. A model strain Pseudomonas putida KT2440 has broad applications in biocatalysis, biotransformation and biodegradation. RESULTS: In this study, the identified GIs in P. putida KT2440 accounting for 4.12% of the total genome size were deleted to generate a series of genome-reduced strains. The mutant KTU-U13 with the largest deletion was advantageous over the original strain KTU in several physiological characteristics evaluated. The mutant KTU-U13 showed high plasmid transformation efficiency and heterologous protein expression capacity compared with the original strain KTU. The metabolic phenotype analysis showed that the types of carbon sources utilized by the mutant KTU-U13 and the utilization capabilities for certain carbon sources were increased greatly. The polyhydroxyalkanoate (PHA) yield and cell dry weight of the mutant KTU-U13 were improved significantly compared with the original strain KTU. The chromosomal integration efficiencies for the γ-hexachlorocyclohexane (γ-HCH) and 1,2,3-trichloropropane (TCP) biodegradation pathways were improved greatly when using the mutant KTU-U13 as the recipient cell and enhanced degradation of γ-HCH and TCP by the mutant KTU-U13 was also observed. The mutant KTU-U13 was able to stably express a plasmid-borne zeaxanthin biosynthetic pathway, suggesting the excellent genetic stability of the mutant. CONCLUSIONS: These desirable traits make the GIs-deleted mutant KTU-U13 an optimum chassis for synthetic biology applications. The present study suggests that the systematic deletion of GIs in bacteria may be a useful approach for generating an optimal chassis for the construction of microbial cell factories.
Asunto(s)
Islas Genómicas , Pseudomonas putida/genética , Eliminación de Secuencia , Biología Sintética , Secuencia de Bases , Biodegradación Ambiental , Vías Biosintéticas , Biotransformación , Carbono/metabolismo , ADN Bacteriano/genética , Ingeniería MetabólicaRESUMEN
BACKGROUND: Iturins, which belong to antibiotic cyclic lipopeptides mainly produced by Bacillus sp., have the potential for application in biomedicine and biocontrol because of their hemolytic and antifungal properties. Bacillus amyloliquefaciens LL3, isolated previously by our lab, possesses a complete iturin A biosynthetic pathway as shown by genomic analysis. Nevertheless, iturin A could not be synthesized by strain LL3, possibly resulting from low transcription level of the itu operon. RESULTS: In this work, enhanced transcription of the iturin A biosynthetic genes was implemented by inserting a strong constitutive promoter C2up into upstream of the itu operon, leading to the production of iturin A with a titer of 37.35 mg l-1. Liquid chromatography-mass spectrometry analyses demonstrated that the strain produced four iturin A homologs with molecular ion peaks at m/z 1044, 1058, 1072 and 1086 corresponding to [C14 + 2H]2+, [C15 + 2H]2+, [C16 + 2H]2+ and [C17 + 2H]2+. The iturin A extract exhibited strong inhibitory activity against several common plant pathogens. The yield of iturin A was improved to 99.73 mg l-1 by the optimization of the fermentation conditions using a response surface methodology. Furthermore, the yield of iturin A was increased to 113.1 mg l-1 by overexpression of a pleiotropic regulator DegQ. CONCLUSIONS: To our knowledge, this is the first report on simultaneous production of four iturin A homologs (C14-C17) by a Bacillus strain. In addition, this study suggests that metabolic engineering in combination with culture conditions optimization may be a feasible method for enhanced production of bacterial secondary metabolites.
Asunto(s)
Bacillus amyloliquefaciens/metabolismo , Ingeniería Metabólica , Péptidos Cíclicos/biosíntesis , Antifúngicos , Bacillus amyloliquefaciens/genética , Vías Biosintéticas , Fermentación , Genoma Bacteriano , Lipopéptidos/biosíntesis , Operón , Regiones Promotoras Genéticas , Transcripción GenéticaRESUMEN
Polyhydroxyalkanoates (PHAs) can be produced by microorganisms from renewable resources and are regarded as promising bioplastics to replace petroleum-based plastics. A medium-chain-length PHAs (mcl-PHA)-producing strain Pseudomonas mendocina NK-01 was isolated previously by our lab and its whole-genome sequence is currently available. Morphology engineering of manipulating cell morphology-related genes has been applied for enhanced accumulation of the intracellular biopolymer short-chain-length PHAs (scl-PHA). However, it has not yet been reported to improve the yield of mcl-PHA by morphology engineering so far. In this work, several well-characterized cell morphology-related genes, including the cell fission ring (Z-ring) location genes minCD, peptidoglycan degradation gene nlpD, actin-like cytoskeleton protein gene mreB, Z-ring formation gene ftsZ, and FtsZ inhibitor gene sulA, were intensively investigated for their impacts on the cell morphology and mcl-PHA accumulation by gene knockout and overexpression in P. mendocina NKU, a upp knockout mutant of P. mendocina NK-01. For a minCD knockout mutant P. mendocina NKU-∆minCD, the average cell length was obviously increased and the mcl-PHA production was improved. However, the nlpD knockout mutant had a shorter cell length and lower mcl-PHA yield compared with P. mendocina NKU. Overexpression of mreB in P. mendocina NKU resulted in spherical cells. When ftsZ was overexpressed in P. mendocina NKU, the cell division was accelerated and the mcl-PHA titer was improved. Furthermore, mreB, ftsZ, or sulA was overexpressed in P. mendocina NKU-∆minCD. Consequently, the mcl-PHA titers were all increased compared with P. mendocina NKU-∆minCD carrying the empty vector. The multiple fission pattern was finally achieved in ftsZ-overexpressing NKU-∆minCD. In this work, improved production of mcl-PHA in P. mendocina NK-01 has been achieved by morphology engineering. This work provides an alternative strategy to enhance mcl-PHA accumulation in mcl-PHA-producing strains.
Asunto(s)
Ingeniería Metabólica/métodos , Polihidroxialcanoatos/metabolismo , Pseudomonas mendocina/citología , Pseudomonas mendocina/metabolismo , Eliminación de Gen , Expresión Génica , Pseudomonas mendocina/genéticaRESUMEN
Direction of arrival (DOA) estimation of sound sources using a spherical microphone array is usually performed in the spherical harmonic (SH) domain. In a non-noisy environment, it suffices to use only the zeroth- and first-order spherical harmonic beams (SHBs) in the SH domain for DOA estimation. One such method is based on the pseudo-intensity vector (PIV), which is attractive due to its low computational complexity. To improve the performance of the PIV method in reverberant environments, some methods have been proposed recently to further exploit high-order SHBs. However, these methods ignore the effect of noise on high-order SHBs, which may lead to poor performance in low signal-to-noise ratio (SNR) environments. To address the problem, this paper proposes an order-aware scheme that is able to select the high-order SHBs reliable for robust DOA estimation of multiple speech sources. Simulation and real-world experimental results demonstrate that the order-aware scheme based methods outperform their existing counterparts with less computational complexity in terms of both accuracy and robustness of DOA estimation. Moreover, the performance improvement is more significant in low SNR environment and in a scenario with small angular separation of sources.
RESUMEN
BACKGROUND: Autoinducer-2 (AI-2) is a universal signal molecule and enables an individual bacteria to communicate with each other and ultimately control behaviors of the population. Harnessing the character of AI-2, two kinds of AI-2 "controller cells" ("consumer cells" and "supplier cells") were designed to "reprogram" the behaviors of entire population. RESULTS: For the consumer cells, genes associated with the uptake and processing of AI-2, which includes LsrACDB, LsrFG, LsrK, were overexpressed in varying combinations. Four consumer cell strains were constructed: Escherichia coli MG1655 pLsrACDB (NK-C1), MG1655 pLsrACDBK (NK-C2), MG1655 pLsrACDBFG (NK-C3) and MG1655 pLsrACDBFGK (NK-C4). The key enzymes responsible for production of AI-2, LuxS and Mtn, were also overexpressed, yielding strains MG1655 pLuxS (NK-SU1), and MG1655 pLuxS-Mtn (NK-SU2). All the consumer cells could decrease the environmental AI-2 concentration. NK-C2 and NK-C4 were most effective in AI-2 uptake and inhibited biofilm formation. While suppliers can increase the environmental AI-2 concentration and NK-SU2 was most effective in supplying AI-2 and facilitated biofilm formation. Further, reporter strain, MG1655 pLGFP was constructed. The expression of green fluorescent protein (GFP) in reporter cells was initiated and guided by AI-2. Mixture of consumer cells and reporter cells suggest that consumer cells can decrease the AI-2 concentration. And the supplier cells were co-cultured with reporter cells, indicating that supplier cells can provide more AI-2 compared to the control. CONCLUSIONS: The consumer cells and supplier cells could be used to regulate environmental AI-2 concentration and the biofilm formation. They can also modulate the AI-2 concentration when they were co-cultured with reporter cells. It can be envisioned that this system will become useful tools in synthetic biology and researching new antimicrobials.
Asunto(s)
Bacterias/metabolismo , Escherichia coli/fisiología , Homoserina/análogos & derivados , Lactonas/metabolismo , Bacterias/crecimiento & desarrollo , Proteínas Bacterianas/genética , Proteínas Bacterianas/metabolismo , Biopelículas/efectos de los fármacos , Biopelículas/crecimiento & desarrollo , Liasas de Carbono-Azufre/genética , Liasas de Carbono-Azufre/metabolismo , Escherichia coli/genética , Escherichia coli/crecimiento & desarrollo , Proteínas de Escherichia coli/genética , Proteínas de Escherichia coli/metabolismo , Regulación Bacteriana de la Expresión Génica , Genes Bacterianos , Homoserina/análisis , Homoserina/genética , Homoserina/metabolismo , Lactonas/análisisRESUMEN
BACKGROUND: Sucrose is an naturally abundant and easily fermentable feedstock for various biochemical production processes. By now, several sucrose utilization pathways have been identified and characterized. Among them, the pathway consists of sucrose permease and sucrose phosphorylase is an energy-conserving sucrose utilization pathway because it consumes less ATP when comparing to other known pathways. Bacillus amyloliquefaciens NK-1 strain can use sucrose as the feedstock to produce poly-γ-glutamic acid (γ-PGA), a highly valuable biopolymer. The native sucrose utilization pathway in NK-1 strain consists of phosphoenolpyruvate-dependent phosphotransferase system and sucrose-6-P hydrolase and consumes more ATP than the energy-conserving sucrose utilization pathway. RESULTS: In this study, the native sucrose utilization pathway in NK-1 was firstly deleted and generated the B. amyloliquefaciens 3Δ strain. Then four combination of heterologous energy-conserving sucrose utilization pathways were constructed and introduced into the 3Δ strain. Results demonstrated that the combination of cscB (encodes sucrose permease) from Escherichia coli and sucP (encodes sucrose phosphorylase) from Bifidobacterium adolescentis showed the highest sucrose metabolic efficiency. The corresponding mutant consumed 49.4% more sucrose and produced 38.5% more γ-PGA than the NK-1 strain under the same fermentation conditions. CONCLUSIONS: To our best knowledge, this is the first report concerning the enhancement of the target product production by introducing the heterologous energy-conserving sucrose utilization pathways. Such a strategy can be easily extended to other microorganism hosts for reinforced biochemical production using sucrose as substrate.
Asunto(s)
Bacillus amyloliquefaciens/metabolismo , Metabolismo Energético , Ingeniería Metabólica , Ácido Poliglutámico/análogos & derivados , Sacarosa/metabolismo , Ácido Poliglutámico/biosíntesis , Ácido Poliglutámico/química , Sacarosa/químicaRESUMEN
BACKGROUND: Poly-γ-glutamic acid (γ-PGA) is a valuable polymer with glutamate as its sole precursor. Enhancement of the intracellular glutamate synthesis is a very important strategy for the improvement of γ-PGA production, especially for those glutamate-independent γ-PGA producing strains. Corynebacterium glutamicum has long been used for industrial glutamate production and it exhibits some unique features for glutamate synthesis; therefore introduction of these metabolic characters into the γ-PGA producing strain might lead to increased intracellular glutamate availability, and thus ultimate γ-PGA production. RESULTS: In this study, the unique glutamate synthesis features from C. glutamicum was introduced into the glutamate-independent γ-PGA producing Bacillus amyloliquefaciens NK-1 strain. After introducing the energy-saving NADPH-dependent glutamate dehydrogenase (NADPH-GDH) pathway, the NK-1 (pHT315-gdh) strain showed slightly increase (by 9.1%) in γ-PGA production. Moreover, an optimized metabolic toggle switch for controlling the expression of É-oxoglutarate dehydrogenase complex (ODHC) was introduced into the NK-1 strain, because it was previously shown that the ODHC in C. glutamicum was completely inhibited when glutamate was actively produced. The obtained NK-PO1 (pHT01-xylR) strain showed 66.2% higher γ-PGA production than the NK-1 strain. However, the further combination of these two strategies (introducing both NADPH-GDH pathway and the metabolic toggle switch) did not lead to further increase of γ-PGA production but rather the resultant γ-PGA production was even lower than that in the NK-1 strain. CONCLUSIONS: We proposed new metabolic engineering strategies to improve the γ-PGA production in B. amyloliquefaciens. The NK-1 (pHT315-gdh) strain with the introduction of NADPH-GDH pathway showed 9.1% improvement in γ-PGA production. The NK-PO1 (pHT01-xylR) strain with the introduction of a metabolic toggle switch for controlling the expression of ODHC showed 66.2% higher γ-PGA production than the NK-1 strain. This work proposed a new strategy for improving the target product in microbial cell factories.
Asunto(s)
Bacillus amyloliquefaciens/genética , Corynebacterium glutamicum/genética , Ácido Glutámico/biosíntesis , Ácido Poliglutámico/análogos & derivados , Bacillus amyloliquefaciens/metabolismo , Corynebacterium glutamicum/metabolismo , Fermentación , Eliminación de Gen , Microbiología Industrial , Ingeniería Metabólica/métodos , Redes y Vías Metabólicas/genética , NADP/genética , Ácido Poliglutámico/biosíntesis , Deshidrogenasas del Alcohol de Azúcar/genética , Deshidrogenasas del Alcohol de Azúcar/metabolismoRESUMEN
Levan is a functional homopolymer of fructose with considerable applications in food, pharmaceutical and cosmetic industries. To improve the levan production in Bacillus amyloliquefaciens, the regulatory elements of sacB (encoding levansucrase) expression and levansucrase secretion were optimized. Four heterologous promoters were evaluated for sacB expression, and the Pgrac promoter led to the highest level for both sacB transcription and levansucrase enzyme activity. The levan production in the corresponding recombinant strain ΔLP-pHTPgrac reached 30.5 g/L, which was 114% higher than that of the control strain NK-ΔLP. In a further step, eight signal peptides were investigated (with Pgrac as the promoter for sacB expression) for their effects on the levansucrase secretion and levan production. The signal peptide yncM was identified as the optimal one, with a secretion efficiency of approximately 90%, and the levan production in the corresponding recombinant strain ΔLP-Y reached 37.4 g/L, which was 161% higher when compared with the control strains NK-ΔLP. Finally, fed-batch fermentation was carried out in 5-L bioreactors for levan production using the recombinant strain ΔLP-Y. A final levan concentration of 102 g/L was achieved, which is very close to the ever reported highest levan production level from the literature. To our best knowledge, this is the first report of the improvement of levan production through metabolic optimization for sacB expression and levansucrase secretion. The results from this study provided essential insights for systematically metabolic engineering of microbial cell factories for enhanced biochemical production.
Asunto(s)
Bacillus amyloliquefaciens/metabolismo , Fructanos/biosíntesis , Regulación Bacteriana de la Expresión Génica , Ingeniería Metabólica/métodos , Bacillus amyloliquefaciens/genética , Bacillus subtilis/genética , Bacillus subtilis/metabolismo , Técnicas de Cultivo Celular por Lotes , Reactores Biológicos , Fermentación , Fructanos/química , Fructosa/metabolismo , Hexosiltransferasas/metabolismo , Peso Molecular , Regiones Promotoras Genéticas , Señales de Clasificación de Proteína , Sacarosa/metabolismoRESUMEN
A Bacillus amyloliquefaciens strain with enhanced γ-PGA production was constructed by metabolically engineering its γ-PGA synthesis-related metabolic networks: by-products synthesis, γ-PGA degradation, glutamate precursor synthesis, γ-PGA synthesis and autoinducer synthesis. The genes involved in by-products synthesis were firstly deleted from the starting NK-1 strain. The obtained NK-E7 strain with deletions of the epsA-O (responsible for extracellular polysaccharide synthesis), sac (responsible for levan synthesis), lps (responsible for lipopolysaccharide synthesis) and pta (encoding phosphotransacetylase) genes, showed increased γ-PGA purity and slight increase of γ-PGA titer from 3.8 to 4.15 g/L. The γ-PGA degrading genes pgdS (encoding poly-gamma-glutamate depolymerase) and cwlO (encoding cell wall hydrolase) were further deleted. The obtained NK-E10 strain showed further increased γ-PGA production from 4.15 to 9.18 g/L. The autoinducer AI-2 synthetase gene luxS was deleted in NK-E10 strain and the resulting NK-E11 strain showed comparable γ-PGA titer to NK-E10 (from 9.18 to 9.54 g/L). In addition, we overexpressed the pgsBCA genes (encoding γ-PGA synthetase) in NK-E11 strain; however, the overexpression of these genes led to a decrease in γ-PGA production. Finally, the rocG gene (encoding glutamate dehydrogenase) and the glnA gene (glutamine synthetase) were repressed by the expression of synthetic small regulatory RNAs in NK-E11 strain. The rocG-repressed NK-anti-rocG strain exhibited the highest γ-PGA titer (11.04 g/L), which was 2.91-fold higher than that of the NK-1 strain. Fed-batch cultivation of the NK-anti-rocG strain resulted in a final γ-PGA titer of 20.3g/L, which was 5.34-fold higher than that of the NK-1 strain in shaking flasks. This work is the first report of a systematically metabolic engineering approach that significantly enhanced γ-PGA production in a B. amyloliquefaciens strain. The engineering strategies explored here are also useful for engineering cell factories for the production of γ-PGA or of other valuable metabolites.
Asunto(s)
Bacillus/genética , Bacillus/metabolismo , Ingeniería Metabólica/métodos , Redes y Vías Metabólicas/genética , Ácido Poliglutámico/análogos & derivados , Bacillus/enzimología , Secuencia de Bases , Biopelículas , Fermentación , Eliminación de Gen , Regulación Bacteriana de la Expresión Génica/genética , Glutamato Deshidrogenasa/biosíntesis , Glutamato Deshidrogenasa/genética , Datos de Secuencia Molecular , Plásmidos/genética , Ácido Poliglutámico/biosíntesis , Polisacáridos/biosíntesis , Polisacáridos/genética , ARN Bacteriano/biosíntesis , ARN Bacteriano/genética , ARN Interferente Pequeño/biosíntesis , ARN Interferente Pequeño/genéticaRESUMEN
Here, we attempted to elevate poly-gamma-glutamic acid (γ-PGA) production by modifying genes involved in glutamate metabolism in Bacillus amyloliquefaciens LL3. Products of rocR, rocG and gudB facilitate the conversion from glutamate to 2-oxoglutarate in Bacillus subtillis. The gene odhA is responsible for the synthesis of a component of the 2-oxoglutarate dehydrogenase complex that catalyzes the oxidative decarboxylation of 2-oxoglutarate to succinyl coenzyme A. In-frame deletions of these four genes were performed. In shake flask experiments the gudB/rocG double mutant presented enhanced production of γ-PGA, a 38 % increase compared with wild type. When fermented in a 5-L fermenter with pH control, the γ-PGA yield of the rocR mutant was increased to 5.83 g/L from 4.55 g/L for shake flask experiments. The gudB/rocG double mutant produced 5.68 g/L γ-PGA compared with that of 4.03 g/L for the wild type, a 40 % increase. Those results indicated the possibility of improving γ-PGA production by modifying glutamate metabolism, and identified potential genetic targets to improve γ-PGA production.
Asunto(s)
Bacillus/genética , Bacillus/metabolismo , Eliminación de Gen , Genes Bacterianos , Ácido Poliglutámico/análogos & derivados , Fermentación , Ácido Glutámico/metabolismo , Concentración de Iones de Hidrógeno , Ácidos Cetoglutáricos/metabolismo , Ácido Poliglutámico/biosíntesisRESUMEN
We herein adapted a markerless gene replacement method by combining a temperature-sensitive plasmid pKSV7 with a counterselectable marker, the upp gene encoding uracil phosphoribosyltransferase (UPRTase), for the poly-γ-glutamic acid (γ-PGA)-producing strain Bacillus amyloliquefaciens LL3. Deletion of the upp gene conferred LL3 5-fluorouracil (5-FU) resistance. Sensitivity to 5-FU was restored when LL3 Δupp was transformed with pKSV7-based deletion plasmid which carries a functional allele of the upp gene of Bacillus subtilis 168. These observations allowed us to adapt a two-step plasmid integration and excision strategy to perform markerless deletion of genes of interest. Deletion plasmid harboring a mutant allele of the target gene was first integrated in the genome by culturing cells under nonpermissive conditions for pKSV7 replication. Single-crossover recombinants were then grown without antibiotics to aid the second recombinational event. 5-FU was used to select for double-crossover recombinants with plasmid evicted from the chromosome. The resulting recombinants either harbored the wild-type or mutated allele of the target gene and could be identified by PCR and DNA sequencing. Using this method, we successively removed the amyA gene and a 47-kb fragment of the bae cluster from the genome of LL3, with higher efficiency compared with previous reports. We also investigated the effects of a transcriptional regulator, RocR, on γ-PGA production and cell growth. Specific γ-PGA production of the rocR mutant was increased by 1.9-fold, which represents a new way to improve γ-PGA production.
Asunto(s)
Bacillus/genética , Genética Microbiana/métodos , Ingeniería Metabólica/métodos , Redes y Vías Metabólicas/genética , Biología Molecular/métodos , Ácido Poliglutámico/metabolismo , Eliminación de Gen , Vectores Genéticos , Plásmidos , Selección GenéticaRESUMEN
Poly-γ-glutamic acid (γ-PGA) is an important biopolymer with greatly potential in industrial and medical applications. In the present study, we constructed a metabolically engineered glutamate-independent Bacillus amyloliquefaciens LL3 strain with considerable γ-PGA production, which was carried out by single, double, and triple markerless deletions of three degradation genes pgdS, ggt, and cwlO. The highest γ-PGA production (7.12 g/L) was obtained from the pgdS and cwlO double-deletion strain NK-pc, which was 93 % higher than that of wild-type LL3 strain (3.69 g/L). The triple-gene-deletion strain NK-pgc showed a 28 % decrease in γ-PGA production, leading to a yield of 2.69 g/L. Furthermore, the cell morphologies of the mutant strains were also characterized. The cell length of cwlO deletion strains NK-c and NK-pc was shorter than that of the wild-type strain, while the ggt deletion strains NK-g, NK-pg, NK-gc, and NK-pgc showed longer cell lengths. This is the first report concerning the markerless deletion of γ-PGA degradation genes to improve γ-PGA production in a glutamate-independent strain and the first observation that γ-glutamyltranspeptidase (encoded by ggt) could be involved in the inhibition of cell elongation.
Asunto(s)
Bacillus/citología , Bacillus/metabolismo , Pared Celular/metabolismo , Genes Bacterianos , Ácido Poliglutámico/análogos & derivados , gamma-Glutamiltransferasa/metabolismo , Bacillus/genética , Eliminación de Gen , Ingeniería Metabólica , Ácido Poliglutámico/metabolismo , gamma-Glutamiltransferasa/genéticaRESUMEN
Citric acid is widely used in the food, chemical and pharmaceutical industries. Aspergillus niger is the workhorse used for citric acid production in industry. A canonical citrate biosynthesis that occurred in mitochondria was well established; however, some research suggested that the cytosolic citrate biosynthesis pathway may play a role in this chemical production. Here, the roles of cytosolic phosphoketolase (PK), acetate kinase (ACK) and acetyl-CoA synthetase (ACS) in citrate biosynthesis were investigated by gene deletion and complementation in A. niger. The results indicated that PK, ACK and ACS were important for cytosolic acetyl-CoA accumulation and had significant effects on citric acid biosynthesis. Subsequently, the functions of variant PKs and phosphotransacetylase (PTA) were evaluated, and their efficiencies were determined. Finally, an efficient PK-PTA pathway was reconstructed in A. niger S469 with Ca-PK from Clostridium acetobutylicum and Ts-PTA from Thermoanaerobacterium saccharolyticum. The resultant strain showed an increase of 96.4% and 88% in the citrate titer and yield, respectively, compared with the parent strain in the bioreactor fermentation. These findings indicate that the cytosolic citrate biosynthesis pathway is important for citric acid biosynthesis, and increasing the cytosolic acetyl-CoA level can significantly enhance citric acid production.
RESUMEN
Streptococcus zooepidemicus, group C Streptococci, is currently used for the industrial production of hyaluronic acid (HA). However, genetic manipulation of S. zooepidemicus is severely limited by its low transformation efficiency, which might be in part due to the Restriction-Modification (R-M) systems. The complete genome sequence of S. zooepidemicus ATCC39920 revealed the presence of two putative R-M systems, type I and type II. The putative type I R-M system is encoded by three closely linked genes: hsdR (SeseC_01315), hsdS, hsdM (SeseC_01318), and the putative type II R-M system consists of two closely linked genes: SeseC_02360 and yhdJ (SeseC_02362). Inactivation of hsdR, encoding the restriction endonuclease (REase) of the type I R-M system, showed no apparent effects on transformation efficiency, implying that disarmament of the type I R-M system alone is not sufficient for increasing transformation efficiency. However, inactivation of SeseC_02360, encoding the REase of the type II R-M system, improved transformation efficiency by 4.97 folds, indicating that type II R-M system is the major barrier that restricts genetic transformation in S. zooepidemicus. Furthermore, S. zooepidemicus strains lacking either of the two R-M systems are phenotypically indistinguishable from the wild-type in terms of cell growth and HA production. In summary, our study revealed that the type II R-M system is the main barrier to genetic transformation in S. zooepidemicus ATCC39920, and that the deletion of the type II R-M system renders S. zooepidemicus more transformable, thus facilitating metabolic engineering of this industrially important microorganism. Supplementary Information: The online version contains supplementary material available at 10.1007/s13205-022-03227-x.
RESUMEN
In this work, we developed an efficient pathway construction strategy, consisting of DNA assembler-assisted pathway assembly and counterselection system-based chromosomal integration, for the rapid and efficient integration of synthetic biodegradation pathways into the chromosome of Pseudomonas putida KT2440. Using this strategy, we created a novel degrader capable of complete mineralization of γ-hexachlorocyclohexane (γ-HCH) and 1,2,3-trichloropropane (TCP) by integrating γ-HCH and TCP biodegradation pathways into the chromosome of P. putida KT2440. Furthermore, the chromosomal integration efficiencies of γ-HCH and TCP biodegradation pathways were improved to 50% and 41.6% in P. putida KT2440, respectively, by the inactivation of a type I DNA restriction-modification system. The currently developed pathway construction strategy coupled with the mutant KTUΔhsdRMS will facilitate implantation of heterologous catabolic pathways into the chromosome for rapid evolution of the biodegradation capacity of P. putida. More importantly, the successful removal of γ-HCH (10 mg/kg soil) and TCP (0.2 mM) from soil and wastewater within 14 days, respectively, highlighted the potential of the novel degrader for in situ bioremediation of γ-HCH- and TCP-contaminated sites. Moreover, chromosomal integration of gfp made the degrader to be monitored easily during bioremediation. In the future, this strategy can be expanded to a broad range of bacterial species for widespread applications in bioremediation.
Asunto(s)
Pseudomonas putida , Biodegradación Ambiental , Hexaclorociclohexano , Pseudomonas putida/genéticaRESUMEN
Polyhydroxyalkanoate (PHA) can be produced by microorganisms from renewable resources and is regarded as a promising bioplastic to replace petroleum-based plastics. Pseudomonas mendocina NK-01 is a medium-chain-length PHA (mcl-PHA)-producing strain and its whole-genome sequence is currently available. The yield of mcl-PHA in P. mendocina NK-01 is expected to be improved by applying a promoter engineering strategy. However, a limited number of well-characterized promoters has greatly restricted the application of promoter engineering for increasing the yield of mcl-PHA in P. mendocina NK-01. In this work, 10 endogenous promoters from P. mendocina NK-01 were identified based on RNA-seq and promoter prediction results. Subsequently, 10 putative promoters were characterized for their strength through the expression of a reporter gene gfp. As a result, five strong promoters designated as P4, P6, P9, P16 and P25 were identified based on transcriptional level and GFP fluorescence intensity measurements. To evaluate whether the screened promoters can be used to enhance transcription of PHA synthase gene (phaC), the three promoters P4, P6 and P16 were separately integrated into upstream of the phaC operon in the genome of P. mendocina NK-01, resulting in the recombinant strains NKU-4C1, NKU-6C1 and NKU-16C1. As expected, the transcriptional levels of phaC1 and phaC2 in the recombinant strains were increased as shown by real-time quantitative RT-PCR. The phaZ gene encoding PHA depolymerase was further deleted to construct the recombinant strains NKU-∆phaZ-4C1, NKU-∆phaZ-6C1 and NKU-∆phaZ-16C1. The results from shake-flask fermentation indicated that the mcl-PHA titer of recombinant strain NKU-∆phaZ-16C1 was increased from 17 to 23 wt% compared with strain NKU-∆phaZ. This work provides a feasible method to discover strong promoters in P. mendocina NK-01 and highlights the potential of the screened endogenous strong promoters for metabolic engineering of P. mendocina NK-01 to increase the yield of mcl-PHA.