A latex agglutination assay to quantify the amount of hemagglutinin protein in adjuvanted low-dose influenza monovalent vaccines.

To formulate inactivated influenza vaccines, the concentration of hemagglutinin (HA) must be accurately determined. The standard test currently used to measure HA in influenza vaccines is the Single Radial Immunodiffusion (SRID) assay. We developed a very rapid, simple and sensitive alternative quantitative HA assay, namely the Latex Agglutination Assay (LAA). The LAA uses the Spherotest® technology, which is based on the agglutination of HA-specific immunoglobulin-coated latex beads. The amount of HA in a sample is calculated from the level of bead agglutination by a simple absorbance measurement at 405nm against a standard curve generated using a monovalent vaccine standard. In less than 2hours, tens of samples could be quantified using the LAA as opposed to 2days for the SRID assay. Ten steps are required to complete an SRID assay as compared to 6 steps for the LAA, from sample preparation through spectrophotometric analysis. Furthermore, the limit of detection of the LAA was found to be approximately 15ng HA/mL, similar to an ELISA, with the quantification of less than 1.8µg HA/mL. The quantification limit of the SRID is usually considered to be approximately 5µg HA/mL. The development of the assay and a comparison of the titers obtained by SRID and LAA for several monovalent vaccines corresponding to various strains were performed. For A/H5N1 and A/H1N1 monovalent vaccines, the LAA was found to be linear and accurate as compared to the SRID. The precision of the LAA was close to that of the standard test, and good reproducibility from one laboratory to another was observed. Moreover, the LAA enabled HA quantification in AlOOH-adjuvanted and in emulsion-adjuvanted low-dose vaccines as well as unadjuvanted vaccines. In conclusion, LAA may be useful to rapidly and accurately measure influenza HA protein in monovalent vaccines, especially in those containing less than 5µg/mL of HA in the presence of an adjuvant.

Optimization of influenza A vaccine virus by reverse genetic using chimeric HA and NA genes with an extended PR8 backbone.

The yield of influenza antigen production may significantly vary between vaccine strains; for example the A/California/07/09 (H1N1)-X179A vaccine virus, prepared during 2009 influenza pandemic, presented a low antigen yield in eggs compared to other seasonal H1N1 reassortants. In this study a bi-chimeric virus expressing HA and NA genes with A/Puerto Rico/8/34 (H1N1) (PR8) and X179A domains was rescued by reverse genetics using a mixture of Vero/CHOK1 cell lines (Medina et al. [7]). The bi-chimeric virus obtained demonstrated to yield much larger amounts of HA than X179A in eggs as measured by single-radial-immunodiffusion (SRID), the reference method to quantify HA protein in influenza vaccine. Such kind of optimized virus using PR8 backbone derived chimeric glycoproteins could be used as improved seed viruses for vaccine production.

Vero/CHOK1, a novel mixture of cell lines that is optimal for the rescue of influenza A vaccine seeds.

Seasonal and pandemic influenza vaccine manufacturing is challenged with a tight production schedule. Reverse genetics constitutes a rapid method for creating viruses. Vero and CHOK1 cells were found to be an appropriate cell mixture for the generation of influenza reassortants by reverse genetics under the constraints of vaccine production, such as the use of regulatory-compliant cells and culture media devoid of components of animal origin. In addition, no further amplification in cell or egg substrates was required, thus reducing the time needed to obtain reassortant seed virus. In parallel, the cloning step was shown to be dramatically improved, permitting the rapid vRNA expression of influenza viruses. In addition, nucleoporation of the cells was conducted to more efficiently target the nucleus and avoid the use of chemical reagents containing proteins of animal origin. In conclusion, the reverse genetics system for influenza A viruses reported in this study was shown to be rapid, simple to perform and totally animal component-free to best comply with the requirements of health authorities for the production of a vaccine seed.

Characterization and immunogenicity in mice of recombinant influenza haemagglutinins produced in Leishmania tarentolae.

The membrane displayed antigen haemagglutinin (HA) from several influenza strains were expressed in the Leishmania tarentolae system. This non-conventional expression system based on a parasite of lizards, can be readily propagated to high cell density (>10(8)cells/mL) in a simple incubator at 26°C. The genes encoding HA proteins were cloned from six influenza strains, among these being a 2009 A/H1N1 pandemic strain from swine origin, namely A/California/07/09(H1N1). Soluble HA proteins were secreted into the cell culture medium and were easily and successfully purified via a His-Tag domain fused to the proteins. The overall process could be conducted in less than 3 months and resulted in a yield of approximately 1.5-5mg of HA per liter of biofermenter culture after purification. The recombinant HA proteins expressed by L. tarentolae were characterized by dynamic light scattering and were observed to be mostly monomeric. The L. tarentolae recombinant HA proteins were immunogenic in mice at a dose of 10µg when administered twice with an oil-in-water emulsion-based adjuvant. These results suggest that the L. tarentolae expression system may be an alternative to the current egg-based vaccine production.

Avian glycan-specific IgM monoclonal antibodies for the detection and quantitation of type A and B haemagglutinins in egg-derived influenza vaccines.

Two IgM monoclonal antibodies (MAbs), Y6F5 and Y13F9, were selected during a screening of clones obtained immunising BALB/c mice with purified envelop proteins of the A/Sydney/5/97 (H3N2) IVR108 influenza strain. These MAbs recognised avian glycans on the haemagglutinin (HA) of the virus. This broad recognition allowed these MAbs to be used as enzyme-labelled secondary antibody reagents in a strain specific enzyme-linked immunosorbent assay (ELISA) in combination with a capture MAb that recognised and allowed the quantitation of the strain specific HA protein present in an egg-produced influenza vaccine. Advantage was taken of these MAbs to develop a universal ELISA in which the MAbs were used both as capture antibody and as enzyme-labelled secondary antibody to detect and quantify the HA protein of any egg-derived influenza vaccine. These avian-glycan specific IgM MAbs may prove to be particularly useful for determining the HA concentration in monovalent egg-derived pandemic influenza vaccines, in which the HA concentration may be lower than 5µg/ml. The HA detection limit in the ELISA assays developed in this study was 1.9µg/ml, as opposed to the 5µg/ml quantitation limit generally accepted for the standard single-radial-immunodiffusion (SRID) assay, the approved technique for quantifying HA content in influenza vaccines. These ELISAs can also be used to quantify influenza HA formulated with emulsion-based or mineral salt adjuvants that could interfere with HA measurement by the SRID assay.

AF03-adjuvanted and non-adjuvanted pandemic influenza A (H1N1) 2009 vaccines induce strong antibody responses in seasonal influenza vaccine-primed and unprimed mice.

Pandemic influenza vaccines have been manufactured using the A/California/07/2009 (H1N1) strain as recommended by the World Health Organization. We evaluated in mice the immunogenicity of pandemic (H1N1) 2009 vaccine and the impact of prior vaccination against seasonal trivalent influenza vaccines (TIV) on antibody responses against pandemic (H1N1) 2009. In naïve mice, a single dose of unadjuvanted H1N1 vaccine (3 microg of HA) was shown to elicit hemagglutination inhibition (HI) antibody titers >40, a titer associated with protection in humans against seasonal influenza. A second vaccine dose of pandemic (H1N1) 2009 vaccine strongly increased these titers, which were consistently higher in mice previously primed with TIV than in naïve mice. At a low immunization dose (0.3 microg of HA), the AF03-adjuvanted vaccine elicited higher HI antibody titers than the corresponding unadjuvanted vaccines in both naïve and TIV-primed animals, suggesting a potential for antigen dose-sparing. These results are in accordance with the use in humans of a split-virion inactivated pandemic (H1N1) 2009 vaccine formulated with or without AF03 adjuvant to protect children and young adults against influenza A (H1N1) 2009 infection.

Preparation of genetically engineered A/H5N1 and A/H7N1 pandemic vaccine viruses by reverse genetics in a mixture of Vero and chicken embryo cells.

BACKGROUND: In case of influenza pandemic, a robust, easy and clean technique to prepare reassortants would be necessary. OBJECTIVES: Using reverse genetics, we prepared two vaccine reassortants (A/H5N1 x PR8 and A/H7N1 x PR8) exhibiting the envelope glycoproteins from non-pathogenic avian viruses, A/Turkey/Wisconsin/68 (A/H5N9) and A/Rhea/New Caledonia/39482/93 (A/H7N1) and the internal proteins of the attenuated human virus A/Puerto Rico/8/34 (H1N1). METHODS: The transfection was accomplished using a mixture of Vero and chicken embryo cells both of which are currently being used for vaccine manufacturing. RESULTS: This process was reproducible, resulting in consistent recovery of influenza viruses in 6 days. Because it is mainly the A/H5N1 strain that has recently crossed the human barrier, it is the A/PR8 x A/H5N1 reassortant (RG5) that was further amplified, either in embryonated hen eggs or Vero cells, to produce vaccine pre-master seed stocks that met quality control specifications. Safety testing in chickens and ferrets was performed to assess the non-virulence of the reassortant, and finally analysis using chicken and ferret sera immunized with the RG5 virus showed that the vaccine candidate elicited an antibody response cross-reactive with the Hong Kong 1997 and 2003 H5N1 strains but not the Vietnam/2004 viruses. CONCLUSIONS: The seeds obtained could be used as part of a pandemic vaccine strain 'library' available in case of propagation in humans of a new highly pathogenic avian strain.

Molecular characterization of Clostridium tetani strains by pulsed-field gel electrophoresis and colony PCR.

Pulsed-field gel electrophoresis and PCR were applied for the first time to the molecular characterization of Clostridium tetani. Among five strains tested, one (CN1339) turned out to contain a mixture of two genetically different clones and two (D11 and G761) to contain bacteria differing by the presence or absence of the 74-kb plasmid harboring the tetX gene.