Investigation and comparison of the transfer of TSNA from tobacco to cigarette mainstream smoke and to the aerosol of a heated tobacco product, THS2.2.

Tobacco-specific nitrosamines (TSNA) levels in tobacco cut filler and cigarette smoke were measured in more than 1000 commercially available cigarettes sampled between 2008 and 2014. Relative contributions to their transfer from tobacco to the mainstream smoke in terms of direct transfer by distillation, pyrorelease, and pyrosynthesis were evaluated on the basis of the comparison with the transfer of nicotine from tobacco to smoke. N'-nitrosonornicotine (NNN) was transferred essentially by distillation, while N'-nitrosoanatabine (NAT), 4-(methylnitrosamino)-1-(3-bipyridyl)-1-butanone (NNK) and N'-nitrosoanabasine (NAB) were transferred by pyrorelease or pyrosynthesis as well. In the case of the Tobacco Heating System 2.2, the transfer of nicotine from tobacco to the aerosol was similar to that observed for cigarettes, while the % transfer of TSNAs from tobacco to THS 2.2 aerosol was 2-3 times lower than in cigarettes. This difference is due to the fact that the tobacco is heated instead of burnt resulting in a lower direct transfer by distillation and a lower if any contribution of pyrosynthesis or pyrorelease.

Evaluation of the Tobacco Heating System 2.2. Part 3: Influence of the tobacco blend on the formation of harmful and potentially harmful constituents of the Tobacco Heating System 2.2 aerosol.

The Tobacco Heating System (THS2.2), which uses "heat-not-burn" technology, generates an aerosol from tobacco heated to a lower temperature than occurs when smoking a combustible cigarette. The concentrations of harmful and potentially harmful constituents (HPHCs) are significantly lower in THS2.2 mainstream aerosol than in smoke produced by combustible cigarettes. Different tobacco types and 43 tobacco blends were investigated to determine how the blend impacted the overall reductions of HPHCs in the THS2.2 mainstream aerosol. The blend composition had minimal effects on the yields of most HPHCs in the aerosol. Blends containing high proportions of nitrogen-rich tobacco, e.g., air-cured, and some Oriental tobaccos, produced higher acetamide, acrylamide, ammonia, and nitrogen oxide yields than did other blends. Most HPHCs were found to be released mainly through the distillation of HPHCs present in the tobacco plug or after being produced in simple thermal reactions. HPHC concentrations in the THS2.2 aerosol may therefore be further minimized by limiting the use of flue- and fire-cured tobaccos which may be contaminated by HPHCs during the curing process and carefully selecting nitrogen rich tobaccos with low concentrations of endogenous HPHCs for use in the tobacco plug blend.