Rapid profiling of antimicrobial compounds characterising B. subtilis TR50 cell-free filtrate by high-performance liquid chromatography coupled to high-resolution Orbitrap™ mass spectrometry.

RATIONALE: Several Bacillus strains, typically isolated from different food sources, represent renowned producers of a multitude of low and high molecular weight compounds, including lipopeptides and macrolactones, with an importance for their antimicrobial activity. The high homology shared by many of these compounds also occurring as closely related isoforms poses a challenge in their prompt detection. METHODS: Identification and structural elucidation is generally achieved by matrix-assisted laser desorption/ionization (MALDI) or liquid chromatography (LC) coupled to mass spectrometry (MS) after a pre-fractionation and/or purification step of the extract. In this paper we report the application of a method based on LC separation and high-resolution Orbitrap™-based MS for the rapid screening of raw filtrate of the strain Bacillus subtilis TR50 endowed with antimicrobial activity, without requiring any sample pre-treatment. RESULTS: Upon direct analysis of the cell-free filtrate of Bacillus subtilis TR50 by high-resolution mass spectrometry (HRMS), different compounds families, that proved to exert a remarked antimicrobial activity against several foodborne pathogens, can be readily displayed along the chromatographic run. Among them, three different classes were identified and characterized belonging to the iturin, fengycin and surfactin groups. The high resolving power and accurate mass accuracy provided by the HRMS system in use ensured an enhanced selectivity compared to other mass spectrometers. In addition, after activation of the HCD cell, the HR-MS/MS spectra can provide insights in the structural elucidation of several compounds. CONCLUSIONS: The acquisition of HRMS spectra of raw filtrates of subtilis strains allows untargeted analysis of the major classes of compounds produced to be performed, thus facilitating identification of other unknown bioactive molecules after retrospective analysis. These features make this approach a fast tool applicable to the rapid screening and further identification of antimicrobial compounds released by Bacillus strains in raw filtrates.

Rapid and label-free detection of egg allergen traces in wines by surface plasmon resonance biosensor.

The development of a surface plasmon resonance (SPR)-based biosensor tailored to the fast detection of egg-related fining allergens in wines is herein described. Ovalbumin (OVA) was chosen as the target protein to be monitored due to its highest abundance in the egg white powder, a typical fining agent used by the winery industry to promote wine clarification. A direct assay was designed, basing on the use of polyclonal anti-OVA antibody as bio-specific receptor. With the aim of optimizing the assay conditions, different parameters able to influence the final biosensor response were carefully investigated (i.e., pH, ionic strength, and additional surfactant concentration). After the fine tuning of these parameters, the assay was tested in the direct analysis of OVA in commercial wines artificially contaminated with egg white powder at different concentration levels in order to assess the reliability of the biosensor in detecting traces of OVA in complex matrices. The devised assay allowed to trace, in a short analysis time and with a minimal sample pre-treatment required, the presence of egg allergens at the lowest concentration comprised between 0.03 and 0.2 µg/mL. Finally, the response provided by the developed biosensor was correlated with an established liquid chromatography mass spectrometry (LC-MS) method developed in our laboratories, and performances of both approaches were assessed for the fast monitoring of egg allergen contamination in fined wines.

Pepsin-digested bovine lactoferrin prevents Mozzarella cheese blue discoloration caused by Pseudomonas fluorescens.

The aim of this work was to check the efficacy of bovine lactoferrin hydrolyzed by pepsin (LFH) to prevent blue discoloration of Mozzarella cheese delaying the growth of the related spoilage bacteria. Among 64 Pseudomonas fluorescens strains, isolated from 105 Mozzarella samples, only ten developed blue discoloration in cold-stored Mozzarella cheese slices. When Mozzarella cheese samples from dairy were treated with LFH and inoculated with a selected P. fluorescens strain, no pigmentation and changes in casein profiles were found up to 14 days of cold storage. In addition, starting from day 5, the count of P. fluorescens spoiling strain was steadily ca. one log cycle lower than that of LFH-free samples. ESI-Orbitrap-based mass spectrometry analyses allowed to reveal the pigment leucoindigoidine only in the blue LFH-free cheese samples indicating that this compound could be considered a chemical marker of this alteration. For the first time, an innovative mild approach, based on the antimicrobial activity of milk protein hydrolysates, for counteracting blue Mozzarella event and controlling psychrotrophic pigmenting pseudomonads, is here reported.

Toxic mechanisms induced by fumonisin b1 mycotoxin on human intestinal cell line.

The gastrointestinal tract is the main target of exposure to mycotoxin fumonisin B1 (FB1), common natural contaminant in food. Previous studies reported that proliferating cells are more sensitive than confluent cells to the toxic effect of FB1. This study aims to investigate, by dose- and time-dependent experiments on human colon proliferating intestinal cell line (HT-29), the modifications induced by FB1 at concentrations ranging from 0.25 to 69 µM. The choice of highest FB1 concentration considered the low toxicity previously reported on intestinal cell lines, whereas the lowest one corresponded to the lower FBs levels permitted by European Commission Regulation. Different functional parameters were tested such as cell proliferation, oxidative status, immunomodulatory effect and changes in membrane microviscosity. In addition FB1-FITC localization in this cell line was assessed by using confocal laser scanning microscopy. Lipid peroxidation induction was the main and early (12 h) effect induced by FB1 at concentrations ranging from 0.5 to 69 µM, followed by inhibition of cell proliferation (up to 8.6 µM), the immunomodulatory effect (up to 17.2 µM), by assessing IL-8 secretion, and increase in membrane microviscosity (up to 34.5 µM). The toxic effects observed in different functional parameters were not dose-dependent and could be the consequence of the FB1 intracytoplasmatic localization as confirmed by confocal microscopy results. The different timescales and concentrations active of different functional parameters could suggest different cellular targets of FB1.

Assessment of Mycotoxin Exposure in Côte d'ivoire (Ivory Coast) Through Multi-Biomarker Analysis and Possible Correlation with Food Consumption Patterns.

SCOPE: The aim of the presented study was to investigate the mycotoxin exposure of Ivorian population related to the consumption patterns of maize, peanuts, millet, and cassava product (attiéké). MATERIALS AND METHODS: Maize flour samples (n = 51) were purchased from all Abidjan local markets, in the south of Ivory Coast, and urine (n = 99) was collected during the same reference period (July-September 2011) from volunteers living in Abidjan and Daloa cities. Reversed-phase liquid chromatography coupled with electrospray ionization triple quadrupole mass spectrometry (LC-ESI-MS/MS) was used to analyze aflatoxins (AFB1, AFB2, AFG1, and AFG2), ochratoxin A (OTA), fumonisins (FB1, FB2), deoxynivalenol (DON), zearalenone (ZEA), and T-2 and HT-2 toxins in maize flour samples, and their relevant biomarkers (AFM1, DON, DON + de-epoxydeoxynivalenol (DOM-1), FB1, α-zearalenol (ZOL), ß-ZOL, and OTA) in urine samples. RESULTS: Critical maize contamination was observed by AFs occurrence (total AFs 4.5 - 330.0 µg/kg) while OTA was found in 13% of samples analyzed. AFM1 was detected in 40% of urines samples (0.06 - 14.11 ng/ml), OTA in 37% (0.01 - 0.42 ng/ml), FB1 in 27% (0.07 to 15.31 ng/ml) and, DON was found in 21% of samples at levels up to 10.0 ng/ml. The correlation coefficients (R(2)) obtained by plotting the percentage of biomarker occurrence (positive samples) versus the frequency of food consumption revealed maize, peanuts, millet and attiéké were strongly linked to AFB1 and OTA exposure with values of R(2) ranged from 0.462 to 0.956. CONCLUSION: The present study provided data on mycotoxin risk in Ivory Coast, revealing a frequent co-exposure to the major mycotoxins such as AFs, OTA, and fumonisins, which appeared to be related to the frequency of peanuts, maize, millet and attiéké consumption.

Multi-allergen quantification of fining-related egg and milk proteins in white wines by high-resolution mass spectrometry.

RATIONALE: A method based on High-Resolution Mass Spectrometry was developed for the simultaneous determination of fining agents containing potentially allergenic milk (casein) and egg-white (lysozyme and ovalbumin) proteins, added to commercial white wines at sub-ppm levels. Selected tryptic peptides were used as quantitative markers. An evaluation of protein digestion yields was also performed by implementing the (15)N-valine-labelled analogues of the best peptide markers identified for αS1 -casein and ovalbumin. METHODS: The method was based on the combination of ultrafiltration (UF) of protein-containing wines, tryptic digestion of the dialyzed wine extracts and liquid chromatography/high resolution mass spectrometry (LC/HRMS) analysis of tryptic digests. Peptides providing the most intense electrospray ionization (ESI)-MS response were chosen as quantitative markers of the proteins under investigation. RESULTS: Six-point calibrations were performed by adding caseinate and egg-white powder in the concentration range between 0.25 and 10 µg/mL, to an allergen-free white wine. The following three peptide markers, LTEWTSSNVMEER, GGLEPINFQTAADQAR and ELINSWVESQTNGIIR, were highlighted as best markers for ovalbumin, while GTDVQAWIR and NTDGSTDYGILQINSR for lysozyme and YLGYLEQLLR, GPFPIIV and FFVAPFPEVFGK for caseinate. Limits of detection (LODs) ranged from 0.4 to 1.1 µg/mL. CONCLUSIONS: The developed method is suited for assessing the contemporary presence of allergenic milk and egg proteins characterizing egg white and caseinate, fining agents typically employed for wine clarification. The LODs of the method enable the detection of sub-ppm concentrations of residual fining agents, that could represent a potential risk for allergic consumers.

Experimental design for in-house validation of a screening immunoassay kit. The case of a multiplex dipstick for Fusarium mycotoxins in cereals.

The benefits of using rapid qualitative methods to verify compliance of food and feed with legislation requirements include user-friendly format, the possibility of detection without expensive instrumentation, rapid response and affordable price. Prior to their use, however, the methods have to pass validation experiments, in order to assess their performance profile. An experimental protocol for in-house validation of a screening immunoassay has been designed and applied to evaluate performance characteristics of a multiplex dipstick kit for the determination of major Fusarium toxins, namely zearalenone, T-2 and HT-2 toxins, deoxynivalenol and fumonisins in wheat and maize. The test is intended for screening of cereals on the presence/absence of these mycotoxins at maximum permitted levels established by European legislation or target levels. The response of the measurement is determined with a reader device. Samples classified as negative are considered as compliant, whereas positive samples need to be re-analysed with confirmatory methods. The in-house validation design consisted of three steps, namely (1) estimating the precision of the method including "between day" effects and influences from different varieties of the matrices, (2) establishing robust cutoff values for the dipstick response at target mycotoxin levels assuming an acceptable rate of false negative results of 5% and (3) assessment of the rate of false positive results of blank samples and samples containing the target analytes below the legal limits. The total precision expressed as relative standard deviation and determined individually for each analyte/concentration/matrix combination varied from 9 to 30% and was considered as acceptable. In 17 out of 28 cases, the repeatability standard deviation was the most important factor. The predominance of the repeatability compared to the other factors (matrix, days) was an indicator for the ruggedness of the assay. The validation study demonstrated that the test was able to differentiate blank samples from samples contaminated at target mycotoxin levels with a false positive rate lower than 6%. Considering realistic mycotoxin occurrence in European samples, significant economical benefits can be expected when using the test under real-world conditions.

New insight into the ochratoxin A biosynthetic pathway through deletion of a nonribosomal peptide synthetase gene in Aspergillus carbonarius.

Ochratoxin A (OTA), a mycotoxin produced by Aspergillus and Penicillium species, is composed of a dihydroisocoumarin ring linked to phenylalanine, and its biosynthetic pathway has not yet been completely elucidated. Most of the knowledge regarding the genetic and enzymatic aspects of OTA biosynthesis has been elucidated in Penicillium species. In Aspergillus species, only pks genes involved in the initial steps of the pathway have been partially characterized. In our study, the inactivation of a gene encoding a nonribosomal peptide synthetase (NRPS) in OTA-producing A. carbonarius ITEM 5010 has eliminated the ability of this fungus to produce OTA. This is the first report on the involvement of an nrps gene product in OTA biosynthetic pathway in an Aspergillus species. The absence of OTA and ochratoxin α, the isocoumaric derivative of OTA, and the concomitant increase of ochratoxin ß, the dechloro analog of ochratoxin α, were observed in the liquid culture of transformed strain. The data provide the first evidence that the enzymatic step adding phenylalanine to polyketide dihydroisocoumarin precedes the chlorination step to form OTA in A. carbonarius and that ochratoxin α is a product of hydrolysis of OTA, giving an interesting new insight into the biosynthetic pathway of the toxin.

Analytical performances of a DNA-ligand system using time-resolved fluorescence for the determination of ochratoxin A in wheat.

The analytical performances of a novel DNA-ligand system using the time-resolved fluorescence (TRF) response of ochratoxin A (OTA)-terbium-DNA aptamer interaction were tested for the quantitative determination of OTA in wheat. Wheat was extracted with acetonitrile/water (60:40, v/v) followed by clean-up through affinity columns containing a DNA-aptamer-based oligosorbent. Then, OTA was detected by TRF spectroscopy after reaction with a terbium fluorescent solution containing the DNA-aptamer probe. The entire procedure was performed in less than 30 min, including sample preparation, and allowed analysis of several samples simultaneously with a 96-well microplate reader. The average recovery from samples spiked with 2.5-25 µg kg(-1) OTA was 77%, with a relative standard deviation lower than 6% and a quantification limit of 0.5 µg kg(-1). Comparative analyses of 29 naturally contaminated (up to 14 µg kg(-1)) wheat samples using the aptamer-affinity column/TRF method or the immunoaffinity column/high-performance liquid chromatography method showed good correlation (r = 0.985) in the range tested. The trueness of the aptamer-based method was additionally assessed by analysis of two quality control wheat materials for OTA. The DNA-ligand system is innovative, simple and rapid, and can be used to screen large quantities of samples for OTA contamination at levels below the EU regulatory limit with analytical performances satisfying EU criteria for method acceptability.

Comparison of slurry mixing and dry milling in laboratory sample preparation for determination of ochratoxin A and deoxynivalenol in wheat.

The significance of laboratory sample preparation for the determination of two important mycotoxins, ochratoxin A (OTA) and deoxynivalenol (DON), in wheat was investigated by comparing water-slurry mixing and dry-milling procedures. The distribution of OTA and DON in 10 kg samples of naturally contaminated wheat was established by analyzing one hundred 100 g subsamples of each sample. A normal distribution and a good repeatability of DON measurements was observed for both water-slurry mixing (mean 2290 microg/kg, CV 4.6%, median 2290 microg/kg) and dry milling (mean 2310 microg/kg, CV 6.4%, median 2290 microg/kg) procedures. For OTA determinations, reliable results could be obtained only by slurry mixing sample preparation (mean 2.62 microg/kg, CV 4.0%, median 2.62 microg/kg), whereas dry-milling comminution resulted in an inhomogeneous distribution with a high variability (mean 0.83 microg/kg, CV 75.2%, median 0.60 microg/kg) and a positive skewness (2.12). Ad hoc experiments were performed on different size portions of the same sample (10 kg) to assess accuracy and precision of the comminution/homogenization procedures (slurry mixing and dry milling). Very good results were obtained for DON determination with both procedures in terms of accuracy (>98.7% of the "weighted value") and precision (CV <3%). For OTA determination good results were only obtained by slurry mixing (99.4% of the "weighted value," CV 10%), whereas dry milling provided results with low accuracy (43.2% of the "weighted value") and high variability (CV 110%). This study clearly demonstrated that sample preparation by slurry mixing is strictly necessary to obtain reliable laboratory samples for OTA determination in wheat to minimize misclassification of acceptable/rejectable lots, mainly within official control.

Development and in-house validation of a robust and sensitive solid-phase extraction liquid chromatography/tandem mass spectrometry method for the quantitative determination of aflatoxins B1, B2, G1, G2, ochratoxin A, deoxynivalenol, zearalenone, T-2 and HT-2 toxins in cereal-based foods.

A sensitive and robust liquid chromatography/tandem mass spectrometry (LC/MS/MS) method was developed for the simultaneous determination of aflatoxins (B(1), B(2), G(1), G(2)), ochratoxin A, deoxynivalenol, zearalenone, T-2 and HT-2 toxins in cereal-based foods. Samples were extracted with a mixture of acetonitrile/water (84:16, v/v) and cleaned up through a polymeric solid-phase extraction column. Detection and quantification of the nine mycotoxins were performed by reversed-phase liquid chromatography coupled with electrospray ionization triple quadrupole mass spectrometry (LC/ESI-MS/MS), using fully (13)C-isotope-labelled mycotoxins as internal standards. The method was validated in-house for five different cereal processed products, namely barley, oat and durum wheat flours, rye- and wheat-based crisp bread. Recoveries and repeatability of the whole analytical procedure were evaluated at contamination levels encompassing the EU maximum permitted levels for each tested mycotoxin. Recoveries ranged from 89 to 108% for deoxynivalenol, from 73 to 114% for aflatoxins, from 85 to 114% for T-2 and HT-2 toxins, from 64 to 97% for zearalenone, from 74 to 102% for ochratoxin A. Relative standard deviations were less than 16% for all tested mycotoxins and matrices. Limits of detection (signal-to-noise ratio 3:1) ranged from 0.1 to 59.2 µg/kg. The trueness of the results obtained by the proposed method was demonstrated by analysis of reference materials for aflatoxins, deoxynivalenol, zearalenone. The use of inexpensive clean-up cartridges and the increasing availability of less expensive LC/MS/MS instrumentation strengthen the potential of the proposed method for its effective application for reliable routine analysis to assess compliance of tested cereal products with current regulation.

Simultaneous LC-MS/MS determination of aflatoxin M1, ochratoxin A, deoxynivalenol, de-epoxydeoxynivalenol, α and ß-zearalenols and fumonisin B1 in urine as a multi-biomarker method to assess exposure to mycotoxins.

Humans and animals can be simultaneously exposed through the diet to different mycotoxins, including aflatoxins, ochratoxin A, deoxynivalenol, zearalenone, and fumonisins, which are the most important. Evaluation of the frequency and levels of human and animal exposure to these mycotoxins can be performed by measuring the levels of the relevant biomarkers in urine. Available data on the toxicokinetics of these mycotoxins in animals suggest that aflatoxin M(1) (AFM(1)), ochratoxin A (OTA), deoxynivalenol (DON)/de-epoxydeoxynivalenol (DOM-1), alpha-zearalenol (α-ZOL)/beta-zearalenol (ß-ZOL), and fumonisin B(1) (FB(1)) can be used as urinary biomarkers. A liquid chromatographic-tandem mass spectrometric method has been developed for simultaneous determination of these mycotoxin biomarkers in human or animal urine. Urine samples were purified and concentrated by a double cleanup approach, using a multitoxin immunoaffinity column and a reversed-phase SPE Oasis HLB column. Separation of the biomarkers was performed by reversed-phase chromatography using a multi-step linear methanol-water gradient containing 0.5% acetic acid as mobile phase. Detection and quantification of the biomarkers were performed by triple quadrupole mass spectrometry (LC-ESI-MS/MS). The clean-up conditions were optimised to obtain maximum analyte recovery and high sensitivity. Recovery from spiked samples was performed at four levels in the range 0.03-12 ng mL(-1), using matrix-matched calibration curves for quantification. Mean recoveries of the biomarkers tested ranged from 62 to 96% with relative standard deviations of 3-20%. Enzymatic digestion with ß-glucuronidase/sulfatase resulted in increased concentrations of the biomarkers, in both human and pig urine, in most samples containing measurable concentrations of DON, DOM-1, OTA, α-ZOL, or ß-ZOL. A highly variable increase was observed between individuals. Co-occurrence of OTA and DON in human urine is reported herein for the first time.

A rapid fluorescence polarization immunoassay for the determination of T-2 and HT-2 toxins in wheat.

A rapid fluorescence polarization (FP) immunoassay has been developed for the simultaneous determination of T-2 and HT-2 toxins in naturally contaminated wheat samples. Syntheses of four fluorescein-labelled T-2 or HT-2 toxin tracers were carried out and their binding response with seven monoclonal antibodies was evaluated. The most sensitive antibody-tracer combination was obtained by using an HT-2-specific antibody and a fluorescein-HT-2 tracer. The developed competitive FP immunoassay in solution showed high cross-reactivity for T-2 toxin (CR% = 100%) while a very low CR% for neosolaniol (0.12%) and no cross-reactivity with other mycotoxins frequently occurring in wheat. A rapid extraction procedure using 90% methanol was applied to wheat samples prior to FP immunoassay. The average recovery from spiked wheat samples (50 to 200 µg kg(-1)) was 96% with relative standard deviation generally lower than 8%. A limit of detection of 8 µg kg(-1) for the combined toxins was determined. Comparative analyses of 45 naturally contaminated and spiked wheat samples by both the FP immunoassay and high-performance liquid chromatography/immunoaffinity clean-up showed a good correlation (r = 0.964). These results, combined with the rapidity (10 min) and simplicity of the assay, show that this method is suitable for high throughput screening as well as for quantitative determination of T-2 and HT-2 toxins in wheat.

Determination of ochratoxin A in wheat after clean-up through a DNA aptamer-based solid phase extraction column.

A DNA aptamer with high affinity and specificity to ochratoxin A (OTA) was conjugated to a coupling gel and used as sorbent for the preparation of solid phase extraction (SPE) columns. The SPE columns packed with 300µl oligosorbent (24nmol DNA) showed a linear (r=0.999) behaviour in the range of 0.4-500ng OTA. After optimisation of the extraction step, SPE columns were used for clean-up of OTA from wheat prior to liquid chromatographic (HPLC) analysis with fluorescence detection (FLD). Average recoveries from wheat samples spiked at levels of 0.5-50ng/g ranged from 74% to 88% (relative standard deviation <6%) with limits of detection and of quantification of 23 and 77pg/g, respectively. The comparative HPLC/FLD analyses of 33 naturally contaminated durum wheat samples cleaned-up on both aptamer-SPE and immunoaffinity (IMA) columns showed a good correlation (r=0.990). Aptamer-SPE columns could be re-used up to five times without any loss of performance.

Reliable detection of milk allergens in food using a high-resolution, stand-alone mass spectrometer.

Reliable methods are needed for detection of allergenic milk proteins in complex food matrixes. The feasibility of an LC/high-resolution MS method for the analysis of milk proteins in a thermally processed model food (incurred cookies) and in white wine spiked, respectively, with milk powder and caseinate is described. Detection of milk proteins was based on the identification of unique peptides in the tryptic digests of cookie/wine extracts using an RP-HPLC separation coupled to an Exactive nonhybrid mass spectrometer using Orbitrap technology. The extremely high mass accuracy and resolution provided by the Orbitrap analyzer allowed a fast preliminary identification of four previously proposed peptide markers of caseins using only accurate values of the m/z of their ions. No interference was observed, despite the complexity of the analyzed matrixes. Moreover, the availability of a high- energy, collisionally activated dissociation cell integrated in the mass spectrometer enabled acquisition of peptide MS/MS-like spectra through post-source fragmentation. Confirmation of peptide marker identity could then be achieved by a comparison between experimental and predicted product ions. The described method shows the great potential of Orbitrap MS as a reliable technique in the field of protein allergen detection once the peptide markers are identified.

Determination of fumonisins B1 and B2 in corn-based foods for infants and young children by LC with immunoaffinity column cleanup: interlaboratory validation study.

A liquid chromatographic method for the determination of fumonisins B1 (FB1) and B2 (FB2) in corn-based foods for infants and young children was subjected to an interlaboratory validation study involving 11 laboratories. Five blind duplicate sample pairs of each matrix were analyzed to establish the accuracy, repeatability, and reproducibility of the method. Mass fractions in the baby food samples ranged from 89.1 to 384.4 microg/kg FB1 and from 22.5 to 73.6 microg/kg FB2. The method involved a warm extraction with citrate phosphate buffer-methanol-acetonitrile (50 + 25 + 25, v/v/v), a cleanup through an immunoaffinity column, and an end-determination of fumonisins by LC after automated precolumn derivatization with o-phthaldialdehyde reagent. RSDs for within-laboratory repeatability (RSDr) ranged from 6.8 to 23.5% for FB1 and 7.6 to 22.9% for FB2. RSDs for between-laboratory reproducibility (RSDR) ranged from 15.4 to 26.2% for FB1 and 21.6 to 36.3% for FB2. Mean FB1 recoveries from baby foods spiked at 100.0 and 250.0 microg/kg were 89 and 96%, respectively; for FB2 spiked foods at 25.0 and 62.5 microg/kg recoveries were 90 and 85%, respectively. HorRat values ranged from 0.8 to 1.2 for FB1, whereas for FB2 they ranged from 0.9 to 1.4 when calculated according to Horwitz, and from 1.0 to 1.7 when calculated according to Thompson, indicating an acceptable among-laboratory precision for all matrixes (HorRat values <2).

Screening and initial binding assessment of fumonisin b(1) aptamers.

Fumonisins are mycotoxins produced by Fusarium verticillioides and F. proliferatum, fungi that are ubiquitous in corn (maize). Insect damage and some other environmental conditions result in the accumulation of fumonisins in corn-based products worldwide. Current methods of fumonisin detection rely on the use of immunoaffinity columns and high-performance liquid chromatography (HPLC). The use of aptamers offers a good alternative to the use of antibodies in fumonisin cleanup and detection due to lower costs and improved stability. Aptamers are single-stranded oligonucleotides that are selected using Systematic Evolution of Ligands by EXponential enrichment (SELEX) for their ability to bind to targets with high affinity and specificity. Sequences obtained after 18 rounds of SELEX were screened for their ability to bind to fumonisin B(1). Six unique sequences were obtained, each showing improved binding to fumonisin B(1) compared to controls. Sequence FB(1) 39 binds to fumonisin with a dissociation constant of 100 ± 30 nM and shows potential for use in fumonisin biosensors and solid phase extraction columns.

Enzymatic hydrolysis of T-2 toxin for the quantitative determination of total T-2 and HT-2 toxins in cereals.

The selective enzymatic deacetylation of T-2 toxin to give HT-2 toxin has been investigated in aqueous crude extracts of different cereals and exploited to develop an analytical method for the determination of the sum of T-2 and HT-2 toxins. The method has been validated for the analysis of total T-2 and HT-2 toxins in maize, wheat, and oats, showing recoveries from 72 to 97% for maize, from 67 to 84% for wheat, and from 61% to 87% for oats, at spiking levels of 20-400 microg/kg, with relative standard deviation lower than 10%. Liquid chromatography-tandem mass spectrometry was used for quantitative toxin determination. The potential biological role of this enzymatic conversion and its perspectives for application in the development of antibody-based analytical techniques are discussed.

Fluorescence polarization immunoassay for rapid screening of ochratoxin A in red wine.

A fluorescence polarization (FP) immunoassay, based on a monoclonal antibody and an ochratoxin A (OTA)-fluorescein tracer, has been developed for rapid screening of OTA in red wine. Wine samples were diluted with methanol and passed through aminopropyl solid-phase extraction columns prior to the FP assay. Average recoveries from samples spiked with OTA at levels of 2.0 and 5.0 ng/mL were 79% with RDS of 11% (n = 6). The limit of detection of the FP immunoassay was 0.7 ng/mL OTA, and the whole analysis was performed in less than 10 min. The assay was tested on 154 red wine samples (naturally contaminated or spiked at level ranging from 0.1 to 5.0 ng/mL) and compared with an high-performance liquid chromatography/immunoaffinity column clean-up method, showing a good correlation (r = 0.9222). Their compliance with the European regulation (2.0 ng/mL OTA maximum permitted level) was correctly assessed for 70% of the analyzed samples of red wine, whereas confirmatory analyses were required for the remaining ones with OTA levels close to the regulatory limit. No false-negative or positive results were observed using the FP immunoassay. The proposed FP assay is a useful screening method for OTA in red wines, when high throughput is required, that could also be used for white and rosé wines, which are known to contain less interfering compounds such as polyphenols.

Use of Lactobacillus plantarum fermentation products in bread-making to prevent Bacillus subtilis ropy spoilage.

Four fermentation products (FPs) of the lactic acid bacterium Lactobacillus plantarum ITM21B were screened for their anti-Bacillus activity in vitro and in bread-making trials. Results of the storage tests performed with loaves prepared with an FP or calcium propionate demonstrated that after 3 days at 30 degrees C, gross spoilage was evident in only the control loaves, which contained Bacillus subtilis at numbers of about 10(9) cfu/g. The highest inhibitory activity was shown by DM-FP obtained by growing L. plantarum in a defined medium (DM). Significantly, this medium contained an amino acceptor of the aminoacid transamination, namely alpha-ketoglutaric acid, and an aminoacid pool. With loaves prepared using the DM-acid mixture which simulated the DM-FP composition, the same reduction of ropy spoilage as with DM-FP was obtained after 3 days, while the efficacy of the mixture decreased after 7 days. This result suggests the potential involvement of some unknown metabolites in the inhibitory activity of DM-FP. In baked products made with flour based media (M1-FP, M2-FP, M3-FP), no ropy symptoms were noticeable after 3 days storage although a considerable Bacillus count was detected. DM-FP was as effective as calcium propionate (0.3% w/w, based on flour mass) in prolonging the Bacillus free-shelf life of yeast-leavened bread for 7 days.