Use of wood-based materials in beef bedded manure packs: 1. Effect on ammonia, total reduced sulfide, and greenhouse gas concentrations.

The objectives of this study were to determine the effect of using corn stover or three different wood-based bedding materials (kiln-dried pine wood chips, dry cedar chips, or green cedar chips) on airborne concentrations of NH, total reduced sulfides (TRS), CO, CH, and NO above lab-scaled bedded manure packs. Four bedded packs of each bedding material were maintained for two 42-d periods. Airborne NH, TRS, CO, CH, and NO were measured weekly. Bedded packs containing dry or green cedar had lower concentrations of NH (350.8 and 357.3 mg m, respectively; < 0.05) than bedded packs containing pine chips or corn stover (466.0 and 516.7 mg m, respectively). Airborne CO was also lower from bedded packs containing dry and green cedar (1343.7 and 1232.3 mg m, respectively; < 0.001) compared with bedded packs containing pine chips or corn stover (2000.2 and 1659.8 mg m, respectively). Air samples from bedded packs containing green cedar chips had a higher ( < 0.01) concentration of CH than bedded packs containing dry cedar chips, corn stover, or pine chips at Day 35 and 42. Initially, TRS concentration was similar among all bedding materials; at 28 to 42 d, TRS was higher ( < 0.001) from bedded packs containing the cedar products. Airborne NO was similar ( = 0.51) for all bedding materials. Pine chips and cedar products can be adequate substitutes for corn stover in deep-bedded barns, but cedar bedding may need to be removed more frequently.

Impact of management practices and distillers' grains feeding on the prevalence of Escherichia coli O157 in feedlot cattle in Minnesota.

Escherichia coli O157 is a foodborne pathogen that can be transmitted by contaminated ground beef and is shed naturally in cattle feces. Recent reports indicated that feeding distillers' grains (DG) to cattle increased fecal shedding and prevalence of E. coli O157. In Minnesota, feeding DG with solubles (DGS) to livestock became widespread within the last 10 years, but there is no report about the prevalence of E. coli O157 in beef cattle in this state. This study was undertaken to survey the fecal prevalence of E. coli O157 in cattle fed diets containing DG and its association with environmental conditions and management practices. Fecal samples were collected from three feedlots during a 1-year period. All animals in those feedlots were fed different DGS levels. E. coli O157 presence was determined using a combination of enrichment, immunomagnetic separation, plating onto sorbitol MacConkey agar, and confirmation of isolates by immunoassay and multiplex virulence genes polymerase chain reaction analysis. Overall, E. coli O157 was confirmed in 9.7% of samples. Prevalence during summer was 30% and declined to less than 10% the rest of the year. In animals grouped by dietary DGS concentration, no significant difference in prevalence (12.0 and 5.5%) was detected between the low and the high average groups (less and more than 20%). Previous feeding of DGS before arriving to the feedlot also had no influence on fecal prevalence. The presence of several interacting variables, uncontrolled in a real-life feedlot environment, was the likely reason for our observation and suggested that at the levels studied, DGS had no effect on the STEC O157 prevalence in cattle populations.

Effects of replacing corn silage with alfalfa haylage in growing beef cattle diets on performance during the growing and finishing period.

Corn silage is the predominant mechanically harvested forage source for feedlot cattle production in the United States because of high yield. Alternatively, because of multiple cuttings per year and lower annual cost, the use of alfalfa or other forages, may increase opportunities for manure spreading, perennial soil cover, pollinator habitat, and greater carbon sequestration. The objective of this trial was to determine the feeding value of alfalfa haylage when replacing corn silage in growing cattle diets. One-hundred-sixty-five Angus crossbred steers [326 ±â€…51 kg of body weight (BW)] were blocked by initial BW and randomly assigned to one of 28 pens at the University of Minnesota feedlot. Pens were randomly assigned to dietary growing treatments. The control diet was comprised of (DM basis) 50% corn silage, 19.25% rolled corn grain, 19.25% high moisture corn, 7% dried distillers grains plus solubles, and 4.5% liquid supplement (corn silage control, CS Control). For alfalfa haylage (AH) diets, AH substituted corn silage at 33% (AH 33), 66% (AH 66), or 100% (AH 100). Growth performance measurements [dry matter intake (DMI), average daily gain (ADG) and gain to feed (G:F) ratio] were assessed for 42 to 70 d depending on BW block. Afterwards, steers were fed a common finishing diet until harvested. There was a linear increase in DMI (P < 0.01) with increasing AH inclusion. Replacing CS with AH linearly decreased (P ≤ 0.05) ADG and G:F. No differences (P ≥ 0.10) were observed in finishing performance or carcass traits. Results from this study demonstrated that greater substitution of corn silage with alfalfa haylage in growing diets resulted in greater intake but reduced rate of gain and gain:feed. Despite slower rate of gain, cattle fed alfalfa haylage at increasing proportions during the growing period were able to compensate in BW gains during the finishing period and reached harvest weight and backfat thickness at similar days on feed than those fed corn silage. Based on these results the energy value of corn silage and alfalfa haylage were 3.05 and 2.39 Mcal ME/kg of DM, respectively, when included at 50% of the diet DM.

The potential for growing systems in beef cattle operations depends on the development of cost-effective alternatives for adding value to cattle after weaning. Alfalfa provides several ecosystem services to beef operations through greater opportunities for manure spreading, longer soil cover, pollinator habitat, and greater carbon sequestration compared to corn silage, which is the predominant mechanically harvested forage source for intensive cattle production in the United States. Increasing alfalfa haylage use in growing beef cattle diets requires understanding the effects of replacing corn silage with alfalfa haylage on ADG and feed cost of gain and carcass quality. The objective of this study was to compare the feeding value of alfalfa haylage vs. that of corn silage in growing diets while examining carry-over effects on the finishing period in terms of animal performance and carcass traits.

Pooled analysis on the effects of inclusion, moisture, and oil removal from distillers grains on cattle performance and economic returns in diets with different corn processing.

A synthesis of data including over 9,300 head of cattle and over 980 pen means was conducted to evaluate the effect of corn processing method, distillers grains type, oil removal from distillers, and dietary distillers concentration on cattle performance and total feeding costs under different historical price scenarios. The corn processing method was either steam-flaked corn, high-moisture or dry-rolled corn or a blend of the latter two and their effects on performance with and without distillers grains. Wet, modified, and dry distillers were analyzed as either full fat or de-oiled products in diets at various dietary concentrations with either corn type to determine cattle performance. Performance estimates were used to determine the inclusion level that minimized total finishing costs ($/head) for each diet given various assumptions on corn price, corn-to-distillers price ratio, supplemental protein cost, and steam flake processing cost. Feeding distillers grains in steam-flaked or high-moisture and dry-rolled corn diets resulted in improved feed conversion and reduced cattle feeding costs, including lower supplemental protein costs and lower total feeding costs compared with a diet without distillers. However, feeding diets with steam-flaked corn improved feed conversion regardless of distillers type or level of inclusion. Feeding full fat distillers improved feed conversion relative to de-oiled distillers. Cattle fed de-oiled distillers were more efficient than those fed diets containing no distillers grains. At all corn price and corn-to-distillers price ratios examined, feeding some level of distillers of any type produced a lower total feeding costs relative to a diet without distillers. Different robustness tests were conducted to determine the impact of varying steam flake corn processing costs and the cost of supplemental protein on the optimal level of distillers inclusion level. The break-even cost a producer could pay for steam-flaking corn varied but was significantly higher when corn price was high. Feeding distillers grains in steam-flaked or high-moisture and dry-rolled corn diets resulted in improved feed efficiency, reduced cattle feeding costs, including replacement of other supplemental protein and associated costs compared to a diet without distillers grains.

A pooled analysis of research was conducted to evaluate the effect of corn processing method, distillers grains type, oil removal from distillers, and distillers inclusion on cattle performance within studies conducted at the University of Nebraska-Lincoln between 1992-2020. Two corn processing methods were included in the dataset, steam-flaked corn (SFC) or any combination of high-moisture (HMC) and dry-rolled corn (DRC), fed with and without distillers gains, a by-product of the dry milling ethanol industry. Distillers products were either wet, modified, or dry distillers grains plus solubles and were analyzed as both full fat and de-oiled products. Cattle performance resulting from feeding the six by-product combinations with both corn types was analyzed and then used to find the inclusion level that minimized the total feeding cost ($/head) given different corn prices and corn-to-distillers price ratios. Cattle had improved feed conversion when fed SFC compared with HMC:DRC in all diets. Cattle fed full-fat distillers grains had slightly improved feed conversions compared with de-oiled distillers grains. Cattle fed distillers grains diets had improved feed conversion compared with cattle fed control diets without distillers. Overall, feeding distillers grains in combination with either corn type offers benefits including improved feed conversions, lower finishing costs, and reduced reliance on supplemental protein sources compared to a diet without distillers.

Effect of inclusion of distillers grains with solubles and crude glycerin in beef cattle finishing diets on ruminal fermentation and fatty acid biohydrogenation.

An experiment was conducted to evaluate the impact of feeding bio-fuel co-products on ruminal fermentation characteristics and composition of omasal digesta flow. Four ruminally cannulated Holstein steers (371 ± 5 kg) were used in a 4 × 4 Latin Square design. Omasal sample collection and triple marker technique was used to quantify fatty acid omasal flow. Treatments were applied as a 2 × 2 factorial where a steam flaked corn (SFC) basal diet (DGS-N CG-N) was replaced with 40% of diet DM as corn distillers grains (DGS; DGS-Y CG-N) or 10% of diet DM as crude glycerin (DGS-N CG-Y) or 40% of diet DM distillers grains and 10% of diet DM as crude glycerin (DGS-Y CG-Y). No effects were observed for the interaction of DGS and glycerin on measured rumen characteristics. Dietary inclusion of glycerin decreased (P = 0.05) ruminal content 4-h post feeding on a DM basis but did not influence DMI (P = 0.64). Feeding DGS had no effect (P = 0.34) on particulate passage to the omasum (kg/d) in spite of greater (P = 0.04) DMI. Feeding DGS reduced flow rate (% of rumen volume/h) (P = 0.05) but did not affect total VFA concentration (P = 0.46) or average ruminal pH (P = 0.72). No differences (P > 0.05) were observed in ruminal parameters when feeding glycerin, besides ruminal particulate content (kg) on DM basis (P = 0.05). An interaction of DGS and glycerin affected intake of stearic (P < 0.01), linoleic (P < 0.01), and linolenic acid (P < 0.01). An interaction of DGS and glycerin did not affect individual fatty acid flow with respect to intake for stearic (P = 0.17), linoleic (P = 0.18), or linolenic acid (P = 0.66). Dietary inclusion of glycerin had no impact on g of linolenic (P = 0.16) or linoleic (P = 0.32) acid transformed. A trend was identified for cattle fed diets with glycerin to have increased (P = 0.07) grams of conjugated linoleic acid (CLA; C18:2 cis-9, trans-11) per gram of linoleic acid intake, with no impact on the percent of saturated fat (P = 0.44) or unsaturated fat (P = 0.43) in omasal flow. For cattle fed diets with DGS, fewer grams of linoleic (P < 0.01) and linolenic (P < 0.01) were present in digesta flow per gram of intake. Inclusion of DGS in the treatment diets also increased (P < 0.01) stearic acid flow (g) and CLA flow (g) per gram of stearic and linoleic acid intake, respectively. Observed differences in CLA proportion post fermentation may indicate interrupted biohydrogenation when glycerin is fed.

Inclusion of corn grain in cattle diets increases the dietary concentration of unsaturated fatty acids like linoleic acid. Ethanol co-products are most often made from corn grain in the United States and contain concentrated amounts of unsaturated fatty acids. Concerns with feeding ethanol co-products could arise for cattle producers because the increased unsaturated fat concentration of meat products can lead to shorter meat shelf life. Co-products from bio-diesel production, such as crude glycerin, can be used to replace grain and reduce total unsaturated fat without affecting dietary energy. This study evaluated the effect of ruminal microbes to transform unsaturated fatty acids to saturated fatty acids in diets where steam-flaked corn was replaced by co-products such as distillers grains and crude glycerin. When steam-flaked corn is replaced with distillers grains in beef cattle diets, the fat composition was shifted to a higher proportion of saturated fatty acids due to increased biohydrogenation by ruminal microbes. However, feeding crude glycerin in place of steam-flaked corn increased conjugated linoleic acid, an intermediate product of the fatty acid transformation pathway. Increased conjugated linoleic acid indicates glycerin may impact the ability of microbes to transform linoleic acid to a saturated form.

Effect of substitution of distillers grains and glycerin for steam-flaked corn in finishing cattle diets on growth performance and carcass characteristics.

An experiment was conducted to determine the effect of substituting modified corn distillers grains with solubles (DGS) or crude soy glycerin (CG) for steam-flaked corn (SFC) in finishing diets on growth performance and carcass characteristics. Treatments were arranged as a 2 × 2 factorial with DGS (0% or 40%) and CG (0% or 10%) replacing dietary SFC in a basal diet. Growth performance and carcass traits were measured on 48 individually fed crossbred yearling cattle (21 steers and 27 heifers; 380 ± 37 kg). Cattle were randomly allotted to 48 Calan gate bunks. After the first 28 days, nine animals were removed from the study for health reasons or observed confirmation of consumption of feed from unassigned Calan gate bunk (n = 39). After the feeding period, cattle were harvested in two groups on day-124 and day-173. No DGS × CG interactions were observed (P > 0.10) for any dependent growth performance or carcass characteristic variable tested. Cattle-fed DGS as 40% of diet dry matter (DM) had greater (P< 0.01) dry matter intake (DMI), while CG inclusion at 10% of diet DM did not affect DMI (P = 0.16). Carcass-adjusted average daily gain (ADG) was not affected by DGS (P = 0.73) or CG (P = 0.28). Decreased (P = 0.03) carcass-adjusted gain-to-feed (G:F) was observed as the main effect of DGS. Greater DMI resulting from feeding DGS as 40% of diet DM appears to have driven the tendency for reduced G:F. Hot carcass weight, longissimus muscle area, 12th rib fat depth, yield grade, and marbling score were not (P> 0.10) influenced by DGS or CG. However, kidney, pelvic, fat (KPH) was increased (P = 0.01) when cattle were fed DGS as 40% of diet DM. Based on the findings presented, it is concluded that CG can substitute up to 10% of SFC in the diet without negatively affecting cattle growth performance or carcass characteristics, regardless of DGS inclusion as 40% of the diet DM.

Livestock producers have an opportunity to improve sustainably through the utilization of co-products of the bio-fuel industry through cattle feeding. Crude glycerin, although less commonly fed compared to distillers grains, provides an opportunity for cattle feeders to increase the versatility of feed ingredient sources without compromising performance. The present study examined the effect of substituting modified corn distillers grains and crude soy glycerin for steam­flaked corn in beef cattle finishing diets on cattle growth performance and carcass characteristics. Growth performance was not influenced by treatment suggesting that crude glycerin and modified corn distillers grains in finishing diets were effective substitutions for steam­flaked corn when market price permits.

Influence of hay feeding method, supplement moisture, or access time on intake and waste by beef cows.

Experiments were performed to determine the effects of feeding method and hay processing (Experiment 1), energy supplement moisture content and feeding method (Experiment 2), and access time to hay (Experiment 3) on cow body weight (BW), dry matter intake (DMI), and hay or energy supplement intake and waste. Experiment 1 was designed as a 4 × 4 Latin Square using 48 multiparous, late-gestating, Angus cows (626 kg initial BW). Cows were stratified by age and BW into four treatment groups (n = 12 cows/group); treatment groups were then initially assigned randomly to treatments in a sequence of preset Latin Square periods. In Experiment 1, round bales were processed and delivered on the pen surface or in a bunk, or left unprocessed and delivered in a hay ring or rolled out on the pen surface. Experiment 2 was designed as a 6 × 6 Latin Square utilizing 54 multiparous, late-gestating, Angus cows (616 kg initial BW). Cows were stratified by age and BW into treatment groups (n = 9 cows/group); treatment groups were then initially assigned randomly to treatments in a sequence of preset Latin Square periods. In Experiment 2, corn screenings (CS) or wet beet pulp (BP) were fed in a structure (inverted tire or bunk) or BP only on the pen surface. Experiment 3 was designed as a replicated 3 × 3 Latin Square utilizing 24 multiparous, late-gestating, Angus cows (584 kg initial BW). Cows were stratified by age and BW into treatment groups (n = 8 cows/group); treatment groups were then initially assigned randomly to treatments in a sequence of preset Latin Square periods. In Experiment 3, cows were permitted access to round-bales in a hay ring for 6, 14, or 24 h. In Experiment 1, hay DMI was not affected (P ≥ 0.579). Hay waste was greater (P ≤ 0.007) when hay, processed or not, was fed on the pen surface. In Experiment 2, hay DMI was greatest (P ≤ 0.011) for cows fed no supplement and those fed CS in a bunk. Feeding BP in a bunk led to the greatest (P ≤ 0.003) hay waste. In Experiment 3, cows permitted 6-h access consumed and wasted less (P < 0.001) hay compared with those permitted longer access; BW was unaffected (P ≥ 0.870). In these experiments, cows fed hay on the pen surface, processed or not, achieved similar DMI as those fed in a ring or bunk, but wasted more hay. Delivering BP in a bunk or on the pen surface increased hay and supplement waste, respectively. Controlling access to hay reduced DMI and waste while maintaining cow BW.

Forage quality and beef cow preference is affected by wrap type of conventional and reduced-lignin alfalfa round bales stored outdoors.

Storing hay outdoors can result in detrimental changes in forage quality. Additionally, alfalfa (Medicago sativa L.) cultivar may influence dry matter intake (DMI) and hay waste when feeding livestock. The objectives were to determine the effects of conventional or reduced-lignin alfalfa round bales stored outdoors and wrapped with plastic twine, net wrap, or B-Wrap on forage quality, beef cow preference, and hay waste. Round bales made from reduced-lignin (n = 12) or conventional (n = 12) alfalfa cultivars were baled and stored outdoors for 16 mo. Within each cultivar, four bale replicates were bound with plastic twine, net wrap, or B-Wrap. After storage, bales were fed in a switchback design with period confounded with alfalfa cultivar to 18 lactating Angus cows (Bos Taurus L.). The pairs had ad libitum access to three round-bale feeders where bales of each wrap type were placed for eight 48 h periods. Position of round bale wrap type was rotated according to a Latin Square arrangement. Bales were weighed and waste surrounding each feeder was collected at 24 and 48 h to calculate DMI and hay waste. Statistical significance was set at P < 0.05. Alfalfa cultivar did not impact any of the response variables (P > 0.05). At feeding, round bales wrapped in net wrap had greater (P < 0.015) moisture content (16.4%) compared with those wrapped with B-Wrap (12.8%). Neutral detergent fiber was lower (P = 0.03) in bales wrapped in B-Wrap (46%) compared with twine-tied bales (49%) while net wrapped bales were not different. Total digestible nutrients (P = 0.02), and relative feed value (P = 0.04) were lower in twine-tied bales compared with B-Wrap while net wrapped bales were not different. Twine (7.1 × 106 colony forming units [CFU]/g) and net wrap (4.7 × 106 CFU/g) bales had greater (P < 0.0001) mold counts than B-Wrap bales (4.8 × 104 CFU/g), while concentrations of other forage components and yeast counts were not different among wrap types (P > 0.05). Total DMI, and DMI during the first 24 h, were greater (P ≤ 0.032) for B-Wrap bales compared to twine-tied bales indicating preference for hay wrapped in B-Wrap; net wrapped bales were not different. Dry matter intake in the first 24 h was negatively associated with the mold count (r = -0.52; P = 0.02), and hay waste was not affected by wrap type (P > 0.05). These results confirm that wrap type affected forage quality and mold counts, which in turn influenced beef cattle preference of round bales stored outdoors.

Effect of organic or inorganic trace mineral supplementation on follicular response, ovulation, and embryo production in superovulated Angus heifers.

We determined whether source of trace mineral supplementation prior to embryo collection affected embryo production and quality. Angus half-sibling heifers (n=20) originating from a common herd were assigned to three treatment groups using a 3 x 3 latin square design replicated in time (3 x) and space (6 x complete and 1x incomplete): (1) heifers received no added mineral to their diet (control; n=53); (2) heifers received a commercially available organic mineral supplement (organic; n=52); or (3) heifers received an all inorganic mineral supplement (inorganic; n=55). All heifers had ad libitum access to hay and were fed a supplement containing corn and soybean meal. Treatments were initiated 23 days prior to embryo recovery. Heifers were given a 45-day adaptation period of no mineral supplementation before initiating a new treatment. Ovarian structures were evaluated using transrectal ultrasonography to determine the presence and number of follicles and CL on each ovary. The mean number of recovered ova/embryos was similar among treatments (4.1+/-0.7, 3.8+/-0.7, and 3.3+/-0.7 for control, inorganic, and organic treatments, respectively), the number of unfertilized oocytes was greater (P<0.05) for inorganic (2.3+/-0.5) and control (1.6+/-0.5) treated heifers than organic (0.4+/-0.4) treated heifers. No differences among treatments existed for the number of degenerate or transferable embryos, but individual heifer influenced the total number of embryos/ova, unfertilized ova, and transferable embryos recovered. We conclude that heifer accounted for the greatest differences in embryo production and quality. Source of trace mineral supplementation did not significantly alter embryo number or quality in superovulated purebred Angus heifers fed a well-balanced diet, meeting all trace mineral requirements.