Effect of Donor Sex on Recipient Mortality in Transfusion.

BACKGROUND: Conflicting observational evidence exists regarding the association between the sex of red-cell donors and mortality among transfusion recipients. Evidence to inform transfusion practice and policy is limited. METHODS: In this multicenter, double-blind trial, we randomly assigned patients undergoing red-cell transfusion to receive units of red cells from either male donors or female donors. Patients maintained their trial-group assignment throughout the trial period, including during subsequent inpatient and outpatient encounters. Randomization was conducted in a 60:40 ratio (male donor group to female donor group) to match the historical allocation of red-cell units from the blood supplier. The primary outcome was survival, with the male donor group as the reference group. RESULTS: A total of 8719 patients underwent randomization before undergoing transfusion; 5190 patients were assigned to the male donor group, and 3529 to the female donor group. At baseline, the mean (±SD) age of the enrolled patients was 66.8±16.4 years. The setting of the first transfusion was as an inpatient in 6969 patients (79.9%), of whom 2942 (42.2%) had been admitted under a surgical service. The baseline hemoglobin level before transfusion was 79.5±19.7 g per liter, and patients received a mean of 5.4±10.5 units of red cells in the female donor group and 5.1±8.9 units in the male donor group (difference, 0.3 units; 95% confidence interval [CI], -0.1 to 0.7). Over the duration of the trial, 1141 patients in the female donor group and 1712 patients in the male donor group died. In the primary analysis of overall survival, the adjusted hazard ratio for death was 0.98 (95% CI, 0.91 to 1.06). CONCLUSIONS: This trial showed no significant difference in survival between a transfusion strategy involving red-cell units from female donors and a strategy involving red-cell units from male donors. (Funded by the Canadian Institutes of Health Research; iTADS ClinicalTrials.gov number, NCT03344887.).

Assessment of stored red blood cells through lab-on-a-chip technologies for precision transfusion medicine.

Transfusion of red blood cells (RBCs) is one of the most valuable and widespread treatments in modern medicine. Lifesaving RBC transfusions are facilitated by the cold storage of RBC units in blood banks worldwide. Currently, RBC storage and subsequent transfusion practices are performed using simplistic workflows. More specifically, most blood banks follow the "first-in-first-out" principle to avoid wastage, whereas most healthcare providers prefer the "last-in-first-out" approach simply favoring chronologically younger RBCs. Neither approach addresses recent advances through -omics showing that stored RBC quality is highly variable depending on donor-, time-, and processing-specific factors. Thus, it is time to rethink our workflows in transfusion medicine taking advantage of novel technologies to perform RBC quality assessment. We imagine a future where lab-on-a-chip technologies utilize novel predictive markers of RBC quality identified by -omics and machine learning to usher in a new era of safer and precise transfusion medicine.

Engineered Compounds to Control Ice Nucleation and Recrystallization.

One of the greatest concerns in the subzero storage of cells, tissues, and organs is the ability to control the nucleation or recrystallization of ice. In nature, evidence of these processes, which aid in sustaining internal temperatures below the physiologic freezing point for extended periods of time, is apparent in freeze-avoidant and freeze-tolerant organisms. After decades of studying these proteins, we now have easily accessible compounds and materials capable of recapitulating the mechanisms seen in nature for biopreser-vation applications. The output from this burgeoning area of research can interact synergistically with other novel developments in the field of cryobiology, making it an opportune time for a review on this topic.

Estimated median density identifies donor age and sex differences in red blood cell biological age.

BACKGROUND: Donors possess heterogeneous red cell concentrates (RCCs) in terms of the biological age of their red blood cells (RBCs) as a direct result of various donor-dependent factors influencing rates of erythropoiesis. This study aimed to estimate the median biological age of RBCs in RCCs based on donor age and sex to investigate inherent differences in blood products' biological ages over hypothermic storage using estimated median densities (EMDs). STUDY DESIGN: Sixty RCCs were collected from four donor groups; male and female teenagers (17-19 years old) and seniors (75+ years old). A Percoll density-based separation approach was used to quantify the EMDs indicative of biological age. EMD and mean corpuscular hemoglobin (MCHC) were compared by correlation analyses. RESULTS: Differences in the median biological age of RCC units were observed with male donors having significantly higher EMDs compared to females (p < .001). Teen male donors possessed the highest EMDs with significantly elevated levels of biologically aged RBCs compared to both female donor groups, regardless of storage duration (p < .05). Throughout most of the 42-day storage period, senior donors, particularly senior females, demonstrated the strongest correlation between EMD and MCHC (R2 > 0.5). CONCLUSIONS: This study provides further evidence that there are inherent differences between the biological age profiles of RBCs between blood donors of different sex and age. Our findings further highlight that biological age may contribute to RBC quality during storage and that donor characteristics need to be considered when evaluating transfusion safety and efficacy.

Red cell concentrates from teen male donors contain poor-quality biologically older cells.

BACKGROUND AND OBJECTIVES: Donor factors influence the quality characteristics of red cell concentrates (RCCs) and the lesions that develop in these heterogeneous blood products during hypothermic storage. Teen male donors' RCCs contain elevated levels of biologically old red blood cells (RBCs). The aim of this study was to interrogate the quality of units of different donor ages and sexes to unravel the complex interplay between donor characteristics, long-term cold storage and, for the first time, RBC biological age. MATERIALS AND METHODS: RCCs from teen males, teen females, senior males and senior females were density-separated into less-dense/young (Y-RBCs) and dense/old RBCs (O-RBCs) throughout hypothermic storage for testing. The unseparated and density-separated cells were tested for haematological parameters, stress (oxidative and osmotic) haemolysis and oxygen affinity (p50). RESULTS: The O-RBCs obtained from teen donor samples, particularly males, had smaller mean corpuscular volumes and higher mean corpuscular haemoglobin concentrations. While biological age did not significantly affect oxygen affinity, biologically aged O-RBCs from stored RCCs exhibited increased oxidative haemolysis and decreased osmotic fragility, with teenage male RCCs exhibiting the highest propensity to haemolyse. CONCLUSION: Previously, donor age and sex were shown to have an impact on the biological age distribution of RBCs within RCCs. Herein, we demonstrated that RBC biological age, particularly O-RBCs, which are found more prevalently in male teens, to be a driving factor of several aspects of poor blood product quality. This study emphasizes that donor factors should continue to be considered for their potential impacts on transfusion outcomes.

Transforming research to improve therapies for trauma in the twenty-first century.

Improvements have been made in optimizing initial care of trauma patients, both in prehospital systems as well as in the emergency department, and these have also favorably affected longer term outcomes. However, as specific treatments for bleeding are largely lacking, many patients continue to die from hemorrhage. Also, major knowledge gaps remain on the impact of tissue injury on the host immune and coagulation response, which hampers the development of interventions to treat or prevent organ failure, thrombosis, infections or other complications of trauma. Thereby, trauma remains a challenge for intensivists. This review describes the most pressing research questions in trauma, as well as new approaches to trauma research, with the aim to bring improved therapies to the bedside within the twenty-first century.

Advancing in vivo assessment of red blood cell transfusions: A call for radiation-free methods in transfusion medicine.

RBC transfusions are a vital clinical therapy to treat anemic patients. The in vivo assessment of red blood cell (RBC) quality post-transfusion is critical to ensuring that the introduction of new RBC products meet established regulatory and clinical quality requirements. Although in vitro quality control testing is routinely performed by blood manufacturers, it is crucial that in vivo tests are performed during the evaluation and regulatory process of new RBC products. This article reviews existing in vivo techniques, like chromium-51 labelling and biotinylation, for determining the circulation and survival of RBCs, and advocates for a move to radiation-free methods. The timely need for radiation-free methods to assess emerging non-DEHP container systems is just one example of why efforts to improve the methods available for in vivo quality assessment is important in transfusion medicine. This review aims to advance our understanding of RBC transfusion in vivo quality assessment and enhance transfusion practices.

A perspective on exogenous redox regulation mediated by transfused RBCs subject to the storage lesion.

Granted with a potent ability to interact with and tolerate oxidative stressors, RBCs scavenge most reactive oxygen and nitrogen species (RONS) generated in circulation. This essential non-canonical function, however, renders RBCs susceptible to damage when vascular RONS are generated in excess, making vascular redox imbalance a common etiology of anemia, and thus a common indication for transfusion. This accentuates the relevance of impairments in redox metabolism during hypothermic storage, as the exposure to chronic oxidative stressors upon transfusion could be exceedingly deleterious to stored RBCs. Herein, we review the prominent mechanisms of the hypothermic storage lesion that alter the ability of RBCs to scavenge exogenous RONS as well as the associated clinical relevance.

Modification of deglycerolization procedure improves processing and post-thaw quality of cryopreserved sickle trait red cell concentrates.

Red blood cell (RBC) transfusion is a critical therapy for those with sickle cell disease (SCD). Alloimmunization is frequent for those with SCD and may limit the availability of matched RBC. Cryopreserved RBCs, from family members or donors with a similar RBC antigen profile could provide a viable alternative to avoid further alloimmunization and prevent hemolytic transfusion-related events. However, cryopreserved SCD and Sickle Cell trait (S-trait) donor RBC units suffer from reduced recovery following deglycerolization. This study proposes and tests a modified deglycerolization protocol using an automated cell processor to mitigate RBC loss. Six red cell concentrates (RCC) from donors with S-trait and six control RCCs were glycerolized, frozen (<-65 °C) and deglycerolized on the ACP 215 using modified parameters (decreased hypertonic solution flow rate (100 mL/min) and hypertonic equilibration delay (120 s), and increased NaCl dilution volumes (500 mL). Quality testing included: hematocrit (HCT), hemolysis, indices, extracellular potassium, morphology, osmotic fragility, osmotic gradient ektacytometry, hemoglobin (HGB), and recovery. Canadian standards (CS) indicate that acceptable deglycerolized units for transfusion require a HCT ≤0.80 L/L, HGB ≥35 g/unit, and hemolysis <0.8 % in 90 % of units tested. No significant differences in HGB or RBC recovery were observed between study groups. Significant differences between study groups were identified in osmotic fragility and osmotic gradient ektacytometry parameters. Of the 6 S-trait RCCs, 3/6 units were within the HCT, HGB and hemolysis thresholds set by the CS. The modified deglycerolization protocol provides a path for the routine cryopreservation of S-trait RBCs.

Extracellular vesicles: effectors of transfusion-related acute lung injury.

Respiratory transfusion reactions represent some of the most severe adverse reactions related to receiving blood products. Of those, transfusion-related acute lung injury (TRALI) is associated with elevated morbidity and mortality. TRALI is characterized by severe lung injury associated with inflammation, pulmonary neutrophil infiltration, lung barrier leak, and increased interstitial and airspace edema that cause respiratory failure. Presently, there are few means of detecting TRALI beyond clinical definitions based on physical examination and vital signs or preventing/treating TRALI beyond supportive care with oxygen and positive pressure ventilation. Mechanistically, TRALI is thought to be mediated by the culmination of two successive proinflammatory hits, which typically comprise a recipient factor (1st hit-e.g., systemic inflammatory conditions) and a donor factor (2nd hit-e.g., blood products containing pathogenic antibodies or bioactive lipids). An emerging concept in TRALI research is the contribution of extracellular vesicles (EVs) in mediating the first and/or second hit in TRALI. EVs are small, subcellular, membrane-bound vesicles that circulate in donor and recipient blood. Injurious EVs may be released by immune or vascular cells during inflammation, by infectious bacteria, or in blood products during storage, and can target the lung upon systemic dissemination. This review assesses emerging concepts such as how EVs: 1) mediate TRALI, 2) represent targets for therapeutic intervention to prevent or treat TRALI, and 3) serve as biochemical biomarkers facilitating TRALI diagnosis and detection in at-risk patients.

Donor sex, pre-donation hemoglobin, and manufacturing affect CD71+ cells in red cell concentrates.

BACKGROUND: Circulating CD71+ red blood cells (RBCs) have been reported to play an immunomodulatory role in vivo, which may contribute to adverse donor-recipient sex-mismatched transfusion outcomes. However, it is not clear how CD71+ RBC quantity in red cell concentrates (RCCs) is affected by manufacturing methods and donor factors such as donor sex, donor age, pre-donation hemoglobin (Hb), venous Hb (Hbv ) levels, and donation frequency. METHODS: We determined CD71+ RBCs and Hb levels in whole blood (WB) from healthy donors (42 male/38 female). Using small-scale red cell filtration (RCF) and whole blood filtration (WBF) methods, leukoreduced RCCs were processed from WB samples (n = 6) and the CD71+ RBCs were determined at days 1, 7, and 28. We examined uni- and multivariate associations among CD71+ RBCs, donor factors, and manufacturing method. RESULTS: Male donors had a higher CD71+ RBC concentration than females (p < .001), especially male donors aged 17-50 years with 1 or 2 WB donations over the previous 12 months. Donors with a Hbv above 155 g/L had a higher CD71+ RBC concentration than an Hbv level below 140 g/L (p < .05). There was a positive correlation between pre-donation Hb and CD71+ RBC concentration (Pearson r = 0.41). WBF RCCs had a higher total number of CD71+ RBCs than RCF-produced RCCs on day 1 (p < .05). DISCUSSION: RCCs have variable numbers of CD71+ RBCs. This makes understanding the impact of donor factors and manufacturing methods on the immunomodulatory effect of CD71+ RBCs critical in exploring donor-recipient sex-mismatched transfusions.

Risk factors for T-cell lymphopenia in frequent platelet donors: The BEST collaborative study.

BACKGROUND: Severe T-cell lymphopenia of uncertain clinical significance has been observed in frequent apheresis platelet donors. Two commonly used plateletpheresis instruments are the Trima Accel, which uses a leukoreduction system (LRS) chamber to trap leukocytes and the Fenwal Amicus, which does not use an LRS chamber. STUDY DESIGN AND METHODS: We performed an international, multicenter, observational study comparing T-cell populations in frequent platelet donors collected exclusively using the Trima instrument (n = 131) or the Amicus instrument (n = 77). Age- and sex-matched whole blood donors (n = 126) served as controls. RESULTS: CD4+ T-cell counts <200 cells/µL were found in 9.9% of frequent Trima (LRS+) platelet donors, 4.4% of frequent Amicus (LRS-) platelet donors, and 0 whole blood donors (p < .0001). CD4+ T-cell counts <200 cells/µL were only seen in platelet donors with ≥200 lifetime donations. In multivariable analysis, age, lifetime donations, and instrument (Trima vs. Amicus) were independent risk factors for lymphopenia. In 40 Trima platelet donors, a plasma rinseback procedure was routinely performed following platelet collections. No Trima platelet donors receiving plasma rinseback had a CD4+ T-cell count <200 cells/µL versus 13/91 Trima platelet donors not receiving plasma rinseback (p = .01). DISCUSSION: Recurrent bulk lymphocyte removal appears to contribute to the development of T-cell lymphopenia in frequent, long-term platelet donors. Lymphopenia is more common when an LRS chamber is used during platelet collection but can occur without an LRS chamber. Blood centers using LRS chambers can mitigate donor lymphopenia by performing plasma rinseback.

Quality assessment of red blood cell concentrates from blood donors at the extremes of the age spectrum: The BEST collaborative study.

BACKGROUND: Blood donors at the extremes of the age spectrum (16-19 years vs. ≥75 years) are characterized by increased risks of iron deficiency and anemia, and are often underrepresented in studies evaluating the effects of donor characteristics on red blood cells (RBC) transfusion effectiveness. The aim of this study was to conduct quality assessments of RBC concentrates from these unique age groups. STUDY DESIGN: We characterized 150 leukocyte-reduced (LR)-RBCs units from 75 teenage donors, who were matched by sex, and ethnicity with 75 older donors. LR-RBC units were manufactured at three large blood collection centers in the USA and Canada. Quality assessments included storage hemolysis, osmotic hemolysis, oxidative hemolysis, osmotic gradient ektacytometry, hematological indices, and RBC bioactivity. RESULTS: RBC concentrates from teenage donors had smaller (9%) mean corpuscular volume and higher (5%) RBC concentration compared with older donors counterparts. Stored RBCs from teenage donors exhibited increased susceptibility to oxidative hemolysis (>2-fold) compared with RBCs from older donors. This was observed at all testing centers independent of sex, storage duration, or the type of additive solution. RBCs from teenage male donors had increased cytoplasmatic viscosity and lower hydration compared with older donor RBCs. Evaluations of RBC supernatant bioactivity suggested that donor age was not associated with altered expression of inflammatory markers (CD31, CD54, and IL-6) on endothelial cells. CONCLUSIONS: The reported findings are likely intrinsic to RBCs and reflect age-specific changes in RBC antioxidant capacity and physical characteristics that may impact RBC survival during cold storage and after transfusion.

Immunological impact of the CD71+ RBCs: A potential immune mediator in transfusion.

Donor - recipient sex - mismatched transfusion is associated with increased mortality. The mechanisms for this are not clear, but it may relate to transfusion-related immunomodulation. Recently, CD71+ erythroid cells (CECs), including reticulocytes (CD71+ RBCs) and erythroblasts, have been identified as potent immunoregulatory cells. The proportion of CD71+ RBCs in the peripheral blood is sufficient to play a potential immunomodulatory role. Differences in the quantity of CD71+ RBCs are dependent on blood donor sex. The total number of CD71+ RBCs in red cell concentrates is also affected by blood manufacturing methods, and storage duration. As a component of the total CECs, CD71+ RBCs can affect innate and adaptive immune cells. Phagocytosed CECs directly reduce TNF-α production from macrophages. CECs can also suppress the production of TNF-α production from antigen presenting cells. Moreover, CECs can suppress T cell proliferation thorough immune mediation and / or direct cell-to-cell interactions. Different in their biophysical features compared to mature RBCs, blood donor CD71+ RBCs may be preferential targets for the macrophages. This report summarizes the currently literature supporting an important role for CD71+ RBCs in adverse transfusion reactions including immune mediation and sepsis.

Towards the crux of sex-dependent variability in red cell concentrates.

Donor sex can alter the RBC 'storage lesion' progression, contributing to dissimilarities in blood product quality, and thus adverse post-transfusion reactions. The mechanisms underlying the reduced sensitivity of female RBCs to storage-induced stress are partially ascribed to the differential effects of testosterone, progesterone, and estrogen on hemolytic propensity. Contributing to this is the increased proportion of more robust, biologically 'young' subpopulations of RBCs in females. Herein, we discuss the impact of sex hormones on RBCs and the relevance of these biological subpopulations to provide further insight into sex-dependent blood product variability.

Cultured CD71+ erythroid cells modulate the host immune response.

OBJECTIVE: The study aimed to determine the impact of Red Blood Cells (RBCs) generated from peripheral blood mononuclear cells (PBMCs) on T cell proliferation and host response following whole blood stimulation. BACKGROUND: Culturing RBCs is a potential solution for donor shortage. The impact of immature cultured RBCs which express CD71+ on host immune response is not known. METHODS/MATERIALS: PBMCs were seeded in an erythroid expansion medium. CD71+ cells were isolated at days 14 and 21 of culture and incubated with either purified T cells or with LPS-stimulated whole blood. Controls were incubated with medium. RESULTS: At day 9, the percentage of cells that expressed CD45 and CD71 reached to the highest level (32.9%, IQR; 26.2-39.05) while the percentage of cells that expressed CD71 and CD235a reached to the highest level on day 17 (70.2%, IQR; 66.1-72.8). Incubation of T cells with days 14 CD71+ cells and day 21 CD71+ cells increased T cell proliferation. In a whole blood stimulation assay, day 21 CD71+ cells, but not day 14 CD71+ cells, inhibited the production of IL-6 and TNFα. CONCLUSION: Cultured erythroid cells can modulate the immune response by promoting T cell proliferation and inhibiting cytokine secretions following whole blood stimulation.

Objective assessment of stored blood quality by deep learning.

Stored red blood cells (RBCs) are needed for life-saving blood transfusions, but they undergo continuous degradation. RBC storage lesions are often assessed by microscopic examination or biochemical and biophysical assays, which are complex, time-consuming, and destructive to fragile cells. Here we demonstrate the use of label-free imaging flow cytometry and deep learning to characterize RBC lesions. Using brightfield images, a trained neural network achieved 76.7% agreement with experts in classifying seven clinically relevant RBC morphologies associated with storage lesions, comparable to 82.5% agreement between different experts. Given that human observation and classification may not optimally discern RBC quality, we went further and eliminated subjective human annotation in the training step by training a weakly supervised neural network using only storage duration times. The feature space extracted by this network revealed a chronological progression of morphological changes that better predicted blood quality, as measured by physiological hemolytic assay readouts, than the conventional expert-assessed morphology classification system. With further training and clinical testing across multiple sites, protocols, and instruments, deep learning and label-free imaging flow cytometry might be used to routinely and objectively assess RBC storage lesions. This would automate a complex protocol, minimize laboratory sample handling and preparation, and reduce the impact of procedural errors and discrepancies between facilities and blood donors. The chronology-based machine-learning approach may also improve upon humans' assessment of morphological changes in other biomedically important progressions, such as differentiation and metastasis.

The timing of gamma irradiation and its effect on cell-free and microvesicle-bound hemoglobin. The BEST collaborative study.

BACKGROUND: Gamma irradiation of red cell concentrates (RCCs) is regularly used to prevent transfusion-associated graft-versus-host disease (TA-GvHD) in at-risk patients. While studies have indicated that irradiated RCCs exhibit increased hemolysis, there have been no efforts to differentiate between free- and microvesicle (MV)-bound hemoglobin (Hb). As an increase in the proportion of free-Hb in irradiated RCCs could alter vascular function, we sought to characterize differences in the state of extracellular Hb based on the timing of irradiation. STUDY DESIGN AND METHODS: Four separate pools of seven CPD/SAGM leukoreduced RCCs were produced and split into four sets of seven identical units. The units from each set were subject to irradiation (25 Gy) at six different points during storage, with one unit serving as a nonirradiated control. All testing was performed immediately following unit expiry on day 43. RESULTS: The earlier in storage that units were irradiated, the higher the hemolysis and the lower the proportion of MV-bound Hb. Units irradiated earlier in storage (1-8 days post collection) additionally had lower membrane rigidity (KEI ), lower mean corpuscular Hb concentrations (MCHC), and higher mean corpuscular fragility (MCF). Morphology indices, mean cell volume (MCV), mean corpuscular Hb (MCH), phosphatidylserine (PS) expression, as well as MV production and size did not however differ significantly between groups based on the timing of irradiation. CONCLUSIONS: Our findings indicate that irradiation timing can alter the state of extracellular Hb, with "early" irradiation promoting an increased proportion of cell-free Hb as well as mechanical damage to the RBC membrane.

Closed system processing variables affect post-thaw quality characteristics of cryopreserved red cell concentrates.

BACKGROUND: Differences in manufacturing conditions using the Haemonetics ACP 215 cell processor result in cryopreserved red cell concentrates (RCCs) of varying quality. This work studied the effect of processing method, additive solution, and storage duration on RCC quality to identify an optimal protocol for the manufacture of cryopreserved RCCs. MATERIALS AND METHODS: RCCs were pooled-and-split and stored for 7, 14, or 21 days before cryopreservation. Units were glycerolized with the ACP 215 using a single or double centrifugation method. After thawing, the RCCs were deglycerolized, suspended in AS-3, SAGM, ESOL, or SOLX/AS-7, and stored for 0, 3, 7, 14, or 21 days before quality testing. Quality assessments included hemoglobin content, hematocrit, hemolysis, adenosine triphosphate (ATP), supernatant potassium, and mean cell volume. RESULTS: Both glycerolization methods produced RCCs that met regulatory standards for blood quality. Dual centrifugation resulted in higher hemoglobin content, fewer processing alerts, and a shorter deglycerolization time than single centrifugation processing. Units processed with AS-3 and ESOL met regulatory standards when stored for up to 21 days pre-cryopreservation and 21 days post-deglycerolization. However, ESOL demonstrated superior maintenance of ATP over RBCs in AS-3. Some RCCs suspended in SAGM and SOLX exceeded acceptable hemolysis values after 7 days of post-deglycerolization storage regardless of pre-processing storage length. CONCLUSIONS: When manufacturing cryopreserved RCCs using the ACP 215, dual centrifugation processing with AS-3 or ESOL additive solutions is preferred, with storage periods of up to 21 days both pre-processing and post-deglycerolization.

Automated closed volume reduction process for apheresis stem cell grafts: From development to clinical implementation.

BACKGROUND: Collection of HPC by apheresis (HPC-A) can sometimes result in higher collection volumes, increasing the dimethyl sulfoxide (DMSO) volume infused into patients and the space requirements in liquid nitrogen freezers. Volume reduction prior to the addition of cryoprotectant is an efficient means to reduce the DMSO load infused into patients and to optimize freezer storage space. STUDY DESIGN AND METHODS: To implement a closed semi-automated volume reduction process, a method was developed to produce leukocyte-rich mock apheresis products using buffy coats derived from whole blood collections. The mock HPC products were then used to measure the efficiency and reliability of the semi-automated process over a range of volumes and cell concentrations. The resulting data was used to support the implementation of the process with concurrent monitoring. RESULTS: A closed, semi-automated volume reduction process resulted in recoveries of over 93% and 91% of white blood cells and CD34+ cells with no significant loss of product viability or potency. Mean doses of CD34+ and CFU infused per kilogram recipient body weight were 4.0 ± 1.1 × 106 /kg and 4.2 ± 1.7 × 105 /kg, resulting in no delays in median time to neutrophil and platelet engraftment, significant increase in adverse reaction or nonconformances. DISCUSSION: The effectiveness outcomes of the first Canadian experience in the implementation of a closed semi-automated volume reduction system in the processing of HPC-A products for autologous transplant have met the predetermined acceptance criteria, supporting its use in a stem cell manufacturing laboratory compliant with good manufacturing practice regulations.