La Substitution into the Melilite Derivative Ca5Ga6O14: Prediction, Synthesis and Ionic Conductivity.

Melilite-type gallates of general formula RE1+xAE1-xGa3O7+x/2 are of interest for their ability to host mobile interstitial oxide ions in [Ga3O7+x] layers. The crystal structure of Ca5Ga6O14 is closely related to melilite, with [Ga3O7] layers stacked in a more complex way to accommodate an additional 0.5 interlayer cations per formula unit, suggesting the potential for similar oxide ion conduction behavior. We used a computational approach to identify the most promising routes to interstitial oxide incorporation into Ca5Ga6O14, leading to an experimental investigation of the system Ca5-xLaxGa6O14+x/2. Single-phase materials were obtained in the range 0 ≤ x ≤ 0.25 by solid state reactions, producing an ∼40× increase in ionic conductivity at 800 °C. This limited compositional range presents a challenge for characterization of the charge-compensating defects. The La substituents were observed directly by X-ray diffraction and STEM-EDX, and a combination of different structural characterization techniques and DFT calculations indicated the presence of interstitial oxide ions indirectly, explaining the conductivity response. As higher carrier concentrations (x > 0.25) are apparently inaccessible in this system, we conclude that its potential as a useful oxide ion conductor is more limited than that of established melilite materials such as La1+xCa1-xGa3O7+x/2.

Stabilization of the Trigonal Langasite Structure in Ca3Ga2-2xZnxGe4+xO14 (0 ≤ x ≤ 1) with Partial Ordering of Three Isoelectronic Cations Characterized by a Multitechnique Approach.

Crystallization of oxide glasses rich in Zn2+, Ga3+, and Ge4+ is of interest for the synthesis of new transparent ceramics. In this context, we report the identification and detailed structural characterization of a new solid solution Ca3Ga2-2xZnxGe4+xO14 (0 ≤ x ≤ 1). These compounds adopt the trigonal langasite structure type, offering three possible crystallographic sites for the coordination of isoelectronic Zn2+, Ga3+, and Ge4+. We used neutron diffraction to determine distributions of Ga3+/Ge4+ and Zn2+/Ge4+ in the simpler end members Ca3Ga2Ge4O14 and Ca3ZnGe5O14, while for the complex intermediate member Ca3GaZn0.5Ge4.5O14, we used an original approach combining quantitative 2D analysis of atomic-resolution STEM-EDS maps with neutron diffraction. This revealed that, across the solid solution, the tetrahedral D sites remain fully occupied by Ge4+, while Zn2+, Ga3+, and the remaining Ge4+ are shared between octahedral B- and tetrahedral C sites in proportions that depend upon their relative ionic radii. The adoption of the trigonal langasite structure by glass-crystallized Ca3ZnGe5O14, a compound that was previously observed only in a distorted monoclinic langasite polymorph, is attributed to substantial disorder between Zn2+ and Ge4+ over the B and C sites. The quantitative 2D refinement of atomic-resolution STEM-EDS maps is applicable to a wide range of materials where multiple cations with poor scattering contrast are distributed over different crystallographic sites in a crystal structure.

Emergence of A-Site Cation Order in the Small Rare-Earth Melilites SrREGa3O7 (RE = Dy-Lu, Y).

SrREGa3O7 melilite ceramics with large rare-earth elements (RE = La to Y) are famous materials especially known for their luminescence properties. Using an innovative approach, the full and congruent crystallization from glass process, SrREGa3O7 transparent polycrystalline ceramics with small rare earth elements (RE = Dy-Lu and Y) have been successfully synthesized and characterized. Interestingly, compared to the classic tetragonal (P4̅21m) melilite structure composed of mixed Sr/RE cationic sites, these compositions can crystallize in a 3 × 1 × 1 orthorhombic (P21212) superstructure. A detailed study of the superstructure, investigated using different techniques (synchrotron and neutron powder diffraction, STEM-HAADF imaging, and EDS mapping), highlights the existence of a Sr/RE cation ordering favored by a large Sr/RE size mismatch and a sufficiently small RE cation. An appropriate control of the synthesis conditions through glass crystallization enables the formation of the desired polymorphs, either ordered or disordered. The influence of this tailored cationic ordering/disordering on the RE luminescent spectroscopic properties have been investigated. A stronger structuration of the RE emission band is observed in the ordered ceramic compared to the disordered ceramic and the glass, whose band shapes are very similar, indicating that the RE environments in the glass and disordered ceramic are close.