Low consistency refined ligno-cellulose microfibre: an MFC alternative for high bulk, tear and tensile mechanical pulp papers.

Low consistency (LC) refining of (chemi-)thermomechanical pulp (TMP) provides an energy efficient alternative to high consistency refining for pulp property development. However, the benefit of LC refining is often limited by excessive fibre shortening, lower tear strength and a reduction of bulk caused by the refining process. In this study, microfibres produced by LC refining of TMP and kraft pulp fibres were investigated for their reinforcement potential in high freeness mechanical pulp. Primary pulp at 645 mL Canadian Standard Freeness was LC refined to different energy targets as a baseline for mechanical and optical property development. In contrast, the same primary pulp was reinforced with different microfibre types in ratios that yielded the same specific energies of the baseline LC refined pulp. The study revealed that at equivalent energies, the addition of TMP microfibres to the high freeness primary pulp displayed tensile development identical to the LC refined pulp, with significantly improved tear and bulk. The addition of kraft microfibre to primary pulp produced the highest tensile and tear strength but compromised light scattering. Additionally, all microfibre composites showed improved elongation, as opposed to no notable change in elongation with conventional LC refining. This investigation proposes an alternative, cost-effective approach for developing high bulk, high strength mechanical pulp by limiting the extent of second stage refining and using LC refined microfibres for pulp reinforcement. The high tear-high bulk open construction of the composite paper is likely to benefit boxboard and packaging applications.

Recycling Paper-Plastic laminate coffee cups using a Single-Disk Refiner: Energy requirements and recovered fiber quality.

Over 64 billion paper-plastic laminate (PPL) coffee cups are consumed between the United States and Canada annually, the majority accumulating in landfills due to a hydrophobic plastic inner-lining. Recycling can mitigate environmental damage and provide economic value from repurposed products. We found that standard repulping methods were insufficient to separate fiber from plastic due to the low intensity of treatment. To increase process intensity, we mechanically refined shredded PPL coffee cups and Kraft eucalyptus sheets (control) at 2%, 3%, and 4% consistencies with three passes to determine the energy required to separate fibers from plastic and the effects on fiber quality. 2% and 3% consistency PPL cups measured under 40 kWh/tonne of input material for one refiner pass and âˆ¼ 80 kWh/tonne for 4% consistency PPL cups. Recovered fiber fraction totaled 87.7%, 85.3%, and 80.5% of input mass of Kraft eucalyptus and 72.3%, 72.6%, and 79.6% of input mass of PPL cups at 2%, 3%, and 4% consistency, respectively. Fines content of PPL cups jumped from 8% pre-refining to âˆ¼ 30% post-refining while Kraft eucalyptus fibers were unaffected, suggesting that breaking the plastic-fiber bonds results in fines generation. Mean fiber length of PPL cups slightly decreased with consistency and tensile strength improved. Freeness decreased with consistency only in PPL cup samples. These results demonstrate a low energy requirement to effectively separate fiber and plastics in PPL cups as well as minimal impact on fiber quality using existing refining technology, and provides an estimate of the financial costs of local recycling efforts.

Application of human haploid cell genetic screening model in identifying the genes required for resistance to environmental toxicants: Chlorpyrifos as a case study.

INTRODUCTION: High-throughput loss-of-function genetic screening tools in yeast or other model systems except in mammalian cells have been implemented to study human susceptibility to chemical toxicity. Here, we employed a newly developed human haploid cell (KBM7)-based mutagenic screening model (KBM7-mu cells) and examined its applicability in identifying genes whose absence allows cells to survive and proliferate in the presence of chemicals. METHODS: KBM7-mu cells were exposed to 200 µM Chlorpyrifos (CPF), a widely used organophosphate pesticide, a dose causing approximately 50% death of cells after 48h of treatment. After a 2-3 week period of continuous CPF exposure, survived single cell colonies were recovered and used for further analysis. DNA isolated from these cells was amplified using Splinkerette PCR with specific designed primers, and sequenced to determine the genomic locations with virus insertion and identify genes affected by the insertion. Quantitative realtime reverse transcription PCR (qRT-PCR) was used to confirm the knockdown of transcription of identified target genes. RESULTS: We identified total 9 human genes in which the cells carrying these genes conferred the resistance to CPF, including AGPAT6, AIG1, ATP8B2, BIK, DCAF12, FNBP4, LAT2, MZF1-AS1 and PPTC7. MZF1-AS1 is an antisense RNA and not included in the further analysis. qRT-PCR results showed that the expression of 6 genes was either significantly reduced or completely lost. There were no changes in the expression of DCAF12 and AGPAT6 genes between the KBM7-mu and the control KBM7 cells. DISCUSSION: The KBM7-mu genetic screening system can be modified and applied to identify novel susceptibility genes in response to environmental toxicants, which could provide valuable insights into potential mechanisms of toxicity.

Intestinal absorption and metabolism of retinoyl beta-glucuronide in humans, and of 15-[14C]-retinoyl beta-glucuronide in rats of different vitamin A status.

In order to prove the hypothesis that humans and animals with adequate vitamin A status do not absorb and metabolize orally administered all-trans retinoyl beta-glucuronide, unlabeled retinoyl glucuronide (0.1 mmol) was orally dosed to fasting well-nourished young men. Neither retinoyl glucuronide nor retinoic acid, a possible metabolite, appeared in the blood within 12 h after ingestion. Next, radiolabeled all-trans 15-[14C]-retinoyl beta-glucuronide was chemically synthesized by a new procedure, and fed orally to rats of different vitamin A status. Analysis of blood and other tissues 5 or 24 h after the dose, showed the presence of radioactivity ( approximately 0.5%) in the blood of vitamin A deficient rats, but not in sufficient rats. Livers of all rats contained small, but detectable amounts (0.3 to 1.1% of the dose) of radioactivity. The accumulation of radioactivity in the liver was highest in deficient rats. Analysis of the retinoids showed that the radioactivity in serum and liver was due to retinoic acid formed from retinoyl glucuronide. Within 24 h after the dose, 31 to 40% of the administered radioactivity was excreted in the feces, and 2 to 4.7% of the dose was excreted in the urine. Results of the present studies show that oral administration of retinoyl beta-glucuronide did not give rise to detectable changes in blood retinoyl glucuronide and/or retinoic acid concentrations in humans or rats with adequate vitamin A status.

Effects of subcutaneously injected graded doses of all-trans retinoic acid and all-trans retinoyl beta-glucuronide on the outcome of pregnancy in Sprague-Dawley rats.

The effects of single subcutaneous injections (s.c.) of graded doses (20, 40, 80, 160, 320, and 480 mumol/kg body weight (BW) of all-trans retinoic acid (RA) and all-trans retinoyl beta-glucuronide (RAG) on day 8.5 of gestation on the outcome of pregnancy in Sprague-Dawley rats was studied. At dose levels of 20, 40, and 80 mumol/kg BW, neither RA nor RAG showed any adverse maternal or fetal effects. However, at dose levels of 160, 320, and 480 mumol/kg, RA was found to be much more toxic than RAG to both mother and fetus. Fetuses of animals receiving a 160 mumol/kg BW dose of RA were significantly reduced in weight and length, while animals receiving the same dose of RAG had fetuses of normal size. RA doses of 320 and 480 mumol/kg BW resulted in symptoms of maternal toxicity and even death. In contrast, RAG at these high levels produced no signs of maternal toxicity. RAG doses of 320 and 480 mumol/kg BW were also less toxic to fetuses. RA doses of 320 mumol/kg BW resulted in only 8% live births, while animals treated with an equivalent amount of RAG experienced 95% live births. Animals receiving a dose of 480 mumol/kg BW of RA had no live births, but similar doses of RAG resulted in 28% live births and pups of normal size.

Elevation of retinyl ester level in the lungs of rats following repeated intraperitoneal injections of retinoic acid or retinoyl glucuronide.

Retinoic acid (RA) is involved in the development of both the conducting airway and alveolar portions of the lung. RA plays a key role in the induction of the formation of alveolar septa. Retinoyl beta-glucuronide (RAG), an endogenous retinoid, acts like RA, but is much less cytotoxic. We examined the effect of daily intraperitoneal doses of RA and RAG (1.66 micromol/kg) in dimethyl sulfoxide (DMSO) and cotton seed oil on the stores of retinol and retinyl ester (RE) in the lung of rats. In two separate experiments, one involving normal rats, and the other involving elastase-treated rats, there was up to a 9-fold increase in REs content in the lungs of rats that received RA or RAG for 12 days as compared to Control rats. The accumulation was most profound when RA was injected in DMSO and least when RAG was injected in cotton seed oil. The reason for the accumulation of REs in the lung is not clearly known.

Comparative histologic effects of daily topical application of creams containing all-trans-retinoic acid or all-trans-retinoyl beta-glucuronide on pig skin.

The efficacy of all-trans-retinoic acid (tRA) and all-trans-retinoyl beta-glucuronide (RAG), a water-soluble metabolite of vitamin A, in the topical treatment of acne is comparable. However, whereas 3.3 mM tRA shows side effects, 3.3 mM RAG does not. To assess the relative toxic and histologic effects (dermal and epidermal changes) of long-term (24-week) daily applications of tRA and RAG on the skin, separate skin patches were measured and marked dorsally on the skin of six 21-day-old, castrated male pigs. Each skin patch area was treated daily with a cream formulation containing either 3.3 mM RAG, 16.5 mM RAG, 33 mM RAG, 3.3 mM tRA, 16.5 mM tRA or blank cream. To serve as controls, one patch received no treatment, one patch received blank cream only and for 5.3 weeks one 'washed' patch was given daily application of 33 mM RAG with routine cleansing using a mild soap typical of skin care. The amount of cream used per square centimeter remained the same during the course of the study. Biopsy tissue was collected at -1, 0, 2, 4, 8, 12 and 24 weeks from 7 test patches. The 'washed' patch was biopsied once at the 5.3-week mark. Topically applied RAG cream (3.3 mM) resulted in significantly lower histologic scores when compared with scores from tissue treated with an equimolar concentration of tRA. The highest concentration of RAG tested (33.3 mM) resulted in a response comparable to that observed in the lowest tRA (3.3 mM) treated patch area. Daily cleansing of the test area receiving 33.3 mM RAG completely eliminated any clinical signs or negative histologic changes. In conclusion, long-term topical tRA treatment in young pigs, as in humans, showed dose-dependent adverse effects on the skin, whereas RAG treatment had significantly lower histologic changes and less irritation and/or inflammation.

Repeated intravenous doses of all-trans-retinoyl beta-D-glucuronide is not effective in the treatment of bacterial bronchopneumonia in lambs but is devoid of gross and acute toxicity.

BACKGROUND: All-trans-retinoyl beta-D-glucuronide, a water-soluble glucuronic acid conjugate of all-trans-retinoic acid, has demonstrated high biological activity and low toxicity in most in vitro and in vivo models. Since the reparative effects of retinoids on epithelium are well-known, our aim was to study the effect(s) of intravenously-administered all-trans-retinoyl beta-D-glucuronide in lambs with chronic bacterial bronchopneumonia. MATERIAL/METHODS: Two groups of lambs were inoculated intrabronchially with either pyrogen-free saline or Mannheimia haemolytica. Thirty-three days later, lambs were injected four times at five-day intervals with 2 mL of 116 mM all-trans-retinoyl beta-D-glucuronide (6.0-9.3 mmol/kg or 2.86-4.42 mg/kg animal body weight) in dimethyl sulfoxide, or dimethyl sulfoxide alone. Animal behavior and signs of clinical illness were logged daily. Lung and liver samples were assessed for histopathology, while serum and liver samples were extracted for retinoids and analyzed by reversed-phase gradient high-performance liquid chromatography. RESULTS: Repeated injections of highly concentrated all-trans-retinoyl beta-D-glucuronide did not cause changes in appetite, activity or other behaviors nor did it cause histologic lesions in liver and lung. However, it had no effect on resolution of lung lesions resultant of chronic Mannheimia haemolytica bronchopneumonia. CONCLUSIONS: Repeated intravenous administration of high amounts of all-trans-retinoyl beta-D-glucuronide to lambs did not elicit signs of gross or microscopic toxicity. However, administering all-trans-retinoyl beta-D-glucuronide too late in the progression of bacterial pneumonia is thought to be the main reason for its lack of effect in this model. A retinoid lactone derivative was detected in sheep serum and liver several days after treatment.