In Vitro Topical Delivery of Chlorhexidine to the Cornea: Enhancement Using Drug-Loaded Contact Lenses and ß-Cyclodextrin Complexation, and the Importance of Simulating Tear Irrigation.

Microbial keratitis is a severe, sight-threatening condition caused by various pathogens. Eyedrops are the standard delivery modality for treating these disorders; however, blinking reflex, elevated tear production, and nasolacrimal drainage eliminate much of the instilled dose within a few seconds. Therefore, eyedrops must be applied repeatedly for prolonged periods. The present study aimed to probe more effective ocular delivery of chlorhexidine based upon drug-loaded hydrogel contact lenses and ß-cyclodextrin (ß-CD), while also determining the effect of constant irrigation with simulated tear fluid (STF) in in vitro experiments. Chlorhexidine digluconate (as 0.2 and 2% solutions, ß-CD inclusion complexes, and loaded hydrogel contact lenses) were applied to enucleated porcine eyes as single or multiple 10 µL doses, or as drug-loaded contact lenses, with and without ß-CD. The corneas were then excised and drug-extracted quantified by high-performance liquid chromatography (HPLC). The effect of constant irrigation by STF was evaluated to test the effect of increased tear production on corneal delivery. Potential antimicrobial activity of the delivered drug was also assessed. Results showed that drug-loaded contact lenses delivered the greatest amount of chlorhexidine into the cornea over a 24 h period, while the eyedrop solution comparator delivered the least. The ß-CD significantly enhanced chlorhexidine delivery to the cornea from eyedrop solution, although contact lenses loaded with chlorhexidine-ß-CD failed to enhance delivery. ß-CD within the hydrogel matrix impeded drug release. Constant irrigation with STF significantly reduced the amount of drug delivered to the cornea in all cases. Chlorhexidine retained antimicrobial activity in all delivery methods. Hydrogel contact lenses loaded with chlorhexidine delivered significantly higher levels to the cornea compared to eyedrops, either multiple hourly doses or a single dose. They also offer reduced application, in particular, to a nonulcerated corneal infection. Finally, the importance of fully accounting for tear production in in vitro ocular delivery experiments was highlighted.

Crown Ethers: Novel Permeability Enhancers for Ocular Drug Delivery?

Crown ethers are cyclic molecules consisting of a ring containing several ether groups. The most common and important members of this series are 12-crown-4 (12C4), 15-crown-5 (15C5), and 18-crown-6 (18C6). These container molecules have the ability to sequester metal ions, and their complexes with drugs are able to traverse cell membranes. This study investigated 12C4, 15C5, and 18C6 for their ability to increase solubility of ocular drugs and enhance their penetration into the cornea. Phase solubility analysis determined crown ethers' ability to enhance the solubility of riboflavin, a drug used for the therapy of keratoconus, and these solutions were investigated for ocular drug permeation enhancing properties. Atomic absorption spectroscopy demonstrated crown ether solutions' ability to sequester Ca2+ from corneal epithelia, and crown ether mediated adsorption of riboflavin into the stroma was investigated. Induced corneal opacity studies assessed potential toxicity of crown ethers. Crown ethers enhanced riboflavin's aqueous solubility and its penetration into in vitro bovine corneas; the smaller sized crown ethers gave greatest enhancement. They were shown to sequester Ca2+ ions from corneal epithelia; doing so loosens cellular membrane tight junctions thus enhancing riboflavin penetration. Induced corneal opacity was similar to that afforded by benzalkonium chloride and less than is produced using polyaminocarboxylic acids. However, in vivo experiments performed in rats with 12C4 did not show any statistically significant permeability enhancement compared to enhancer-free formulation.

On the barrier properties of the cornea: a microscopy study of the penetration of fluorescently labeled nanoparticles, polymers, and sodium fluorescein.

Overcoming the natural defensive barrier functions of the eye remains one of the greatest challenges of ocular drug delivery. Cornea is a chemical and mechanical barrier preventing the passage of any foreign bodies including drugs into the eye, but the factors limiting penetration of permeants and nanoparticulate drug delivery systems through the cornea are still not fully understood. In this study, we investigate these barrier properties of the cornea using thiolated and PEGylated (750 and 5000 Da) nanoparticles, sodium fluorescein, and two linear polymers (dextran and polyethylene glycol). Experiments used intact bovine cornea in addition to bovine cornea de-epithelialized or tissues pretreated with cyclodextrin. It was shown that corneal epithelium is the major barrier for permeation; pretreatment of the cornea with ß-cyclodextrin provides higher permeation of low molecular weight compounds, such as sodium fluorescein, but does not enhance penetration of nanoparticles and larger molecules. Studying penetration of thiolated and PEGylated (750 and 5000 Da) nanoparticles into the de-epithelialized ocular tissue revealed that interactions between corneal surface and thiol groups of nanoparticles were more significant determinants of penetration than particle size (for the sizes used here). PEGylation with polyethylene glycol of a higher molecular weight (5000 Da) allows penetration of nanoparticles into the stroma, which proceeds gradually, after an initial 1 h lag phase.

Cyclodextrin-mediated enhancement of riboflavin solubility and corneal permeability.

Cyclodextrins are water-soluble cyclic oligosaccharides consisting of six, seven, and eight α-(1,4)-linked glucopyranose subunits. This study reports the use of different cyclodextrins in eye drop formulations to improve the aqueous solubility and corneal permeability of riboflavin. Riboflavin is a poorly soluble drug with a solubility up to 0.08 mg mL(-1) in deionized water. It is used as a drug topically administered to the eye to mediate UV-induced corneal cross-linking in the treatment of keratoconus. Aqueous solutions of ß-cyclodextrin (10-30 mg mL(-1)) can enhance the solubility of riboflavin up to 0.12-0.19 mg mL(-1), whereas the higher concentration of α-cyclodextrin (100 mg mL(-1)) achieved a lower level of enhancement of 0.11 mg mL(-1). The other oligosaccharides were found to be inefficient for this purpose. In vitro diffusion experiments performed with fresh and cryopreserved bovine cornea have demonstrated that ß-cyclodextrin enhances riboflavin permeability. The mechanism of this enhancement was examined through microscopic histological analysis of the cornea and is discussed in this paper.

Controlled in vitro delivery of voriconazole and diclofenac to the cornea using contact lenses for the treatment of Acanthamoeba keratitis.

Acanthamoeba keratitis is caused by a protozoal infection of the cornea, with 80% of cases involving the improper use of contact lenses. The infection causes intense pain and is potentially blinding. However, early diagnosis improves treatment efficacy and the chances of healing. Despite the apparent accessibility of the cornea, patients do not always respond well to current eye drop treatments largely due to rapid dose loss due to blinking and nasolacrimal drainage. Here, the topical drug delivery of voriconazole alone and in combination with diclofenac via drug-loaded contact lenses, were investigated in vitro. The contact lenses were applied onto excised porcine eyeballs and maintained at 32 °C under constant irrigation, with simulated tear fluid applied to mimic in vivo conditions. The drug delivered to the corneas was quantified by HPLC analysis. The system was further tested in terms of cytotoxicity and a scratch wound repopulation model, using resident cell types. Sustained drug delivery to the cornea was achieved and for voriconazole, the MIC against Acanthamoeba castellanii was attained alone and in combination with diclofenac. MTT and scratch wound data showed reasonable cell proliferation and wound repopulation at the drug doses used, supporting further development of the system to treat Acanthamoeba keratitis.

Penetration Enhancers in Ocular Drug Delivery.

There are more than 100 recognized disorders of the eye. This makes the development of advanced ocular formulations an important topic in pharmaceutical science. One of the ways to improve drug delivery to the eye is the use of penetration enhancers. These are defined as compounds capable of enhancing drug permeability across ocular membranes. This review paper provides an overview of anatomical and physiological features of the eye and discusses some common ophthalmological conditions and permeability of ocular membranes. The review also presents the analysis of literature on the use of penetration-enhancing compounds (cyclodextrins, chelating agents, crown ethers, bile acids and bile salts, cell-penetrating peptides, and other amphiphilic compounds) in ocular drug delivery, describing their properties and modes of action.

Enhancement in corneal permeability of riboflavin using calcium sequestering compounds.

Ethylenediaminetetraacetic acid, ethylenediamine-N,N'-disuccinic acid and ethylene glycol-bis(2-aminoethylether)-N,N,N',N'-tetraacetic acid are polyaminocarboxylic acids that are able to sequester metal ions. Calcium is implicated in maintenance of intercellular matrix, zonula occludens (tight junctions) and zonula adherens of epithelium and endothelium cells. Corneal epithelium is impervious to many aqueous formulations due to it being lipophilic, whereby transcellular drug transit is resisted, whilst tight junctions restrict access via the paracellular route. Research has shown that integrity of tight junctions breaks down through loss of Ca(2+) for endothelial and epithelial cells. This study investigates different Ca(2+) sequestering compounds and their effect on corneal permeability of riboflavin at physiological pH. Riboflavin is a topically administered ocular drug applied during UV-induced corneal cross-linking for the treatment of keratoconus.

Advances in ophthalmic drug delivery.

Various strategies for ocular drug delivery are considered; from basic formulation techniques for improving availability of drugs; viscosity enhancers and mucoadhesives aid drug retention and penetration enhancers promote drug transport into the eye. The use of drug-loaded contact lenses and ocular inserts allows drugs to be better placed where they are needed for more direct delivery. Developments in ocular implants gives a means to overcome the physical barriers that traditionally prevented effective treatment. Implant technologies are under development allowing long-term drug delivery from a single procedure, these devices allow posterior chamber diseases to be effectively treated. Future developments could bring artificial corneas to eliminate the need for donor tissue and one-off implantable drug depots lasting the patient's lifetime.

Hydrogen-bonded complexes and blends of poly(acrylic acid) and methylcellulose: nanoparticles and mucoadhesive films for ocular delivery of riboflavin.

Poly(acrylic acid) (PAA) and methylcellulose (MC) are able to form hydrogen-bonded interpolymer complexes (IPCs) in aqueous solutions. In this study, the complexation between PAA and MC is explored in dilute aqueous solutions under acidic conditions. The formation of stable nanoparticles is established, whose size and colloidal stability are greatly dependent on solution pH and polymers ratio in the mixture. Poly(acrylic acid) and methylcellulose are also used to prepare polymeric films by casting from aqueous solutions. It is established that uniform films can be prepared by casting from polymer mixture solutions at pH 3.4-4.5. At lower pHs (pH < 3.0) the films have inhomogeneous morphology resulting from strong interpolymer complexation and precipitation of polycomplexes, whereas at higher pHs (pH 8.3) the polymers form fully immiscible blends because of the lack of interpolymer hydrogen-bonding. The PAA/MC films cast at pH 4 are shown to be non-irritant to mucosal surfaces. These films provide a platform for ocular formulation of riboflavin, a drug used for corneal cross-linking in the treatment of keratoconus. An in vitro release of riboflavin as well as an in vivo retention of the films on corneal surfaces can be controlled by adjusting PAA/MC ratio in the formulations.