Briquetting of sugarcane bagasse as a proper waste management technology in Vietnam.

The present research describes an application of high-pressure briquetting technology to the waste management of sugarcane processing in Vietnam. The amount of generated sugarcane bagasse was monitored during sugarcane processing within the street juice production in Hue city, Vietnam. Generated sugarcane bagasse was subjected to fuel parameters analysis within its suitability for direct combustion. The obtained sugarcane bagasse was converted into bio-briquette fuel by a high-pressure briquetting press and its mechanical quality was determined. Results proved that the proportion of generated sugarcane bagasse from whole sugarcane stem mass was equal to 35.45%. This indicated generation of an abundant amount of sugarcane bagasse worldwide in general. Fuel parameters analysis proved high quality level of low ash content = 0.97% and high calorific values (gross calorific value = 18.35 MJ·kg-1, net calorific value = 17.06 MJ·kg-1), which indicated good suitability for direct combustion processes. Indicators of mechanical quality proved the following observations: mechanical durability = 99.29%, compressive strength = 150.82 N∙mm-1 and bulk density = 1022.44 kg·m-3, with all these indicators representing positive results. In general, the observed results indicated suitability of sugarcane bagasse valorization within the production of bio-briquette fuel by using high-pressure briquetting technology. Finally, analysis of such waste biomass proved its great potential for energy recovery, thus, the advantage of its valorization within the sustainable technologies.

Practice on improving fattening local cattle production in Vietnam by increasing crude protein level in concentrate and concentrate level.

Two experiments were conducted to determine the effects of crude protein (CP) level in concentrate (experiment 1) and concentrate level (experiment 2) on feed intake, nutrient digestibility, nitrogen (N) retention, ruminal pH and NH3-N concentration and average daily gain (ADG) of Vietnamese local fattening cattle. Animals (24 cattle, initial live weight (LW) 150.3 ± 11.8 kg in experiment 1 and 145.1 ± 9.8 kg in experiment 2) were allotted based on LW to one of four treatments in a randomised complete block design. In experiment 1, concentrate with four levels of CP (10, 13, 16 and 19 %) was fed at 1.5 % of LW. In experiment 2, concentrate was fed at 1.0, 1.4, 1.8 and 2.2 % of LW. In both experiments, roughage was 5 kg/day native grass and ad libitum rice straw (fresh basis). Results showed that the CP level in concentrate significantly affected dry matter (DM) intake (P < 0.05), N retention, ADG and ruminal NH3-N concentration (P < 0.01), but it had no significant effect on DM, organic matter (OM) and neutral detergent fibre (NDF) digestibility (P > 0.05), whereas CP digestibility increased (P < 0.001) along with the CP level. DM intake, N retention and ADG increased (P < 0.001) linearly with concentrate intake. DM and CP digestibility were not significantly affected by concentrate intake (P > 0.05). OM digestibility and NH3-N concentration increased linearly (P < 0.05), whereas NDF digestibility and ruminal pH declined linearly with increased concentrate consumption (P < 0.01). These results indicate that 16 % CP in concentrate and feeding concentrate at the rate of 2.2 % of LW are recommendable for fattening local cattle in Vietnam.

Evaluation of a nutrition model in predicting performance of vietnamese cattle.

The objective of this study was to evaluate the predictions of dry matter intake (DM) and average daily gain (ADG) of Vietnamese Yellow (Vang) purebred and crossbred (Vang with Red Sindhi or Brahman) bulls fed under Vietnamese conditions using two levels of solution (1 and 2) of the large ruminant nutrition system (LRNS) model. Animal information and feed chemical characterization were obtained from five studies. The initial mean body weight (BW) of the animals was 186, with standard deviation ±33.2 kg. Animals were fed ad libitum commonly available feedstuffs, including cassava powder, corn grain, Napier grass, rice straw and bran, and minerals and vitamins, for 50 to 80 d. Adequacy of the predictions was assessed with the Model Evaluation System using the root of mean square error of prediction (RMSEP), accuracy (Cb), coefficient of determination (r(2)), and mean bias (MB). When all treatment means were used, both levels of solution predicted DMI similarly with low precision (r(2) of 0.389 and 0.45 for level 1 and 2, respectively) and medium accuracy (Cb of 0.827 and 0.859, respectively). The LRNS clearly over-predicted the intake of one study. When this study was removed from the comparison, the precision and accuracy considerably increased for the level 1 solution. Metabolisable protein was limiting ADG for more than 68% of the treatment averages. Both levels differed regarding precision and accuracy. While level 1 solution had the least MB compared with level 2 (0.058 and 0.159 kg/d, respectively), the precision was greater for level 2 than level 1 (0.89 and 0.70, respectively). The accuracy (Cb) was similar between level 1 and level 2 (p = 0.8997; 0.977 and 0.871, respectively). The RMSEP indicated that both levels were on average under- or over-predicted by about 190 g/d, suggesting that even though the accuracy (Cb) was greater for level 1 compared to level 2, both levels are likely to wrongly predict ADG by the same amount. Our analyses indicated that the level 1 solution can predict DMI reasonably well for this type of animal, but it was not entirely clear if animals consumed at their voluntary intake and/or if the roughness of the diet decreased DMI. A deficit of ruminally-undegradable protein and/or a lack of microbial protein may have limited the performance of these animals. Based on these evaluations, the LRNS level 1 solution may be an alternative to predict animal performance when, under specific circumstances, the fractional degradation rates of the carbohydrate and protein fractions are not known.