Optimizing the First Step of the Biocatalytic Process for Green Leaf Volatiles Production: Lipase-Catalyzed Hydrolysis of Three Vegetable Oils.

Green leaf volatiles (GLVs), including short chain volatile aldehydes, are widely used in the flavor and food industries because of their fresh aroma. To meet the growing demand for natural GLVs with high added value, the use of biocatalytic processes appears as a relevant application. In such processes, vegetable oils are bioconverted into GLVs. First, the triacylglycerols of the oils are hydrolyzed by a lipase. Then, the free polyunsaturated fatty acids are converted by a lipoxygenase. Finally, volatile C6 or C9 aldehydes and 9- or 12-oxoacids are produced with a hydroperoxide lyase. Optimization of each biocatalytic step must be achieved to consider a scale-up. In this study, three oils (sunflower, hempseed, and linseed oils) and three lipases (Candida rugosa, Pseudomonas fluorescens, and Rhizomucor miehei lipases) have been tested to optimize the first step of the process. The experimental design and response surface methodology (RSM) were used to determine the optimal hydrolysis conditions for each oil. Five factors were considered, i.e., pH, temperature, reaction duration, enzyme load, and oil/aqueous ratio of the reaction mixture. Candida rugosa lipase was selected as the most efficient enzyme to achieve conversion of 96 ± 1.7%, 97.2 ± 3.8%, and 91.8 ± 3.2%, respectively, for sunflower, hempseed, and linseed oils under the defined optimized reaction conditions.

Neuropeltis acuminata (P. Beauv.): Investigation of the Chemical Variability and In Vitro Anti-inflammatory Activity of the Leaf Essential Oil from the Ivorian Species.

The variability of chemical composition of the leaf essential oil (EO) from Neuropeltis acuminata, a climbing liana growing wild in Ivory Coast, was investigated for the first time. The in vitro anti-inflammatory activity was also evaluated. Thirty oil samples were isolated from leaves collected in three forests of the country and analyzed using a combination of Column Chromatography (CC), Gas Chromatography with Retention Indices (GC(FID)), Gas Chromatography-Mass Spectrometry (GC-MS), and 13Carbon-Nuclear Magnetic Resonance (13C-NMR). Fractionation by CC led to the first-time isolation from natural source of δ-cadinen-11-ol, whose structural elucidation by one dimension (1D) and 2D-NMR spectroscopy is reported here. Finally, 103 constituents accounting for 95.7 to 99.6% of the samples' compositions were identified. As significant variations of the major constituents were observed, the 30 oil compositions were submitted to hierarchical cluster and principal components analyses. Five distinct groups were evidenced: Group I, dominated by (E)-ß-caryophyllene, kessane, and δ-cadinene, while the main constituents of Group II were germacrene B, ledol, α-humulene, (E)-γ-bisabolen-12-ol, and γ-elemene. Group III exhibited guaiol, germacrene D, atractylone, (E)-γ-bisabolen-12-ol, δ-cadinene and bulnesol as main compounds. Group IV was dominated by (E)-nerolidol, guaiol, selina-4(15),7(11)-diene and bulnesol, whereas (E)-ß-caryophyllene, α-humulene and α-muurolene were the prevalent compounds of Group V. As the harvest took place in the same dry season in the three forests, the observed chemical variability could be related to harvest sites, which includes climatic and pedologic factors, although genetic factors could not be excluded. The leaf oil sample S24 behaved as a high inhibitor of LipOXygenase (LOX) activity (half maximum Inhibitory Concentration, IC50: 0.059 ± 0.001 mg mL-1), suggesting an anti-inflammatory potential.

Activation and Stabilization of Olive Recombinant 13-Hydroperoxide Lyase Using Selected Additives.

The stabilization of olive recombinant hydroperoxide lyases (rHPLs) was investigated using selected chemical additives. Two rHPLs were studied: HPL full-length and HPL with its chloroplast transit peptide deleted (matured HPL). Both olive rHPLs are relatively stable at 4 °C, and enzyme activity can be preserved (about 100% of the rHPL activities are maintained) during 5 weeks of storage at -20 or at -80 °C in the presence of glycerol (10%, v/v). Among the additives used in this study, glycine (2.5% w/v), NaCl (0.5 M), and Na2SO4 (0.25 M) provided the highest activation of HPL full-length activity, while the best matured HPL activity was obtained with Na2SO4 (0.25 M) and NaCl (1 M). Although the inactivation rate constants (k) showed that these additives inactivate both rHPLs, their use is still relevant as they strongly increase HPL activity. Results of C6-aldehyde production assays also showed that glycine, NaCl, and Na2SO4 are appropriate additives and that NaCl appears to be the best additive, at least for hexanal production.

Olive Recombinant Hydroperoxide Lyase, an Efficient Biocatalyst for Synthesis of Green Leaf Volatiles.

Volatile C6-aldehydes are the main contributors to the characteristic odor of plants known as "green note" and are widely used by the flavor industry. Biotechnological processes were developed to fulfill the high demand in C6-aldehydes in natural flavorants and odorants. Recombinant hydroperoxide lyases (HPLs) constitute an interesting alternative to overcome drawbacks arising from the use of HPL from plant extracts. Thus, olive recombinant 13-HPL was assayed as biocatalysts to produce C6-aldehydes. Firstly, a cDNA encoding for olive HPL of Leccino variety was isolated and cloned in pQE-30 expression vector. In order to improve the enzyme solubility, its chloroplast transit peptide was deleted. Both enzymes (HPL wild type and HPL deleted) were expressed into Escherichia coli strain M15, purified, characterized, and then used for bioconversion of 13-hydroperoxides of linoleic and linolenic acids. Aldehydes produced were extracted, then identified and quantified using gas chromatography and mass spectrometry. Recombinant HPL wild type (HPLwt) allowed producing 5.61 mM of hexanal and 4.39 mM of 3Z-hexenal, corresponding to high conversion yields of 93.5 and 73 %, respectively. Using HPL deleted (HPLdel) instead of HPLwt failed to obtain greater quantities of hexanal or 3Z-hexenal. No undesirable products were formed, and no isomerization of 3Z-hexenal in 2E-hexenal occurred. The olive recombinant HPLwt appears to be a promising efficient biocatalyst for the production of C6-aldehydes.