Deciphering the Dual Roles of an Alginate-Based Biodegradable Flocculant in Anaerobic Fermentation of Waste Activated Sludge: Dewaterability and Degradability.

Biodegradable flocculants are rarely used in waste activated sludge (WAS) fermentation. This study introduces an alginate-based biodegradable flocculant (ABF) to enhance both the dewatering and degradation of WAS during its fermentation. Alginate was identified in structural extracellular polymeric substances (St-EPS) of WAS, with alginate-producing bacteria comprising ∼4.2% of the total bacterial population in WAS. Owing to its larger floc size, higher contact angle, and lower free energy resulting from the Lewis acid-base interaction, the addition of the prepared ABF with a network structure significantly improved the dewaterability of WAS and reduced capillary suction time (CST) by 72%. The utilization of ABF by an enriched alginate-degrading consortium (ADC) resulted in a 35.5% increase in the WAS methane yield owing to its higher hydrolytic activity on both ABF and St-EPS. Additionally, after a 30 day fermentation, CST decreased by 62% owing to the enhanced degradation of St-EPS (74.4%) and lower viscosity in the WAS + ABF + ADC group. The genus Bacteroides, comprising 12% of ADC, used alginate lyase (EC 4.2.2.3) and pectate lyase (EC 4.2.2.2 and EC 4.2.2.9) to degrade alginate and polygalacturonate in St-EPS, respectively. Therefore, this study introduces a new flocculant and elucidates its dual roles in enhancing both the dewaterability and degradability of WAS. These advancements improve WAS fermentation, resulting in higher methane production and lower CSTs.

Core-Shell Au@Nanoplastics as a Quantitative Tracer to Investigate the Bioaccumulation of Nanoplastics in Freshwater Ecosystems.

Studies on the adverse effects of nanoplastics (NPs, particle diameter <1000 nm) including physical damage, oxidative stress, impaired cell signaling, altered metabolism, developmental defects, and possible genetic damage have intensified in recent years. However, the analytical detection of NPs is still a bottleneck. To overcome this bottleneck and obtain a reliable and quantitative distribution analysis in complex freshwater ecosystems, an easily applicable NP tracer to simulate their fate and behavior is needed. Here, size- and surface charge-tunable core-shell Au@Nanoplastics (Au@NPs) were synthesized to study the environmental fate of NPs in an artificial freshwater system. The Au core enables the quantitative detection of NPs, while the polystyrene shell exhibits NP properties. The Au@NPs showed excellent resistance to environmental factors (e.g., 1% hydrogen peroxide solution, simulating gastric fluid, acids, and alkalis) and high recovery rates (>80%) from seawater, lake water, sewage, waste sludge, soil, and sediment. Both positively and negatively charged NPs significantly inhibited the growth of duckweed (Lemna minor L.) but had little effect on the growth of cyanobacteria (Microcystis aeruginosa). In addition, the accumulation of positively and negatively charged NPs in cyanobacteria occurred in a concentration-dependent manner, with positively charged NPs more easily taken up by cyanobacteria. In contrast, negatively charged NPs were more readily internalized in duckweed. This study developed a model using a core-shell Au@NP tracer to study the environmental fate and behavior of NPs in various complex environmental systems.

Effects of salvaged cyanobacteria content on larval development and feedstock humification during black soldier fly larvae (Hermetia illucens) composting.

Cyanobacteria salvage is widely used to deal with massive cyanobacterial blooms. Improper disposal of salvaged cyanobacteria would cause secondary pollution. Black soldier fly (Hermetia illucens) larvae (BSFL) can bio-convert organic wastes into larval biomass, which is rich in protein and lipid. This study evaluated the possibility of using BSFL composting for salvaged cyanobacteria treatment. Results showed that increasing salvaged cyanobacteria waste (CW) content (from 0 to 50%, dry weight basis) extended BSFL development time, e.g., BSFL fed with 50% CW needed 14 days more to finish development than Control (0% CW). The CW content (0-20%) in feeding substrates had no significant effect on BSFL body length and weight. Whereas further increase of CW content (from 20 to 50%) led to significant reductions in substrate-to-BSFL biomass conversion ratio, body size, body weight, and crude protein content of BSFL. Meanwhile, the presence of salvaged cyanobacteria in the feeding substrate reduced the degradation efficiency of feeding substrate. The dissolved organic matter (DOM) results demonstrated that the increased salvaged cyanobacteria content made it more difficult for BSFL to degrade the feeding substrate into simple organic matter and further into humic-like substances. Furthermore, salvaged cyanobacteria in feeding substrates affected the intestinal microbial community significantly. With 20% CW content in the feeding substrate, the relative abundance of Firmicutes decreased from 92.43 to 81.24%, while the relative abundance of Proteobacteria and Bacteroidetes increased from 4.10 to 2.93-8.75% and 7.51%, respectively. BSFL composting is feasible to convert salvaged cyanobacteria into insect biomass. However, the salvaged cyanobacteria content in the feeding substrate should be carefully controlled (e.g., less than 30%).

Effects of size and surface charge on the sedimentation of nanoplastics in freshwater.

The environmental issues caused by nanoplastics (NPs) are increasingly noticeable. Environmental behavior study of the NPs could provide vital information for their environmental impact assessment. However, associations between NPs' inherent properties and their sedimentation behaviors were seldom investigated. In this study, six types of PSNPs (polystyrene nanoplastics) with different charges (positive and negative) and particle sizes (20-50 nm, 150-190 nm and 220-250 nm) were synthesized, and their sedimentations under different environmental factors, (e.g., pH value, ionic strength (IS), electrolyte type and natural organic matter) were investigated. Results displayed that both particle size and surface charge would affect the sedimentation of PSNPs. The maximum sedimentation ratio of 26.48% was obtained in positive charged PSNPs with size of 20-50 nm, while the minimum sedimentation ratio of 1.02% was obtained in negative charged PSNPs with size of 220-250 nm at pH 7.6. The pH value shift (range of 5-10) triggered negligible changes of sedimentation ratio, the average particle size and the Zeta potential. Small size PSNPs (20-50 nm) showed higher sensitivity to IS, electrolyte type and HA condition than large size PSNPs. At high IS value ( [Formula: see text]  = 30 mM or ISNaCl = 100 mM), the sedimentation ratios of the PSNPs all increased differently according to their properties, and the sedimentation promoting effect of CaCl2 was more significant on negative charged PSNPs than positive charged PSNPs. When [Formula: see text] increased from 0.9 to 9 mM, the sedimentation ratios of negative charged PSNPs increased by 0.53%-23.49%, while that of positive charged PSNPs increased by less than 10%. Besides, humic acid (HA) addition (1-10 mg/L) would lead to a stable suspension status for PSNPs in water with different degree and perhaps different mechanism due to their charge characteristics. These results showed new light on influence factor studies of NPs' sedimentation and would be helpful for further knowledge of NPs' environmental behaviors.

Integrated Passive Sensing Chip for Highly Sensitive and Reusable Detection of Differential-Charged Nanoplastics Concentration.

In this work, a new type, highly sensitive, and reusable nanoplastics (NPs) microwave detection method is proposed, which can be used to rapidly analyze NPs with different surface charges and sizes. The effective dielectric constant of NPs varies according to the different concentrations, particle sizes, and surface charges of NPs in aqueous solution. The feasibility of the microwave method for differential-charged NPs detection is verified using a complementary split ring resonator sensor manufactured on a cost-effective printed circuit board, which shows a high sensitivity only for positively charged NPs (PS-NH2) detection. To achieve microwave detection of both positively and negatively charged NPs (PS-SO3H), a microscale spiral-coupled resonator sensing chip is manufactured through integrated passive technology, which demonstrates extremely low detection limits and high sensitivity for both PS-NH2 and PS-SO3H, with different concentrations, particle sizes, and charges. In addition, for NPs solution doped with methyl orange, the device can still perform stable measurements, overcoming the inability of traditional NPs molecular element determination and optical detection methods to detect NPs aqueous solution with organic matter doping and color presence. The proposed microwave detection method could also be extended to sensing detection for detecting other hazardous environmental substances.

Improving anaerobic digestion of corn straw by using solid-state urea pretreatment.

The resistant structure and high carbon/nitrogen ratio (C/N) of cellulosic substrate are the barriers during their anaerobic digestion (AD). Solid-state urea pretreatment was developed in this study to pretreat corn straw and adjust C/N ratio simultaneously for the downstream AD of corn straw. Results showed solid-state urea pretreatment was efficient in lignin removal and achieved the highest lignin reduction of 7.06% with C/N ratio = 15 during pretreatment. Scanning electron microscopy demonstrated the destruction of the dense structure by pretreatment, which benefited to the hydrolysis of corn straw. The cumulative methane yields of the pretreated corn straw ranged from 234.07 to 250.03 mL/g VS, which were obviously higher than that of the untreated corn straw. The maximum methane yield of 250.03 mL/g VS was achieved with C/N = 15 during pretreatment, which was 23.91% higher than that of the untreated group. In addition, AD digestates from the pretreated groups had 9.62% higher nutrients than that from the untreated group. The solid-state urea pretreatment can destroy the dense structure of corn straw and regulate the C/N ratio during AD, thus benefit the methane production and fertilizer use of the digestate, which is a potential choice during the AD of cellulosic substrate.

Understanding the mechanisms behind enhanced anaerobic digestion of corn straw by humic acids.

Humic acids (HAs) are abundant on earth, yet their effects on anaerobic digestion (AD) of cellulosic substrate are not fully uncovered. The effects of HAs on AD of corn straw and the mechanisms behind were analyzed in this study. Results showed that the effects of HAs on methane yield were closely related to the total solids (TS) content. At relative high TS content of 5.0%, HAs benefited AD process by increasing 13.8% of methane yield, accelerating methane production rate by 43% and shortening lag phase time by 37.5%. Microbial community analysis indicated that HAs increased the relative abundance of syntrophic bacteria (Syntrophomonadaceae and Synergistaceae), facilitating the degradation of volatile fatty acids. HAs might act as electron shuttles to directly transfer electrons to hydrogenotrophic methanogens for CO2 reduction to CH4. This study provides a simple and efficient strategy to facilitate the AD of cellulosic substrate by HAs addition.

Producing insect protein from food waste digestate via black soldier fly larvae cultivation: A promising choice for digestate disposal.

The treatment of food waste digestate with high salinity is a big challenge. This paper evaluated the possibility of using black soldier fly larvae for food waste digestate disposal and insect protein production. Results showed that both digestates from hydrogen and methane fermentations were rich in protein and lipid contents, which benefited the BSFL cultivation. The BSFL reared on digestates from hydrogen and methane fermentations of food waste performed better in pre-pupal weight (19.12% and 41.13% higher, respectively), body length (3.62% and 18.21% higher, respectively) and crude protein contents (7.85% and 39.05% higher, respectively) than that reared on raw food waste. In addition, the maximum body weight growth rate (Rm) of BSFL cultivated on both digestates were 28.28% and 47.10% higher than that of BSFL cultivated on raw food waste, respectively. During BSFL cultivation, organic matter reduction between 40.97% and 46.07% were achieved. Digestates from hydrogen and methane fermentations represent favorable feeding substrates for BSFL cultivation. Using BSFL to treat AD digestate not only provides a digestate disposal approach, but also produces insect biomass and organic fertilizer as value-added byproducts, which shows tremendous potential in digestate disposal.

Improved anaerobic digestion efficiency of high-solid sewage sludge by enhanced direct interspecies electron transfer with activated carbon mediator.

High-solid anaerobic digestion (AD) faces the problems of easy acidification and low methane production efficiency. In this study, activated carbon (AC)-enhanced direct interspecies electron transfer (DIET) was investigated to overcome such problems. Results showed the conversion of volatile fatty acids (VFAs) into methane rate was increased with AC addition, which led improved methane production efficiency. The methane yields from the early AD stage improved by 124.0-146.3% with AC addition. The T80 shortened by 8-9 days with AC addition. The relative abundances of Geobacter, Syntrophomonas and Methanosaeta that associated with DIET improved for 63.65%, 256.3% and 4.35% by AC addition, which reflected the enhanced DIET with AC addition. The redox activity of AC might be responsible for the enhanced DIET. This study would advance the understanding of DIET and provide a potential solution to the problems existed in high-solid AD.

Improved methane removal in exhaust gas from biogas upgrading process using immobilized methane-oxidizing bacteria.

Methane in exhaust gas from biogas upgrading process, which is a greenhouse gas, could cause global warming. The biofilter with immobilized methane-oxidizing bacteria (MOB) is a promising approach for methane removal, and the selections of inoculated MOB culture and support material are vital for the biofilter. In this work, five MOB consortia were enriched at different methane concentrations. The MOB-20 consortium enriched at the methane concentration of 20.0% (v/v) was then immobilized on sponge and two particle sizes of volcanic rock in biofilters to remove methane in exhaust gas from biogas upgrading process. Results showed that the immobilized MOB performed more admirable methane removal capacity than suspended cells. The immobilized MOB on sponge reached the highest methane removal efficiency (RE) of 35%. The rough surface, preferable hydroscopicity, appropriate pore size and particle size of support material might favor the MOB immobilization and accordingly methane removal.

Exposure to polystyrene nanoplastic leads to inhibition of anaerobic digestion system.

In this study, impacts of nanoplastic on the pure and mixed anaerobic digestion systems were investigated. Results showed the growth and metabolism of Acetobacteroides hydrogenigenes were partly inhibited by nanoplastic existed in the pure anaerobic digestion system. The anaerobic digestion of sewage sludge was also obviously inhibited by nanoplastic existed in the mixed anaerobic digestion system. Both the methane yield and methane production rate of the mixed anaerobic digestion system showed negative correlation with the nanoplastic concentration. Compared with anaerobic digestion system without nanoplastic, methane yield and maximum daily methane yield at the nanoplastic concentration of 0.2g/L decreased for 14.4% and 40.7%, respectively. In addition, the start-up of mixed anaerobic digestion system was prolonged by addition of nanoplastic. Microbial community structure analysis indicated the microbial community structures were also affected by nanoplastic existed in the system. At the nanoplastic concentration of 0.2g/L, the relative abundances of family Cloacamonaceae, Porphyromonadaceae, Anaerolinaceae and Gracilibacteraceae decreased partly. Conversely, the relative abundances of family Anaerolinaceae, Clostridiaceae, Geobacteraceae, Dethiosulfovibrionaceae and Desulfobulbaceae improved partly.

Elimination of methane in exhaust gas from biogas upgrading process by immobilized methane-oxidizing bacteria.

Biogas upgrading is essential for the comprehensive utilization of biogas as substitute of natural gas. However, the methane in the biogas can be fully recovered during the upgrading process of biogas, and the exhaust gas produced during biogas upgrading may contain a very low concentration of methane. If the exhaust gas with low concentration methane releases to atmosphere, it will be harmful to environment. In addition, the utilization of large amounts of digestate produced from biogas plant is another important issue for the development of biogas industry. In this study, solid digestate was used to produce active carbon, which was subsequently used as immobilized material for methane-oxidizing bacteria (MOB) in biofilter. Biofilter with MOB immobilized on active carbon was used to eliminate the methane in exhaust gas from biogas upgrading process. Results showed porous active carbon was successfully made from solid digestate. The final methane elimination capacity of immobilized MOB reached about 0.13molh-1m-3, which was more 4 times higher than that of MOB without immobilization.

Effects of organic loading rate on biogas production from macroalgae: Performance and microbial community structure.

Macroalgae biomass has been considered as a promising feedstock for biogas production. In order to improve the efficiency of anaerobic digestion (AD) of macroalgae, semi-continuous fermentation was conducted to examine the effects of organic loading rate (OLR) on biogas production from Macrocystis pyrifer. Results showed that, under OLRs of 1.37, 2.74, 4.12 and 6.85kgVSsubstrate/(m3·d), the average unit biogas yields were 438.9, 477.3, 480.1 and 188.7mL/(gVSsubstrated), respectively. It indicated that biogas production was promoted by the increased OLR in an appropriate range while inhibited by the OLR beyond the appropriate range. The investigation on physical-chemical parameters revealed that unfavorable VFAs concentration, pH and salinity might be the main causes for system failure due to the overrange OLR, while the total phenols failed to reach the inhibitory concentration. Microbial community analysis demonstrated that several bacterial and archaeal phyla altered with increase in OLR apparently.

The chemical properties and microbial community characterization of the thermophilic microaerobic pretreatment process.

Thermophilic microaerobic pretreatment (TMP) was recently reported as an efficient pretreatment method of anaerobic digestion (AD). In this study, the chemical properties and microbial community were characterized to reveal how TMP working. Compared with thermophilic treatment under anaerobic condition (TMP0), cellulase activity obviously improved under microaerobic condition (TMP1), which was 10.9-49.0% higher than that of TMP0. Reducing sugar, SCOD and VFAs concentrations of TMP1 were 2.6-8.9%, 1.8-4.8% and 13.8-24% higher than those of TMP0, respectively. TMP gave obvious rise to phylum Firmicutes, which associated with extracellular enzymes production. The proportion of class Bacilli (belongs to phylum Firmicutes and mainly acts during hydrolysis) in TMP1 was 124.89% higher than that of TMP0, which reflected the greater hydrolytic ability under microaerobic condition. The improved abundance of phylum Firmicutes (especially class Bacilli, order Bacillales) under microaerobic condition could be the fundamental reason for the improved AD performance of thermophilic microaerobic pretreated corn straw.

The thermophilic (55°C) microaerobic pretreatment of corn straw for anaerobic digestion.

Microaerobic process has been proven to be an alternative pretreatment for the anaerobic digestion (AD) process in several studies. In this study, the effect of thermophilic microaerobic pretreatment (TMP) on the AD of corn straw was investigated. Results indicated that TMP process obviously improved the methane yield. The maximum methane yield was obtained at the oxygen loads of 5ml/g VSsubstrate, which was 16.24% higher than that of untreated group. The modified first order equation analysis showed the TMP process not only accelerated the hydrolysis rates but also reduced the lag-phase time of AD process. The structural characterization analysis showed cellulosic structures of corn straw were partly disrupted during TMP process. The crystallinity indexes were also decreased. In addition, large or destroyed pores and substantial structural disruption were observed after pretreatment. The results showed that TMP is an efficient pretreatment method for the AD of corn straw.

Secondary thermophilic microaerobic treatment in the anaerobic digestion of corn straw.

Thermophilic microaerobic pretreatment (TMP) has been proved to be an alternative pretreatment method during anaerobic digestion (AD) of corn straw. In this study, in order to improve the fermentation efficiency during late AD stage, improve the methane yield and volatile solid (VS) removal efficiency, a secondary thermophilic microaerobic treatment (STMT) was applied in the late AD stage of corn straw. Results showed STMT obviously improved the fermentation efficiency, methane yield and VS removal efficiency. The maximum methane yield and maximum VS removal efficiency were simultaneously obtained when the oxygen loads during STMT was 10 ml/g VS (VS of residual substrate). The maximum methane yield was 380.6 ml/g VS(substrate), which was 28.45% and 10.61% higher than those of untreated and once thermophilic microaerobic pretreated samples, respectively. The maximum VS removal efficiency was 81.85%, which was 29.43% and 17.23% higher than those of untreated and once thermophilic microaerobic pretreated samples, respectively.