Study of two approaches for the process water management from hydrothermal carbonization of swine manure: Anaerobic treatment and nutrient recovery.

Hydrothermal carbonization (HTC) is a promising alternative to transform biomass waste into a solid carbonaceous material (hydrochar) and a process water with potential for material and energy recovery. In this study, two alternatives for process water treatment by conventional and acid-assisted HTC of swine manure are discussed. Process water from conventional HTC at 180 °C showed high biodegradability (55% COD removal) and methane production (∼290 mL STP CH4 g-1 CODadded) and the treatment in an upflow anaerobic sludge blanket reactor allowed obtaining a high methane production yield (1.3 L CH4 L-1 d-1) and COD removal (∼70%). The analysis of the microbiota showed a high concentration of Synergistota and Firmicutes phyla, with high degradation of organic nitrogen-containing organic compounds. Acid-assisted HTC proved to be a viable option for nutrient recovery (migration of 83% of the P to the process water), which allowed obtaining a solid salt by chemical precipitation with Mg(OH)2 (NPK of 4/4/0.4) and MgCl2 (NPK 8/17/0.5), with a negligible content of heavy metals. The characteristics of the precipitated solid complied with the requirements of European Regulation (2019)/1009 for fertilizers and amendments in agricultural soils, being a suitable alternative for the recycling of nutrients from wastes.

Swine manure management by hydrothermal carbonization: Comparative study of batch and continuous operation.

Hydrothermal carbonization (HTC) is considered a promising technology for biomass waste management without pre-drying. This study explores the potential for swine manure management by comparing batch and continuous processes, emphasizing the benefits of the continuous mode, particularly for its potential full-scale application. The continuous process at low temperature (180 °C) resulted in a hydrochar with a lower degree of carbonization compared to the batch process, but similar characteristics were found in both hydrochars at higher operating temperatures (230-250 °C), such as C content (∼ 52 wt%), fixed carbon (∼ 24 wt%) and higher calorific value (21 MJ kg-1). Thermogravimetric and combustion analyses showed that hydrochars exhibited characteristics suitable as solid biofuels for industrial use. The process water showed a high content of organic matter as soluble chemical oxygen demand (7-22 g L-1) and total organic carbon (4-10 g L-1), although a high amount of refractory species such as N- and O-containing long aromatic compounds were detected in the process water from the batch process, while the process water from the continuous process presented more easily biodegradable compounds such as acids and alcohols, among others. The longer time required to reach operating temperature in the case of the batch system (longer heating time to reach operating temperature) resulted in lower H/C and O/C ratios compared to hydrochar from the continuous process. This indicates that the dehydration and decarboxylation reactions of the feedstock play a more important role in the batch process. This study shows the efficiency of the continuous process to obtain carbonaceous materials suitable for use as biofuel, providing a solution for swine manure management.

Treatment of hydrothermal carbonization process water by electrochemical oxidation: Assessment of process performance.

Herein electrochemical oxidation (EO) is proposed as a novel path to treat the process water obtained from hydrothermal carbonization of olive tree pruning. The aim of this work is to analyze the organic matter removal achieved by the treatment along with the identification of the chemical species formed after the electro-oxidation process at different experimental conditions. Three different tests were performed in a boron doped diamond cell, using Na2SO4 and NaCl as supporting electrolytes to compare the results obtained with the raw process water. The organic matter removal was evaluated by means of total organic carbon and chemical oxygen demand, while Gas Chromatography Mass Spectrometry was used to determine the chemical species present before and after the treatment. The addition of a promoter considerably increased the organic matter removal. In fact, the experiments performed using supporting electrolytes showed the best results in terms of organic matter removal compared to the control experiment (30-40% vs. 17%); This reduction agrees with the volatile fatty acids' measurements. Almost all the chemical species identified in the different feedstocks were partially or totally removed after the EO treatment depending on the experimental conditions. The specific energy consumption and the cost calculated for the treatment is highly dependent on the time of electro-oxidation and the supporting electrolyte used, obtaining values from 1 to 45 €/kg CODremoved. All in all, this work suggests an interesting path towards a further utilization of process water from hydrothermal carbonization processes.

Potential Use of Waste Activated Sludge Hydrothermally Treated as a Renewable Fuel or Activated Carbon Precursor.

In this work, dewatered waste activated sludge (DWAS) was subjected to hydrothermal carbonization to obtain hydrochars that can be used as renewable solid fuels or activated carbon precursors. A central composite rotatable design was used to analyze the effect of temperature (140-220 °C) and reaction time (0.5-4 h) on the physicochemical properties of the products. The hydrochars exhibited increased heating values (up to 22.3 MJ/kg) and their air-activation provided carbons with a low BET area (100 m2/g). By contrast, chemical activation with K2CO3, KOH, FeCl3 and ZnCl2 gave carbons with a well-developed porous network (BET areas of 410-1030 m2/g) and substantial contents in mesopores (0.079-0.271 cm3/g) and micropores (0.136-0.398 cm3/g). The chemically activated carbons had a fairly good potential to adsorb emerging pollutants such as sulfamethoxazole, antipyrine and desipramine from the liquid phase. This was especially the case with KOH-activated hydrochars, which exhibited a maximum adsorption capacity of 412, 198 and 146 mg/g, respectively, for the previous pollutants.

Anaerobic co-digestion of the aqueous phase from hydrothermally treated waste activated sludge with primary sewage sludge. A kinetic study.

The mesophilic anaerobic co-digestion of the liquid fraction from hydrothermal carbonization (LFHTC) of dewatered waste activated sludge with primary sewage sludge (PSS) has been studied. Mixtures of different composition (25, 50 and 75% of LFHTC on a chemical oxygen demand (COD) basis), as well as the individual substrates, have been tested using two inocula (flocculent (FS) and granular (GS) sludges). Methane production decreased as the LFHTC/PSS ratio increased, which can be related to the presence of recalcitrant compounds in the LFHTC, such as alkenes, phenolics, and other oxygen- and nitrogen-bearing aromatics hard-to-degrade through anaerobic digestion. Methane yield reached 248 ±â€¯11 mL CH4 STP/g CODadded with the GS inoculum and 25% LFHTC. A 74 and a 30% increase of methane production was achieved in the 25% LFHTC runs respect to the obtained in the similar experiments with 100% LFHTC, using the FS and GS inocula, respectively. In those late runs, the COD was reduced more than 86%, with a negligible concentration of total volatile fatty acids. With both inocula, total Kjeldahl nitrogen hydrolysis increased as the LFHTC to PSS mixture ratio decreased, reaching values higher than 79% at the end of the experiments. Methane yield values fitted well the first-order, Cone and Weibull kinetic models for both inocula. Significant differences in the kinetic constant values, ranging from 0.100 to 0.168 d-1 and 0.059-0.068 d-1, were found with the FS and GS inocula, respectively. The results obtained support the potential integration of HTC of dewatered waste activated sludge in wastewater treatment plants.

Biowaste management by hydrothermal carbonization and anaerobic co-digestion: Synergistic effects and comparative metagenomic analysis.

The feasibility of anaerobic co-digestion in semicontinuous mode of two major urban biowaste, food waste (FW) and garden and park waste (GPW) (75 % FW and 25 % GPW) as well as the co-digestion of FW with the process water originated from the hydrothermal carbonization of GPW (95 % FW and 5 % process water), both on a COD basis, has been assessed. The effect of varying organic loading rate (OLR) from 1.5 to 3.5 g COD/L·d on methane yield, gross energy recovery, and microbiome population was evaluated. For comparison, anaerobic digestion of FW was also conducted to determine the best strategy for sustainable biowaste management. This study showed an optimal OLR of 2.5 g COD/L·d. Acetic and propionic acid content increased as OLR raised for each condition studied, while methane yield decreased at the highest OLR tested indicating overloading of the system. The anaerobic co-digestion of FW and process water showed a 10 % increase on methane production compared to anaerobic digestion of FW (324 vs. 294 mL CH4 STP/L·d). Moreover, it enhances the process due to a greater abundance and diversity of hydrolytic and acidogenic bacteria belonging to Bacterioidota, Firmicutes, and Chloroflexi phyla, as well as promotes the hydrogenotrophic pathway under higher propionic concentrations which is not usually favoured for methane production. The integration of hydrothermal carbonization of GPW with the anaerobic co-digestion of 95 % FW and 5 % of process water results in the highest potential energy recovery and could be a good strategy for sustainable management of urban biowaste.

Thermophilic anaerobic digestion of sewage sludge: focus on the influence of the start-up. A review.

The thermophilic anaerobic digestion (TAD) of sewage sludge has often been found to be less stable than mesophilic treatment. In comparison to mesophilic digesters, thermophilic reactors treating sludge are generally characterized by relatively high concentrations of volatile fatty acids (VFA) in the effluent along with poor effluent quality, indicating a lower level of process stability. However, reviewing the literature related to the procedure for obtaining a thermophilic inoculum, it seems that most of the problems associated with the instability and the accumulation of organic intermediates are the result of the manner in which the thermophilic sludge has been obtained. In this paper, the different options available for obtaining an anaerobic digester operating at thermophilic temperature (55°C) have been reviewed. In this light, rapid heating to the target temperature followed by the development of thermophilic microorganisms, which can be determined by VFA dropping to ≤ 500 mg acetic acid L(-1) before increasing the organic loading rate (OLR), has been determined the most suitable means of establishing TAD.

Anaerobic digestion of sunflower oil cake: a current overview.

Due to the chemical and physical structure of a lignocellulosic biomass, its anaerobic digestion (AD) is a slow and difficult process. In this paper, the results obtained from a batch biochemical methane potential (BMP) test and fed-batch mesophilic AD assays of sunflower oil cake (SuOC) are presented. Taking into account the low digestibility shown during one-stage experiments the methane yield decreased considerably after increasing the organic loading rate (OLR) from 2 to 3 g VS L(-1) d(-1), SuOC was subjected to a two-stage AD process (hydrolytic-acidogenic and methanogenic stages), in two separate reactors operating in series where the methanogenic stage became acidified (with >1,600 mg acetic acid L(-1)) at an OLR as low as 2 g VS L(-1) d(-1). More recently, BMP assays were carried out after mechanical, thermal, and ultrasonic pre-treatments to determine the best option on the basis of the methane yield obtained.

Co-hydrothermal carbonization of swine manure and lignocellulosic waste: A new strategy for the integral valorization of biomass wastes.

Co-hydrothermal carbonization (co-HTC) is a promising strategy to improve hydrothermal carbonization (HTC) of low-quality wastes. HTC of swine manure (SM), with high N (2.9 wt%), S (0.7 wt%) and ash (22.6 wt%) contents, as well as low C (35.6 wt%) and higher heating value (HHV; 14.3 MJ kg-1), resulted in a hydrochar with unsuitable characteristics as a solid fuel. Co-HTC of SM and garden and park waste (GPW) improved hydrochar properties (C content (43 - 48 wt%) and HHV (18 - 20 MJ kg-1), and decreased N (∼2 wt%), S (<0.3 wt%) and ash (<15 wt%) content. A high GPW ratio (>50 wt%) during co-HTC resulted in a hydrochar similar to that obtained from GPW. The co-HTC increased nutrient migration to the process water, which allowed the precipitation of salt with high P (7.8 wt%) and negligible heavy metal content. Anaerobic digestion of co-HTC process water allowed high organic matter removal (up to 65%), and methane production (315 - 325 mL CH4 g-1CODadded). Gross energy recovery by HTC and anaerobic digestion was 5 - 6-fold higher than anaerobic treatment of feedstocks. Therefore, co-HTC of SM and GPW with a ratio > 50% GPW proved to be a suitable approach to valorize and manage SM and obtain value-added products (hydrochar, mineral fertilizer and methane).

Energy recovery from garden and park waste by hydrothermal carbonisation and anaerobic digestion.

Hydrothermal carbonisation (HTC) can transform wet lignocellulosic biomass, which is not considered an effective biofuel for energy production at the industrial level, into a carbonaceous product called hydrochar (HC) that is suitable for combustion and a process water (PW). PW is an interesting by-product that can be valorised for biogas production via anaerobic digestion (AD). This study presents a new approach for the valorisation of garden and park wastes (GPW) by integrating HTC to generate HC for energy production, while PW is subjected to AD for biogas production. The hydrothermal treatment was performed at 180, 210, and 230 °C, yielding HC with improved physicochemical properties, such as an elevated higher heating value (21-25 MJ kg-1); low ash (<5 wt.%), nitrogen (1.3 wt.%), and sulphur (0.2 wt.%) contents; better fuel ratio (0.4-0.6); and a broad comprehensive combustibility index (8.0×10-7 to 9.6×10-7 min-2 °C-3). AD of the generated PW was conducted under mesophilic conditions (35 °C), resulting in a methane production in the range of 253-326 mL g-1 CODadded and COD removal of up to 65%. The combination of HTC and AD allowed the recovery of 91% and 94% of the energy content feedstock, as calculated from the combustion of HC and methane, respectively.

New Fe3+/Cr3+ perovskites with anomalous transport properties: the solid solution La(x)Bi(1-x)Fe(0.5)Cr(0.5)O3 (0.4 ≤ x ≤ 1).

In this work, the sol-gel synthesis, structural characterization, and transport properties of a new solid solution of the general formula La(x)Bi(1-x)Fe(0.5)Cr(0.5)O(3) (0.4 ≤ x ≤ 1) are presented. The solubility limit x has been determined and variation of the lattice parameters measured through profile fitting. The cell parameters, space group, and atomic positions, as obtained by the Rietveld refinement of X-ray diffraction data, are reported. This analysis and electron diffraction studies as well do not reveal any evidence of Fe/Cr ordering. Regarding the transport properties, magnetic and electric characterizations are described. The electrical response with the temperature and frequency has been studied, and a "positive temperature coefficient" for the resistivity has been found for temperatures between 270 and 400 °C. The magnetic behavior is striking because, for all materials studied, zero-field-cooling curves appear above field-cooling ones, an anomalous feature that is interpreted as being due to complex ferromagnetic/antiferromagnetic interactions in the B perovskite sublattice.

Influence of COVID-19 confinement on students' performance in higher education.

This study analyzes the effects of COVID-19 confinement on the autonomous learning performance of students in higher education. Using a field experiment with 458 students from three different subjects at Universidad Autónoma de Madrid (Spain), we study the differences in assessments by dividing students into two groups. The first group (control) corresponds to academic years 2017/2018 and 2018/2019. The second group (experimental) corresponds to students from 2019/2020, which is the group of students that had their face-to-face activities interrupted because of the confinement. The results show that there is a significant positive effect of the COVID-19 confinement on students' performance. This effect is also significant in activities that did not change their format when performed after the confinement. We find that this effect is significant both in subjects that increased the number of assessment activities and subjects that did not change the student workload. Additionally, an analysis of students' learning strategies before confinement shows that students did not study on a continuous basis. Based on these results, we conclude that COVID-19 confinement changed students' learning strategies to a more continuous habit, improving their efficiency. For these reasons, better scores in students' assessment are expected due to COVID-19 confinement that can be explained by an improvement in their learning performance.

Energy and phosphorous recovery through hydrothermal carbonization of digested sewage sludge.

This work evaluates the potential of hydrothermal carbonization (HTC) to valorize the digestate derived from the anaerobic digestion of sewage sludge into useful materials for P and energy recovery. The hydrothermal treatment of digestate at 180-240 °C did not lead to high-rank hydrochars. On the other hand, inorganic P concentration did not change with the temperature, while as the carbonization temperature increased, the organic P retention yield in hydrochar became lower, increasing the total P in the process water obtained at the highest temperature, up to 25.3%. P recovery from acid leaching of the hydrochar obtained at 180 °C, via precipitation with CaO at pH up to 9, led to a brown solid precipitate with total P content close to 42 mg g-1, in the range of low grade phosphorus ores. Moreover, acid leaching reduced by 50% the ash content, yielding lignite-like upgraded hydrochars with higher heating values in the range of 20.5-23.1 MJ kg-1, fairly interesting as solid fuels. Anaerobic digestion of the process water enabled additional energy recovery in form of biogas (325 and 279 mL CH4 g-1 VS -at standard temperature and pressure; STP- from the process water resulting at 180 and 210 °C, respectively).

Valorization of microalgal biomass by hydrothermal carbonization and anaerobic digestion.

The potential of hydrothermal carbonization (HTC) as a novel choice for treating microalgal biomass (MAB) was assessed. The hydrochar obtained at 210 °C had a carbon content and a higher heating value (HHV) 1.09 and 1.1 times greater, respectively, than that of the feedstock. Also, washing the hydrochar with HCl efficiently removed ash and increased its carbon content 1.40-fold. Energy recovery in the liquid fraction from the hydrothermal treatment (LF) by anaerobic digestion (AD) allowed methane yields of 188-356 mL STP CH4 g-1 VSadded, to be obtained. As a result, the amount of energy recovered from MAB was increased from about 4 MJ kg-1 (20% in terms of HHV) to 15.4, 12.1 and 10.4 MJ kg-1 by combining HTC at 180, 210 and 240 °C, respectively, with AD. Therefore, HTC at 180 °C in combination with AD seemingly provides an effective method for valorizing MAB.

Mesophilic anaerobic co-digestion of the organic fraction of municipal solid waste with the liquid fraction from hydrothermal carbonization of sewage sludge.

In the present study, the influence of substrate pre-treatment (grinding and sieving) on batch anaerobic digestion of the organic fraction of municipal solid waste (OFMSW) was first assessed, then followed by co-digestion experiments with the liquid fraction from hydrothermal carbonization (LFHTC) of dewatered sewage sludge (DSS). The methane yield of batch anaerobic digestion after grinding and sieving (20 mm diameter) the OFMSW was considerably higher (453 mL CH4 STP g-1 VSadded) than that of untreated OFMSW (285 mL CH4 STP g-1 VSadded). The modified Gompertz model adequately predicted process performance. The maximum methane production rate, Rm, for ground and sieved OFMSW was 2.4 times higher than that of untreated OFMSW. The anaerobic co-digestion of different mixtures of OFMSW and LFHTC of DSS did not increase the methane yield above that of the anaerobic digestion of OFMSW alone, and no synergistic effects were observed. However, the co-digestion of both wastes at a ratio of 75% OFMSW-25% LFHTC provides a practical waste management option. The experimental results were adequately fitted to a first-order kinetic model showing a kinetic constant virtually independent of the percentage of LFHTC (0.52-0.56 d-1) and decreasing slightly for 100% LFHTC (0.44 d-1).

[The assessment of the nutritional status of patients with familial amyloid neuropathy type I (Corino Andrade's disease) who are candidates for orthotopic liver transplantation]. / Valoración del estado nutricional de los pacientes con polineuropatía amiloidótica familiar tipo I (enfermedad de Corino Andrade) candidatos a trasplante ortotópico de hígado.

Corino Andrade's disease (Type I Family amyloidotic polyneuropathy) (FAP I) is a slow-evolving hereditary amyloidosis affecting, among other things, the digestive system, with the appearance of an amyloid deposit which produces a malabsorptive syndrome with diarrhea in those affected. At present, the only effective therapeutic option is orthotopic liver transplant (OLT): clearance from the hospital's transplant commission as a candidate requires, among other things, a prior nutritional study. We therefore proposed to carry out a nutritional assessment of these patients, comparing them with a group of terminal liver patients who are OLT candidates. The PAF I group showed a high level of calorie energy malnutrition (86%) and, to a lesser extent, visceral and protein malnutrition. The liver patient group showed 67% of visceral malnutrition and lower levels of calorific energy and protein malnutrition. All the OLT candidates showed a high rate of nutritional deterioration. The greater presence of calorific energy malnutrition in the PAF I patients might be due to the neuropathic gastro-intestinal condition. The high level of malnutrition encountered suggest the need for pre-transplant nutritional intervention designed to minimise post-surgical risk.

[The assessment of the nutritional status of patients in the terminal stage of liver disease who are candidates for orthotopic liver transplantation]. / Valoración del estado nutricional de los pacientes en estadio terminal de enfermedad hepática, candidatos a trasplante ortotópico de hígado.

Orthotopic liver transplant (OLT) is nowadays an accepted procedure for the treatment of patients with end-stage liver disease. Because of the significant state of malnutrition of such patients, we decided to evaluate the nutritional condition of patients accepted by the hospital's Transplants Committee as candidates for this type of therapy, with the eventual aim of discovering the types of malnutrition in the different pathologies, and which were the most frequent. The sample studied showed a significant prevalence of malnutrition. Patients with viral hepatitis showed only visceral type malnutrition, which affected 100% of them. The ethanolic cirrhosis group presented all types of malnutrition-energy-calorific (35%), protein (24%) and visceral (53%), while the group of other liver diseases presented 15% of energy-calorific malnutrition and 85% visceral. From these results, we conclude that the sample studied has a high prevalence of malnutrition and that the importance of its detection makes it possible to reduce pre- and post-surgical morbidity and mortality rates with an appropriate nutritional support.

[Cardiovascular response to orotracheal intubation using midazolam or etomidate in anesthesia induction]. / Respuesta cardiovascular a la intubación orotraqueal utilizando midazolam o etomidato en la inducción anestésica.

By means of the present study, we compare the variations in the cardiovascular response to the orotracheal intubation while using midazolam or etomidate during the anesthetic induction. For this purpose, we studied 2 groups of 10 patients each one which were premedicated with fentanyl and atropine, and succinylcholine as muscle relaxant. We took the data at a basal state, 10 minutes after premedication and 0, 1, 2, 3, 4, 5 and 10 minutes after the intubation handling. As hemodynamic data we registered heart rate, systolic and diastolic blood pressure and the rate product (PRP). In both groups, the peak response occurred two minutes after intubation in all the studied parameters. Systolic and diastolic blood pressure as well as PRP were significantly lower with midazolam. We conclude that midazolam and etomidate do not prevent the cardiovascular response to the intubation handling, although midazolam smooths pressure response.

Impact of ultrasonic pretreatment under different operational conditions on the mesophilic anaerobic digestion of sunflower oil cake in batch mode.

In this study ultrasonic (US) pretreatment was investigated with the aim of improving the anaerobic digestion of sunflower oil cake (SuOC), the solid waste derived from the extraction process of sunflower oil. Five ultrasonic pretreatment assays were conducted at specific energy (SE) and sonication times in a range from 24,000 kJ/kg TS and 16.6 min (assay 1: US1) to 597,600 kJ/kg TS and 331.2 min (assay 5: US5), respectively, all operating at a constant sonication frequency (20 kHz) and ultrasonic power (120 W). As regards ultrasonic pretreatment, the working conditions of the first assay (US1) using samples of SuOC at 2% (w/v) showed to be the most appropriate in terms of both lignin and hemicellulose degradation (57.7% and 66.7%, respectively) and cellulose increase (54% increase with respect to its initial concentration). The percentage of COD solubilization increased from only 14% to 21% when SE was 25 times higher. Results obtained in batch anaerobic digestion experiments (biochemical methane potential - BMP - tests) conducted at 35°C of the solid and liquid fractions released from the different ultrasonic conditions tested, indicated that for the first experiment (US1) the average ultimate methane yield obtained was 53.8% higher than that achieved for untreated SuOC. Finally, the kinetic constants of the anaerobic digestion of the solid and liquid fractions released after the ultrasonic pretreatment were virtually independent of the operation conditions assayed.

Kinetic evaluation of the psychrophylic anaerobic digestion of synthetic domestic sewage using an upflow filter.

A study of the anaerobic digestion process of synthetic domestic sewage (total COD: 705 mg/L) was carried out. The digestion was conducted in an upflow anaerobic filter with corrugated plastic rings as packing media at psychrophilic temperature (15-17 degrees C). For HRTs of between 10.0 and 17.1h, the total COD removal efficiency was almost constant and independent on the HRT, achieving an average value of around 80%. However, when the HRT decreased from 7.0 to 3.2h the efficiency diminished from 77% to 65%. This decrease in removal efficiency was parallel to the increase in the VFA/Alkalinity ratio for this HRT range. The flow pattern observed in the reactor studied was intermediate between plug-flow and CSTR systems, although the plug-flow was predominant. It can also be observed that Young and McCarty's model almost coincided with the CSTR model, when the biodegradable COD was used for fitting the data. The Manariotis equation allowed a better fit of the experimental data (total COD removal efficiency with influent substrate concentration and HRT) than the Young model. The methane yield coefficient obtained was 0.15 L CH(4)/g COD consumed.