New System for Simultaneous Measurement of Oxygen Consumption and Changes in Wine Color.

The design, construction and validation of a device for the accurate measurement of the dissolved oxygen content in wine and simultaneously the variation of its spectral fingerprint is presented. The novelty of this system is due to two innovative approaches. First, robustness in measurements is obtained by using cuvettes designed to simultaneously measure the dissolved oxygen and color. Secondly, automatic monitoring is performed to ensure that measurements are always taken at the same cuvette position. The fine-tuning of the device with the study of white and red wines makes it possible, on the one hand, to establish the appropriate measurement conditions and, on the other hand, to determine the amount of oxygen required to cause specific changes in the wine spectrum, information that could not be obtained until now. The preliminary results are very interesting, presenting precise data on the amount of oxygen consumed by the wine and the variations in its visible spectrum, thus reflecting the modification of the responsible phenolic compounds. This information is of great interest, since it helps to optimize the handling of the wine and, if necessary, to moderate the uptake of oxygen in each type of wine to ensure the maintenance of the color during the winemaking and conservation processes of each type of wine. The results of the experiments indicate that this new instrument is feasible and accurate for detecting oxygen changes during wine production.

Influence of Oxygen Management on Color and Phenolics of Red Wines.

Winemaking involves contact at different stages with atmospheric oxygen, the consumption of which determines its final properties. The chemical analysis of red wines subjected to consecutive cycles of air saturation has been extensively researched; however, the capacity to consume different doses of oxygen before bottling is an aspect that has been little studied. In this work, the effect of saturation of different levels of oxygen on the final characteristics of different wines made from Tempranillo and Garnacha grape extracts was studied. For this purpose, the wines were subjected to controlled oxygen saturation levels to simulate their possible oxygenation before bottling. The only difference was the phenolic composition of grape extracts that were reconstituted under the same conditions to avoid the interferences inherent to the fermentation process and the additives added in the winery. The kinetics of oxygen consumption was then evaluated and its effect on the color, antioxidant capacity, and phenols of three different wines was analyzed. This work shows the relationship between the oxidation state of wine and changes in its chemical composition. In addition, it provides insight into the effect of oxygen consumption before bottling on the properties of wines subjected to high and single doses of oxygen.

Alternative Woods in Enology: Characterization of Tannin and Low Molecular Weight Phenol Compounds with Respect to Traditional Oak Woods. A Review.

Wood is one of the most highly valued materials in enology since the chemical composition and sensorial properties of wine change significantly when in contact with it. The need for wood in cooperage and the concern of enologists in their search for new materials to endow their wines with a special personality has generated interest in the use of other Quercus genus materials different from the traditional ones (Q. petraea, Q. robur and Q. alba) and even other wood genera. Thereby, species from same genera such as Q. pyrenaica Willd., Q. faginea Lam., Q. humboldtti Bonpl., Q. oocarpa Liebm., Q. stellata Wangenh, Q. frainetto Ten., Q. lyrata Walt., Q. bicolor Willd. and other genera such as Castanea sativa Mill. (chestnut), Robinia pseudoacacia L. (false acacia), Prunus avium L. and P. cereaus L. (cherry), Fraxinus excelsior L. (European ash) and F. americana L. (American ash) have been studied with the aim of discovering whether they could be a new reservoir of wood for cooperage. This review aims to summarize the characterization of tannin and low molecular weight phenol compositions of these alternative woods for enology in their different cooperage stages and compare them to traditional oak woods, as both are essential to proposing their use in cooperage for aging wine.

Effect of rootstocks on volatile composition of Merlot wines.

BACKGROUND: Scion physiology and grape quality are impacted by rootstock choice. There is little available information about the effects of rootstock on wine volatile composition, particularly when comparing grafted with own-rooted grapevines. This field trial was aimed at studying the influence of rootstock choice on volatile composition of Merlot wines. RESULTS: Wines made from grapes harvested from own-rooted grapevines had the lowest content of (E)-3-hexenol, diethyl succinate and total ethyl esters and the highest content of 1-pentanol, 1-hexanol, (Z)-3-hexenol, diethyl malate and acetovanillone. Rootstocks such as 99R and 140Ru led to a higher content of total ethyl esters in wines followed by 110R, 1103P and Gravesac. According to odor activity values, Merlot wines were characterized by roses, sweat, cheese and banana aromas. CONCLUSIONS: This work provides valuable information about the potential impact of rootstocks on wine volatile composition for Merlot wines. © 2020 Society of Chemical Industry.

Phenolic and volatile compounds in Quercus humboldtii Bonpl. wood: effect of toasting with respect to oaks traditionally used in cooperage.

BACKGROUND: The most frequent renewal of barrels of different origins and species is a current trend, but this demand does not match the current availability of wood. An alternative could be the use of Quercus humboldtii wood. However, there is little information about its composition. Because of this, the aim was to study low-molecular-weight phenols (LMWP), ellagitannins and volatile compounds in untoasted and toasted Q. humboldtii oak, and compare these with the species traditionally used in cooperage: Q. petraea (French and Romanian) and Q. alba (American). RESULTS: The LMWPs in Q. humboldtii were comparable to those in Q. petraea and Q. alba. Ellagitannin composition in Q. humboldtii was similar to that in Q. alba. The toasting process improved volatile composition, mainly in Q. humboldtii, presenting the highest concentration of several volatile compounds. CONCLUSION: The results indicate that Q. humboldtii could be considered suitable for aging wine, although it is necessary to continue the study of this wood species to confirm its potential use in oenology. © 2018 Society of Chemical Industry.

Rootstock effects on grape anthocyanins, skin and seed proanthocyanidins and wine color and phenolic compounds from Vitis vinifera L. Merlot grapevines.

BACKGROUND: Rootstocks affect vegetative and reproductive parameters of the scion. However, limited knowledge exists on the effects of the adoption of a specific rootstock on grape and wine phenolic composition, which contribute to certain sensory attributes such as color, body and astringency of wine. These compounds are mainly affected by the variety, viticultural management and rootstock. The aim of this work was to study the influence of eight rootstocks on grape anthocyanin content, skin and seed proanthocyanidins and wine chromatic characteristics obtained from Merlot vines. RESULTS: Grapevines grafted onto SO4 rootstock, in general, presented a higher concentration of total proanthocyanidins in skins and seeds compared to the rest of the rootstocks, whereas grapevines grafted onto Gravesac presented a lower concentration of proanthocyanidins in skins and seeds. These differences were found in the wines developed from grapevines grafted onto SO4. Wines from grapevines grafted onto SO4, 140 Ruggeri, Gravesac and 4453 M rootstocks presented, in general, better chromatic characteristics and a higher anthocyanin and tannin content than the rest of the samples. CONCLUSION: This work gives additional information concerning the influence of rootstock on grape and wine phenolic composition. © 2018 Society of Chemical Industry.

Characterization of phenolic composition in Carignan noir grapes (Vitis vinifera L.) from six wine-growing sites in Maule Valley, Chile.

BACKGROUND: Among Chilean varieties, Carignan noir has had a major resurgence due to its rediscovered wine quality potential. For this, the aim of this study was to characterize phenolic composition of grapes grown in six sites from the Maule Valley. RESULTS: The data showed that myricetin-3-glc and catechin were the most important flavonol and flavanol, respectively. Anthocyanin and flavonol composition was correlated with biologically effective degree days, exhibiting a relationship with grape maturity. Flavanol and hydroxycinnamic acid composition was inversely correlated to the average maximum temperature of the warmest month, showing that their synthesis is favored by cooler temperatures during the warmest month. CONCLUSION: These results have enological and viticultural interest for grape growers as vineyard site selection for this cultivar can confer differentiable attributes in terms of grape composition and quality. On the other hand, understanding the effects of climate on the synthesis of phenolic compounds may be useful for managing the vineyards with the aim of improving grape quality. © 2017 Society of Chemical Industry.

Volatile composition of Carignan noir wines from ungrafted and grafted onto País (Vitis vinifera L.) grapevines from ten wine-growing sites in Maule Valley, Chile.

BACKGROUND: Carignan noir is one of the minor and ancient varieties from the Chilean wine scenario that has had a resurgence as a result of to its rediscovered oenological potential when cultivated under the conditions of the interior dryland area. Under these growing conditions Carignan noir wines stand out as fruit driven and fresh compared to those originating from other growing areas. On the other hand, it is well known that wine aroma composition depends mainly on variety, viticultural management and winemaking. Thus, the present study aimed to investigate the volatile composition of wines from Carignan noir grapes originating from ungrafted and grafted onto País grapevines, in ten sites of the Maule Valley (Chile) during two consecutive vintages. RESULTS: Higher alcohols were the most abundant volatile compounds, whereas ethyl esters and ß-damascenone were the most odoriferous compounds according to their odorant activity value. The dominant factor in Carignan noir wine volatile composition was season, whereas rootstock did not have a significant effect in differentiating the wines. In terms of climate, cold nights during the month prior to harvest correlated with higher linalool, α-terpineol and trans-3-hexen-1-ol content. The biologically effective degree-days index was inversely correlated with isoamyl acetate and 2-phenylethyl acetate content. Huglin's heliothermal and the average mean temperature of the warmest month indices were inversely correlated with ethyl vanillate, ethyl hexanoate and ethyl octanoate content. CONCLUSION: Site climate conditions were related to the accumulation of certain wine volatile compounds. This information may be useful for devising new Carignan noir vineyard management strategies when aiming to improve wine quality or adjust site selection approaches to maximize grape/wine volatile composition according to wine style. © 2018 Society of Chemical Industry.

Aroma Release in Wine Using Co-Immobilized Enzyme Aggregates.

Aroma is a remarkable factor of quality and consumer preference in wine, representing a distinctive feature of the product. Most aromatic compounds in varietals are in the form of glycosidic precursors, which are constituted by a volatile aglycone moiety linked to a glucose residue by an O-glycosidic bond; glucose is often linked to another sugar (arabinose, rhamnose or apiose). The use of soluble ß-glycosidases for aroma liberation implies the addition of a precipitating agent to remove it from the product and precludes its reuse after one batch. An attractive option from a technological perspective that will aid in removing such constraints is the use of immobilized glycosidases. Immobilization by aggregation and crosslinking is a simple strategy producing enzyme catalysts of very high specific activity, being an attractive option to conventional immobilization to solid inert supports. The purpose of this work was the evaluation of co-immobilized ß-glycosidases crosslinked aggregates produced from the commercial preparation AR2000, which contains the enzymes involved in the release of aromatic terpenes in Muscat wine (α-l-arabinofuranosidase and ß-d-glucopyranosidase). To do so, experiments were conducted with co-immobilized crosslinked enzyme aggregates (combi-CLEAs), and with the soluble enzymes, using an experiment without enzyme addition as control. Stability of the enzymes at the conditions of winemaking was assessed and the volatiles composition of wine was determined by SPE-GC-MS. Stability of enzymes in combi-CLEAs was much higher than in soluble form, 80% of the initial activity remaining after 60 days in contact with the wine; at the same conditions, the soluble enzymes had lost 80% of their initial activities after 20 days. Such higher stabilities will allow prolonged use of the enzyme catalyst reducing its impact in the cost of winemaking. Wine treated with combi-CLEAs was the one exhibiting the highest concentration of total terpenes (18% higher than the control) and the highest concentrations of linalool (20% higher), nerol (20% higher) and geraniol (100% higher), which are the most important terpenes in determining Muscat typicity. Co-immobilized enzymes were highly stable at winemaking conditions, so their reutilization is possible and technologically attractive by reducing the impact of enzyme cost on winemaking cost.

Chemical and sensorial profile of Tempranillo wines elaborated with toasted vine-shoots of different varieties and micro-oxygenation.

The positive impact of use SEGs ("Shoot from vines - Enological - Granule") in winemaking for wines of the same variety has been extensively demonstrated, but their combination with different SEGs varieties and micro-oxygenation (MOX) remains unstudied. In this study, Tempranillo wines were in contact along 35 days with two doses of Tempranillo and Cabernet Sauvignon SEGs (12 and 24 g/L) and two fixed doses of MOX (LOTR, 6.24 mg/L·month, and HOTR, 11.91 mg/L·month). Chemical composition and sensory profiles were analyzed after SEGs-MOX treatments. Results indicated a greater impact of MOX on volatile composition when Cabernet Sauvignon SEGs were used, with similar results for CS12-HOTR and CS24-LOTR wines. Phenolic compounds showed a total concentration decrease in all treated wines, though trans-resveratrol increased in all cases, particularly with the highest MOX dose. In sensory evaluation, MOX accelerated the integration of characteristic SEGs aromas into the wine, reducing the required bottle time for round them.

Effect of eugenol and guaiacol application on tomato aroma composition determined by headspace stir bar sorptive extraction.

BACKGROUND: The present work was carried out because there is only a small amount of literature on how the volatile composition of tomatoes can be modified by the effect of exogenous substances in contact with tomato plants. This work studies how eugenol and guaiacol, either by foliar application and/or in the surrounding atmosphere, can affect the volatile composition of this fruit. An important work of this study was also conduced to validate the analytical method [headspace stir bar sorptive extraction-gas chromatography-mass spectrometry (HS-SBSE-GC-MS)] to determine the composition of the volatiles in tomato. RESULTS: Analytical method validation parameters such as linearity, limit of detection, limit of quantification, and recovery proved that this method is suitable for the analysis of tomato volatiles. Their eugenol and guaiacol content changed, with an increase of 200 and 35 times, respectively, when foliar treatment was used, and an increase of 10, in both cases, when plants were in contact with the contaminated atmosphere. As consequence of the treatments other volatile compounds changed considerably. CONCLUSION: For first time, a HS-SBSE-GC-MS method was successfully validated for the study of volatiles in tomatos. Results suggests that exogenous compounds in contact with the plants, such as eugenol and guaiacol, can be absorbed changing the global volatile composition of fruits, which could produce a negative or positive effect in their aroma.

Development of a New Strategy for Studying the Oxygen Consumption Potential of Wine through the Grape Extract Evaluation.

The development of a method to determine the aging potential of wine at the time of harvest, through the evaluation of its oxygen avidity, is a potential tool for the winemaking sector. To this end, it is necessary to formulate a potential wine with this grape prior to alcoholic fermentation. The main objective of this method was to optimize a formulation of the potential wine, based on the grape extracts (GEs), to subsequently evaluate its oxygen consumption kinetics, guaranteeing maximum differentiation between the different GEs. The optimization was carried out with a Taguchi orthogonal matrix design, which optimized the variables to be used in the GE reconstitution. The variables studied were pH, Fe2+, Cu2+, Mn2+, alcohol content and acetaldehyde. The evaluation of the characteristic parameters of the consumption kinetics of each of the GEs allowed us to know the different reconstitution conditions that most influence the differentiation of the oxygen consumption kinetics of very similar GEs. The reconstitution conditions chosen were pH 3.3; 1 mg/L Fe2+; 0.1 mg/L Cu2+; 1 mg/L Mn2+; 12% (v/v) alcoholic strength and 10 mg/L acetaldehyde, with pH, Fe2+ and Mn2+ being the significant conditions. The kinetics of reconstituted GE could be a tool for the classification and evaluation of grapes according to their aging potential or shelf life of the wine made.

Air saturation methodology proposal for the analysis of wine oxygen consumption kinetics.

The great heterogeneity currently present when characterizing wine consumption kinetics means that a saturation method, as well as different parameters that allow comparison between wines, need to be established. The aim of this work was to establish a robust method for a wine saturation protocol and compare different fitting models to approximate the oxygen consumption kinetics. To differentiate wines, parameters extracted from the oxygen consumption curves were studied and proposed. 72 young commercial wines (red, white and rosé) from different Spanish appellations of origin, varieties and vintages were used. The results revealed that 5 min was enough to saturate wines up to the maximum level for each one at 35 °C. The inverse curve fitting model showed the best results for all wines. Oxygen at half consumption time (Omid) and time required to consume from 90% to 10% of the oxygen initially available (ΔtO_90_10) were the parameters that differentiated wines the most.

Effect of size, seasoning and toasting level of Quercus pyrenaica Willd. wood on wine phenolic composition during maturation process with micro-oxygenation.

Seasoning and toasting treatments carried out in cooperage influence the chemical composition of the oak, and these treatments affect different oak species in different ways. For this reason, numerous studies have focused on the evaluation of both the oak wood materials and the resulting aged wines in order to optimize the different cooperage processes. Seasoning involves immobilizing the wood for long periods of time, leading to an increase in the price of the final product. When using alternative products instead of barrels, in addition to the seasoning and toasting of the wood, the size of the wood pieces is a determining factor in the characteristics of the final wine. Therefore, the objective of this work was to evaluate the polyphenolic composition of the same red wine aged with different alternative products and a small amount of oxygen for 120 days. Specifically, the effect of 2 types of seasoning and 3 types of toasting of chips and staves made from the wood of Q. pyrenaica Willd. was studied. The results showed that the size of the alternative product was the factor that determines the phenolic composition of the wines over the entire ageing process, independent of the seasoning or toasting method carried out on the wood.

Volatile composition and sensory characteristics of Carménère wines macerating with Colombian (Quercus humboldtii) oak chips compared to wines macerated with American (Q. alba) and European (Q. petraea) oak chips.

Different oak species or origins have been studied to find an alternative to traditional ones and Quercus humboldtii from Colombia is a candidate. Some studies analyse the composition of this oak, but no work has been found to study its use for wine treatment. The aim was to evaluate volatile composition of toasted Q. humboldtii oak chips and the wines treated with these chips. To evaluate its oenological potential Q. alba and Q. petraea have been included in this trial. The wines were subjected to a sensory analysis. Results indicated that oak chips and wines macerated for 90 days with toasted Colombian chips exhibited higher 5-methylfurfural, guaiacol, trans-isoeugenol and syringol concentrations than others, while the furfural and cis-ß-methyl-γ-octalactone content was lower. Sensory analysis showed that the wines treated with Colombian oak presented more notes of smoked and less of coconut. Therefore, this oak could probably be considered suitable for ageing.

Foliar nitrogen application in Cabernet Sauvignon vines: Effects on wine flavonoid and amino acid content.

Wine quality greatly depends on its chemical composition. Among the most important wine chemical compounds, flavonoids are the major contributors to wine organoleptic properties while amino acids have a huge impact on fermentation development and wine volatile profile. Likewise, nitrogen applications are known to have an impact on wine composition. Therefore, the aim of this work was to study the effects of foliar nitrogen applications on wine flavonoid and amino acid composition. The experiment involved five foliar nitrogen applications at veraison time: urea (Ur), urea plus sulphur (Ur+S), arginine (Arg), and two commercial fertilizers Nutrimyr Thiols (NT) and Basfoliar Algae (BA). The results showed that nitrogen foliar treatments decreased wine flavonoid content although the effect varied according to each treatment. This could be related to a low vine nitrogen requirement, since must yeast assimilable nitrogen (YAN) was above acceptable threshold values for all samples. With regard to wine amino acid content, all treatments except for Ur increased its values after the applications. Finally, foliar nitrogen treatments greatly influenced wine composition. Among them, urea seemed to exert the most negative effect on both phenolics and amino acids. In addition, an inverse relationship between wine amino acid content and flavonol concentration was exhibited.

On-line monitoring of oxygen as a method to qualify the oxygen consumption rate of wines.

Measuring the oxygen content during winemaking and bottle storage has become increasingly popular due to its impact on the sensory quality and longevity of wines. Nevertheless, only a few attempts to describe the kinetics of oxygen consumption based on the chemical composition of wines have been published. Therefore, this study proposes firstly a new fitting approach describing oxygen consuming kinetics and secondly the use of an Artificial Neural Network approach to describe and compare the oxygen avidity of wines according to their basic chemical composition (i.e. the content of ethanol, titratable acidity, total sulfur dioxide, total phenolics, iron and copper). The results showed no significant differences in the oxygen consumption rate between white and red wines, and allowed the sorting of the wines studied according to their oxygen consumption rate.

An Approach to the Study of the Interactions between Ellagitannins and Oxygen during Oak Wood Aging.

During the aging of red wine in oak wood barrels, or in alternative aging systems, interactions between the compounds released from wood, the compounds of the wine, and oxygen can take place. The main objective of the present work was to study oxygen-ellagitannin interactions by monitoring their levels in three model systems, all containing the same amounts of French oak chips and differing only in the oxygen content: total absence, only the oxygen released from the chips, and air-saturated (model systems F, OW, and OS, respectively). This study has highlighted the influence of oxygen in the ellagitannins' evolution and the relevance of the oxygen trapped into the oak chips, reporting for the first time the kinetics of oxygen release to the model wine. Furthermore, the indirect contribution of oxygen to the ellagitannins' disappearance by boosting autoxidative reactions has also been pointed out. Vescalagin seems to be the ellagitannin most affected by the initial oxygen levels.

Glycosidic aroma precursors of Syrah and Chardonnay grapes after an oak extract application to the grapevines.

Syrah and Chardonnay grapevines were treated with an oak extract in order to determine the effect on glycosidic aroma precursors. Grapevines were treated at three different timings of the veraison (treatment 1, 2 and 3). Aglycons were obtained by enzymatic hydrolysis, and these were identified and quantified by means of gas chromatography-mass spectrometry (GC-MS). Results suggest that after the applications the majority of compounds from the oak extract were assimilated and stored as glycosidic forms in both cultivars. Also, other compounds not present in the extract were affected, with a different behaviour observed depending on the timing of application and the variety. In general, C6 compounds, alcohols, terpenes, phenols and C13-norisoprenoids in Syrah showed a decrease and in Chardonnay an increase. Thus, this study proved a change in the glycosidic aroma profile in grapes after the oak application, so these treated grapes could produce wines with different aromatic quality.

Volatile compounds formation in alcoholic fermentation from grapes collected at 2 maturation stages: influence of nitrogen compounds and grape variety.

The aim of this work was to study the influence of nitrogen compounds on the formation of volatile compounds during the alcoholic fermentation carried out with 4 nonaromatic grape varieties collected at 2 different maturation stages. To do this, Monastrell, Merlot, Syrah, and Petit Verdot grapes were collected 1 wk before harvest and at harvest. Then, the musts were inoculated with the same Saccharomyces cerevisiae yeast strain and were fermented in the same winemaking conditions. Amino acids that showed the highest and the lowest concentration in the must were the same, regardless of the grape variety and maturation stage. Moreover, the consumption of amino acids during the fermentation increased with their concentration in the must. The formation of volatile compounds was not nitrogen composition dependent. However, the concentration of amino acids in the must from grapes collected 1 wk before harvest can be used as a parameter to estimate the concentration of esters in wines from grapes collected at harvest and therefore to have more information to know the grape oenological capacity. Application of principal components analysis (PCA) confirmed the possibility to estimate the concentration of esters in the wines with the concentration of nitrogen compounds in the must.